NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
4 reportsClear category filter75,000 miles · Feb 6, 2025
Electrical SystemEngine
The contact owns a 2022 Ford F-450SD. The contact stated while driving 50-65 MPH, the vehicle lost drive power and the instrument panel lights started flickering. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart, and the contact resumed dri…
Read full complaint
The contact owns a 2022 Ford F-450SD. The contact stated while driving 50-65 MPH, the vehicle lost drive power and the instrument panel lights started flickering. The check engine warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was able to restart, and the contact resumed driving. The contact stated that the failure recurred while driving on several occasions. The vehicle was taken to the dealer, where it was diagnosed and determined that both batteries had failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 75,000. The VIN was not available.
NHTSA ODI #11641049
Mileage unknown · Oct 11, 2024
Electrical SystemEngineFire
on 6/7/24, while driving around the Baltimore beltway towing a 44' RV in rush-hour traffic a battery warning light appeared. Within 1 min, the vehicle dashboard information went out and the engine stalled. I immediately put the vehicle in neutral and was able to coast to the shoulder without advantage of turn signals on either t…
Read full complaint
on 6/7/24, while driving around the Baltimore beltway towing a 44' RV in rush-hour traffic a battery warning light appeared. Within 1 min, the vehicle dashboard information went out and the engine stalled. I immediately put the vehicle in neutral and was able to coast to the shoulder without advantage of turn signals on either the RV or truck as a result. Once there I popped the hood and was able to get out to open it, however, there was a fire and my fingers were singed. After opening the hood, I noticed a full engine fire. I yelled for my wife to get out ASAP. I was able to extinguish the fire (thanks to the RV extinguisher), however, a secondary fire started, and a Samaritan help extinguish that fire. A fire department truck appeared, and they cut the batter cable since it seemed to have started the fire. The vehicle was towed back to the dealership where it was purchased. The insurance agent stated a mechanic had informed him; they believe it was the battery that was the cause. All vehicle maintenance was conducted by the dealership due to warranty AND an extended vehicle maintenance plan purchased at the time of sale. Ford has failed to acknowledge any problems with the vehicle and refused to honor the warranty.
NHTSA ODI #11619319
Mileage unknown · Jul 16, 2024
EngineFire
I was towing my 5th wheel trailer on a highway and up an incline. Almost at the top of the hill a notification appeared on the dash screen stating, "low power mode". As I was on top of a hill, towing a trailer, on a highway, and with no available offramps, I coasted down the hill trying to find a place to pull off of the highw…
Read full complaint
I was towing my 5th wheel trailer on a highway and up an incline. Almost at the top of the hill a notification appeared on the dash screen stating, "low power mode". As I was on top of a hill, towing a trailer, on a highway, and with no available offramps, I coasted down the hill trying to find a place to pull off of the highway. At the bottom of the hill I heard a loud noise from the engine, noticed smoke in my rearview mirror, and lost all power to the vehicle including power steering. I managed to pull off to the side of the busy highway. I exited the vehicle and removed my kids from the car, moving them up a hill on the side of the highway as it was the safest place I could find. It was at that point I noticed flames coming from the right font front wheel well. I quickly opened my trailer, grabbed my fire extinguisher, and doused the flames. Had I not acted quickly the entire truck, trailer, and hillside would have caught fire. The vehicle is still at the dealership waiting on Ford Motor Company to approve the repairs. The vehicle has approximately 26,000 miles on it and is unmodified.
NHTSA ODI #11602753
168,000 miles · Apr 16, 2024
Engine
The contact owns a 2022 Ford F-450 SD. The contact stated that while starting the vehicle, he started to hear a loud knocking noise coming from the engine. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed and determined that the engine needed to be replaced. The manufacturer was noti…
Read full complaint
The contact owns a 2022 Ford F-450 SD. The contact stated that while starting the vehicle, he started to hear a loud knocking noise coming from the engine. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed and determined that the engine needed to be replaced. The manufacturer was notified of the failure and advised the contact to reach out to the NHSTA Hotline for assistance. The failure mileage was 168,000.
NHTSA ODI #11583404
Official recalls
14Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Jan 31, 2025
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Consequence & remedy
Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Nov 9, 2023
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Consequence & remedy
Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.
Additional source detail variants (2)
Wheels:lugs/nuts/bolts/studs
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.
Power Train:axle Hubs
Ford Motor Company is recalling certain 2022-2023 Ford Super Duty F-350, F-450, F-550, and F-600 vehicles. The fasteners for the front wheel hub extender may be insufficiently tightened, which can result in the wheel and wheel extender detaching from the vehicle.
Consequence: Wheel detachment can result in a loss of vehicle control and create a road hazard, increasing the risk of a crash.
Remedy: Owners are advised not to drive their vehicle until the repair has been performed. Dealers will inspect the front wheel hub extender retaining nuts. If the retaining nuts are loose, dealers will replace the wheel hub extender, retaining nuts, and hub assembly. Repairs will be performed free of charge. Owner notification letters were mailed December 7, 2023. Owners may contact Ford customer service at -866-436-7332. Ford's number for this recall is 23S59.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
May 27, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."
Consequence & remedy
Consequence: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.
Remedy: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration