NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
217 reportsMileage unknown · Jul 8, 2014
Service Brakes
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT 15 MPH, THE BRAKE LIGHT FAILED TO ILLUMINATE WHENEVER THE BRAKES WERE ENGAGED. ALSO, THE TBC WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONNECTOR TO THE BREAK LIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT STATED WHILE DRIVING AT 15 MPH, THE BRAKE LIGHT FAILED TO ILLUMINATE WHENEVER THE BRAKES WERE ENGAGED. ALSO, THE TBC WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONNECTOR TO THE BREAK LIGHT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 140,000.
NHTSA ODI #10609006
113,000 miles · Jun 17, 2014
Engine
APPROXIMATELY 16,000 MILES PRIOR TO THIS INCIDENT (96,450) THE VEHICLE HAD A LACK OF TOWING POWER. I TOOK IT TO FORD, AND THEY TOLD ME THAT IT WAS THE EGR COOLER AND OIL COOLER. THE SERVICE MANAGER ADVISED ME THAT THIS HAPPENS TO EVERY 6.0 LITER DIESEL. HE STATED THEY UPDATED THE COOLERS TO FIX THE PROBLEM (PRETTY MUCH ADMITT…
Read full complaint
APPROXIMATELY 16,000 MILES PRIOR TO THIS INCIDENT (96,450) THE VEHICLE HAD A LACK OF TOWING POWER. I TOOK IT TO FORD, AND THEY TOLD ME THAT IT WAS THE EGR COOLER AND OIL COOLER. THE SERVICE MANAGER ADVISED ME THAT THIS HAPPENS TO EVERY 6.0 LITER DIESEL. HE STATED THEY UPDATED THE COOLERS TO FIX THE PROBLEM (PRETTY MUCH ADMITTING THAT THEY DID NOT BUILD IT RIGHT). I SEARCHED ONLINE AND FOUND THIS TO BE TRUE, BUT FOR SOME REASON THERE IS NO RECALL. $4,730.78 LATER, MY VEHICLE WAS FIXED. ALTHOUGH I DO TOW WITH THE VEHICLE (THAT'S WHAT ITS MADE FOR), I BABY THE VEHICLE. I DO OIL CHANGES EVERY 3000 (RECOMMENDED AT 5000) AND CHANGE THE FUEL FILTER 2 TIMES A YEAR (RECOMMENDED EVERY 12,000). THREE YEARS LATER AND ONLY 16,000 MILES LATER (113,239) THE VEHICLE AGAIN HAD A LACK OF POWER. I TOOK IT TO FORD AGAIN, AND THEY TOLD ME IT WAS THE EGR COOLER, OIL COOLER, AND HEAD GASKETS. I TOLD THE SERVICE MANAGER THAT I JUST HAD THE EGR COOLER AND OIL COOLER REPLACED, BUT IT WAS OUT OF THE REPAIR WARRANTY. HE SAID ALL OF THESE TRUCKS HAVE THESE PROBLEMS. $7,937 (DISCOUNTED) AND TWO WEEKS LATER I RECEIVED MY VEHICLE BACK. MY FAMILY HAS USED FORD DIESEL TRUCKS FOR YEARS AND NORMALLY GET 250,000 OUT OF THEM BEFORE ANY MAJOR REPAIRS. FORD DOES NOT STAND BEHIND THEIR PRODUCT LIKE THEY USED TO. I WILL NEVER BUY ANOTHER FORD. *TR
NHTSA ODI #10598790
137,000 miles · Feb 5, 2014
Electrical System
TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V270…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 05V27000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 137,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10563003
59,675 miles · Jan 25, 2014
SteeringSuspension
I HAVE A 2005, CREW CAB, SHORT BED, 6.0 DIESEL F-350. WHEN DRIVING AT 55-75MPH ON THE HIGHWAY, I PASSED A SMALL BUMP TRIGGERING A RIGOROUS SHAKING OF THE FRONT END. I COULD NOT APPLY BRAKES RAPIDLY, AND THE STEERING WHEEL BEGAN TO SHAKE. I BARELY HAD CONTROL OF THE VEHICLE, BUT AFTER FINALLY SLOWING DOWN TO A STOP THE SHAKING ST…
Read full complaint
I HAVE A 2005, CREW CAB, SHORT BED, 6.0 DIESEL F-350. WHEN DRIVING AT 55-75MPH ON THE HIGHWAY, I PASSED A SMALL BUMP TRIGGERING A RIGOROUS SHAKING OF THE FRONT END. I COULD NOT APPLY BRAKES RAPIDLY, AND THE STEERING WHEEL BEGAN TO SHAKE. I BARELY HAD CONTROL OF THE VEHICLE, BUT AFTER FINALLY SLOWING DOWN TO A STOP THE SHAKING STOPPED. IT WAS VERY DANGEROUS, AND HAS HAPPENED 6 TIMES SINCE AT 55-75MPH. *TR
NHTSA ODI #10561488
101,000 miles · Jan 3, 2014
Air BagsCrashInjury
FORD F350 PULLING A 31' TRAILER CRASHED INTO REAR OF A COMMERCIAL TRUCK/TRAILER DUE TO ICY ROAD CONDITIONS. AIR BAGS DID NOT ACTIVATE ON IMPACT. PASSENGER IN RIGHT/FRONT SEAT WAS CRUSHED DUE TO IMPACT. *TR
NHTSA ODI #10558391
97,300 miles · Oct 15, 2013
Electrical System
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER SEVERAL ATTEMPTS THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE FUEL INJECTION CONTROL MODULE WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAM…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. AFTER SEVERAL ATTEMPTS THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE FUEL INJECTION CONTROL MODULE WOULD HAVE TO BE REPLACED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM) HOWEVER, THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 97,300.
NHTSA ODI #10548000
42,206 miles · Jul 15, 2013
EngineFuel System, Diesel
COMING HOME FROM A CAMPING TRIP WITH A 5TH WHEEL CAMPER & TRUCK JUST STOPPED WORKING. COME TO FIND OUT THE STC FITTING ON HIGH PRESSURE OIL PUMP SHOT APART & CRACKED REAR TIMING COVER. AFTER BEING STUCK ON THE HIGHWAY FOR OVER 8 HOURS, STRANDED AT THE CAMPGROUND FOR 4 MORE DAYS & $3000 TO GET IT FIXED, WE THEN FINDING OUT THAT…
Read full complaint
COMING HOME FROM A CAMPING TRIP WITH A 5TH WHEEL CAMPER & TRUCK JUST STOPPED WORKING. COME TO FIND OUT THE STC FITTING ON HIGH PRESSURE OIL PUMP SHOT APART & CRACKED REAR TIMING COVER. AFTER BEING STUCK ON THE HIGHWAY FOR OVER 8 HOURS, STRANDED AT THE CAMPGROUND FOR 4 MORE DAYS & $3000 TO GET IT FIXED, WE THEN FINDING OUT THAT THIS IS A COMMON PROBLEM WITH THIS ENGINE. THIS STC FITTING HAS SINCE BEEN CHANGED BY THE MANUFACTURER SO THAT IT IS ONE PIECE NOW, HOWEVER THERE HAS NOT BEEN A RECALL ON IT. WE HAVE SEVERAL FORD VEHICLES AND IT IS VERY UPSETTING TO GO THROUGH ALL OF THIS WHEN A SIMPLE RECALL COULD HAVE AVOIDED IT. THANK YOU FOR YOUR ATTENTION TO RESOLVING THIS MATTER & HELPING US GET A REFUND FOR THE $3000. *TR
NHTSA ODI #10524945
170,000 miles · May 23, 2013
Electrical System
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE, STATING THAT THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE, STATING THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT MILEAGE WAS 180,000. *TR
NHTSA ODI #10513270
82,462 miles · May 7, 2013
Tires
TL* THE CONTACT OWNS A 2005 FORD F-350 SD EQUIPPED WITH MICHELIN TIRES, SIZE: LT245/75/R17 TIRES(N/A). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE HOOD ON THE TRUCK, BEGAN TO VIBRATE IN A VIOLENT MANNER. WITHIN 2-3 SECONDS, THE FRONT PASSENGER'S SIDE TIRE EXPLODED WHICH CAUSED THE VEHICLE TO PULL TOWARD THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350 SD EQUIPPED WITH MICHELIN TIRES, SIZE: LT245/75/R17 TIRES(N/A). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE HOOD ON THE TRUCK, BEGAN TO VIBRATE IN A VIOLENT MANNER. WITHIN 2-3 SECONDS, THE FRONT PASSENGER'S SIDE TIRE EXPLODED WHICH CAUSED THE VEHICLE TO PULL TOWARD THE RIGHT AND SWAY UNCONTROLLABLY OFF ROAD, THROUGH SAND, BRUSH ROCKS, ACROSS A CULVERT, WHICH CAUSED THE FRONT END OF THE VEHICLE, TO BECOME BURIED DEEP IN THE SAND. THERE WAS DAMAGE TO THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE THE DEFECTIVE TIRE WAS REPLACED WITH A SPARE. THE VEHICLE WAS THEN TAKEN TO A TIRE CENTER WHERE THE FRONT PASSENGER AND DRIVER'S SIDE TIRES WERE REPLACED. THE TIRE CENTER REPLACED THE DEFECTIVE TIRE FREE OF CHARGE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 82,462. UPDATED 6/17/13 *CN THE CONSUMER STATED THE RETAIL ESTABLISHMENT REFUNDED THE COST OF THE BLOWN TIRE, STATING IT WAS DEFECTIVE. MICHELIN DISAGREED WITH THE RETAIL ESTABLISHMENTS FINDINGS AND STATED THE TIRE WAS NOT DEFECTIVE. MICHELIN STATED THEIR INSPECTION REVEALED A RADIAL BREAK THROUGH THE CASING IN THE CROWN AREA FROM BEAD TO BEAD. A PORTION OF THE TREAD AND BOTH STEEL BELTS WERE DETACHED AND MISSING IN THAT AREA EXPOSING THE RADIAL CASING PILED. MICHELIN, WENT ON TO STATED, THAT INDICATED THE INNER LINER ALLOWING AIR TO INFILTRATE INTO THE CASING. AS THE TIRE REMAINED IN SERVICE, THE AIR INFILTRATION PROGRESSED, ULTIMATELY CAUSING THE TREAD TO DETACH. UPDATED 06/25/13
NHTSA ODI #10510938
104,255 miles · Apr 29, 2013
Steering
DRIVING ST HIGHWAY SPEED (50-55MPH) I RAN OVER THREE SMALL BUMPS IN SUCCESSION, THE STEERING WHEEL WENT INTO A VIOLENT SIDE TO SIDE SHAKING AND I EXPERIENCED A SEVERE AND VIOLENT SHAKING OF THE ENTIRE FRONT END OF THE TRUCK. I MANAGED TO SLOW THE TRUCK AND PULL TO THE SHOULDER OF THE DIVIDED HIGHWAY. I GOT OUT AND INSPECTED THE…
Read full complaint
DRIVING ST HIGHWAY SPEED (50-55MPH) I RAN OVER THREE SMALL BUMPS IN SUCCESSION, THE STEERING WHEEL WENT INTO A VIOLENT SIDE TO SIDE SHAKING AND I EXPERIENCED A SEVERE AND VIOLENT SHAKING OF THE ENTIRE FRONT END OF THE TRUCK. I MANAGED TO SLOW THE TRUCK AND PULL TO THE SHOULDER OF THE DIVIDED HIGHWAY. I GOT OUT AND INSPECTED THE TRUCK TO SEE IF THERE WAS ANY DAMAGE. I COULD SEE NONE SO I DROVE CAREFULLY BACK ON TO THE HIGHWAY AND THE TRUCK SEEMED TO DRIVE OK FROM THAT POINT ON. I TOOK THE TRUCK TO A FRONT END ALIGNMENT SHOP AND HAD THE FRONT END AND SUSPENSION CHECKED. THEY SAID IT ALL LOOKED GOOD, BUT AFTER THAT ABOUT A MONTH LATER I HAD THE SAME THING HAPPEN AGAIN ON AN INTERSTATE HIGHWAY. SAME DEAL, I HIT A SUCCESSION OF SMALL BUMPS , THEN ALL HELL BROKE LOOSE, VIOLENT SHAKING AND OSCILLATION OF THE STEERING WHEEL. I WAS FORCED TO PULL OVER TO THE BERM IN HEAVY TRAFFIC AND HAD TO PULL BACK OUT INTO FAST MOVING TRAFFIC. THESE F-350'S ARE A DEATH TRAP ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10509866
Official recalls
3Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Jun 9, 2005
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence & remedy
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration