NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
38 reportsClear category filter143,000 miles · Sep 2, 2018
Steering
DRIVING DOWN THE HIGHWAY I HIT A SMALL BUMP AT 65MPH AND THE ENTIRE FRONT END STARTED VIOLENTLY SHAKING LIKE IT WAS GOING TO FALL APART. HAS HAPPENED TO ME 3 TIMES NOW AND TO MY PREGNANT WIFE 3 TIMES IN ONE TRIP! VERY SCARY AND A SERIOUS ISSUE THAT SHOULD BE RECTIFIED IMMEDIATELY. EXTREMELY DANGEROUS SITUATION AT 60MPH+ OR ANY S…
Read full complaint
DRIVING DOWN THE HIGHWAY I HIT A SMALL BUMP AT 65MPH AND THE ENTIRE FRONT END STARTED VIOLENTLY SHAKING LIKE IT WAS GOING TO FALL APART. HAS HAPPENED TO ME 3 TIMES NOW AND TO MY PREGNANT WIFE 3 TIMES IN ONE TRIP! VERY SCARY AND A SERIOUS ISSUE THAT SHOULD BE RECTIFIED IMMEDIATELY. EXTREMELY DANGEROUS SITUATION AT 60MPH+ OR ANY SPEED REALLY.
NHTSA ODI #11124008
170,000 miles · Feb 8, 2016
SteeringSuspensionUnknown Or Other
I WAS DRIVING ON A TWO LANE BACK ROAD AROUND 45 TO 50 MPH, AND MY TRUCK STARTED VIOLENTLY SHAKING AND I LOST ALL CONTROL OF STEERING. I WENT INTO THE ONCOMING LANE, LUCKILY NO ONE WAS COMING, AND HAD TO HIT MY BRAKES HARD TO GET THE SHAKING TO STOP. IT HAS ALSO HAPPENED WHILE DRIVING AT SPEEDS OF 35-40 ON A CITY STREET AND 60 MP…
Read full complaint
I WAS DRIVING ON A TWO LANE BACK ROAD AROUND 45 TO 50 MPH, AND MY TRUCK STARTED VIOLENTLY SHAKING AND I LOST ALL CONTROL OF STEERING. I WENT INTO THE ONCOMING LANE, LUCKILY NO ONE WAS COMING, AND HAD TO HIT MY BRAKES HARD TO GET THE SHAKING TO STOP. IT HAS ALSO HAPPENED WHILE DRIVING AT SPEEDS OF 35-40 ON A CITY STREET AND 60 MPH ON A HIGHWAY. THIS IS KNOWN AS DEATH WOBBLE. THE WOBBLE WAS SO BAD THAT IT LOOSENED THE TRACK BAR AND THE BOLT HOLDING THE POWER STEERING HARD LINE. I LOST ALL POWER STEERING FLUID WITHIN SECONDS. I HAVE RESEARCHED IT, TRIED REPLACING SEVERAL PARTS, LIKE TIE-RODS, AND IT HAS LESSENED A LITTLE BIT, BUT IF I HIT A BUMPY ROAD OR EVEN JUST A PATCH OF NEW PAVEMENT, IT STARTS SHAKING. I HAVE READ A LOT OF OTHER FORD OWNERS ARE EXPERIENCING THIS SAME ISSUE WITH THEIR TRUCKS.
NHTSA ODI #10824888
59,675 miles · Jan 25, 2014
SteeringSuspension
I HAVE A 2005, CREW CAB, SHORT BED, 6.0 DIESEL F-350. WHEN DRIVING AT 55-75MPH ON THE HIGHWAY, I PASSED A SMALL BUMP TRIGGERING A RIGOROUS SHAKING OF THE FRONT END. I COULD NOT APPLY BRAKES RAPIDLY, AND THE STEERING WHEEL BEGAN TO SHAKE. I BARELY HAD CONTROL OF THE VEHICLE, BUT AFTER FINALLY SLOWING DOWN TO A STOP THE SHAKING ST…
Read full complaint
I HAVE A 2005, CREW CAB, SHORT BED, 6.0 DIESEL F-350. WHEN DRIVING AT 55-75MPH ON THE HIGHWAY, I PASSED A SMALL BUMP TRIGGERING A RIGOROUS SHAKING OF THE FRONT END. I COULD NOT APPLY BRAKES RAPIDLY, AND THE STEERING WHEEL BEGAN TO SHAKE. I BARELY HAD CONTROL OF THE VEHICLE, BUT AFTER FINALLY SLOWING DOWN TO A STOP THE SHAKING STOPPED. IT WAS VERY DANGEROUS, AND HAS HAPPENED 6 TIMES SINCE AT 55-75MPH. *TR
NHTSA ODI #10561488
104,255 miles · Apr 29, 2013
Steering
DRIVING ST HIGHWAY SPEED (50-55MPH) I RAN OVER THREE SMALL BUMPS IN SUCCESSION, THE STEERING WHEEL WENT INTO A VIOLENT SIDE TO SIDE SHAKING AND I EXPERIENCED A SEVERE AND VIOLENT SHAKING OF THE ENTIRE FRONT END OF THE TRUCK. I MANAGED TO SLOW THE TRUCK AND PULL TO THE SHOULDER OF THE DIVIDED HIGHWAY. I GOT OUT AND INSPECTED THE…
Read full complaint
DRIVING ST HIGHWAY SPEED (50-55MPH) I RAN OVER THREE SMALL BUMPS IN SUCCESSION, THE STEERING WHEEL WENT INTO A VIOLENT SIDE TO SIDE SHAKING AND I EXPERIENCED A SEVERE AND VIOLENT SHAKING OF THE ENTIRE FRONT END OF THE TRUCK. I MANAGED TO SLOW THE TRUCK AND PULL TO THE SHOULDER OF THE DIVIDED HIGHWAY. I GOT OUT AND INSPECTED THE TRUCK TO SEE IF THERE WAS ANY DAMAGE. I COULD SEE NONE SO I DROVE CAREFULLY BACK ON TO THE HIGHWAY AND THE TRUCK SEEMED TO DRIVE OK FROM THAT POINT ON. I TOOK THE TRUCK TO A FRONT END ALIGNMENT SHOP AND HAD THE FRONT END AND SUSPENSION CHECKED. THEY SAID IT ALL LOOKED GOOD, BUT AFTER THAT ABOUT A MONTH LATER I HAD THE SAME THING HAPPEN AGAIN ON AN INTERSTATE HIGHWAY. SAME DEAL, I HIT A SUCCESSION OF SMALL BUMPS , THEN ALL HELL BROKE LOOSE, VIOLENT SHAKING AND OSCILLATION OF THE STEERING WHEEL. I WAS FORCED TO PULL OVER TO THE BERM IN HEAVY TRAFFIC AND HAD TO PULL BACK OUT INTO FAST MOVING TRAFFIC. THESE F-350'S ARE A DEATH TRAP ! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10509866
20,000 miles · Jan 16, 2013
Steering
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL AND FRONT END OF THE VEHICLE STARTED TO SHAKE. THE CONTACT RELEASED THE ACCELERATOR PEDAL AND THE SHAKING BECAME MORE EXTREME. AFTER DEPRESSING THE BRAKES, THE VEHICLE WAS MOVED OFF THE ROADWAY AND THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL AND FRONT END OF THE VEHICLE STARTED TO SHAKE. THE CONTACT RELEASED THE ACCELERATOR PEDAL AND THE SHAKING BECAME MORE EXTREME. AFTER DEPRESSING THE BRAKES, THE VEHICLE WAS MOVED OFF THE ROADWAY AND THE CONTACT INSPECTED THE VEHICLE. THE CONTACT FOUND NOTHING LOOSE OR HANGING. THE VEHICLE WAS THEN TAKEN TO A DEALER WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PERFORMING NORMALLY WHEN DRIVING AT HIGHWAY SPEEDS. THE MANUFACTURER WAS CONTACTED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE CURRENT MILEAGE WAS APPROXIMATELY 62,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10493165
45,000 miles · Dec 20, 2011
Steering
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD SHAKE VIOLENTLY WHILE DRIVING OVER 50 MPH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE CONTACT MADE ATTEMPTS TO REPAIR THE FAILURE, BUT THE DEFECT CONTINUOUSLY RECURRED. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD SHAKE VIOLENTLY WHILE DRIVING OVER 50 MPH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE CONTACT MADE ATTEMPTS TO REPAIR THE FAILURE, BUT THE DEFECT CONTINUOUSLY RECURRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 60,000.
NHTSA ODI #10440552
50 miles · Dec 7, 2011
Steering
TL* THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING APPROXIMATELY 40 MPH OVER A ROAD BUMP, THE FRONT END OF THE VEHICLE BEGAN PULL TO THE LEFT ABNORMALLY. THE FAILURE RECURRED THREE TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER SENT A LETTER TO NOTIFY THE OWNER'S TO INSPECT THE TIRE TREAD AND AIR P…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F350 SD. WHILE DRIVING APPROXIMATELY 40 MPH OVER A ROAD BUMP, THE FRONT END OF THE VEHICLE BEGAN PULL TO THE LEFT ABNORMALLY. THE FAILURE RECURRED THREE TIMES. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER SENT A LETTER TO NOTIFY THE OWNER'S TO INSPECT THE TIRE TREAD AND AIR PRESSURE TO PREVENT THE PULLING OF THE VEHICLE AND STEERING WHEEL VIBRATION. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 50.
NHTSA ODI #10438847
35,300 miles · Jul 28, 2011
Steering
ON JULY 2, 2011, I WAS DRIVING MY 2005 F350 4X4 FORD TRUCK AT APPROXIMATELY 60 MPH ON A DOWNHILL GRADE AND HIT A POTHOLE IN THE ROAD. THE TRUCK STARTED SHAKING SO VIOLENTLY THAT I LOST CONTROL AND DRIFTED INTO THE ONCOMING TRAFFIC LANE FOR SEVERAL SECONDS WITHOUT BEING ABLE TO CONTROL THE VEHICLE. FORTUNATELY IT WAS LATE AT NI…
Read full complaint
ON JULY 2, 2011, I WAS DRIVING MY 2005 F350 4X4 FORD TRUCK AT APPROXIMATELY 60 MPH ON A DOWNHILL GRADE AND HIT A POTHOLE IN THE ROAD. THE TRUCK STARTED SHAKING SO VIOLENTLY THAT I LOST CONTROL AND DRIFTED INTO THE ONCOMING TRAFFIC LANE FOR SEVERAL SECONDS WITHOUT BEING ABLE TO CONTROL THE VEHICLE. FORTUNATELY IT WAS LATE AT NIGHT AND NO OTHER VEHICLES WERE APPROACHING. THE STEERING WHEEL SHOOK SO VIOLENTLY THAT IT BLURRED MY VISION WHILE TRYING TO HOLD ON AND REGAIN CONTROL. THE SHAKING LASTED 10-15 SECONDS AND ONLY STOPPED AFTER I WAS ABLE TO SLOW THE VEHICLE BELOW 40 MPH. I HAD MY WIFE AND TWO SONS IN THE VEHICLE WITH ME. THIS INCIDENT MAY HAVE CAUSED A CRASH IF THERE WAS ONCOMING TRAFFIC OR IF IT HAD OCCURRED ON A BEND IN THE ROAD. THIS INCIDENT WAS THE MOST VIOLENT EXPERIENCED TO DATE, BUT I HAVE EXPERIENCED THIS VIOLENT SHAKING ON 3 OTHER OCCASIONS AFTER HITTING A BUMP IN THE ROAD. I HAD MY TRUCK CAMPER ON THE VEHICLE AND IT SHOOK THE CAMPER SO VIOLENTLY IN THE BED THAT THE TAILGATE DOES NOT FIT PROPERLY ANYMORE DUE TO WHAT APPEARS TO BE A FLARING OF THE TRUCK BED. I FIRMLY BELIEVE MY ENTIRE FAMILY WAS IN MORTAL DANGER WITH THIS EVENT AND I AM HESITANT TO DRIVE THE VEHICLE. FORD NEEDS TO RECALL AND FIX THIS VERY DANGEROUS DEFECT IN THEIR TRUCKS. *TR
NHTSA ODI #10415452
42,000 miles · May 23, 2011
SteeringSuspension
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT WAS DRIVING WITH THE CRUISE CONTROL ACTIVATED AT 75 MPH. THE VEHICLE EXHIBITED AN ABNORMALLY LOUD EXPLOSION FROM THE FRONT OF THE VEHICLE. THE CONTACT PULLED AND WAS UNABLE TO FIND ANY PROBLEM WITH THE VEHICLE. ONE HOUR LATER, THE NOISE RECURRED WITHOUT WARNING. THE CONTACT TOO…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-350. THE CONTACT WAS DRIVING WITH THE CRUISE CONTROL ACTIVATED AT 75 MPH. THE VEHICLE EXHIBITED AN ABNORMALLY LOUD EXPLOSION FROM THE FRONT OF THE VEHICLE. THE CONTACT PULLED AND WAS UNABLE TO FIND ANY PROBLEM WITH THE VEHICLE. ONE HOUR LATER, THE NOISE RECURRED WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THE FAILURE CAME FROM THE TIE RODS AND COIL SPRINGS. THE CONTACT SPOKE WITH THE MANUFACTURER AND THEY CONFIRMED THAT THE FAILURE WAS COMMON AND THERE WAS AN ALIGNMENT ISSUE, BUT WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 42,000.
NHTSA ODI #10402382
38,000 miles · Jan 20, 2011
Steering
I OWN A 2005 FORD F350, THIS TRUCK STARTS TO SHIMMY AND SHAKE WHEN YOU GO OVER A SMALL BUMP IN THE ROAD, IT IS SEVERE ENOUGH TO CAUSE YOU TO LOOSE CONTROL OF THE VEHICLE. I HAVE AVOIDED A COUPLE OF ACCIDENTS BY DRIVING OFF THE ROAD WHICH IS NOT MUCH FUN. AFTER THE SHAKING STARTS YOU HAVE TO GET THE TRUCK SLOWED DOWN AS FAST AS P…
Read full complaint
I OWN A 2005 FORD F350, THIS TRUCK STARTS TO SHIMMY AND SHAKE WHEN YOU GO OVER A SMALL BUMP IN THE ROAD, IT IS SEVERE ENOUGH TO CAUSE YOU TO LOOSE CONTROL OF THE VEHICLE. I HAVE AVOIDED A COUPLE OF ACCIDENTS BY DRIVING OFF THE ROAD WHICH IS NOT MUCH FUN. AFTER THE SHAKING STARTS YOU HAVE TO GET THE TRUCK SLOWED DOWN AS FAST AS POSSIBLE WITHOUT CAUSING A CRASH. I LIVE IN SNOW COUNTRY AND TRY TO SLOW A TRUCK DOWN ON SNOW PACKED ROADS AND NOT CAUSE AN ACCIDENT. I'VE BEEN LUCKY SO FAR. I'VE HAD THE TRUCK LOOKED AT AND I'VE REPLACED PARTS AND TIRES TRYING TO GET IT TO GO AWAY, BUT NOTHING HELPS. THEY JUST TELL ME TO LIVE WITH IT. I WOULD LIKE TO SEE IF THERE IS SOMETHING THAT CAN AND WILL BE DONE. WELL I WOULD HOPE THAT THE PEOPLE WHO CLAIM THERE IS NOTHING WRONG WITH THESE TRUCKS ARE DRIVING THEM AND THEY CAN SEE FOR THEMSELVES WHAT'S GOING ON HERE. THERE ARE TO MANY PEOPLE WHO OWN THESE TRUCKS TO NOT LOOK INTO THESE CLAIMS. I'LL GLADLY LET YOU ALL DRIVE WITH ME AND CHECK OUT THE CLAIMS AND SEE THAT THERE IS A PROBLEM. THIS HAS HAPPENED MANY TIMES, IT'S NOT GETTING ANY BETTER. AFTER THOUSANDS OF DOLLARS AND NO BETTER SERVICE, I GIVE UP. *TR
NHTSA ODI #10378013
Official recalls
3Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Jun 9, 2005
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence & remedy
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration