TL*THE CONTACT OWNS A 2005 FORD F350 SUPERDUTY. WHILE DRIVING APPROXIMATELY 65 MPH, THE STEERING WHEEL STARTED SHAKING UNCONTROLLABLY. THE FAILURE OCCURRED WHEN DRIVING OVER 55 MPH AND WHEN DRIVING OVER A BUMP IN THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TIRES WERE CHANGED AND A NEW SNUBBER WAS PLACED ON THE STEERI…
Read full complaint
TL*THE CONTACT OWNS A 2005 FORD F350 SUPERDUTY. WHILE DRIVING APPROXIMATELY 65 MPH, THE STEERING WHEEL STARTED SHAKING UNCONTROLLABLY. THE FAILURE OCCURRED WHEN DRIVING OVER 55 MPH AND WHEN DRIVING OVER A BUMP IN THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TIRES WERE CHANGED AND A NEW SNUBBER WAS PLACED ON THE STEERING. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIRS. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
NHTSA ODI #10376343
85,800 miles · Dec 27, 2010
Steering
TRAVELING AT ANY SPEED BETWEEN 35 AND ABOUT 65 SO FAR AND HITTING A SMALL BUMP OR POTHOLE IN THE ROAD THE STEERING WHEEL STARTS TO VIOLENTLY SHAKE BACK AND FORTH UNTIL COMING TO ALMOST A COMPLETE STOP AND THEN THE SHAKING WILL CEASE. ALMOST IMPOSSIBLE TO CONTROL DURING THIS AND ALMOST IMPOSSIBLE TO STEER. ENTIRE TRUCK WILL SHA…
Read full complaint
TRAVELING AT ANY SPEED BETWEEN 35 AND ABOUT 65 SO FAR AND HITTING A SMALL BUMP OR POTHOLE IN THE ROAD THE STEERING WHEEL STARTS TO VIOLENTLY SHAKE BACK AND FORTH UNTIL COMING TO ALMOST A COMPLETE STOP AND THEN THE SHAKING WILL CEASE. ALMOST IMPOSSIBLE TO CONTROL DURING THIS AND ALMOST IMPOSSIBLE TO STEER. ENTIRE TRUCK WILL SHAKE SO BAD YOU CAN'T SEE STRAIGHT. JUST TOOK IT TO LES SCHWAB FOR ALIGNMENT THINKING IT WOULD FIX THE PROBLEM. THEY DID AN ALIGNMENT AND CHECKED ALL TIRE PRESSURES TO MAKE SURE THEY WERE CORRECT. LESS THAN 48 HOURS LATER, SAME ISSUE AGAIN. HAS HAPPENED ABOUT A DOZEN TIMES IN THE MONTH THAT I'VE OWNED THE 2005 FORD F-350 SUPER DUTY DIESEL CREW CAB LONG BOX. *TR
NHTSA ODI #10372621
18,202 miles · May 29, 2010
Steering
WE EXPERIENCED A SEVERE STEERING SHIMMY AT 65 MPH. THE VEHICLE WAS UNCONTROLLABLE. THE SHIMMY LASTED UNTIL THE VEHICLE WAS BROUGHT TO A COMPLETE STOP. THE STEERING DAMPER WAS FOUND TO BE DEFECTIVE AND REPLACED. *TR
NHTSA ODI #10333818
20,000 miles · Feb 15, 2010
SteeringSuspension
I HAVE A 2005 FORD F-350 4X4 CREWCAB DIESEL WHICH EXHIBITS SEVERE FRONT END SHIMMY AND STEERING WHEEL VIBRATION WHEN GOING OVER ROUGH ROADS OR CATTLE GUARDS. THIS IS SO SEVERE THAT I HAVE TO COME TO A COMPLETE STOP IN ORDER TO CONTINUE. FORD IS AWARE OF THIS PROBLEM BUT APPARENTLY WON'T ISSUE A RECALL TO FIX IT. IT IS AN EXTR…
Read full complaint
I HAVE A 2005 FORD F-350 4X4 CREWCAB DIESEL WHICH EXHIBITS SEVERE FRONT END SHIMMY AND STEERING WHEEL VIBRATION WHEN GOING OVER ROUGH ROADS OR CATTLE GUARDS. THIS IS SO SEVERE THAT I HAVE TO COME TO A COMPLETE STOP IN ORDER TO CONTINUE. FORD IS AWARE OF THIS PROBLEM BUT APPARENTLY WON'T ISSUE A RECALL TO FIX IT. IT IS AN EXTREMELY DANGEROUS SITUATION. *TR
NHTSA ODI #10310533
80,000 miles · Dec 9, 2009
Steering
OCCASIONAL LOSS OF STEERING "CENTERING" AFTER MAKING A 90 DEGREE TURN. THIS REQUIRES AN EXAGGERATED AND UNEXPECTED AMOUNT OF STEERING EFFORT TO CORRECT THIS OVERSTEERING CONDITION AND TO PREVENT CROSSING INTO THE ONCOMING TRAFFIC. THIS MAY OCCUR DAILY OR WEEKLY. *TR
NHTSA ODI #10295105
50,000 miles · Oct 14, 2009
Steering
TL*THE CONTACT OWNS 2005 FORD F350 SUPERDUTY. WHILE DRIVING APPROXIMATELY 65 TO 75 MPH, HE HIT A BUMP IN THE ROAD AND THE VEHICLE PROCEEDED TO SHAKE VIOLENTLY CAUSING HIM TO ALMOST LOSE CONTROL OF THE VEHICLE. HE WAS ABLE TO REGAIN CONTROL OF THE VEHICLE WHEN THE SPEED DECREASED TO 30 MPH. AN INDEPENDENT MECHANIC WAS UNABLE TO D…
Read full complaint
TL*THE CONTACT OWNS 2005 FORD F350 SUPERDUTY. WHILE DRIVING APPROXIMATELY 65 TO 75 MPH, HE HIT A BUMP IN THE ROAD AND THE VEHICLE PROCEEDED TO SHAKE VIOLENTLY CAUSING HIM TO ALMOST LOSE CONTROL OF THE VEHICLE. HE WAS ABLE TO REGAIN CONTROL OF THE VEHICLE WHEN THE SPEED DECREASED TO 30 MPH. AN INDEPENDENT MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE MECHANIC STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. HE CONTACT NOTIFIED THE MANUFACTURER; HOWEVER, THEY HAVE NOT RESPONDED. THE CURRENT AND THE FAILURE MILEAGES WERE 50,000.
NHTSA ODI #10287346
135,000 miles · May 15, 2009
SteeringSuspensionTires
MY FORD F-350 HAS SEVERE VIBRATION AND STEERING ISSUES. I RECEIVED THE LETTER ABOUT THESE ISSUES APRIL 2009. SHORTLY THERE AFTER WHILE ON THE HIGHWAY AT 65MPH THE TRUCK STARTED VIBRATING UNCONTROLLABLE. ABOUT THE TIME I GOT IT SLOWED DOWN I HEARD A LOUD POP IN THE PASSENGERS SIDE FRONT END. THIS WAS ABOUT APRIL 25 2009. ON MAY 1…
Read full complaint
MY FORD F-350 HAS SEVERE VIBRATION AND STEERING ISSUES. I RECEIVED THE LETTER ABOUT THESE ISSUES APRIL 2009. SHORTLY THERE AFTER WHILE ON THE HIGHWAY AT 65MPH THE TRUCK STARTED VIBRATING UNCONTROLLABLE. ABOUT THE TIME I GOT IT SLOWED DOWN I HEARD A LOUD POP IN THE PASSENGERS SIDE FRONT END. THIS WAS ABOUT APRIL 25 2009. ON MAY 14 2009 I WENT TO FORD FOR MY OIL CHANGE. THEY DISCOVERED THE FRONT PASSENGERS UNIVERSAL JOINT IS BROKEN. I WAS NOT IN FOUR WHEEL DRIVE WHEN THIS LOUD POP OCCURRED. BUT I DID ALMOST LOSE CONTROL PRIOR TO HEARING IT POP, MY SPEED AT THE TIME OF POP WAS ABOUT 35MPH. I KEEP THE TIRE PRESSURE UP, BY CHECKING IT ALMOST EVERY TIME I ADD FUEL. AND THE TIRES ARE CHECKED AT EACH OIL CHANGE, EVERY 3,000 MILES. THE LETTER I RECEIVED FROM FORD, SAYS TO CHECK TIRE PRESSURE. THE TIRE PRESSURE WAS GOOD WHEN I CHECKED IT SHORTLY AFTER HEARING THE UNIVERSAL JOINT POP. THE SIZE OF TIRE IS THE SAME AS THE ONES INSTALLED AT THE FACTORY. I DO NOT HAVE ANY SUSPENSION MODIFICATIONS. AFTER THE FORD DEALER TOLD ME I NEED A NEW UNIVERSAL JOINT, I TOOK THE TRUCK TO ANOTHER ALIGNMENT SHOP. HE HAD A F250 HE WAS WORKING ON THAT HAD ABOUT THE SAME THING HAPPEN. AND TOLD ME THIS HAS BEEN HAPPENING ALOT. AFTER WHICH I CALLED FORD, THEY WILL NOT WARRANTY THE ISSUE, ALTHOUGH IT SOUNDED TO ME THAT THE OPERATORS WERE WELL AWARE THESE TRUCKS SHIMMY AND THEN POP THERE UNIVERSAL JOINTS. I AM FEARFUL TO DRIVE THE TRUCK, AS I THINK NEXT TIME I MAY LOSE ALL CONTROL. FORD WILL NOT WARRANTY THE ISSUE BECAUSE THE WARRANTY IS EXPIRED, BUT THE OPERATORS TOLD ME I SHOULD SELL IT, AS THEY HAVE LOTS OF COMPLAINTS LIKE THIS. I WOULD NOT WANT TO HURT SOMEBODY ELSE BY PASSING THIS PROBLEM TRUCK ON, BUT I DO NOT HAVE FINANCES TO SCRAP IT ETHER. PLEASE HELP ME. THANK YOU *TR
NHTSA ODI #10268840
9,000 miles · Apr 14, 2009
Steering
I HAVE A SEVERE VIBRATION IN THE FRONT END AND STEERING ON MY TRUCK AFTER GOING OVER A BUMP OR DIP IN THE ROAD. I HAVE ONLY NOTICED THIS AT FREEWAY SPEEDS AND IT SEEMS LIKE ONE TIRE HITS THE BUMP OR DIP AND THEN THE OTHER AND IT GOES INTO SEVERE VIBRATIONS FOR SEVERAL SECONDS. *TR
NHTSA ODI #10265279
72,000 miles · Mar 10, 2009
Steering
STEERING JERKS TO RIGHT THEN PULLS LEFT AFTER CORRECTION THEN OSCILLATES LEFT AND RIGHT. WON'T CENTER AFTER MAKING A CORNER. OCCURS ALL THE TIME. TIRES WERE ROTATED, BALANCED AND PROPERLY INFLATED AND LUG NUTS TIGHTENED BALL JOINTS AND LINKAGES WERE INSPECTED TO NO AVAIL. *TR
NHTSA ODI #10261420
30,000 miles · Feb 23, 2009
SteeringSuspension
2005 FORD F-350 SUPER DUTY. WHEN DRIVING AT HIGHWAY SPEEDS AND CROSSING ROUGH BRIDGE ABUTMENTS OR OTHER UNEVEN SURFACES, WHOLE TRUCK BEGINS TO SHAKE UNCONTROLLABLY AND SOMETIMES LASTS FOR SEVERAL MINUTES BEFORE SETTLING DOWN. THIS IS A SEVER PROBLEM AS I'M UNABLE TO STEER OR CONTROL THE TRUCK. I'VE COMPLAINED SEVERAL TIMES TO…
Read full complaint
2005 FORD F-350 SUPER DUTY. WHEN DRIVING AT HIGHWAY SPEEDS AND CROSSING ROUGH BRIDGE ABUTMENTS OR OTHER UNEVEN SURFACES, WHOLE TRUCK BEGINS TO SHAKE UNCONTROLLABLY AND SOMETIMES LASTS FOR SEVERAL MINUTES BEFORE SETTLING DOWN. THIS IS A SEVER PROBLEM AS I'M UNABLE TO STEER OR CONTROL THE TRUCK. I'VE COMPLAINED SEVERAL TIMES TO MY DEALER AND THEY SAY THERE'S NOTHING WRONG WITH THE TRUCK. I DISAGREE AND BELIEVE THIS IS A REAL SAFETY HAZARD. *TR
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.
Consequence & remedy
Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
2005 Ford F-350 Sd Problems, Complaints & Recalls | Skip That Year
Illustration