IllustrationWHEN I HIT A SMAL BUMP IN ROAD TRAVEL 60 MPH FRONT END OF VEHICLE VIBRATED VIOLENTLY AS WELL AS STEERING WHEEL OUT OF CONTROL. COULD BARELY KEEP CONTROL OF STEERING WHEEL. WAS ON INTERSTATE HIGHWAY HAD TO COME TO COMPLETE STOP
2014 Ford F-250
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2014 Ford F-250 do not stand out strongly from the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
1125–50K
1750–75K
1575–100K
23100–150K
5150K+
75 reports with mileage · 67 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 81 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports0 injury reports
Steering complaints
74 reportsDEATH WOBBLE
WHILE DRIVING, I EXPERIENCE A SEVERE AND HORRIFYING 'DEATH WOBBLE' IN MY STEERING WHEEL, AT WHICH TIME THE ENTIRE FRONT END OF MY TRUCK VIOLENTLY SHAKES. IT BECOMES DIFFICULT TO CONTROL IT AND FORCES ME TO APPLY MY BRAKES IN ORDER TO REGAIN CONTROL. THIS HAS BEEN HAPPENING FOR ABOUT 8 MONTHS AND HAPPENS OFTEN. IT HAPPENS AT VARI…
Read full complaint
WHILE DRIVING, I EXPERIENCE A SEVERE AND HORRIFYING 'DEATH WOBBLE' IN MY STEERING WHEEL, AT WHICH TIME THE ENTIRE FRONT END OF MY TRUCK VIOLENTLY SHAKES. IT BECOMES DIFFICULT TO CONTROL IT AND FORCES ME TO APPLY MY BRAKES IN ORDER TO REGAIN CONTROL. THIS HAS BEEN HAPPENING FOR ABOUT 8 MONTHS AND HAPPENS OFTEN. IT HAPPENS AT VARIOUS SPEEDS. NOBODY APPEARS TO KNOW HOW TO FIX IT.
WHILE ACCELERATING ON THE ENTRANCE RAMP TO GET ON THE HIGHWAY, MY 2014 FORD F-250 SUPERDUTY WITH 142,000 MILES BEGAN TO VIOLENTLY SHAKE UNCONTROLLABLY. I HAD BARELY REACHED 45-50 MILES PER HOUR WHEN IT HAPPENED. THE SHAKE WAS STRONG ENOUGH TO THROW MY HANDS OFF THE STEERING WHEEL. I WAS ABLE TO SAFELY SLOWDOWN AND PULL THE TRUCK…
Read full complaint
WHILE ACCELERATING ON THE ENTRANCE RAMP TO GET ON THE HIGHWAY, MY 2014 FORD F-250 SUPERDUTY WITH 142,000 MILES BEGAN TO VIOLENTLY SHAKE UNCONTROLLABLY. I HAD BARELY REACHED 45-50 MILES PER HOUR WHEN IT HAPPENED. THE SHAKE WAS STRONG ENOUGH TO THROW MY HANDS OFF THE STEERING WHEEL. I WAS ABLE TO SAFELY SLOWDOWN AND PULL THE TRUCK OFF THE ROAD THEREAFTER. I AM CONCERNED ABOUT THE DRIVABILITY OF THIS TRUCK AND HAVE RAISED A CONCERN WITH FORD AND THE DEALER THAT SOLD ME THE TRUCK.
VEHICLE WILL HAVE VIOLENT SHAKING AT HIGHWAY SPEEDS KNOW AS A "DEATH WOBBLE". DEATH WOBBLE HAPPENED AT DIFFERENT SPEEDS AND ON DIFFERENT ROAD TERRAINS. THIS ISSUES ALSO HAPPENED WHEN AT HIGHWAY SPEEDS AND BRAKING AROUND CURVES.
DRIVING AT 70 MILES PER HOUR ON A STATE HWY MY FRONT END STARTED SHAKING VIOLENTLY. IT ALMOST CAUSED ME TO CRASH ,I APPLIED THE BRAKES BUT MADE IT WORSE.FINALLY WAS ABLE TO REGAIN CONTROL AND STOPPED.
WHEN DRIVING APPROXIMATELY 58MPH ON CITY ROADS OR INTERSTATE A SLIGHT VIBRATION STARTS AND TURNS INTO AN UNCONTROLLABLE WOBBLE IN FRONT TIRES AND STEERING WHEEL. NO WAY TO POWER THRU THE VIBRATION YOU HAVE TO COME TO ALMOST A COMPLETE STOP AT TIMES FOR WOBBLE TO STOP.
MY 2014 F250 HAS SINCE AROUND 80K MILES HAD AN UNCONTROLLABLE WOBBLE WHEN AT LOW HIGHWAY SPEEDS HITTING EVEN THE SMALLEST BUMP IN THE ROAD. AFTER MULTIPLE ALIGNMENTS AND TIRE CHANGES MY DEALER ADMITTED THAT ITS KNOWN AS "DEATH WOBBLE" AND I NEED TO DO THOUSANDS OF DOLLARS IN REPAIRS THAT ARE VERY COMMON. I AM AT 140K NOW AND THE…
Read full complaint
MY 2014 F250 HAS SINCE AROUND 80K MILES HAD AN UNCONTROLLABLE WOBBLE WHEN AT LOW HIGHWAY SPEEDS HITTING EVEN THE SMALLEST BUMP IN THE ROAD. AFTER MULTIPLE ALIGNMENTS AND TIRE CHANGES MY DEALER ADMITTED THAT ITS KNOWN AS "DEATH WOBBLE" AND I NEED TO DO THOUSANDS OF DOLLARS IN REPAIRS THAT ARE VERY COMMON. I AM AT 140K NOW AND THEY FINALLY ADMITED THAT ITS A SYSTEMIC PROBLEM
I WAS ACCELERATING UP THE ON-RAMP ONTO A FREEWAY WHEN I ENCOUNTERED SOME ROUGH PAVEMENT ON THE OVERPASS. THE FRONT OF THE TRUCK BEGAN TO SHAKE VIOLENTLY. I HAD DIFFICULTY HOLDING ONTO THE STEERING WHEEL AND THE TRUCK BEGAN HEADING TOWARD THE RIGHT SIDE GRASSY MEDIAN. I WAS ABLE TO SLOW BY LETTING OFF THE ACCELERATOR. I WAS AFRAI…
Read full complaint
I WAS ACCELERATING UP THE ON-RAMP ONTO A FREEWAY WHEN I ENCOUNTERED SOME ROUGH PAVEMENT ON THE OVERPASS. THE FRONT OF THE TRUCK BEGAN TO SHAKE VIOLENTLY. I HAD DIFFICULTY HOLDING ONTO THE STEERING WHEEL AND THE TRUCK BEGAN HEADING TOWARD THE RIGHT SIDE GRASSY MEDIAN. I WAS ABLE TO SLOW BY LETTING OFF THE ACCELERATOR. I WAS AFRAID THAT BRAKING MIGHT CAUSE ME TO LOSE CONTROL ALTOGETHER. AT REDUCED SPEED THE SHAKING STOPPED. LOOKING IN MY MIRROR I COULD TELL THAT THE DRIVER BEHIND ME SAW WHAT WAS HAPPENING AND HAD BACKED OFF SOME DISTANCE FROM ME. I HAVE FELT THE SHAKING SEVERAL TIMES SINCE THE ORIGINAL OCCURRENCE BUT IT HAS NOT BEEN AS VIOLENT AS THE FIRST TIME.
AT APPROXIMATELY 181,000 THIS VEHICLE EXHIBITED "SUSTAINED STEERING WHEEL OSCILLATION" (AKA DEATH WOBBLE). THE VEHICLE WAS TAKEN TO A NON-FORD ASE CERTIFIED MECHANIC AND REPAIRED PER FORD TSB 18-2268, BUT DID NOT CORRECT THE PROBLEM. FORD HAS CLAIMED THIS VEHICLE IS NOT ON THEIR LIST OF VEHICLES SUBJECT TO CORRECTION OR MITIGA…
Read full complaint
AT APPROXIMATELY 181,000 THIS VEHICLE EXHIBITED "SUSTAINED STEERING WHEEL OSCILLATION" (AKA DEATH WOBBLE). THE VEHICLE WAS TAKEN TO A NON-FORD ASE CERTIFIED MECHANIC AND REPAIRED PER FORD TSB 18-2268, BUT DID NOT CORRECT THE PROBLEM. FORD HAS CLAIMED THIS VEHICLE IS NOT ON THEIR LIST OF VEHICLES SUBJECT TO CORRECTION OR MITIGATION. THE ONLY SUSPENSION MODIFICATIONS WERE AFTERMARKET BRAKES AND SHOCKS (I.E. HIGH QUALITY COMPONENTS). THE VEHICLE NOW HAS APPROXIMATELY 184,000 MILES AND STILL EXHIBITS SEVERE OSCILLATIONS WHEN TRAVELING OVER A BUMP OR ROUGH SURFACE, CAUSING HAZARDOUS DRIVING CONDITIONS AND DANGER TO OTHER VEHICLES WHEN A SUDDEN SLOW-DOWN OR STOP IS NEEDED TO REGAIN CONTROL OF THE VEHICLE.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ14005 · Vehicle Commanded Engine Shutdown
Opened Jan 13, 2015 · Closed Mar 15, 2016
Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Additional source detail variants (5)
Electrical System:software
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:engine:diesel
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.