← New search

2012 Ford F-250

Owner reports · Recalls · Investigations

More warning signs than most F-250 years

Owner complaints for the 2012 Ford F-250 are substantially higher than the model-year median of 119.

About this comparison →

When problems were reported

Mileage at the reported incident

198 reports with mileage · 68 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Suspension. Review the 125 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Steering. Review the 112 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

4 crash reports5 fire reports4 injury reports

Engine complaints

27 reports
Clear category filter
Mileage unknown · Jul 23, 2025
Electrical SystemEnginePower Train

I just had to replace the ECM because it fired. after replacing that it still won't start. I've talked to multiple people who have had the same problem.

NHTSA ODI #11675751

Mileage unknown · Jun 9, 2025
Electrical SystemEngineFuel/propulsion System

it keeps throwing a check engine light for miss fire but ive replaced all of the ignition and fuel parts and it keeps happening now its loosing power and getting hot for no reason.

NHTSA ODI #11665869

Mileage unknown · Jun 6, 2024
Engine

Leaving oil spots on ground. Inside Cab smelling very strongly like burnt oil.

NHTSA ODI #11592865

42,500 miles · Feb 7, 2024
Engine

The contact owns a 2012 Ford F-250. The contact stated while driving 20 MPH, the vehicle began to make an abnormal cranking sound with several unknown warning lights flashing on the instrument panel. Due to the failure, the vehicle was towed to a dealer where it was discovered that piston rod #3 had snapped inside the engine and…

Read full complaint

The contact owns a 2012 Ford F-250. The contact stated while driving 20 MPH, the vehicle began to make an abnormal cranking sound with several unknown warning lights flashing on the instrument panel. Due to the failure, the vehicle was towed to a dealer where it was discovered that piston rod #3 had snapped inside the engine and that the engine needed to be replaced. After a year, the engine was replaced; however, three weeks later, the check engine warning light illuminated. The vehicle was taken back to the dealer where the contact was informed that the exhaust gas cooling system had failed and needed to be replaced. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The vehicle had yet to be repaired. The failure mileage was approximately 42,500.

NHTSA ODI #11570520

Mileage unknown · Dec 31, 2022
Engine

Ford previously issued warranty extension for this vehicle 18-M-01 related to the replacement of the reductant heater unit. I acquired the subject vehicle above and had the repair done at my expense on September 9, 2015 with 115,710 miles on the vehicle using an OEM part. Eventually, Ford would reimburse me for this expense. Th…

Read full complaint

Ford previously issued warranty extension for this vehicle 18-M-01 related to the replacement of the reductant heater unit. I acquired the subject vehicle above and had the repair done at my expense on September 9, 2015 with 115,710 miles on the vehicle using an OEM part. Eventually, Ford would reimburse me for this expense. The truck currently has 150,000 miles and once again the DEF heater failed . So, roughly 35,000 miles on a single unit. That seems ridiculous to me that an emissions part would fail after a mere 35,000 miles. My experience is far from being alone and others have reported similar experiences on internet forums. I will preserve this unit that failed for 60 days after the submission of this claim in case Ford or you would like to inspect it. Unfortunately, the result of having to perform repeated repairs is that people decide to remove and bypass the DEF system completely. That seems to be a terrible outcome for the environment. However, in communities where there is no emissions testing, no one will find out. Please require Ford to extend the warranty on this part again.

NHTSA ODI #11499624

Mileage unknown · Aug 6, 2022
EnginePower Train

Very intermittently, when I brake this vehicle to bring it to a stop, the engine will start to rev uncontrollably. I have to practically "stand" on the brake to keep it from charging forward. I have to turn off the truck to stop this high speed revving. After this happened 3 times in 2 months we took it to the dealer to check. T…

Read full complaint

Very intermittently, when I brake this vehicle to bring it to a stop, the engine will start to rev uncontrollably. I have to practically "stand" on the brake to keep it from charging forward. I have to turn off the truck to stop this high speed revving. After this happened 3 times in 2 months we took it to the dealer to check. There was nothing on the floor that could cause the gas pedal to accelerate. The dealer in Kingwood, WV could not duplicate, and found nothing wrong when inspected. We only use the truck once or twice a month so it is a low use vehicle. For this reason the problem does not occur frequently enough to replicate "on demand". While there was not a crash, it almost revved through an intersection and almost ran into another vehicle. Fortunately I was able to throw it into park (Not Good for the vehicle) and then turn it off.

NHTSA ODI #11477905

Mileage unknown · Jun 20, 2022
Engine

Many early model vehicles with the 6.7 Powerstroke experience broken exhaust manifold bolts. Ford corrected this problem after the first few years of known defects but never issued a recall for the faulty design on 2011-2012 models. The exhaust leak can lead to a lack of power, “limp mode”, and/or a fire as the exhaust is locate…

Read full complaint

Many early model vehicles with the 6.7 Powerstroke experience broken exhaust manifold bolts. Ford corrected this problem after the first few years of known defects but never issued a recall for the faulty design on 2011-2012 models. The exhaust leak can lead to a lack of power, “limp mode”, and/or a fire as the exhaust is located on top of the engine (not a common design). While Ford is aware of the problem, they’ve done nothing to rectify the situation.

NHTSA ODI #11470023

101,000 miles · Mar 20, 2021
EngineInjury

ON MY 2012 FORD F250 IT HAS THE CRANK CASE VENTILATION FILTER THAT LEAKS OIL INTO THE INTAKE I HAVE SEEN ALOT OF POST ABOUT THIS EXACT PROBLEM IT SORTA FEELS LIKE FORD WANTS OUR TRUCKS TO BREAK SOBWE HAVE TO BUY A NEW ONE THE FILTER IS CHEAP BUT ITS A DEFECT THAT THE DEALER MADE THIS TRUCK HAS BEEN IN THE SHOP TWICE ALREADY BC O…

Read full complaint

ON MY 2012 FORD F250 IT HAS THE CRANK CASE VENTILATION FILTER THAT LEAKS OIL INTO THE INTAKE I HAVE SEEN ALOT OF POST ABOUT THIS EXACT PROBLEM IT SORTA FEELS LIKE FORD WANTS OUR TRUCKS TO BREAK SOBWE HAVE TO BUY A NEW ONE THE FILTER IS CHEAP BUT ITS A DEFECT THAT THE DEALER MADE THIS TRUCK HAS BEEN IN THE SHOP TWICE ALREADY BC OF THE DEF SENDING UNIT AND NOW WITH THIS PROBLEM THIA TRUCK ONLY HAS 101K MILES AND I FORGOT TO SAY WHEN THIS HAPPENS IT BUILDS UP EXTREAM PRESSURE ON THE OIL CAP WHEN IT OPENS UP IT THROWS OIL IN YOUR FACE I NEEDED TO GO TO THE EYE DOCTOR SO I COULD GET A FLUSH TRUST ME FORD KNOWS ABOUT THE PROBLEM ON THESE 6.7 THEY JUST HAVENT FIGURED OUT A SOLUTION TO KEEP THERE FORD CUSTOMERS SATISFIED I WOULD LIKE THEM TO PUT IN A NEW CCV FILTER BECAUSE OF THERE POOR DESIGN ON THIS TRUCK..

NHTSA ODI #11403986

174,000 miles · Feb 5, 2021
EnginePower Train

THE 6.2 ENGINE HAS BROKEN VALVE SPRINGS 3 TIMES NOW. FIRST TWO TIMES WAS ABLE TO JUST REPLACE THE BROKEN VALVE SPRING. THE 3RD TIME IT BROKE A VALVE SPRING IT DROPPED THE VALVE IN THE MOTOR AND PUT HOLE RIGHT THROUGH THE BLOCK AND SEIZED THE MOTOR ALMOST CAUSING ME TO WRECK

NHTSA ODI #11394899

Mileage unknown · Mar 18, 2020
EngineSuspension

EGR SISTEM FAILS TO SOON AND I HAVE DEAD WOBBLE FRONT SUSPENSION

NHTSA ODI #11318537

Official recalls

1

11V582000 · Power Train:automatic Transmission

Dec 8, 2011

FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150 VEHICLES MANUFACTURED FROM SEPTEMBER 9, 2011, THROUGH SEPTEMBER 22, 2011, AND MODEL YEAR 2012 F-250, F-350, F-450 AND F-550 HEAVY DUTY VEHICLES MANUFACTURED FROM SEPTEMBER 12, 2011, THROUGH SEPTEMBER 22, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 114, “THEFT PROTECTION.” THE TRANSMISSION CAN BE SHIFTED OUT OF THE PARK POSITION WITHOUT PRESSING THE BRAKE PEDAL DUE TO BRAKE SHIFT INTERLOCK SWITCH PROBLEM.

Consequence & remedy

Consequence: THIS WILL ALLOW THE OPERATOR TO INADVERTENTLY SHIFT THE VEHICLE INTO GEAR WITHOUT THE BRAKE PEDAL BEING DEPRESSED, INCREASING THE RISK OF A CRASH OR INJURY TO A NEARBY PEDESTRIAN.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE BRAKE SHIFT INTERLOCK SWITCH FUNCTION AND REPLACE THE SWITCH IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2011. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

1

RQ14005 · Vehicle Commanded Engine Shutdown

Opened Jan 13, 2015 · Closed Mar 15, 2016

Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Additional source detail variants (5)

Electrical System:software

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Engine And Engine Cooling:engine:diesel

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Engine And Engine Cooling:exhaust System:emission Control

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Engine And Engine Cooling:exhaust System

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Engine

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.