NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
14 reportsClear category filterMileage unknown · Apr 6, 2025
Electrical SystemEnginePower Train
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start bac…
Read full complaint
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue
NHTSA ODI #11653078
Mileage unknown · Aug 5, 2024
Electrical SystemPower TrainSteering
Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road
NHTSA ODI #11606568
Mileage unknown · May 25, 2022
Power Train
Transmission has a hole in it. Linkage inside broke and caused hole on case. Can’t use item for a core due to this. Happened while driving home from just across town.
NHTSA ODI #11466076
116,000 miles · May 27, 2019
Power Train
ON DECELERATION THE ENGINE STALLS AFTER DRIVEN FOR 10-15 MINUTES. THE CHECK ENGINE LIGHT COMES ON. I DON'T NOTICE THE STALL UNTIL I APPLY THE GAS PEDAL. A COUPLE OF TIMES I WAS TURNING, I HAD TO SLOW DOWN SEVERELY TO GIVE ME MORE TIME TO TURN( NO POWER STEERING). I ALMOST HAD AN ACCIDENT SEVERAL TIMES. THE CODE WAS A THROTTLE BO…
Read full complaint
ON DECELERATION THE ENGINE STALLS AFTER DRIVEN FOR 10-15 MINUTES. THE CHECK ENGINE LIGHT COMES ON. I DON'T NOTICE THE STALL UNTIL I APPLY THE GAS PEDAL. A COUPLE OF TIMES I WAS TURNING, I HAD TO SLOW DOWN SEVERELY TO GIVE ME MORE TIME TO TURN( NO POWER STEERING). I ALMOST HAD AN ACCIDENT SEVERAL TIMES. THE CODE WAS A THROTTLE BODY CODE P2104.I REPLACED THE THROTTLE BODY. AFTER A FEW MONTHS THE STALLING OCCURRED AGAIN. THIS IS DANGEROUS. AT THIS TIME THE STALLING HASN'T HAPPEN VERY OFTEN BUT THE CODE IS STILL THERE, NOW I HAVE TO SMOG THIS VEHICLE. I SEE ON THE INTERNET THERE HAVE BEEN OTHER PEOPLE WITH THIS CONDITION.
NHTSA ODI #11210202
85,000 miles · Jun 23, 2017
Power Train
TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR IN NEUTRAL, RESTARTED THE VEHICLE, AND WAS ABLE TO RESUME DRIVING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR IN NEUTRAL, RESTARTED THE VEHICLE, AND WAS ABLE TO RESUME DRIVING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC (BOLAN TRANSMISSION SHOP) WHO DIAGNOSED THAT THE TRANSMISSION WAS BURNED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.
NHTSA ODI #11000884
57,265 miles · Dec 18, 2015
Power Train
NOTICED A CLOUD OF SMOKE BEHIND VEHICLE WHILE DRIVING 55 MPH ON HIGHWAY. UPON INSPECTION FOUND IT WAS LEAKING TRANSMISSION FLUID FROM HOLE IN TOP OF TRANSMISSION ONTO EXHAUST (EXACT SAME PROBLEM AS DESCRIBED IN FORD BULLETIN 05B27) HAD TO REPLACE TRANSMISSION AT 57,265 MILES AT A COST OF $4,000.00. FORD WOULD NOT WARRANTY IT.
NHTSA ODI #10811057
29,000 miles · Jun 5, 2014
Engine And Engine CoolingPower Train
TL * THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 65 MPH DOWN AN INCLINE, HE SHIFTED INTO NEUTRAL AND RELEASED THE CLUTCH WHEN THE VEHICLE STALLED. THE CONTACT MENTIONED THAT ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE …
Read full complaint
TL * THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 65 MPH DOWN AN INCLINE, HE SHIFTED INTO NEUTRAL AND RELEASED THE CLUTCH WHEN THE VEHICLE STALLED. THE CONTACT MENTIONED THAT ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO RECTIFY THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 31,000. UPDATED 08/12/14*LJ
NHTSA ODI #10596438
88,094 miles · Jan 28, 2013
Engine And Engine CoolingPower Train
REGULAR DRIVING ON OPEN ROAD , NO HARSH CONDITIONS - POWER LOSS, WITHOUT ANY WARNING - NO ENGINE LIGHTS OR WARNNGS - SUDDEN DECELLERATION , JERKY RESPONSE MORE DECELLERATION - LIMP OFF RAMP , LIMP HOME. TURBO SOUNDING WHINY AND DIFFERENT , NO RESPONSE TO ADDED PRESSING ON GAS , NOR STOP , RESTART. HAS BEEN EVALUATED AT DEALE…
Read full complaint
REGULAR DRIVING ON OPEN ROAD , NO HARSH CONDITIONS - POWER LOSS, WITHOUT ANY WARNING - NO ENGINE LIGHTS OR WARNNGS - SUDDEN DECELLERATION , JERKY RESPONSE MORE DECELLERATION - LIMP OFF RAMP , LIMP HOME. TURBO SOUNDING WHINY AND DIFFERENT , NO RESPONSE TO ADDED PRESSING ON GAS , NOR STOP , RESTART. HAS BEEN EVALUATED AT DEALERSHIP MANY TIMES AND MANY PROBLEMS CORRECTED, PAID FOR YET NOTHING WORKS - REGULAR MAINTENANCE IS PREFORMED ON THIS VEHICLE , MUCH CARE IS TAKEN BY OWNER. VERY DANGEROUS CONDITION WILL CAUSE A WRECK , CAN NO LONGER ENDANGER LIVES, WE DO EVERYTHING THE DEALERS ASK AND CONDITION RETURNS. MUST EVALUATE AT NEW DEALERSHIP AND WHETHER OR NOT CAN KEEP. I AM GETTING POST TRAUMATIC STRESS FROM THIS VEHICLE AND IT'S LACK OF UNRELIABLE TRANSPORT . I FEAR GETTING INTO THE CAR FOR ANY DISTANCE - IF I HAVE TO RETURN TO THE BANK , I MUST ADVISE THEM NOT TO RE-SELL LIABILITY REASONS AND INFORM THEM OF CHRONIC LEMON PROBLEMS IN THIS MODEL F250 6.0 FORD TRUCK . *TR
NHTSA ODI #10494921
30,070 miles · Oct 25, 2012
EnginePower Train
WHILE AT A DEAD STOP, PLACED TRUCK IN DRIVE AND THE ENGINE SUDDENLY ACCELERATED TO FULL POWER LUNGING THE VEHICLE FORWARD 10' WHILE I SIMULTANEOUSLY APPLIED BOTH FEET TO THE BRAKE FOR MAXIMUM STOPPING POWER. THIS IS THE THIRD TIME IN TWO TO THREE MONTHS THIS HAS HAPPENED. NO CHECK ENGINE LIGHTS ARE ON. TOOK MY CAR TO THE LOCA…
Read full complaint
WHILE AT A DEAD STOP, PLACED TRUCK IN DRIVE AND THE ENGINE SUDDENLY ACCELERATED TO FULL POWER LUNGING THE VEHICLE FORWARD 10' WHILE I SIMULTANEOUSLY APPLIED BOTH FEET TO THE BRAKE FOR MAXIMUM STOPPING POWER. THIS IS THE THIRD TIME IN TWO TO THREE MONTHS THIS HAS HAPPENED. NO CHECK ENGINE LIGHTS ARE ON. TOOK MY CAR TO THE LOCAL FORD DEALER AND WAS TOLD BY THE SERVICE MANAGER THAT THEY HAVE NEVER HEARD OF THIS PROBLEM BEFORE. RESEARCHED THE INTERNET ONLY TO FIND LOTS OF OTHER SIMILAR COMPLAINTS. ORIGINALLY THOUGHT IT WAS HUMAN ERROR, FLOOR MAT, OR SIMILAR PROBLEM... BUT THIS LAST TIME, I WAS PREPARED BECAUSE OF PREVIOUS INCIDENTS. THIS PROBLEM CAN CAUSE A TERRIBLE ACCIDENT AND MAY EVEN RESULT IN DEATH. *TR
NHTSA ODI #10482166
48,000 miles · Jan 17, 2011
Power Train
2005 FORD F250 SD HAD CRACKED TRANSMISSION BECUASE OF LOW/REVERSE SNAP RING FAILURE IN THE 5R110 TORQSHIFT TRANSMISSION. FORD ISSUED A CUSTOMER SATISFACTION PROGRAM 05B27 BUT PUT AN EXPIRATION DATE ON IT. THE PROGRAM WAS NOT EVER FOR A WHOLE YEAR. FORD IS NOT WILLING TO REIMBURSE OR ISSUE A RECALL WHEN THEY KNOW THIS IS A PROBLE…
Read full complaint
2005 FORD F250 SD HAD CRACKED TRANSMISSION BECUASE OF LOW/REVERSE SNAP RING FAILURE IN THE 5R110 TORQSHIFT TRANSMISSION. FORD ISSUED A CUSTOMER SATISFACTION PROGRAM 05B27 BUT PUT AN EXPIRATION DATE ON IT. THE PROGRAM WAS NOT EVER FOR A WHOLE YEAR. FORD IS NOT WILLING TO REIMBURSE OR ISSUE A RECALL WHEN THEY KNOW THIS IS A PROBLEM. THE SNAP RING FAILED INSIDE AND BUSTED MY TRANSMISSION. ALOT OF PEOPLE HAVE EXPERIENCED THIS PROBLEM AND THERE NEEDS TO BE A RECALL ON THIS TRANSMISSION. *TR
NHTSA ODI #10376895
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration