NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
26 reportsClear category filterMileage unknown · Apr 6, 2025
Electrical SystemEnginePower Train
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start bac…
Read full complaint
Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue
NHTSA ODI #11653078
246,808 miles · Oct 15, 2024
Engine
The contact owns a 2005 Ford F-250. The contact stated while driving at an undisclosed speed, the contact heard a loud rumbling noise that sounded like rocks in the engine. In addition, the contact stated that when the vehicle was parked and the engine was turned off, the vehicle was started, however, the vehicle did not star…
Read full complaint
The contact owns a 2005 Ford F-250. The contact stated while driving at an undisclosed speed, the contact heard a loud rumbling noise that sounded like rocks in the engine. In addition, the contact stated that when the vehicle was parked and the engine was turned off, the vehicle was started, however, the vehicle did not start. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that her husband was an independent mechanic and had recently replaced several unknown parts, however the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was 246,808.
NHTSA ODI #11619962
36,000 miles · May 24, 2021
Electrical SystemEngine
The contact owns a 2005 Ford F-250. The contact stated while driving at various speeds, the vehicle loss motive power. The vehicle was later restarted and the vehicle operated as designed. The vehicle was taken to the local dealer who replaced the fuel injection control module however, the failure recurred. The manufacturer was …
Read full complaint
The contact owns a 2005 Ford F-250. The contact stated while driving at various speeds, the vehicle loss motive power. The vehicle was later restarted and the vehicle operated as designed. The vehicle was taken to the local dealer who replaced the fuel injection control module however, the failure recurred. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in NHTSA campaign number 05V270000 (Electrical System). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 36,000.
NHTSA ODI #11418273
95,000 miles · Feb 19, 2021
Electrical SystemEngine
WHEN DRIVING, THE TRUCK WILL DIE. SOMETIMES TRUCK CAN BE RESTARTED OTHER TIMES HAD TO HAVE IT TOLLED. WE HAVE REPLACED FUEL PRESSURE REGULATOR, REGULATOR, START SWITCH R&R INSTRUMENT CLUSTER, ALTERNATOR, BATTERIES AND THE PROBLEM STILL EXIST. HAVE TAKEN IT TO A FORD DEALER AND THEY CAN NOT FIND THE PROBLEM. THEY SAY IT IS NOT…
Read full complaint
WHEN DRIVING, THE TRUCK WILL DIE. SOMETIMES TRUCK CAN BE RESTARTED OTHER TIMES HAD TO HAVE IT TOLLED. WE HAVE REPLACED FUEL PRESSURE REGULATOR, REGULATOR, START SWITCH R&R INSTRUMENT CLUSTER, ALTERNATOR, BATTERIES AND THE PROBLEM STILL EXIST. HAVE TAKEN IT TO A FORD DEALER AND THEY CAN NOT FIND THE PROBLEM. THEY SAY IT IS NOT COVERED ON RECALL 05V270000
NHTSA ODI #11396937
110,000 miles · Mar 1, 2019
Engine
ENGINE WOULD PUT OUT WHITE SMOKE THEN WOULD START TO OVER HEAT.
NHTSA ODI #11183342
45,000 miles · Aug 6, 2018
Engine
THIS PARTICULAR MODEL AND YEAR WITH THE 6.0 LITRE ENGINE (2005 ) IS NORTORIOUS FOR THE OIL COOLER TO BLOW UP LEAVING YOU STRANDED WHEREVER. WHEN IT HAPPENED TO ME I WAS PULLING A 33FT 5TH WHEEL TRAILER AND ALMOST WRECKED. FORD KNOWS ALL ABOUT THIS FAULTY PIECE OF EQUIPMENT YET DOESN'T RECALL IT AND SHOULD BE HELD ACCOUNTABLE FOR…
Read full complaint
THIS PARTICULAR MODEL AND YEAR WITH THE 6.0 LITRE ENGINE (2005 ) IS NORTORIOUS FOR THE OIL COOLER TO BLOW UP LEAVING YOU STRANDED WHEREVER. WHEN IT HAPPENED TO ME I WAS PULLING A 33FT 5TH WHEEL TRAILER AND ALMOST WRECKED. FORD KNOWS ALL ABOUT THIS FAULTY PIECE OF EQUIPMENT YET DOESN'T RECALL IT AND SHOULD BE HELD ACCOUNTABLE FOR REPLACING IT. IT COST ME $6000 TO GET MY TRUCK FIXED. THE FAULTY PIECE WAS INSTALLED BY FORD AND SHOULD BE RESPONSIBLE BY FORD FOR REPAIR COSTS
NHTSA ODI #11118168
20,000 miles · May 9, 2018
Engine
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE DRIVING VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. FERRARIO FORD LINCOLN (2472 CORNING RD, ELMIRA, NY) WAS CONTACTED AND DIAGNOSED THE FAILURE AS A HIGH PRESSURE OIL PUMP MALFUNCTION AND THE PART WOU…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE DRIVING VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. FERRARIO FORD LINCOLN (2472 CORNING RD, ELMIRA, NY) WAS CONTACTED AND DIAGNOSED THE FAILURE AS A HIGH PRESSURE OIL PUMP MALFUNCTION AND THE PART WOULD NEED TO BE REPLACED. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000.
NHTSA ODI #11092623
205,000 miles · Dec 14, 2017
Engine
TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 25 MPH, THE ENGINE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE LOST POWER, ROLLED BACK DOWN THE HILL, AND STOPPED. THE VEHICLE WAS TOWED ON DECEMBER 10TH TO LEGACY FORD (2906 ISLAND LAGRANDE, OR 97850). THE DEALER STATED THAT THERE WERE NO RECALLS ON THE V…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 25 MPH, THE ENGINE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE LOST POWER, ROLLED BACK DOWN THE HILL, AND STOPPED. THE VEHICLE WAS TOWED ON DECEMBER 10TH TO LEGACY FORD (2906 ISLAND LAGRANDE, OR 97850). THE DEALER STATED THAT THERE WERE NO RECALLS ON THE VEHICLE FOR THE FICM. THE DEALER MADE TWO REPAIRS DUE TO AN UNKNOWN RECALL REGARDING THE PRESSURE SENSOR AND RECALIBRATION. THE MANUFACTURER WAS CONTACTED AT 1-800-392-3673 AND STATED THAT THERE WERE NO RECALLS ON THE FICM FOR THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED DUE TO NOT BEING ABLE TO REGAIN POWER. THE VEHICLE HAD NOT BEEN REPAIRED AND REMAINED AT THE DEALER. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 205,000.
NHTSA ODI #11054691
58,000 miles · Oct 21, 2017
EngineStructureUnknown Or Other
TRUCK FRAME SEEMS TO BE ROTTING. TOLD 3-4 YEARS AT MOST BY MECHANIC. ALREADY REPLACES FUEL TANK BRACKETS, ANY RUST RECALLS AS IN ONES TOYOTA DID A WHILE AGO/ ALSO TOLD AT 1000,000 MI WILL NEED SPARK PLUG CHANGE (ONLY59000 NOW) AND THERE WAS A RECALL OF THIS PLUG REMOVAL COULD BE DIFFICULT. ANY HELP
NHTSA ODI #11035371
215,000 miles · Sep 6, 2016
Engine
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE DID NOT OCCUR ONCE THE VEHICLE WAS RESTARTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 215,000.
NHTSA ODI #10903817
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration