NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
17 reportsClear category filter29,000 miles · Jun 5, 2014
Engine And Engine CoolingPower Train
TL * THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 65 MPH DOWN AN INCLINE, HE SHIFTED INTO NEUTRAL AND RELEASED THE CLUTCH WHEN THE VEHICLE STALLED. THE CONTACT MENTIONED THAT ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE …
Read full complaint
TL * THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 65 MPH DOWN AN INCLINE, HE SHIFTED INTO NEUTRAL AND RELEASED THE CLUTCH WHEN THE VEHICLE STALLED. THE CONTACT MENTIONED THAT ALL OF THE WARNING LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO RECTIFY THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 31,000. UPDATED 08/12/14*LJ
NHTSA ODI #10596438
88,094 miles · Jan 28, 2013
Engine And Engine CoolingPower Train
REGULAR DRIVING ON OPEN ROAD , NO HARSH CONDITIONS - POWER LOSS, WITHOUT ANY WARNING - NO ENGINE LIGHTS OR WARNNGS - SUDDEN DECELLERATION , JERKY RESPONSE MORE DECELLERATION - LIMP OFF RAMP , LIMP HOME. TURBO SOUNDING WHINY AND DIFFERENT , NO RESPONSE TO ADDED PRESSING ON GAS , NOR STOP , RESTART. HAS BEEN EVALUATED AT DEALE…
Read full complaint
REGULAR DRIVING ON OPEN ROAD , NO HARSH CONDITIONS - POWER LOSS, WITHOUT ANY WARNING - NO ENGINE LIGHTS OR WARNNGS - SUDDEN DECELLERATION , JERKY RESPONSE MORE DECELLERATION - LIMP OFF RAMP , LIMP HOME. TURBO SOUNDING WHINY AND DIFFERENT , NO RESPONSE TO ADDED PRESSING ON GAS , NOR STOP , RESTART. HAS BEEN EVALUATED AT DEALERSHIP MANY TIMES AND MANY PROBLEMS CORRECTED, PAID FOR YET NOTHING WORKS - REGULAR MAINTENANCE IS PREFORMED ON THIS VEHICLE , MUCH CARE IS TAKEN BY OWNER. VERY DANGEROUS CONDITION WILL CAUSE A WRECK , CAN NO LONGER ENDANGER LIVES, WE DO EVERYTHING THE DEALERS ASK AND CONDITION RETURNS. MUST EVALUATE AT NEW DEALERSHIP AND WHETHER OR NOT CAN KEEP. I AM GETTING POST TRAUMATIC STRESS FROM THIS VEHICLE AND IT'S LACK OF UNRELIABLE TRANSPORT . I FEAR GETTING INTO THE CAR FOR ANY DISTANCE - IF I HAVE TO RETURN TO THE BANK , I MUST ADVISE THEM NOT TO RE-SELL LIABILITY REASONS AND INFORM THEM OF CHRONIC LEMON PROBLEMS IN THIS MODEL F250 6.0 FORD TRUCK . *TR
NHTSA ODI #10494921
30,000 miles · Feb 27, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STARTED TO JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE AND SENT A LETTER ADVISING TO CHECK THE TIRE INFL…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STARTED TO JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE AND SENT A LETTER ADVISING TO CHECK THE TIRE INFLATION PRESSURE LEVEL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 110,000.
NHTSA ODI #10449499
60,000 miles · Feb 27, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 50 MPH THE VEHICLE STARTED TO JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE DEALER COULD NOT DIAGNOSED THE PROBLEM. …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 50 MPH THE VEHICLE STARTED TO JERK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE DEALER COULD NOT DIAGNOSED THE PROBLEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 80,000.
NHTSA ODI #10449450
100,000 miles · Feb 17, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THERE WAS A SLIGHT LOSS IN ENGINE POWER WITH AN UNUSUAL NOISE. THE FAILURE BECAME MORE SEVERE OVER A PERIOD OF TIME AND OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DETECTED COOLANT SEEPA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH WHEN THERE WAS A SLIGHT LOSS IN ENGINE POWER WITH AN UNUSUAL NOISE. THE FAILURE BECAME MORE SEVERE OVER A PERIOD OF TIME AND OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DETECTED COOLANT SEEPAGE WHICH CAUSED SUBSTANTIAL DAMAGE TO THE ENGINE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10448316
105,000 miles · Feb 14, 2012
Engine And Engine Cooling
THE ABOVE VEHICLE HAS HAD MULTIPLE PROBLEMS DUE TO THE DESIGN OF THE ENGINE INCLUDING SUCH THINGS AS THE EGR COOLER, THE EGR VALVE (TWICE), THE FUEL INJECTOR CONTROL MOD (FICM), THE HIGH PRESSURE OIL REGULATOR SCREEN, (A .10 CENT PIECE 450.00 LABOR). IF YOU WILL SEARCH THIS ENGINE FROM 2003 TO 2007 YOU WILL FIND HUNDRED IF NOT T…
Read full complaint
THE ABOVE VEHICLE HAS HAD MULTIPLE PROBLEMS DUE TO THE DESIGN OF THE ENGINE INCLUDING SUCH THINGS AS THE EGR COOLER, THE EGR VALVE (TWICE), THE FUEL INJECTOR CONTROL MOD (FICM), THE HIGH PRESSURE OIL REGULATOR SCREEN, (A .10 CENT PIECE 450.00 LABOR). IF YOU WILL SEARCH THIS ENGINE FROM 2003 TO 2007 YOU WILL FIND HUNDRED IF NOT THOUSAND OF POST BY OWNERS OF THE 6.0 POWERSTROKE THAT ARE HAVING THE SAME PROBLEMS OVER AND OVER. FORD REFUSES TO DO ANYTHING TO HELP ANYONE AND THEY TOLD ME IN AN EMAIL YOU WERE THE ONLY ONES THAT CAN MAKE THEM HAVE A RECALL. I HOPE YOU WILL STEP UP AND HELP ALL OF US. FORD FILED SUIT AGAINST THE MANUFACTURE (INTERNATION/ NAVISTAR) OVER THIS ENGINES PROBLEMS BACK IN 2004 BUT THEY KEPT SELLING IT KNOWING IT HAD PROBLEMS THAT WOULD BE LEFT UP TO THE BUYERS OF THE VEHICLES, I WAS PERSONALLY TOLD BY A SALESMAN TO EXPECT 350,000 MILES FROM THIS ENGINE. IF YOU CAN NOT HELP ME AND THE OTHERS CAN YOU TELL ME WHAT ELSE I CAN DO? WILL IT TAKE LEGAL ACTION OR IS THERE ANOTHER PATH I CAN TAKE? *TR
NHTSA ODI #10447992
Mileage unknown · Jan 4, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THE FUMES ENTER THE CABIN AND MAKE THE VEHICLE OCCUPANTS DIZZY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE BOLTS FOR THE ENGINE MANIFOLD CORRODED AND FRACTURED. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE BECAUSE THE BOLTS WER…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THE FUMES ENTER THE CABIN AND MAKE THE VEHICLE OCCUPANTS DIZZY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE BOLTS FOR THE ENGINE MANIFOLD CORRODED AND FRACTURED. THE DEALER STATED THAT THIS WAS A KNOWN FAILURE BECAUSE THE BOLTS WERE METAL AND THE FRAME WAS ALUMINUM. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 55,000.
NHTSA ODI #10442346
20,000 miles · Oct 3, 2011
Engine And Engine CoolingStructure
FRAME IS RUSTING, HEADERS ARE LEAKING FROM RUST. *TR
NHTSA ODI #10428260
65,000 miles · Aug 10, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WOULD OVERHEAT AND THEN STALL. THE VEHICLE WOULD NOT RESTART AFTER THE FAILURES. BOTH THE DEALER AND MANUFACTURER WERE AWARE OF THE FAILURE; HOWEVER, THEY DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO REPLACED THE HIGH PR…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WOULD OVERHEAT AND THEN STALL. THE VEHICLE WOULD NOT RESTART AFTER THE FAILURES. BOTH THE DEALER AND MANUFACTURER WERE AWARE OF THE FAILURE; HOWEVER, THEY DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO REPLACED THE HIGH PRESSURE OIL PUMP, OIL SENDING UNIT, FUEL INJECTION CONTROL MODULE, AND THE EGR COOLER. AS A RESULT, THE HEAD GASKET BLEW OUT. NO ADDITIONAL REPAIRS WERE PERFORMED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 114,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10418376
Mileage unknown · Oct 18, 2010
Engine And Engine Cooling
2005 FORD F-250. CONSUMER STATES VEHICLE OVERHEATED AND BLEW OUT WHITE SMOKE WHILE DRIVING *TGW THE CONSUMER STATED UPON DOING RESEARCH, SHE DISCOVERED THERE WERE NUMEROUS COMPLAINTS FROM OTHER OWNERS WHO EXPERIENCED FAILURES WITH THE EGR COOLER.
NHTSA ODI #10360888
NHTSA investigations
2EA08007 · Violent Front End Oscillation
Opened Mar 14, 2008 · Closed Mar 31, 2009
Status: closed (inferred from source dates) · Suspension; Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:front
THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE07057 · Violent Front End Oscillation
Opened Nov 15, 2007 · Closed Mar 14, 2008
Status: closed (inferred from source dates) · Suspension; Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Additional source detail variants (2)
Suspension
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Suspension:front
ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.
Illustration