NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
13 reportsClear category filterMileage unknown · Jun 9, 2026
Electrical SystemEngineFuel/propulsion System
10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from…
Read full complaint
10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from 70 mph,to 50, 30, 15 in such a short period of time. Pulled over to "investigate" code failures we deemed as o2 sensors. Afterwards the truck started back up, no engine lights and drove as normal. Started using premium gasoline, hoping it would help. Started driving in right lane as much as possible but had a failure ocurr right in front of on ramp as well at interstate speeds. Had another family following us so they also witnessed and pulled over all incidents. Brought into Ford 7/18/24 upon return home. Paid $125 inspection fee, concern not present, come back if happens again. Makes no sense that codes not present to pull. 12/13/2024 engine light on, catalytic converter replaced. 06/19/25 truck had catastrophic failure returning from work on hwy. XXX on [XXX], just two miles from leaving home another failure with no warning lights in heavy Friday traffic in construction zone. Couldn't clear the traffic lane completely. Very scary. Waited for clearing and limped it to a nearby off ramp. Same jerking, loss of power. Vehicle towed to shop for 2 weeks, testing, fuel pump replaced. Picked up 07/07/25. Next day received recall notice 25S75 in the mail 7/08/25. Everything made sense. 1/24/26 - Battery failed inspection @ 40% during oil change. Replaced battery ourselves from Costco. 04/23/26- Warning light, P0420 pulled, shop recommended engine tune -up. Paid $175 inspection fee + $671.20 tune up. 5/29/26 engine light on, P0420 pulled, recommend catalytic convertor replaced but not under factory warranty anymore so wants us to pay $4000 bill. Escalated up through Ford. As of 6/5/26 - Ford will pay half. I refuse. Should be covered by recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I
NHTSA ODI #11742882
Mileage unknown · May 28, 2026
Fuel/propulsion System
Cp4 pump failed and truck died pulling out onto the highway and won't restart! Luckily I didn't get hit by other vehicles and couple people helped push it out of the road!!! (I DO HAVE FORD DEALER REPORT STATING CP4 PUMP FAILURE!!!!!)
NHTSA ODI #11740514
Mileage unknown · Jan 19, 2026
Electrical SystemExterior LightingFuel/propulsion System
Vehicle: 2022 Ford F-250 Super Duty Component: Door latch / door ajar sensor system This complaint concerns a latent manufacturing defect involving the door latch / door ajar sensor system on a 2022 Ford F-250. The defect causes the vehicle to falsely indicate that doors are open when they are fully closed, triggering alarms an…
Read full complaint
Vehicle: 2022 Ford F-250 Super Duty Component: Door latch / door ajar sensor system This complaint concerns a latent manufacturing defect involving the door latch / door ajar sensor system on a 2022 Ford F-250. The defect causes the vehicle to falsely indicate that doors are open when they are fully closed, triggering alarms and safety warnings and impairing normal vehicle operation. This failure was detectable during the warranty period and manifested shortly after expiration of the bumper-to-bumper warranty, consistent with a latent defect rather than wear or maintenance. The same defect has occurred on multiple Ford vehicles purchased by the same family, including an identical repair performed on another Ford truck for the same door latch sensor failure. This demonstrates a patterned manufacturing issue, not an isolated incident. Numerous owner reports document this same failure mode on 2022 Ford F-250 vehicles, frequently occurring immediately following warranty expiration. The dealership declined to classify the failure as a defect and limited review to warranty dates only, refusing to provide a written determination or pursue goodwill consideration. Because this defect affects vehicle security systems and driver safety alerts, it warrants investigation as a systemic manufacturing defect. The dealership has also failed to repair recalls on the vehicle due to part shipment delays per their service team.
NHTSA ODI #11711930
Mileage unknown · Dec 15, 2025
Fuel/propulsion System
NHTSA recall 24v455 - possible fuel pump failure can result in engine stall which increases the risk of crash. This recall has been open since July 2025 with no action or reasonable fix or repair from Ford putting myself and family in danger.
NHTSA ODI #11705110
Mileage unknown · Jul 19, 2025
Fuel/propulsion System
Fuel pumps failure causing the truck to loose power while in traffic. I have spent 8 thousand dollars in repairs and I am still all of a sudden low Fuel pressure pops up on the screen and it looses power. Has left me stranded 200 miles from my house. Ford has told me that they can't get it to happen for their tech and told me to…
Read full complaint
Fuel pumps failure causing the truck to loose power while in traffic. I have spent 8 thousand dollars in repairs and I am still all of a sudden low Fuel pressure pops up on the screen and it looses power. Has left me stranded 200 miles from my house. Ford has told me that they can't get it to happen for their tech and told me to drive it. Same thing happened again 200 miles away from my house. I feel like Ford knows what it does and doesn't want to correct the problem. These trucks are very expensive to buy and to operate with all the service that has to be done to keep it on the road. I have been driving Ford trucks for over 35 years and this has got to be the worst one ever also the most expensive.
NHTSA ODI #11674711
Mileage unknown · Feb 5, 2025
EngineFuel/propulsion System
I was driving at a highway speed of 65 mph when suddenly the check engine light came on and the speed quickly dropped to 25 mph. The alert that appeared on the truck computer was low fuel pump pressure. This put myself and my family at risk of a severe accident. The dealership found corrosion in the fuel line and a problem …
Read full complaint
I was driving at a highway speed of 65 mph when suddenly the check engine light came on and the speed quickly dropped to 25 mph. The alert that appeared on the truck computer was low fuel pump pressure. This put myself and my family at risk of a severe accident. The dealership found corrosion in the fuel line and a problem with fuel pump. They felt it was possibly from contaminated fuel. They were working on 3 other vehicles with the same problem. This had not happened before and this is a vehicle driven daily. The term the came up with was a " Catastrophic fuel system Failure"
NHTSA ODI #11641009
Mileage unknown · Jan 15, 2025
Fuel/propulsion System
While driving on freeway, engine started to miss/hesitate. No check engine light. Miss/hesitation started to get more frequency and started smelling gas. No check engine light. Took offramp and truck died at stop sign. Pushed truck to gas station. Once out of truck, the smell of gas was prominent. Checked under hood and s…
Read full complaint
While driving on freeway, engine started to miss/hesitate. No check engine light. Miss/hesitation started to get more frequency and started smelling gas. No check engine light. Took offramp and truck died at stop sign. Pushed truck to gas station. Once out of truck, the smell of gas was prominent. Checked under hood and saw nothing unusual. Looked under truck on driver side and saw gas dripping from the transmission to the bumper under the truck. Looked under passenger side and saw more gas. Walked around to driver side, opened the driver door (which turns the fuel pump on) and saw gas spraying from under the truck. Got under the truck and determined that the supply connector on front side of fuel tank was disconnected. I reconnected the connector, clipped it locked, checked for leaks and restarted engine. There have been no further problems. Determined that approximately 10 plus gallons of gas sprayed under the truck. Approximate milage at time of incident was 6500 miles, current mileage is 6900 miles. I have purchased and plan to replace the following Ford part numbers per the Ford workshop manual which contains the connector and downstream fuel line: PC3Z 9J280, LC3Z 9S278.
NHTSA ODI #11636166
Mileage unknown · Jan 8, 2025
EngineFuel/propulsion System
Engine started to tick and loss of power, had it hauled to ford dealership in Tulia tx to later find out that it had faulty rocker arms which is a known problem after calling around asking other dealerships if they have seen other pickups come in with the same issue! After digging further into the motor they found that the fuel …
Read full complaint
Engine started to tick and loss of power, had it hauled to ford dealership in Tulia tx to later find out that it had faulty rocker arms which is a known problem after calling around asking other dealerships if they have seen other pickups come in with the same issue! After digging further into the motor they found that the fuel system was going bad and also would have to be replaced which is also a well known issue after ford recalled 300,000 of these pickups with the same issue
NHTSA ODI #11634808
Mileage unknown · Jan 2, 2025
Fuel/propulsion System
I brought y car to the ford dealer in NOv 2024 for the open recall of reprogram integrated trailer relay module #22V193 and then they called me that the fuel pump needed to be replace because the truck al of the sudden stop working i spend over 12,000 to get the car fix and now i see the open recall for the fuel pump defective #…
Read full complaint
I brought y car to the ford dealer in NOv 2024 for the open recall of reprogram integrated trailer relay module #22V193 and then they called me that the fuel pump needed to be replace because the truck al of the sudden stop working i spend over 12,000 to get the car fix and now i see the open recall for the fuel pump defective #24V-957 i would like to get a refund for the money i paid
NHTSA ODI #11633689
Mileage unknown · Aug 16, 2024
Electrical SystemFuel/propulsion SystemVehicle Speed Control
The BJB fuse panel gets water in it .The vehicle produces multiple alarms and the throttle stops working . So when going down the road it goes to a idle and you can't get out of the way of other vehicle's . The ford dealership said the BJB Panels do get water in them but have not heard of them causing this problem. There was a l…
Read full complaint
The BJB fuse panel gets water in it .The vehicle produces multiple alarms and the throttle stops working . So when going down the road it goes to a idle and you can't get out of the way of other vehicle's . The ford dealership said the BJB Panels do get water in them but have not heard of them causing this problem. There was a list of alarm's from the fuse panel failure it all happened about the same time .
NHTSA ODI #11608882
Official recalls
17Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Jan 31, 2025
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Consequence & remedy
Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
May 27, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."
Consequence & remedy
Consequence: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.
Remedy: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Nov 24, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250 and F-350 vehicles. The strength of the driver-side air bag cover may be insufficient.
Consequence & remedy
Consequence: During a crash, the air bag cover may break apart and project fragments towards occupants, increasing the risk of injury.
Remedy: Dealers will replace the driver-side air bag module, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S49.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Additional source detail variants (2)
Air Bags:sensor:side Impact
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration