NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
17 reportsClear category filterMileage unknown · Jun 9, 2026
Electrical SystemEngineFuel/propulsion System
10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from…
Read full complaint
10 day roundtrip from [XXX] to [XXX]. 5 incidents of catastrophic engine failure on interstates. Truck started to jerk, sputter, lost power at an alarming rate. No engine light until failure ocurred. Very dangerous with heavy holiday traffic. Lives were in danger, us and other vehicles around us. No one expects travel to go from 70 mph,to 50, 30, 15 in such a short period of time. Pulled over to "investigate" code failures we deemed as o2 sensors. Afterwards the truck started back up, no engine lights and drove as normal. Started using premium gasoline, hoping it would help. Started driving in right lane as much as possible but had a failure ocurr right in front of on ramp as well at interstate speeds. Had another family following us so they also witnessed and pulled over all incidents. Brought into Ford 7/18/24 upon return home. Paid $125 inspection fee, concern not present, come back if happens again. Makes no sense that codes not present to pull. 12/13/2024 engine light on, catalytic converter replaced. 06/19/25 truck had catastrophic failure returning from work on hwy. XXX on [XXX], just two miles from leaving home another failure with no warning lights in heavy Friday traffic in construction zone. Couldn't clear the traffic lane completely. Very scary. Waited for clearing and limped it to a nearby off ramp. Same jerking, loss of power. Vehicle towed to shop for 2 weeks, testing, fuel pump replaced. Picked up 07/07/25. Next day received recall notice 25S75 in the mail 7/08/25. Everything made sense. 1/24/26 - Battery failed inspection @ 40% during oil change. Replaced battery ourselves from Costco. 04/23/26- Warning light, P0420 pulled, shop recommended engine tune -up. Paid $175 inspection fee + $671.20 tune up. 5/29/26 engine light on, P0420 pulled, recommend catalytic convertor replaced but not under factory warranty anymore so wants us to pay $4000 bill. Escalated up through Ford. As of 6/5/26 - Ford will pay half. I refuse. Should be covered by recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I
NHTSA ODI #11742882
Mileage unknown · May 15, 2026
Engine
Lifter failure causes cylinder to misfire resulting in loss of power while towing. Defect causes catastrophic failure to the engine.
NHTSA ODI #11738076
70,000 miles · Mar 6, 2026
Engine
The contact owns a 2022 Ford F-250. The contact stated that while driving on several occasions at various speeds, the vehicle was driving sluggishly while accelerating, the RPM fell, and the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer and was diagnosed with engine …
Read full complaint
The contact owns a 2022 Ford F-250. The contact stated that while driving on several occasions at various speeds, the vehicle was driving sluggishly while accelerating, the RPM fell, and the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The spark plugs were replaced, and a tune-up was performed; however, the failure persisted. The vehicle was then taken to an independent mechanic to be diagnosed. The contact was informed that there was a misfire coming from the engine and that the ignition wires needed to be replaced. The vehicle was repaired, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.
NHTSA ODI #11722461
Mileage unknown · Dec 8, 2025
EnginePower Train
Subject: Safety Recall 24V-957 – Loss of Power Risk – Dealer Mishandling I am filing a complaint regarding Ford recall 24V-957 (Ford reference 24S78) for my vehicle. The recall states the defect can cause: “Loss of driving power, increasing the risk of a crash” “Engine stall” “Loss of motive power while driving” My vehicl…
Read full complaint
Subject: Safety Recall 24V-957 – Loss of Power Risk – Dealer Mishandling I am filing a complaint regarding Ford recall 24V-957 (Ford reference 24S78) for my vehicle. The recall states the defect can cause: “Loss of driving power, increasing the risk of a crash” “Engine stall” “Loss of motive power while driving” My vehicle has shown symptoms consistent with these safety risks. When I brought the vehicle to the dealership: 1. They claimed fuel contamination but provided a fuel sample with a Dec 3 timestamp, even though they originally claimed the issue was discovered on Nov 26, raising chain-of-custody concerns. 2. They have refused to properly address the recall or escalate the matter. 3. They threatened to report my rental car as stolen, even though I have not refused to return it and the vehicle is still under an unresolved recall safety issue. 4. Ford Customer Care refuses to intervene and instructs me to deal only with the dealership, despite this being a manufacturer safety recall. This situation has left me without clear direction, without safe transportation, and with concerns about dealership misconduct and improper handling of a safety-critical recall. I am requesting NHTSA review this recall handling and ensure Ford properly manages recall repairs, towing, rental support, and dealer oversight.
NHTSA ODI #11703727
Mileage unknown · Oct 18, 2025
Engine
The failed component is a lifter/camshaft. Luckily I was attentive to my vehicle and noticed a ticking noise within the engine and took it to a dealer for diagnosis. An engine failure while traveling at highway speeds could be a disastrous to occupants and others around them. This appears to be a common problem with the 7.3l eng…
Read full complaint
The failed component is a lifter/camshaft. Luckily I was attentive to my vehicle and noticed a ticking noise within the engine and took it to a dealer for diagnosis. An engine failure while traveling at highway speeds could be a disastrous to occupants and others around them. This appears to be a common problem with the 7.3l engine. The check engine light illuminated after i noticed the ticking noise.
NHTSA ODI #11694232
30,000 miles · Oct 6, 2025
EngineFuel System, Gasoline
The contact owns a 2022 Ford F-250. The contact stated that while depressing the accelerator pedal, the vehicle hesitated and then lunged forward. The contact stated there was no warning light illuminated. The contact stated that the failure had occurred while driving at various speeds. The contact had taken the vehicle to a loc…
Read full complaint
The contact owns a 2022 Ford F-250. The contact stated that while depressing the accelerator pedal, the vehicle hesitated and then lunged forward. The contact stated there was no warning light illuminated. The contact stated that the failure had occurred while driving at various speeds. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the vehicle was functioning normally. The vehicle was not repaired. The manufacturer was not informed of the failure. The contact reported that in December 2024, the engine had failed and needed to be replaced. The contact recently received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline) and related the failure to the recall. The failure mileage was approximately 30,000.
NHTSA ODI #11691617
Mileage unknown · Sep 10, 2025
EngineService BrakesSteering
The truck has 66,500 miles. One of our employees was driving and had the harmonic balancer bolt back out and harmonic balancer fell off. Truck has been sent to Midway Ford in Roseville, MN for repair.
NHTSA ODI #11686331
30,000 miles · Jul 30, 2025
EnginePower Train
The contact owns a 2022 Ford F-250. The contact stated that while driving 60 MPH, the vehicle skipped gears, decelerated unintendedly and lost motive power. The check engine warning light was illuminated. The contact stated that the failure had progressively increased. The vehicle was taken to the local dealer, where the failure…
Read full complaint
The contact owns a 2022 Ford F-250. The contact stated that while driving 60 MPH, the vehicle skipped gears, decelerated unintendedly and lost motive power. The check engine warning light was illuminated. The contact stated that the failure had progressively increased. The vehicle was taken to the local dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.
NHTSA ODI #11677273
80,000 miles · Jun 23, 2025
Engine
The contact owns a 2022 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that there was a misfire in cylinder #2. The contact was informed that the vehicle needed to be taken to a Ford dealer for…
Read full complaint
The contact owns a 2022 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that there was a misfire in cylinder #2. The contact was informed that the vehicle needed to be taken to a Ford dealer for assistance. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 24B25. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 80,000.
NHTSA ODI #11668603
Mileage unknown · Jun 3, 2025
EngineForward Collision AvoidanceLane Departure
Engine making noise and has misfire
NHTSA ODI #11664669
Official recalls
17Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, 2021-2022 F600, and 2022 F750 vehicles previously repaired incorrectly under recall number 24V957. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed mailed April 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S17. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 18, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The 360-degree view camera system may not display a rearview image properly in certain lighting conditions.
Consequence & remedy
Consequence: A rearview camera image that does not display properly can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the image processing module software, free of charge.This will be a phased campaign, with the remedy becoming available in different phases based on model years. Interim letters notifying owners of the safety risk were mailed on October 30, 2025. Additional letters will be mailed once the remedy is available on each phase. Owner notification letters were mailed May 19, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA8. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Jan 31, 2025
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Consequence & remedy
Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 F-Super Duty F250, F350, F450, F550, F600, and 2021-2022 F-650, F750 vehicles. Biodiesel deposits may form on the pump drivetrain roller components, which could lead to failure of the high pressure fuel pump.
Consequence & remedy
Consequence: High pressure fuel pump failure can cause a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) and Transmission Control Module (TCM) software, free of charge. Owner notification letters were mailed January 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S78.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
May 27, 2022
Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."
Consequence & remedy
Consequence: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.
Remedy: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Nov 24, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250 and F-350 vehicles. The strength of the driver-side air bag cover may be insufficient.
Consequence & remedy
Consequence: During a crash, the air bag cover may break apart and project fragments towards occupants, increasing the risk of injury.
Remedy: Dealers will replace the driver-side air bag module, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S49.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Additional source detail variants (2)
Air Bags:sensor:side Impact
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration