IllustrationUPON STARTING THE ENGINE, NO DASH DISPLAYS CAME ON. I LEFT THE ENGINE RUNNING AND OPENED THE HOOD TO LOOK FOR WIRING ISSUES, FOUND NO DAMAGE. WENT BACK TO DRIVERS SEAT AND DASH LIGHTS WERE ALL ON ALONG WITH A "SERVICE REQUIRED" WARNING LIGHT. SHORTLY AFTER, THE WARNING LIGHT WENT OFF AND THE TRUCK APPEARS NORMAL.
2018 Ford F-250 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-250 Sd years
Owner complaints for the 2018 Ford F-250 Sd are substantially higher than the model-year median of 89.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1170–25K
12725–50K
2850–75K
875–100K
11100–150K
2150K+
293 reports with mileage · 104 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 252 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 198 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports9 fire reports3 injury reports
What owners actually said
397 reports2018 FORD F-250 DIESEL 4 WHEEL DRIVE - ABOUT 25,000 MILES ON IT I EXPERIENCED MY FIRST "DEATH WOBBLE" I HAD GONE AROUND A CURVE ON A NARROW ROAD (PROBABLY 45 MPH) AND HIT A BUMP JUST RIGHT AND THERE IT WENT, SCARED THE SNOT OUT OF ME, HIT THE BRAKES, IT STOPPED, I THOUGHT THAT WAS WEIRD. DIDN'T HAPPEN AGAIN FOR A LONG TIME. TH…
Read full complaint
2018 FORD F-250 DIESEL 4 WHEEL DRIVE - ABOUT 25,000 MILES ON IT I EXPERIENCED MY FIRST "DEATH WOBBLE" I HAD GONE AROUND A CURVE ON A NARROW ROAD (PROBABLY 45 MPH) AND HIT A BUMP JUST RIGHT AND THERE IT WENT, SCARED THE SNOT OUT OF ME, HIT THE BRAKES, IT STOPPED, I THOUGHT THAT WAS WEIRD. DIDN'T HAPPEN AGAIN FOR A LONG TIME. THEN A FEW MONTHS LATER I WAS DRIVING DOWN A 4 LANE BUSY ROAD WITH A SEMI-TRUCK NEXT TO ME AND IN THE 20 MILES I DRIVE ON THAT ROAD TWICE DAILY (BETWEEN 55-65 MILES AN HOUR), IT DID IT 4 TIMES. THEN NOTHING. I DON'T FEEL SAFE IN THIS VEHICLE B/C I NEVER KNOW WHEN IT IS GOING TO HAPPEN. IT WAS TAKEN TO AN INDEPENDENT SHOP FOR INSPECTION 3/19/20, ALL SUSPENSION AND JOINTS, AND EVERYTHING ELSE FORD IS SUGGESTION COULD BE AN ISSUE HAS BEEN INSPECTED AND FOUND TO NOT BE LOOSE OR BROKEN. NEW TIRES ARE BEING PUT ON IT THIS WEEKEND WITH ANOTHER ALIGNMENT. AT THIS POINT AFTER ALL OF THAT IF IT HAPPENS AGAIN I WILL BE TRADING THIS VEHICLE. EVERYTHING I SEE SAYS FORD KNOWS AOBUT IT, HAS KNOWN ABOUT IT, AND IS EITHER UNWILLING TO FIX IT, OR DOESN'T KNOW HOW TO FIX IT. THERE NEEDS TO BE A MAJOR RECALL ON ALL THE PARTS IN QUESTION IMMEDIATELY TO MAKE US GULLIBLE IDIOTS THAT BOUGHT THEIR PIECES OF JUNK AT LEAST FEEL LIKE WE CAN USE THEM SAFELY! I AM JUST NOW HEARING THAT THIS IS A PROBLEM WITH THIS FAMILY OF TRUCKS, IF I HAD KNOW THIS WAS THIS BIG OF AN ISSUE I WOULDN'T HAVE BOUGHT IT AND THAT IS WHAT FORD IS COUNTING ON AND THAT IS WRONG! I DO NOT FEEL SAFE TAKING MY FAMILY ANYWHERE IN THIS VEHICLE, IT'S THE ONLY ONE I HAVE AND I AM 1,800 MILES FROM ANY FAMILY, IF I HAVE TO GO HOME FOR AN EMERGENCY I WILL HAVE TO RENT A VEHICLE AT THIS POINT B/C I CAN'T IMAGINE RUNNING DOWN AN INTERSTATE AT 85MPH AND THIS HAPPEN!
ON THREE SEPARATE OCCASIONS WHILE TRAVELING AT APPROXIMATELY 65 MPH, THE TRUCK HAS EXPERIENCED A SEVERE WOBBLE IN THE STEERING AND SUSPENSION AFTER HITTING A SMALL POTHOLE OR BUMP. THE TRUCK BECOMES IMPOSSIBLE TO MANEUVER UNTIL SLOWING TO APPROXIMATELY 45 MPH. DEATH WOBBLE.
TRAVELING ON THE HIGHWAY ABOUT 65MPH AND THE TRUCK STARTED TO WOBBLE. THE STEERING WHEEL WAS WOBBLING VIOLENTLY. I HAD TO SLAM ON THE BRAKES TO SLOW DOWN TO APPROXIMATELY 40MPH ON A BUSY, RAINY, AND WET HIGHWAY TO GET THE WOBBLE OF THE STEERING WHEEL TO STOP. IT HAS HAPPENED APPROXIMATELY 5 TIMES UNDER SIMILAR CIRCUMSTANCES.
WHILE ACCELERATING AND ENTERING AN INTERSTATE, I DROVE OVER A ROUGH SECTION OF ASPHALT WHILE MERGING INTO THE DRIVING LANE, WHICH RESULTED IN MY STEERING WHEEL AND FRONT SUSPENSION VIBRATING AND SHAKING IN A VIOLENT AND DANGEROUS MANNER. I HAD TO IMMEDIATELY DEACCELERATE AND PULL OFF TOWARDS THE SHOULDER IN ORDER TO GET IT TO S…
Read full complaint
WHILE ACCELERATING AND ENTERING AN INTERSTATE, I DROVE OVER A ROUGH SECTION OF ASPHALT WHILE MERGING INTO THE DRIVING LANE, WHICH RESULTED IN MY STEERING WHEEL AND FRONT SUSPENSION VIBRATING AND SHAKING IN A VIOLENT AND DANGEROUS MANNER. I HAD TO IMMEDIATELY DEACCELERATE AND PULL OFF TOWARDS THE SHOULDER IN ORDER TO GET IT TO STOP. RESEARCHING FORUMS AND I LEARNED THAT IS BEING REFERRED TO AS A "DEATH WOBBLE".
WHEN TRAVELING AT VARIOUS SPEEDS WHEN I CROSS A BRIDGE OR UNEVEN ROAD MY FRONT END WILL SHAKE VIOLENTLY AND ALMOST HAVE TO COME TO A COMPLETE STOP FOR IT TO STOP SHAKING THE USED DEALER I BOUGHT IT FROM SAYS IT BECAUSE SOME KIND OF SHOCK ON THE FRONT END BUT I'M NOT SURE IT ONLY HAS 45,000 MILES ON IT I'VE TRIED ADJUSTING THE AI…
Read full complaint
WHEN TRAVELING AT VARIOUS SPEEDS WHEN I CROSS A BRIDGE OR UNEVEN ROAD MY FRONT END WILL SHAKE VIOLENTLY AND ALMOST HAVE TO COME TO A COMPLETE STOP FOR IT TO STOP SHAKING THE USED DEALER I BOUGHT IT FROM SAYS IT BECAUSE SOME KIND OF SHOCK ON THE FRONT END BUT I'M NOT SURE IT ONLY HAS 45,000 MILES ON IT I'VE TRIED ADJUSTING THE AIR IN THE TIRES TO NO AVAIL I'M AFRAID TO EVEN LET MY WIFE DRIVE IT.
MY TRUCK STARTED EXPERIENCING THE WOBBLE AT 29500 MILE(1-22-20) DEALERSHIP INSTALLED PART#KC3Z*3E651*B* ON 1-21-2020. SAME PROBLEM AT MILE39200 (10-04-2020 , DEALERSHIP INSTALLED SAME PIECE ON 10-23--2021. SAME PROBLEM AT MILE 44100, 1-20-2021 DEALERSHIP INSTALLED SAME PIECE AGAIN ON 2-3-2021. WHILE DRIVING ON 2-4-2021 AND…
Read full complaint
MY TRUCK STARTED EXPERIENCING THE WOBBLE AT 29500 MILE(1-22-20) DEALERSHIP INSTALLED PART#KC3Z*3E651*B* ON 1-21-2020. SAME PROBLEM AT MILE39200 (10-04-2020 , DEALERSHIP INSTALLED SAME PIECE ON 10-23--2021. SAME PROBLEM AT MILE 44100, 1-20-2021 DEALERSHIP INSTALLED SAME PIECE AGAIN ON 2-3-2021. WHILE DRIVING ON 2-4-2021 AND 2-6-21 WAS ALMOST THROWN INTO SHOULDER FROM SAME PROBLEM. EVERYTIME PROBLEM HAS OCURRED WAD DRIVING BETWEEN 70-78 ON HIGHWAY WITH MININMAL BUMPS.
PROBLEM PERSISTING REGARDING EVAP SYSTEM AND FUEL PUMP. VEHICLE HAS AN EXTENDED CRANK TIME AND SPUTTERS AT OR AROUND 400 RPM FROM ANYWHERE BETWEEN TWO TO FOUR SECONDS DUE TO THE LOSS OF PRESSURE IN THE FUEL LINES DUE TO A FAULTY CHECK VALVE OR FAULTY EVAP PURGE VALVE. DUST CAN ENTER THE EVAP VENT AND OVERTIME WORK ITS WAY TO THE…
Read full complaint
PROBLEM PERSISTING REGARDING EVAP SYSTEM AND FUEL PUMP. VEHICLE HAS AN EXTENDED CRANK TIME AND SPUTTERS AT OR AROUND 400 RPM FROM ANYWHERE BETWEEN TWO TO FOUR SECONDS DUE TO THE LOSS OF PRESSURE IN THE FUEL LINES DUE TO A FAULTY CHECK VALVE OR FAULTY EVAP PURGE VALVE. DUST CAN ENTER THE EVAP VENT AND OVERTIME WORK ITS WAY TO THE EVAP SYSTEM AND CAUSE THE EVAP PURGE VALVE TO STICK OR WORK PAST THE EVAP SYSTEM AND INTO THE FUEL VENT TUBE DESENDING INTO THE FUEL SENDING UNIT WHICH CAN CAUSE THE FUEL PUMP CHECK VALVE, WHICH KEEPS FUEL PRESSURE IN THE LINES AFTER THE MOTOR IS TURNED OFF, TO FAIL. IN A WORST CASE SCENARIO,VEHICLE MAY NOT START AT ALL UNLESS FUEL IS PUMPED BACK INTO THE LINES BY TURNING THE KEY ON AND OFF MULTIPLE TIMES. PROBLEM WITH MY VEHICLE MOST OFTEN OCCURS WHEN VEHICLE HAS BEEN SITTING OVERNIGHT OR SITTING DURING THE DAY WHILE I AM AT WORK. THIS ISSUE CAN BE FIXED BY REROUTING THE EVAP VENT UNDERNEATH THE HOOD BY THE FRESH AIR INTAKE AND REPLACING FUEL SENDING UNIT AND IN THE WORST CASE REPLACING THE FUEL TANK DUE TO THE ACCUMULATION OF SEDIMENT AND ALSO REPLACING THE EVAP CANISTER. DATE GIVEN IS AN APPROXIMATE WHEN THE ISSUE BEGAN AND IS CURRENTLY AN ONGOING ISSUE. PLEASE NOTE THAT BATTERY IS NEW AND TESTED EXCELLENT AND I USE CLEAN FUEL FROM VALERO. I BELIEVE THAT THIS ISSUE IS ALSO WHY I HAVE POOR GAS MILEAGE AS WELL WHICH IS 11.4 MPG. VEHICLE HAS HAD NO MODIFICATIONS IMPACTING ITS WEIGHT AND I HAVE THE OEM TIRE SIZE AS WELL.
I EXPERIENCED THE 'DEATH WOBBLE' FROM PREMATURE FAILURE OF VARIOUS STEERING AND SUSPENSION COMPONENTS AT APPROXIMATELY 25,000 MILES. THE DEATH WOBBLE HAPPENED AT LEAST 20 TIMES ON A 200 MILE TRIP AND NEARLY CAUSED AN ACCIDENT AT HIGHWAY SPEEDS. A VIDEO OF ONE OF THE INCIDENTS CAN BE VIEWED AT HTTPS://YOUTU.BE/ALHDTXIRSIG
OVER THE PERIOD OF A COUPLE OF MONTHS I'VE HAD 3 DIFFERENT OCCASIONS THAT WHEN I'M GOING OVER 60 AND HIT ANY KIND OF BUMP OR UNEVEN PATCH OF ROAD MY TRUCK STARTS VIOLENTLY SHAKING CAUSING ME TO LOSE CONTROL UNTIL MY VEHICLE IS BACK DOWN UNDER 45 MILES PER HOUR. THE LAST TIME IT HAPPEN I WAS DOING 55 AND SPED UP A LITTLE TO GET A…
Read full complaint
OVER THE PERIOD OF A COUPLE OF MONTHS I'VE HAD 3 DIFFERENT OCCASIONS THAT WHEN I'M GOING OVER 60 AND HIT ANY KIND OF BUMP OR UNEVEN PATCH OF ROAD MY TRUCK STARTS VIOLENTLY SHAKING CAUSING ME TO LOSE CONTROL UNTIL MY VEHICLE IS BACK DOWN UNDER 45 MILES PER HOUR. THE LAST TIME IT HAPPEN I WAS DOING 55 AND SPED UP A LITTLE TO GET AROUND ANOTHER TRUCK BEFORE COMING UP ON AN EXIT RAMP, I SPED UP TO 60 AS I WAS CHANGING LANES TO GO AROUND AND IT STARTED SHAKING THE ENTIRE TRUCK EXTREMELY ROUGH LIKE IT WOULD IF YOU HAD A BLOWOUT, IT THREW ME OVER INTO THE LEFT SIDE LANE WHILE ON US HWY 287 UNDER HWY 69 IN THE TUNNEL WHERE I NEARLY HIT THE OTHER TRUCK, LUCKILY THE DRIVE REALIZED SOMETHING WAS WRONG AND MOVED OVER ONTO THE SHOULDER AVOIDING ME. I WAS ABLE TO REGAIN CONTROL AND MAKE IT HOME. LOOKING BACK NOW AFTER THE FACT I REALIZE THIS PROBLEM HAD BEEN HAPPENING FOR SOME TIME HOWEVER THERE WAS NO WAY FOR ME TO REALLY KNOW. I HAD FELT SMALLER TREMBLES BUT THOUGHT IT WAS JUST THE ROAD OR ME NOT REALIZING WHAT EVERYTHING WAS LEADING UP TO. I'M A 5FT 2-3IN TALL FEMALE AND THIS TRUCK WAS MY DREAM CAR THAT I WORKED REALLY HARD TO PAY FOR. I CALLED FORD LAST YEAR ABOUT HAVING IT FIXED THEY SAID WARRANTY WOULDN'T COVER IT. ALSO THE "COOLING" WENT OUT IN MY SEAT WITHIN THE FIRST 6 MONTHS, FORD ALSO REFUSED TO FIX THAT AND SAID IT WASN'T UNDER MY WARRANTY, WHICH BTW I BOUGHT THE EXTENDED WARRANTY. MY MOTHERBOARD IN MY COMPUTER OR SCREEN IN THE DASH ALSO WENT OUT HOWEVER THEY DID REPAIR THIS BUT THEY TRIED TO CHARGE MY FOR A PLASTIC PEICE THEIR TECHNICIAN BROKE AND IN WHICH I HAD TO POINT OUT WHEN I PICKED UP AND NEARLY HAD TO THROW A TEMPER TO GET THEM TO REPAIR THE DAMAGE THEY CAUSED. I HAVEN'T BEEN VERY HAPPY, NOW I NO LONGER FEEL SAFE IN MY VEHICLE. HELP PLEASE!
Official recalls
925V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
22V880000 · Power Train:driveline:driveshaft
Nov 29, 2022
Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.
Remedy: Dealers will replace the driveshaft, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S74.
22V644000 · Back Over Prevention: Sensing System: Camera
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
22V087000 · Power Train:driveline:driveshaft; Structure:frame And Members:underbody Shields
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
21V155000 · Tires
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
19V880000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 11, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
19V864000 · Latches/locks/linkages:tailgate:latch
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Consequence & remedy
Consequence: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.
19V808000 · Exterior Lighting:headlights
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the "On" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18011 · Power Tailgate Opens Unintended
Opened Oct 12, 2018 · Closed Dec 12, 2019
Status: closed (inferred from source dates) · Electrical System:wiring; Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Additional source detail variants (2)
Electrical System:wiring
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.