IllustrationTransmission just went out no tell tale signs or anything.
2018 Ford F-250 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-250 Sd years
Owner complaints for the 2018 Ford F-250 Sd are substantially higher than the model-year median of 89.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1170–25K
12725–50K
2850–75K
875–100K
11100–150K
2150K+
293 reports with mileage · 104 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 252 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 198 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports9 fire reports3 injury reports
Power Train complaints
15 reportsI was driving down the highway when the truck started shaking vigorously I could not control it. I went into another lane as I could finally push the break hard enough to stop. I checked for a recall. There is a recall for the Radial damper, but my Vin number is not covered under this and my dealership refuses to fix this. I al…
Read full complaint
I was driving down the highway when the truck started shaking vigorously I could not control it. I went into another lane as I could finally push the break hard enough to stop. I checked for a recall. There is a recall for the Radial damper, but my Vin number is not covered under this and my dealership refuses to fix this. I also read there is a class action lawsuit regarding the death wobble, which is what I think is happening with my truck when I read the description of the issue. I need this vehicle added to the recall list so I can take it to the dealership and have repaired.
While driving 75MPH on the freeway, the vehicle started to shake violently and wouldn't stop until I got the speed down around 45MPH (which was very dangerous given the location).
Leaving stop sign turning right onto cross street. Touched accelerator pedal and truck lurched forward under what seemed to be full throttle. (Unintended Acceleration) Jammed on the brake pedal stopping vehicle. Engine still revs still high and rear tire started to squeal/spin on pavement. Grabbed shifter and threw into park…
Read full complaint
Leaving stop sign turning right onto cross street. Touched accelerator pedal and truck lurched forward under what seemed to be full throttle. (Unintended Acceleration) Jammed on the brake pedal stopping vehicle. Engine still revs still high and rear tire started to squeal/spin on pavement. Grabbed shifter and threw into park then immediately grabbed key and turned vehicle off. Upon restart normal operation resumed. No mats in area of accelerator pedal. No ODBC error codes. Did not have foot on both pedals. Scheduled to go to dealer for investigation.
2018 has Death Wobble which has been reported by many and a recall was issued but we have taken it back 3 times for this recall/death wobble=tie rod, sector shaft, drag link replaced (the first time it wasn't recalled yet so we had to pay for it and still have not been reimbursed) last 2 times they fix the tie rod, shaft or what…
Read full complaint
2018 has Death Wobble which has been reported by many and a recall was issued but we have taken it back 3 times for this recall/death wobble=tie rod, sector shaft, drag link replaced (the first time it wasn't recalled yet so we had to pay for it and still have not been reimbursed) last 2 times they fix the tie rod, shaft or whatever but it keeps happening and it is scary. Lucky not to have caused an accident. Also because of the "death wobble" it has ruined the alignment and some tracker line thing as well as our tires and we have to pay for those things even though it is caused by the death wobble/recall?! -Component described above, yes it is available for inspection upon request -Safety at risk because if we are going over 60 and hit a bump the vehicle starts to shake uncontrollably and we have to slam on the brakes to make it stop while going that fast with other vehicles going that fast we have almost caused several accidents and almost hit a barrier trying to stop it -yes problem has been preproduced, verified and supposedly fixed but never lasts more than a month --yes the vehicle component has been inspected by the manufacturer it is an open RECALL -NO WARNING LAMP, MESSAGE etc. Just uncontrollable shaking of vehicle if hits a bump
I WAS DRIVING DOWN I-69 RUNNING ABROUND 75MPH. ALL OF THE SUDDEN, THE TRUCK STARTED TO VIOLENTLY SHAKE AS IF BOTH REAR TIRES BLEW OUT. I GENTLY PRESSED ON THE BRAKES TO NOT EXASERBATE THE ISSUE. IT WAS EVERYTHING I COULD DO TO KEEP THE TRUCK ON THE ROAD. SCARIEST MOMENT OF MY LIFE FOR SURE. LOOKING IN THE REARVIEW, I SAW SMOKE C…
Read full complaint
I WAS DRIVING DOWN I-69 RUNNING ABROUND 75MPH. ALL OF THE SUDDEN, THE TRUCK STARTED TO VIOLENTLY SHAKE AS IF BOTH REAR TIRES BLEW OUT. I GENTLY PRESSED ON THE BRAKES TO NOT EXASERBATE THE ISSUE. IT WAS EVERYTHING I COULD DO TO KEEP THE TRUCK ON THE ROAD. SCARIEST MOMENT OF MY LIFE FOR SURE. LOOKING IN THE REARVIEW, I SAW SMOKE COMING FROM THE TIRES AND THOUGHT EITHER MY BRAKES LOCKED UP, BEARING WENT BAD IN ONE OF WHEELS OR BLOWN TIRES. AS I SLOWED TO 25 MPH, THE SHAKING STOPPED AND I NOTICED THAT THE ENGINE WAS REVVING SUPER HIGH. I STOPPED THE TRUCK AND CHECKED OUT THE BRAKES, TIRES, WHEELS AND MAKE SURE NOTHING WAS WRAPPED AROUND THE AXLE. ALL CLEAR. I CAN ONLY ASSUME THE TRUCK DOWNSHIFTED INTO 1ST OR 2ND GEAR. I DID NOT SEE IT HAPPEN BUT THE REAR TIRES LOST TRACTION AND BOUNCED AROUND UNTIL I SLOWED DOWN. I-69 THROUGH DELEWARE COUNTY HAS RECENTLY BEEN PAVED SO I DONT THINK I HIT ANY BIG BUMPS BEFORE THIS HAPPENED. THE TRUCK HAS 38,028 MILES ON IT AND I HAVE NEVER HAD TRANMISSION ISSUE'S WITH IT. THE OCCASIONAL HARD TO START CONDITION HAS HAPPENED A FEW TIMES BEFORE. 5 -10 SECONDS TURNING OVER BEFORE STARTING BUT NO TRANMISSION ISSUE'S. THIS HAPPENED LAST NIGHT AND SINCE, I HAVE HAD IT UP TO 70 MPH AND IT DIDNT HAPPEN AGAIN. AGAIN THOUGH, THIS HAPPENED LAST NIGHT.
MULTIPLE EPISODES OF SEVERE FRONT END SHAKING AND INSTABILITY THAT OCCURS AT HIGHWAY SPEEDS WHEN DRIVING OVER MINIMAL BUMPS OR OTHER ROAD IMPERFECTIONS. RECENTLY THIS CAUSED A LOSS OF CONTROL WHEN IT OCCURRED ON A FREEWAY NOT KNOWN TO HAVE ICE SPOTS AT 50 MPH. THE ONLY WAY I HAVE BEEN ABLE TO DISRUPT THIS IS TO QUICKLY REDUCE …
Read full complaint
MULTIPLE EPISODES OF SEVERE FRONT END SHAKING AND INSTABILITY THAT OCCURS AT HIGHWAY SPEEDS WHEN DRIVING OVER MINIMAL BUMPS OR OTHER ROAD IMPERFECTIONS. RECENTLY THIS CAUSED A LOSS OF CONTROL WHEN IT OCCURRED ON A FREEWAY NOT KNOWN TO HAVE ICE SPOTS AT 50 MPH. THE ONLY WAY I HAVE BEEN ABLE TO DISRUPT THIS IS TO QUICKLY REDUCE SPEED TO BELOW 40 MPH WHICH IS ALSO DANGEROUS ON THE FREEWAY.
IF YOU GO OVER 60 MPH AND HIT A BUMP OR SOMETIMES DON'T EVEN HAVE TO HIT A BUMP THE WHOLE TRUCK AND STEERING WHEEL WOBBLES OUT OF CONTROL. OBVIOUSLY THEY KNOW ABOUT IT AS THERE IS A NICK NAME "THE DEATH WOBBLE" FOR IT. I TOOK MY TRUCK IN AND NOW THEY WANT ME TO PAY CLOSE TO $800 TO REPAIR IT WHEN IT IS CLEARLY A MANUFACTURING DE…
Read full complaint
IF YOU GO OVER 60 MPH AND HIT A BUMP OR SOMETIMES DON'T EVEN HAVE TO HIT A BUMP THE WHOLE TRUCK AND STEERING WHEEL WOBBLES OUT OF CONTROL. OBVIOUSLY THEY KNOW ABOUT IT AS THERE IS A NICK NAME "THE DEATH WOBBLE" FOR IT. I TOOK MY TRUCK IN AND NOW THEY WANT ME TO PAY CLOSE TO $800 TO REPAIR IT WHEN IT IS CLEARLY A MANUFACTURING DEFECT THAT FORD HAS KNOWN ABOUT AND HAS TRIED TO CONCEAL. THERE IS A CLASS ACTION LAWSUIT STARTED IN CALIFORNIA. FORD SHOULD BE MADE TO RECALL THERE F250 AND F350'S TO DO THE REPAIRS AT NO COST TO THE CUSTOMER. WE PAID A LOT OF MONEY FOR THIS VEHICLE. THEY SAY ITS OK JUST DON'T DRIVE OVER 60 MPH. IT IS VERY SCARY WHEN IT HAPPENS
BEFORE THE V8 GASOLINE ENGINE REACHES SOME PRESCRIBED OPERATING TEMPERATURE ( BEFORE THE ENGINE IS FULLY WARMED UP ), WHEN HEADED DOWNHILL, NO LOW GEARS FUNCTION IN ANY MODE AND THE ENGINE EXPERIENCES SUDDEN UNINTENDED ACCELERATION. THE TRUCK WAS PURCHASED NEW IN 2018. THE FORD COMPANY HAS REPEATEDLY ACKNOWLEDGED THE DEFECTS, AN…
Read full complaint
BEFORE THE V8 GASOLINE ENGINE REACHES SOME PRESCRIBED OPERATING TEMPERATURE ( BEFORE THE ENGINE IS FULLY WARMED UP ), WHEN HEADED DOWNHILL, NO LOW GEARS FUNCTION IN ANY MODE AND THE ENGINE EXPERIENCES SUDDEN UNINTENDED ACCELERATION. THE TRUCK WAS PURCHASED NEW IN 2018. THE FORD COMPANY HAS REPEATEDLY ACKNOWLEDGED THE DEFECTS, AND HOWEVER CLAIMS THAT ALL 2018 GASOLINE POWERED F250S ARE DESIGNED THAT WAY TO MEET CERTAIN STANDARDS AND THEREFORE EVERYTHING IS FINE DESPITE BEING EXTREMELY DANGEROUS IN CERTAIN CIRCUMSTANCES. PLEASE CONTACT ME FOR FURTHER ELABORATION WITH NAMES, DATES, AND PLACES. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TRUCK IS A 2018 FORD F250 AND IS LEAKING OIL AT 28,000 MILES FROM THE UPPER OIL PAN FAULTY ROBOTIC SEAL. THIS HAS COATED MY TRUCKS UNDERSIDE IN OIL AND HAS BEEN SLOWLY LEAKING FOR SOME TIME NOW AS I JUST NOTICED YESTERDAY AFTER EXPERIENCING THE DEATH WOBBLE IN THIS TRUCK.
Official recalls
925V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
22V880000 · Power Train:driveline:driveshaft
Nov 29, 2022
Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.
Remedy: Dealers will replace the driveshaft, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S74.
22V644000 · Back Over Prevention: Sensing System: Camera
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
22V087000 · Power Train:driveline:driveshaft; Structure:frame And Members:underbody Shields
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
21V155000 · Tires
Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Consequence & remedy
Consequence: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the tires, and replace them as necessary, free of charge. The recall began on March 27, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S10.
19V880000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 11, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
19V864000 · Latches/locks/linkages:tailgate:latch
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Consequence & remedy
Consequence: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.
19V808000 · Exterior Lighting:headlights
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2018-2019 F-250, F-350 and F-450 Super Duty trucks. The Daytime Running Lights (DRL) may not dim when the headlight switch is moved into the "On" position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford has notified owners, and dealers will reprogram the Body Control Module (BCM) software, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C10.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18011 · Power Tailgate Opens Unintended
Opened Oct 12, 2018 · Closed Dec 12, 2019
Status: closed (inferred from source dates) · Electrical System:wiring; Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Additional source detail variants (2)
Electrical System:wiring
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.