IllustrationVEHICLE EXHIBITS SEVERE STEERING OSCILLATION WHEN SPEEDS ARE ABOVE 45MPH AND PASS OVER A POTHOLE, EXPANSION JOINT, OR OTHER NORMAL UNEVEN SURFACE. LOSS OF VEHICLE CONTROL IS HIGHLY POSSIBLE WITH THIS SCENARIO. ALSO COMMONLY REFERRED TO AS DEATH WOBBLE.
2017 Ford F-250 Sd
Owner reports · Recalls · Investigations
More warning signs than most F-250 Sd years
Owner complaints for the 2017 Ford F-250 Sd are substantially higher than the model-year median of 89.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 Sd years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3540–25K
39125–50K
9350–75K
3375–100K
25100–150K
10150K+
906 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 717 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 587 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Wheels. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports13 fire reports10 injury reports
Steering complaints
717 reports2017 F-250 FACTORY STOCK WITH 15,800 MILES. TIRES ARE LIKE NEW, NEVER USED AS A TOW VEHICLE. CITY AND HIGHWAY DRIVING BY 69 YEAR OLD MAN. I WAS DRIVING ON A HIGHWAY TOLL ROAD AT 70 MPH AND HIT AN EXPANSION JOINT IN A BRIDGE AND THE FRONT END STARTED SHAKING SO VIOLENTLY THAT I ALMOST LOST CONTROL OF THE TRUCK. IT CONTINUED TO SH…
Read full complaint
2017 F-250 FACTORY STOCK WITH 15,800 MILES. TIRES ARE LIKE NEW, NEVER USED AS A TOW VEHICLE. CITY AND HIGHWAY DRIVING BY 69 YEAR OLD MAN. I WAS DRIVING ON A HIGHWAY TOLL ROAD AT 70 MPH AND HIT AN EXPANSION JOINT IN A BRIDGE AND THE FRONT END STARTED SHAKING SO VIOLENTLY THAT I ALMOST LOST CONTROL OF THE TRUCK. IT CONTINUED TO SHAKE UNTIL I HAD SLOWED TO 40 MPH. IT HAS ONLY HAPPENED THIS ONE TIME (TWO DAYS AGO) BUT AFTER READING SIMILAR REPORTS ONLINE, I AM AFRAID TO GO OVER 65 MPH.
I WAS TRAVELING ON A FLAT HIGHWAY IN KANSAS AT APPROXIMATELY 65 MPH, THERE WAS NO INCLEMENT WEATHER. I CAME UPON A TYPICAL HIGHWAY BRIDGE, AND WHEN FRONT WHEELS CROSSED THE BRIDGE EXPANSION JOINT THE FRONT OF THE TRUCK STARTED TO VIOLENTLY SHAKE. THE STEERING WHEEL STARTED TO ALSO VIOLENTLY SHAKE AND TURN BACK AND FORTH, ABOUT A…
Read full complaint
I WAS TRAVELING ON A FLAT HIGHWAY IN KANSAS AT APPROXIMATELY 65 MPH, THERE WAS NO INCLEMENT WEATHER. I CAME UPON A TYPICAL HIGHWAY BRIDGE, AND WHEN FRONT WHEELS CROSSED THE BRIDGE EXPANSION JOINT THE FRONT OF THE TRUCK STARTED TO VIOLENTLY SHAKE. THE STEERING WHEEL STARTED TO ALSO VIOLENTLY SHAKE AND TURN BACK AND FORTH, ABOUT AN 1/8TH TURN EACH WAY, BACK AND FORTH VERY FAST. I IMMEDIATELY BEGAN SLOWING THE VEHICLE AND GRIPPED THE WHEEL HARDER TO TRY TO KEEP FROM GOING OFF THE ROAD. THE SHAKING CONTINUED UNCHANGED UNTIL VEHICLE REACHED SPEEDS OF APPROXIMATELY 20MPH. AFTER THE INCIDENT I DROVE THE VEHICLE HOME AND INSPECTED THE STEERING AND SUSPENSION COMPONENTS, FINDING NO ABNORMALITIES.
TL* THE CONTACT OWNS A 2017 FORD F-250. WHILE DRIVING 75 MPH ON THE FREEWAY, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT MANAGED TO GAIN CONTROL OF THE VEHICLE BY REMOVING HIS FOOT FROM THE ACCELERATOR PEDAL AND ALLOWING THE VEHICLE TO COME TO A COMPLETE STOP. KEN STOEPEL FORD (400 SIDNEY BAKER ST S, KERRVILL…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD F-250. WHILE DRIVING 75 MPH ON THE FREEWAY, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT MANAGED TO GAIN CONTROL OF THE VEHICLE BY REMOVING HIS FOOT FROM THE ACCELERATOR PEDAL AND ALLOWING THE VEHICLE TO COME TO A COMPLETE STOP. KEN STOEPEL FORD (400 SIDNEY BAKER ST S, KERRVILLE, TX 78028, (830) 257-5553) WAS CONTACTED AND STATED THAT THE PARTS WERE NOT AVAILABLE FOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED MULTIPLE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.
I OWN A 2017 FORD F250 THAT I BOUGHT NEW AND NOW HAS APPROXIMATELY 30,000 MILES. IN AUGUST 2019 I WAS DRIVING WITH MY WIFE AND TWO YOUNG CHILDREN AT APPROX 60MPH ON A TWO LANE HIGHWAY. ROAD CONDITIONS WERE DRY AND I HIT A SLIGHT FROST HEAVE ON A STRAIGHT STRETCH OF HIGHWAY. ALL OF A SUDDEN THE VEHICLE STARTED SHAKING VIOLENTL…
Read full complaint
I OWN A 2017 FORD F250 THAT I BOUGHT NEW AND NOW HAS APPROXIMATELY 30,000 MILES. IN AUGUST 2019 I WAS DRIVING WITH MY WIFE AND TWO YOUNG CHILDREN AT APPROX 60MPH ON A TWO LANE HIGHWAY. ROAD CONDITIONS WERE DRY AND I HIT A SLIGHT FROST HEAVE ON A STRAIGHT STRETCH OF HIGHWAY. ALL OF A SUDDEN THE VEHICLE STARTED SHAKING VIOLENTLY AND I HAVE VERY LITTLE CONTROL. I WAS ABLE TO SLOW THE VEHICLE DOWN TO APPROX. 25MPH BEFORE THE SHAKING STOPPED. LUCKILY THERE WAS NO ONCOMING TRAFFIC OR IT COULD HAVE RESULTED IN A CATASTROPHIC HEAD ON COLLISION. I HAVE NEVER EXPERIENCED SUCH VIOLENT SHAKING FROM A VEHICLE, IT FELT AS IF ALL FOUR WHEELS WERE HELD ON BY A SINGLE LUG NUT AND I HAD VERY LITTLE CONTROL. I CALLED THE DEALER IMMEDIATELY AND THEY SCHEDULE ME FOR REPAIRS. I LATER RESEARCHED THE ISSUE AND REALIZED THAT THIS ISSUE HAS A NAME "DEATH WOBBLE" AND THAT IT IS COMMON IN FORD TRUCKS. I HAVE NOT EXPERIENCED THE ISSUE SINCE BUT I FEEL THIS IS AN EXTREMELY SIGNIFICANT SAFETY CONCERN AND I AM HONESTLY VERY CONCERNED THAT IT MAY HAPPEN AGAIN. IF THERE WOULD HAVE BEEN ONCOMING TRAFFIC OR ICY ROAD CONDITIONS THAT DAY IT COULD HAVE RESULTED IN A VERY TRAGIC ACCIDENT. I JUST LEARNED OF THIS SITE TO REPORT SAFETY ISSUES OR ELSE I WOULD HAVE DONE IT MUCH SOONER. IT APPEARS THAT FORD HAS A DESIGN FLAW THAT NEEDS TO BE ADDRESSED AND I CANNOT BELIEVE THEY CONTINUE TO ALLOW THIS TO HAPPEN. I AM FEARFUL THAT IT IS GOING TO TAKE FATALITIES BEFORE THIS EXTREME SAFETY ISSUE IS CORRECTED.
WHEN DRIVING AT HIGHWAY SPEEDS AND HITTING A SMALL BUMP OR RIDGE IN THE ROAD, THE FRONT STEERING SYSTEMS STARTS SHAKING VIOLENTLY AND CAN ONLY BE STOPPED BY BRAKING HARD AND SLOWING THE VEHICLE TO A STOP. THIS IS A KNOWN ISSUE WITH MANY FORD TRUCK OWNERS AND IS KNOWN AS THE 'DEATH WOBBLE'. I LIVE IN HOUSTON AND BRAKING HARD TO A…
Read full complaint
WHEN DRIVING AT HIGHWAY SPEEDS AND HITTING A SMALL BUMP OR RIDGE IN THE ROAD, THE FRONT STEERING SYSTEMS STARTS SHAKING VIOLENTLY AND CAN ONLY BE STOPPED BY BRAKING HARD AND SLOWING THE VEHICLE TO A STOP. THIS IS A KNOWN ISSUE WITH MANY FORD TRUCK OWNERS AND IS KNOWN AS THE 'DEATH WOBBLE'. I LIVE IN HOUSTON AND BRAKING HARD TO A STOP HERE, DURING RUSH HOUR, ON A MAJOR HIGHWAY IS EXTREMELY HAZARDOUS. I'M BEGINNING TO BE AFRAID TO DRIVE THIS TRUCK ON THE ROAD.
I WAS TRAVELING ALONG I-40 GOING ABOUT 75 MILES PER HOUR AROUND A SLIGHT CURVE TO THE LEFT WHEN I HIT A SMALL BUMP. THE ENTIRE FRONT END OF MY TRUCK BEGAN TO SHAKE VIOLENTLY. THE TRUCK BECAME VERY DIFFICULT TO CONTROL AS THE STEERING WHEEL WAS RIPPED OUT OF MY HANDS. I PULLED A MUSCLE IN MY ARM TRYING TO REGAIN CONTROL THE FIRST…
Read full complaint
I WAS TRAVELING ALONG I-40 GOING ABOUT 75 MILES PER HOUR AROUND A SLIGHT CURVE TO THE LEFT WHEN I HIT A SMALL BUMP. THE ENTIRE FRONT END OF MY TRUCK BEGAN TO SHAKE VIOLENTLY. THE TRUCK BECAME VERY DIFFICULT TO CONTROL AS THE STEERING WHEEL WAS RIPPED OUT OF MY HANDS. I PULLED A MUSCLE IN MY ARM TRYING TO REGAIN CONTROL THE FIRST TIME IT HAPPENED. THE SHAKING WENT AWAY AS SOON AS I SLOWED DOWN TO ABOUT 68MPH, AND DID NOT RETURN AS I ACCELERATED FURTHER. THIS BEGAN HAPPENING ON 11/12/2019 AT APPROXIMATELY 38K MILES. HERE IS A LINK TO THE VIDEO OF WHAT OCCURRED. HTTPS://WWW.FACEBOOK.COM/100036038931239/VIDEOS/158294595381837/ HERE IS ANOTHER LINK TO A VIDEO FROM ANOTHER OCCASION. HTTPS://WWW.FACEBOOK.COM/100036038931239/VIDEOS/158075658737064/ HERE IS A LINK OF THIS SAME ISSUE AFFECTING ANOTHER PERSON'S TRUCK. HTTPS://WWW.FACEBOOK.COM/CLINT.PATTON.5/VIDEOS/10101610077554026/ THIS PROBLEM IS SO COMMON, THERE IS A CLASS ACTION LAWSUIT IN PROGRESS. HTTPS://TOPCLASSACTIONS.COM/LAWSUIT-SETTLEMENTS/CONSUMER-PRODUCTS/AUTO-NEWS/901841-FORD-CLASS-ACTION-ALLEGES-DEATH-WOBBLE-TRUCK-DEFECT/ YOU GUYS SERIOUSLY NEED TO FORCE FORD TO ISSUE A RECALL AND FIX THESE TRUCKS BEFORE SOMEONE LOSES IT AND GETS KILLED. THIS IS NOT A MYTH, THIS IS NOT B.S., THIS IS SERIOUS. YOU'RE WELCOME TO COME DRIVE MY TRUCK AND EXPERIENCE IT YOURSELF. *TR
6 TIMES IN THE LAST FOUR MONTHS, MY TRUCK HAS ENCOUNTERED STEERING WOBBLES, THAT HAVE NEARLY RESULTED IN ME CRASHING MY TRUCK IN HEAVY TRAFFIC AT SPEEDS EXCEEDING 60MPH. THE WOBBLES ARE GETTING MORE INTENSE, TO THE POINT IT'S NEARLY IMPOSSIBLE TO CONTROL MY TRUCK.
40,000 MILES DEATH WOBBLE UNCONTROLLABLE SHAKING AFTER DRIVING OVER BRIDE WHILE DRIVING ON HIGHWAY HAD TO RUN OFF INTO THE MEDIAN AND GRASS SLOWING DOWN AS QUICKLY AS POSSIBLE. THIS IS A DEADLY ISSUE AND KNOWN TO FORD. PLEASE TAKE ACTION BEFORE PEOPLE ARE KILLED IN THESE TRUCKS. I CONTACTED MY LOCAL FORD DEALER AND…
Read full complaint
40,000 MILES DEATH WOBBLE UNCONTROLLABLE SHAKING AFTER DRIVING OVER BRIDE WHILE DRIVING ON HIGHWAY HAD TO RUN OFF INTO THE MEDIAN AND GRASS SLOWING DOWN AS QUICKLY AS POSSIBLE. THIS IS A DEADLY ISSUE AND KNOWN TO FORD. PLEASE TAKE ACTION BEFORE PEOPLE ARE KILLED IN THESE TRUCKS. I CONTACTED MY LOCAL FORD DEALER AND THERE IS NO RECALL FOR THIS ISSUE.
WHILE DRIVING STRAIGHT AT 65MPH, I HIT A SMALL BUMP IN THE ROAD (TWO LANE COUNTY HIGHWAY WITH A 60MPH SPEED LIMIT). MY STEERING WHEEL STARTED TO VIOLENTLY SHAKE AND I HAD TO GRIP IT WITH BOTH HANDS TO KEEP FROM LOOSING CONTROL. THIS VIOLENT SHAKING CONTINUED FOR APPROXIMATELY 20 SECONDS AND WOULDN'T STOP UNTIL I REDUCED MY SPEED…
Read full complaint
WHILE DRIVING STRAIGHT AT 65MPH, I HIT A SMALL BUMP IN THE ROAD (TWO LANE COUNTY HIGHWAY WITH A 60MPH SPEED LIMIT). MY STEERING WHEEL STARTED TO VIOLENTLY SHAKE AND I HAD TO GRIP IT WITH BOTH HANDS TO KEEP FROM LOOSING CONTROL. THIS VIOLENT SHAKING CONTINUED FOR APPROXIMATELY 20 SECONDS AND WOULDN'T STOP UNTIL I REDUCED MY SPEED TO APPROXIMATELY 40MPH. THIS WAS THE WORST THIS HAS EVER HAPPENED, BUT DESPITE MY TRUCK HAVING BEEN WORKED ON (PER FORD'S TSB), I STILL HAVE REGULAR STEERING OSCILLATION OR BUMP STEER. MY TRUCK IS CURRENTLY AT THE FORD SERVICE DEPT. AND THE SUGGESTION GIVEN TO THE SERVICE MANAGER BY FORD TECH IS THAT IT'S NORMAL. I HAVE MY CDL AND HAVE BEEN DRIVING HEAVY EQUIPMENT/AG EQUIPMENT FOR ALMOST 25 YEARS. THIS HAS ME SCARED.
Official recalls
1425V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
22V880000 · Power Train:driveline:driveshaft
Nov 29, 2022
Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.
Remedy: Dealers will replace the driveshaft, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S74.
22V644000 · Back Over Prevention: Sensing System: Camera
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Consequence & remedy
Consequence: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed July 14, 2023. Owners may contact Ford customer service at 1-800-1-866-436-7332. Ford's number for this recall is 22S51.
22V087000 · Power Train:driveline:driveshaft; Structure:frame And Members:underbody Shields
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed on April 7, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S09.
19V880000 · Seat Belts:pretensioner; Structure:body:roof And Pillars
Dec 11, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will apply heat resistant tape to the carpet and its insulation, and modify the B-Pillar insulation as necessary, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S52.
19V864000 · Latches/locks/linkages:tailgate:latch
Dec 4, 2019
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Consequence & remedy
Consequence: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits and will install a new tailgate handle release switch, free of charge. The recall is expected to begin January 20, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S48.
19V278000 · Engine; Equipment:electrical
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
17V652000 · Latches/locks/linkages:doors:latch
Oct 16, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.
Consequence & remedy
Consequence: A door that opens while driving can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.
17V599000 · Seat Belts:front:anchorage; Seats
Sep 25, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence & remedy
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
Seat Belts:front:anchorage
Ford Motor Company (Ford) is recalling certain 2017 Ford F-150, F-250, F-350, F-450, and F-550 trucks with manually-adjusted front passenger seats. The seat belt anchor may not be adequately welded to the seat cushion frame. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages," and 207, "Seating Systems."
Consequence: The seat belt buckle weld may fail, preventing the occupants from being properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger manual seat track, free of charge. The recall is expected to begin November 6, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C17.
17V526000 · Seat Belts:rear/other
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.
17V332000 · Seats; Seats:front Assembly:recliner
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Additional source detail variants (2)
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
17V225000 · Power Train:automatic Transmission
Mar 31, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford F-250 Super Duty trucks equipped with 6.2L engines and six-speed automatic transmissions. These transmissions may have a damaged park rod actuating plate that can result in unexpected vehicle movement even though the transmission has been shifted to 'Park.' As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence/Starter Interlock/Transmission Braking Effect", and number 114, "Theft Protection."
Consequence & remedy
Consequence: Unexpected vehicle movement such as a vehicle rollaway can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the park rod actuating plate and replace it, if necessary, free of charge. The recall began on June 1, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C06.
16V945000 · Fuel System, Gasoline:storage:tank Assembly:mounting
Dec 29, 2016
Ford Motor Company (Ford) is recalling certain 2017 Ford F-250 and F-350 Super Duty trucks manufactured August 10, 2016, to September 17, 2016. The frame reinforcement bracket may not have been attached to the front fuel tank strap, allowing the fuel tank strap to separate from the frame.
Consequence & remedy
Consequence: A fuel tank strap that separates and allows the fuel tank to contact the ground may cause a fuel leak, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install the reinforcement bracket, free of charge. The recall began on February 7, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S45.
16V778000 · Fuel System, Diesel
Oct 26, 2016
Ford Motor Company (Ford) is recalling certain model year 2017 Ford F-250 SD, F-350 SD, F-450 SD, and F-550 SD trucks manufactured March 21, 2016, to August 28, 2016. The protective shield on the fuel conditioning module may have inadequate adhesion, allowing the shield to become dislodged.
Consequence & remedy
Consequence: If the shield becomes dislodged, the drain valve may open resulting in a fuel leak. A fuel leak, in the presence of an ignition source, increases the risk of a fire. Under certain conditions, significant liquid fuel on the road surface may cause a slip hazard, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the protective shield, free of charge. The recall began November 11, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S39.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE24014 · Sogefi Secondary Diesel Fuel Filter Leak
Opened May 9, 2024 · No close date supplied
Status: open (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Other:fuel Filter
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that the low-pressure fuel system is capable of a maximum operating pressure of 8.5 Bar, while the secondary fuel filter is only tested to seven (7) Bar during the manufacturing process. Additionally, changes starting in 2022 by both Ford and Sogefi align with a lack of similar complaints on MY 2022 and newer vehicles. ODI is opening this Preliminary Evaluation (PE) to evaluate the severity of the potential problem and to fully assess the potential safety-related problems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21001 · Power Tailgate Release Systems
Opened Jan 15, 2021 · Closed Jan 10, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:tailgate ; Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Structure:body:door
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:tailgate:hinge And Attachments
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the recall and production update and communicated how they were unable to verify the owners’ complaints or replicate the concern. Despite this, Ford began developing ways to prevent uncommanded tailgate openings from various human, mechanical or electrical causes. Based on testing, Ford issued a Customer Satisfaction program, 21M05-S1/S2/S3, to further address the potential of unintended tailgate openings. This work was applied to vehicles being produced as of December 20, 2021. The program began for already delivered vehicles on July 22, 2022. The covered models include 2017-2022 F-250, 350, 450, 550, 650 and 750 Super Duty and 2020-2022 F-600 Super Duty trucks. ODI has received 39 VOQs between February 24, 2020, and December 15, 2023, alleging uncommanded tailgate openings. In a detailed analysis, none of the vehicles in the VOQs were found to have received the Customer Satisfaction update. Since ODI has not received any complaints of post-Customer Satisfaction program tailgate openings, this office is closing this Recall Query. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18011 · Power Tailgate Opens Unintended
Opened Oct 12, 2018 · Closed Dec 12, 2019
Status: closed (inferred from source dates) · Electrical System:wiring; Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Additional source detail variants (2)
Electrical System:wiring
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.
Structure:body:tailgate:hinge And Attachments
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, water can enter the electrical wiring system and may cause a short circuit resulting in the unintended activation and release of the tailgate latch. This could allow unintended opening of the tailgate while the vehicle is in motion.Analysis of the data provided by Ford found that the frequency of a tailgate opening unintended was high in vehicles equipped with electric tailgates. Unintended tailgate opening without vehicle operator knowledge may result in loss of unrestrained cargo, increasing the risk of a crash. In response to this investigation, Ford decided to conduct recall 19V-864.Owners will be notified by mail and instructed to take their vehicle to a Ford dealer to modify the tailgate/frame wiring harnesses by adding jumper pigtails to isolate the tailgate release control circuits, and will install a new tailgate handle release switch. With recall action 19V-864 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.The ODI reports cited above can be reviewed at: http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID using the following complaint identification numbers: 10984283,11004227,11082643,11090089,11104638,11115381,11140680,11141071, 11141075,11141174,11141200,11141331,11141447,11141547,11141548,11142572, 11142618,11142657,11153541,11153959,11157225,11160936,11165124,11165590, 11166199,11166802,11170049,11171409,11171509,11171685,11180009,11182035, 11186146,11191151,11191353,11193045,11194958,11203615,11206443,11209199, 11229482,11230768,11233349,11233436,11255126,11265643.