2025 Ford F-150

issues with my 2025 f150 tremor when I applied my brakes firmly, really not that hard ( not hard enough to skid) my truck locked into park and I wasn’t even able to put it back into a gear with a flashing message! Couldn’t get it back into gear for about 30 sec to 60 sec until a message stopped flashing. Had this happened in traffic or on a freeway this could have been really bad especially in traffic. Very dangerous!

I am submitting a formal complaint regarding a safety-related issue with my 2025 Ford F-150, 5.0, that began immediately following recent recall service on the brake booster system. Since the recall work was completed, the ABS system has been producing a loud electrical rattling or grinding noise during vehicle takeoff. This noise is consistent and occurs at low speeds when accelerating from a stop. Prior to the recall service, this issue was not present. Given that this problem appears to be directly related to the anti-lock braking system, I am concerned about the safety and reliability of my vehicle. The ABS system is critical for maintaining control and braking performance, and any malfunction or abnormal behavior raises serious concerns about potential failure or degraded performance. Please treat this matter with urgency, as it involves a critical safety system. I expect prompt resolution and clear communication regarding the findings and corrective actions.

While driving slowly in a traffic queue, the driver applied the brakes to stop behind the vehicle ahead. The ABS activated unexpectedly, causing the truck to lurch/jump forward instead of stopping smoothly. The driver was forced to steer left to avoid a collision, but the vehicle ultimately struck the car in front, damaging the left front of the truck. No injuries occurred. This is not the first time this behavior has been observed in this vehicle, and the vehicle had previously been inspected by an authorized Ford dealership for similar braking behavior without resolution. The incident occurred at low speed in stop-and-go traffic conditions. The vehicle is currently at a Ford dealership for repair related to this incident.

I have repeatedly received an error on my vehicle dashboard stating " 1 pedal drive fault: Press break pedal to reduce speed". I have taken my vehicle to the dealer twice for this and was told both times that it was not reproducible and therefore nothing that could be fixed. I was told there was an active recall and that it has been repaired. Today after coming to a complete stop I let go of the break and the vehicle suddenly forcefully lurched forward without me stepping on the accelerator almost resulting in an accident. After looking up the information online it seems other drivers have experienced this too and I was never warned about this by the dealer or its potential safety implications. I feel unsafe. I have a video but was unable to upload to due its size.

The contact owns a 2025 Ford F-150. The contact stated that while driving on the interstate and depressing the brake pedal, the vehicle lost braking functionality. The brake pedal was depressed to the floorboard. The ABS warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined there was a computer fault. The vehicle was repaired, but the failure recurred approximately 6,100 miles later. While driving 65 MPH, the brakes became inoperable. The vehicle was taken to another local dealer, Lebanon Ford Parts & Accessories, Lebanon Ford Service Center (770 Columbus Ave, Lebanon, OH 45036); but the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,000.

While backing at low speed in a residential driveway, the vehicle struck a parked car causing significant damage. No ADAS safety systems activated: reverse automatic braking did not engage, no parking sensor warnings sounded, no audible or visual alerts occurred. The vehicle made no attempt to slow or stop despite approaching a large stationary obstacle. The vehicle has two open unrepaired recalls at the time of incident: Recall 25V488 (Electronic Brake Booster): EBB module may shut off unexpectedly during ADAS use. The EBB is integral to the electronic braking system ADAS relies on to autonomously apply brakes. If faulted, reverse automatic braking cannot engage regardless of sensor detection. Software fix was available but never applied. Ford documented 37 warranty claims and one crash before issuing this recall. Recall 25V863 (Integrated Park Module): May fail to lock into park. Remedy not yet available. The vehicle provided zero warning of degraded safety capability. No dashboard indicators or alerts that ADAS was unavailable. Multiple overlapping systems failed simultaneously suggesting cascading failure from the EBB fault or multiple independent defects. Ford SSMs 52161, 49767, and 50360 document known Lightning issues with inoperative park aid and reverse brake assist unavailability. The recall notice emphasizes brake pedal feel but does not clearly communicate that the defect can disable automatic emergency braking. Consumers may delay repair not realizing ADAS is compromised. Vehicle is available for inspection.

When you’re stopped and have the Auto Hold feature on, and open your door, the gear selector will automatically shift to park and engage the e-brake. Off and on, this will cause the brake system to fault and will tell you to service immediately. A couple other times it triggered randomly with just having the Auto Hold feature activated. it’s happened on and off since i got the truck new. i have a video of me trying to engage and disengage the parking brake and nothing happens. i have to start and restart the truck multiple times to fix it

Wednesday [XXX]/Phantom Braking Proceeding northbound on [XXX] at estimated speed of 35 mph. Road was clear with no oncoming traffic. Suddenly the brakes locked up and a collision notice appeared on dash. Brakes released and continued northbound with no further issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Parking break fault warning light service now light comes on intermittently when the parking break was set. The ford dealer I bought the truck from found a leaking rear left break line and replaced the left rear parking break motor assembly. The Warning light kept coming on intermittently when setting the parking break after this repair. I took it to my local ford dealer who said nothing was wrong. I’m now on a trip and the warning light continues to intermittently come on. Took it to another ford dealer who reconnected a wire and said if that didn’t work it needed a new ABS module. I continued on my trip and the warning light kept coming on. Stopped at another ford dealer who cleaned up some connectors. The warning light kept coming on and I took it back. Now they think it needs a new ABS module and said it is back ordered for 2 months and I’m a 1000+ miles from home.