2024 Ford F-150

soy-based wire insulation has caused engine damage to vehicle. Rodents have Damaged the vehicle Wiring due to soy-based wires installed during manufacturing. I have to pay expensive repairs due to mice chewing on soy-based wires installation. The vehicle engine is smoking This will be a reoccurring problem. New wires need to be installed that does NOT attract rodents.

Our 2025 Ford F-150 experienced a complete instrument cluster failure immediately following a manufacturer-initiated over-the-air software update. Component/System Failure: The instrument cluster/display failed completely. The speedometer, fuel gauge, warning lights, and all critical driving information are inoperable. The vehicle is available for inspection upon request. Safety Risk: This creates a serious safety hazard because the driver cannot monitor speed, fuel level, or warning indicators, increasing the risk of unsafe operation. Event Details: After the update installed overnight, the dashboard display was nonfunctional upon startup. The vehicle was operating normally prior to the update, and the failure occurred immediately afterward with no other issues. Inspection/Confirmation: The vehicle was taken to Southwest Ford dealership, where the issue was confirmed. We were told it is an electrical problem requiring repair. The dealership also stated another vehicle there had the same issue following an update. Manufacturer Response: The vehicle has approximately 46,000 miles and is out of warranty. We were quoted about $1,500 for repair. We opened a case with Ford Motor Company (Case #CCH-07666598-Q6Y1R3), but coverage was denied. Prior Warnings: There were no warning lights, messages, or symptoms prior to the failure. We believe this may indicate a defect in the software update system that could affect other vehicles and pose a broader safety risk. We request investigation and appropriate action.

The contact owns a 2024 Ford F-150. The contact stated that while his wife was in the process of parking the vehicle on the side of the street, the driver released the accelerator pedal; however, the vehicle failed to stop as intended, jolted forward, and hit one unoccupied and parked vehicle, and hit another occupied vehicle stopped at the stop light. The air bags did not deploy. The driver sustained nerve pain, causing the fingers to become numb, and the driver sustained headaches, back, hips, and shoulder pain. It was unknown whether the other driver sustained injuries. The contact's wife drove to an emergency room after the collision and received medical assistance. A police report was filed. The vehicle was taken to an auto collision repair shop, where it was serviced for the collision damage. An independent mechanic had diagnosed the vehicle with a one-pedal driving system and ABS failures. The vehicle was not repaired. The dealer was not contacted. The manufacturer was notified of the failure and referred the contact to the insurance company for assistance. The failure mileage was 13,290.

As I went to reverse to pull out of a parking area, the truck accelerated, I applied the brakes and the truck continued going dragging the front tires at one point. I decided at the last min to attempt to put the truck in neutral or park and at that time it was stopped between two trees. This could of been very bad if my kids were in the yard playing or many other scenarios. The 2024 F150 is still at the dealership waiting on approval to do body work. We have requested they run diagnostics or telemetry on the trucks systems to verify the problem but after a month that has not been done yet.

Instrument cluster has started to flicker when driving. Have had incidents where instrument cluster freezes while driving and a blank black screen when first starting. Whenever the screen freezes or turns black, turning the vehicle off and on again fixes the issue. It seems that the flickering is intermittent. Has recently become more frequent and why I wanted the dealership to take a look. They're now asking for video proof. As soon as I have that I'm going to return to dealership. I'm making this complaint because it seems to be a well-known issue with no fix in most cases. My dealership has contacted Ford engineering and they have asked for video proof.

The contact owns a 2024 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V512000 (Power Train) and 26V104000 (Electrical System, Exterior Lighting); however, the parts to do the recall repairs were not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact had not experienced a failure.

The digital dash cluster will randomly blank out while driving. After it sits for aboutba few hrs parked, it will turn back on just to repeat it down the road again. I tried bring it up with the dealership a few times and I was told they aren't able to replicate the issue and it's within factory spec. This is extremely dangerous since this creates issues of not knowing how fast the vehicle is going, and no indicators of what the truck is doing.

The contact owns a 2024 Ford F-150. The contact received notifications of NHTSA Campaign Number: 25V512000 (Power Train) and 25V104000 (Electrical System, Exterior Lighting); however, the parts to do the recall repairs were not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and provided a case number. The contact had not experienced a failure.

After operating the vehicle normally and backing into a parking space, I stopped the vehicle and selected Park, turned the vehicle off, and exited. Before the driver’s door was closed, the vehicle began to roll forward unexpectedly. I ran back to the vehicle and reentered it to regain control, with the driver’s door still open and the seatbelt not fastened. After stopping the vehicle, I selected Reverse, at which point the vehicle surged backward unexpectedly. The open driver’s door struck another vehicle and the driver, and my vehicle continued backward, colliding with a fence and then a tree. The vehicle did not behave as expected after Park was selected, creating a serious safety risk to myself and others. Several vehicle systems appeared to malfunction or fail during the incident. The specific component or system responsible is not yet known, and the vehicle is currently available for inspection. The incident resulted in property damage and back pain, for which I later sought medical care. The vehicle has been inspected by a collision repair facility and is currently being handled through insurance. The manufacturer has been informed and stated that insurance should make determinations regarding the incident.

I purchased this vehicle new 7/31/25. Within the first week of ownership I noticed a noise coming from the rear axle. Brought into Ford dealer for diagnosis at 723 miles: tech notes indicated that the abs tone ring was not manufactured correctly and was hitting the ABS wheel speed sensor. The sensor had visible impact marks. The rear axle assembly was replaced under warranty. The repair took over 10 days. At this point I was concerned about the Q/C and build quality of the vehicle. I asked Ford for an extended warranty as a goodwill gesture, which was denied. This failure was related to a Federally regulated safety system: ABS brakes. ~5 months later on 1/8/26 (12, 336 miles), I attempted to place the vehicle in park using column shifter, a service light came on and the truck was not responding to the shifter input. I turned the truck off with the parking brake engaged, restarted truck and another warning light came on saying place vehicle into park. The truck would not start and I was left stranded without warning. The vehicle was towed to the nearest dealer. Diagnosis revealed the shifter module was faulty and needed to be replaced. Ford had a TSB about this issue. The repair took 7 days. At this point I'm extremely concerned about the reliability of this vehicle. This has been two major failures within less than 6 months of ownership. Ford contacted me asking how my experience was with the vehicle. I informed them I was very disappointed and had safety concerns. I asked for an extended warranty which was denied. I then escalated the ticket to asking for a voluntary buyback from Ford. Ford notified me that I didn't meet the criteria for a voluntary buyback and the claim was denied. Due to the repeated failures I do not feel safe continuing to drive this vehicle and I want Ford to step in and assist with this matter.