NHTSA owner reports · September 18, 2026 snapshot.
Lane Departure complaints
12 reportsClear category filterMileage unknown · Aug 24, 2026
Lane DepartureSteering
My 2021 F-150 has been diagnosed with a failed electric steering gear Code PSCM C1B00 49 2F. I understand there was a recall on some 2021 trucks with similar steering issues, although my VIN is not included. The part is on national backorder and my dealer says there are approximately 150 vehicles ahead of mine. This is a safety-…
Read full complaint
My 2021 F-150 has been diagnosed with a failed electric steering gear Code PSCM C1B00 49 2F. I understand there was a recall on some 2021 trucks with similar steering issues, although my VIN is not included. The part is on national backorder and my dealer says there are approximately 150 vehicles ahead of mine. This is a safety-related steering component, part number "ML3Z3504G"
NHTSA ODI #11759149
Mileage unknown · Aug 16, 2026
Electrical SystemLane Departure
When backing up, the rear camera display shows a gray filter over the rear image on the display cluster and the right side warning sensors indicate a blue trapezoid on the cluster for the right side of the vehicle. The driver dashboard also has an alert that the rear brake assist feature is inactive
NHTSA ODI #11757313
Mileage unknown · Jun 11, 2026
Lane DepartureSteering
The EPAS (Electric Power Assisted Steering) module experienced an internal sensor failure, causing a sudden and complete loss of power steering assist. The vehicle is available for inspection upon request and the EPAS module has been retained. The loss of power steering occurred without warning while the vehicle was in motion, …
Read full complaint
The EPAS (Electric Power Assisted Steering) module experienced an internal sensor failure, causing a sudden and complete loss of power steering assist. The vehicle is available for inspection upon request and the EPAS module has been retained. The loss of power steering occurred without warning while the vehicle was in motion, requiring significantly greater physical force to maintain control of the steering wheel. This creates a serious risk of losing vehicle control, particularly at higher speeds, during lane changes, or in emergency maneuver situations. Because the failure occurs randomly and without any prior indication, there is no opportunity to safely prepare or pull over before it happens, putting both the driver and other motorists at risk. Yes. The issue has been acknowledged by multiple Ford dealerships and independent mechanics, all of whom confirmed this is a known and recurring problem with this vehicle’s EPAS system. Numerous online automotive forums also document other owners experiencing the identical failure, suggesting this is a widespread issue rather than an isolated incident. The vehicle was inspected by an authorized Ford dealership, which confirmed the EPAS module failure and acknowledged familiarity with the issue. No warning lights, dashboard messages, unusual sounds, or handling changes occurred before the failure. The power steering loss happened suddenly and without any prior symptoms, leaving no opportunity to anticipate or react to the malfunction before it occurred.
NHTSA ODI #11743418
Mileage unknown · May 29, 2026
Forward Collision AvoidanceLane Departure
RECALL 25V-315/25S49 has not been fixed on my truck. ive taken in multiple times since last year and programming doesnt fix the issue. final conclusion from the dealer is replace camera system. which they want me to pay $800 for. Since this is a recall Ford should take care of these charges. info. below [XXX] =aXXX INFORM…
Read full complaint
RECALL 25V-315/25S49 has not been fixed on my truck. ive taken in multiple times since last year and programming doesnt fix the issue. final conclusion from the dealer is replace camera system. which they want me to pay $800 for. Since this is a recall Ford should take care of these charges. info. below [XXX] =aXXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11740900
Mileage unknown · Oct 31, 2024
Back Over PreventionLane DepartureVisibility/wiper
I am writing to bring to your attention a critical safety issue affecting my 2021 Ford F-150, caused by a recent SYNC software update. On or around August 2024, Ford issued a software update that has resulted in significant malfunctions in multiple vehicle systems, including intermittent freezing and non-responsiveness shortly a…
Read full complaint
I am writing to bring to your attention a critical safety issue affecting my 2021 Ford F-150, caused by a recent SYNC software update. On or around August 2024, Ford issued a software update that has resulted in significant malfunctions in multiple vehicle systems, including intermittent freezing and non-responsiveness shortly after vehicle startup. These issues persist for several minutes, severely impairing safety features—most notably the federally mandated backup camera that all vehicles sold after 2018 are required to have for driver and pedestrian safety. Following Ford's issuance of a recall number, I scheduled a service appointment with my local dealership and was later informed that Ford's specified service procedures would incur additional charges since my vehicle is now out of warranty. Ford has indicated that rolling back to a previous software version is not an option, as only Ford has access to the software. The company further requires an official diagnostic assessment at an estimated cost of $500 to $1,000 to even consider covering part of the repair costs. This approach is unreasonable, given that the malfunction originates from Ford’s own software update and directly impacts the safe operation of the vehicle. This is especially concerning as it compromises the backup camera and other critical driver-alert systems, which could lead to severe injury or even fatalities if the issue remains unaddressed. This issue is not isolated; a significant number of Ford F-150 owners are reporting similar problems on public forums, where Ford has acknowledged the software defect but has not offered a resolution without additional financial burden on affected customers. Given the safety risks posed by the non-functional backup camera and the importance of fully operational driver alert systems, I urge the NHTSA to investigate this matter. Ford’s reluctance to address this defect without cost to owners directly undermines the federally mandated safety standards that
NHTSA ODI #11623033
Mileage unknown · May 1, 2024
Forward Collision AvoidanceLane Departure
The Ford copilot 360 is not working on my f150 Raptor The speed limit sign recognition has stopped working correctly some of the time. Vehicle is currently at the Ford dealership in Palmyra Pennsylvania. For he last 45 days as the dealership has been unable to fix the problem. My Vehicle is still under the original 3 year 36…
Read full complaint
The Ford copilot 360 is not working on my f150 Raptor The speed limit sign recognition has stopped working correctly some of the time. Vehicle is currently at the Ford dealership in Palmyra Pennsylvania. For he last 45 days as the dealership has been unable to fix the problem. My Vehicle is still under the original 3 year 36k warranty. Purchased [XXX] currently has 18k miles. Vehicle is not as safe as is compared to how it operated prior to an update performed at the dealership.. Not happy or as safe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11586435
Mileage unknown · Mar 27, 2024
Exterior LightingLane Departure
Tail lamp assembly both sides, allowing moisture within the lighting assembly potentially resulting in short circuit or fire if water comes in contact with electrical connections.
NHTSA ODI #11579686
Mileage unknown · Jan 13, 2024
Lane Departure
This vehicle is equipped with Ford BlueCruise hands-free highway driving system. This system was activated when this occurred and my hands were off the wheel. Driving Southbound on [XXX] in Georgia, [XXX], left-most lane, with an ~8 ft shoulder and barrier, a few miles before mile [XXX], right around Sparks and Adel, GA. The…
Read full complaint
This vehicle is equipped with Ford BlueCruise hands-free highway driving system. This system was activated when this occurred and my hands were off the wheel. Driving Southbound on [XXX] in Georgia, [XXX], left-most lane, with an ~8 ft shoulder and barrier, a few miles before mile [XXX], right around Sparks and Adel, GA. There were two dark tire skid marks in the road leading from the lane into the shoulder/barrier. It seemed like the truck thought those tire skid marks were the lines in the road and took the truck with them into the shoulder. Luckily I was paying close attention and consider myself to have quick reflexes. I was able to grab the wheel and correct before the truck got too far out of the lane. Only when the truck started going out of the lane did the system turn off and tell the driver to take control. This dash warning occurred fractions of a second after I grabbed the wheel to correct. I had my dash camera operating at the time, but I was too slow to capture and save the exact occurrence, however I do have an image of the same portion of highway where this occurred. I have uploaded two images. One unedited image and one "example" image of what the tire skid marks looked like in the road. Someone paying less attention or with slower reflexes could have easily ended up in the barrier at 70-80 MPH. The vehicle has not been inspected for this. Other than this incident, it has functioned seemingly fine and without indicating any error codes or check engine lights. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11565371
Mileage unknown · Sep 21, 2023
Electrical SystemLane DepartureSteering
In April 2023, while driving to work, at least a dozen error messages were displayed on the instrument cluster. When I arrived at work and was driving at a slower speed, I noticed some irregular feedback in the steering wheel and quickly realized the power steering was intermittently disabling itself. The truck had just rolled o…
Read full complaint
In April 2023, while driving to work, at least a dozen error messages were displayed on the instrument cluster. When I arrived at work and was driving at a slower speed, I noticed some irregular feedback in the steering wheel and quickly realized the power steering was intermittently disabling itself. The truck had just rolled over 30k miles at this point and was well within the manufacturer's warranty period. I took the truck to the dealer for repair and got the truck back within a few days and was told it was repaired. The very next morning while driving to work again, the same problem ensued again with a dozen error messages and the power steering intermittently disabling itself. I took the truck bad to the dealer, contacted Ford customer care, and they got an engineering team to help work the problem. The service advisor also told me there were 3 other vehicles at their dealer with the same problem. After more than 30 days of being at the dealer for repair, the truck was returned to me again. Everything seemed to be fine for a couple months and then it returned again with many error messages and power steering failures. On Monday this week I started to pull out in traffic and the power steering disabled and caused me to cross the 2-lane road into oncoming traffic.
NHTSA ODI #11545803
Mileage unknown · Sep 8, 2023
Forward Collision AvoidanceLane Departure
The vehicle no longer sends signal when blind spot monitors are triggered front parking camera access not available rear view mirrors do not have blinker lights or original camera working
NHTSA ODI #11543414
Official recalls
29Jul 28, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Additional source detail variants (2)
Back Over Prevention:display Function
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature that were repaired incorrectly under recall 24V443. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence & remedy
Consequence: Inoperative reverse lights may fail to alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed on June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S57.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles previously repaired incorrectly under recall number 22V-188. The Diagnostic Trouble Code (DTC) for low transmission fluid pressure may falsely activate and cause the transmission to unexpectedly shift into neutral.
Consequence & remedy
Consequence: An unexpected shift into neutral will cause a loss of drive power and increase the risk of a crash.
Remedy: Dealers will update the Powertrain Control Module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S24.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
Jun 14, 2024
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence & remedy
Consequence: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.
Additional source detail variants (2)
Electrical System:body Control Module:software
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.
Exterior Lighting:back Up Lights
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.
Dec 22, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Consequence & remedy
Consequence: Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.
Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. Owner notification letters were mailed on May 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.
Jul 21, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.
Consequence & remedy
Consequence: Unexpected activation of the electric parking brake while driving increases the risk of a crash.
Remedy: Dealers will install a protective tie strap, tape wrap, and replace the harness as necessary, free of charge. Owner notification letters were mailed February 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S35.
Mar 10, 2023
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed December 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S10. This recall expands previous recall number 22V-250.
Nov 15, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 30, 2023. Remedy parts are expected in the 3rd Quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S71. This recall expands previous recall number 22V-142.
Aug 12, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Jun 10, 2022
Ford Motor Company (Ford) is recalling one 2021 F-150 vehicle. A single vehicle may have been assembled without a fuel tank front attachment resulting in an unsecured fuel tank attachment strap.
Consequence & remedy
Consequence: An improperly attached fuel tank increases the risk of a fuel leak and potential for fire.
Remedy: Dealers will inspect and repair (if necessary) the fuel tank strap bracket, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S42.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The Diagnostic Trouble Code (DTC) for low transmission fluid pressure may falsely activate and cause the transmission to unexpectedly shift into neutral.
Consequence & remedy
Consequence: An unexpected shift into neutral will cause a loss of drive power and increase the risk of a crash.
Remedy: Dealers will update the Powertrain Control Module (PCM) software, free of charge. Owner notification letters were mailed on April 12, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S15.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S12.
Dec 16, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Additional source detail variants (2)
Air Bags:sensor:side Impact
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Aug 23, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 Super Cab vehicles. The front seatbelt webbing may be incorrectly routed.
Consequence & remedy
Consequence: A misrouted seatbelt may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Owners are advised to perform a preliminary self-inspection of the front seatbelts. If the passenger-side seatbelt fails inspection, owners should not use the passenger seat until the repair is performed. If the driver-side seatbelt fails inspection, owners should not drive their vehicle until the repair is performed. Dealers will inspect the front seatbelts and, if the webbing is misrouted, will replace the seatbelt retractor and pretensioner, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C20.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The electronic brake booster may leak brake fluid into the electronic control unit, which could result in reduced braking performance.
Consequence & remedy
Consequence: Reduced braking performance can increase the risk of a crash.
Remedy: Dealers will replace the electronic brake booster assembly, free of charge. Owner notification letters were mailed on July 28, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S33.
May 29, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence & remedy
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
Additional source detail variants (3)
Steering:rack And Pinion
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
Steering:gear Box (other Than Rack And Pinion)
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
Steering
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
May 24, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The two-piece driveshafts may have been improperly assembled, which could result in driveshaft separation.
Consequence & remedy
Consequence: Driveshaft separation may result in a sudden loss of drive power, or unintended vehicle movement if the vehicle is in park without the parking brake applied, increasing the risk of a crash.
Remedy: Dealers will inspect the driveshaft, and replace it if necessary, free of charge. Owner notification letters were mailed on June 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S25.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Additional source detail variants (2)
Visibility:windshield:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Visibility:windshield
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA23002 · Loss Of Motive Power
Opened Sep 29, 2023 · Closed Oct 31, 2024
Status: closed (inferred from source dates) · Engine
On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the ability to restart. During PE22007, the cause of engine failure and loss of motive power in the subject vehicles was determined to be intake valve fracture, and the full scope of vehicles affected by the subject defect was identified as all MY 2021-2022 Ford and Lincoln models equipped with either the 2.7L or 3.0L EcoBoost engines, referred to as the “Nano” engine family. If an intake valve fractures in the subject engines, it may drop into the cylinder and contact the piston, often resulting in catastrophic engine damage. On September 29, 2023, PE22007 was upgraded to an Engineering Analysis (EA23002) to further investigate the subject defect across the full scope of affected vehicles. During EA23002, ODI visited Ford facilities to review technical information related to intake valve fracture in “Nano” engines, coordinated with NHTSA’s Vehicle Research and Testing Center (VRTC), and analyzed updated field data relating the subject defect. Forensic analysis of fractured intake valves demonstrated that the defective components exhibited “grinding burn” or out of specification hardness in the area of the keeper grooves. The presence of grinding burn is evidence that during the groove grinding phase of production, the temperature of the valve became sufficiently high to alter the microstructure of the material and is indicative that the valve supplier’s manufacturing processes were not within control specifications. Grinding burn results in a hard, brittle microstructure and high residual stresses toward the surface of the valve. Through normal engine loading, a valve with grinding burn will likely fracture at the area of highest vulnerability, which is the third keeper groove. In its response to the EA23002 Information Request (IR) letter, Ford provided evidence of 396 customer complaints (including field reports), 825 warranty claims, and 936 engine exchanges. When considering both ODI and manufacturer failure report data, there have been reports representing 1066 unique vehicles within the subject vehicle population. Analysis of the failure report data demonstrates that vehicles equipped with potentially defective intake valves were built within a production “spike period” of May 2021 – October 2021. The beginning of the spike period corresponds to a ramp up in production at the valve supplier manufacturing facility, and the end of the spike period aligns with the implementation of several mid-production process improvements and the decision to change the metal alloy used to produce intake valves from “Silchrome Lite” to “Silchrome 1”. Ford began investigating the subject defect in July 2021, determined the root cause, and took corrective measures for the new production vehicles. Analysis of the failure report data demonstrates that these corrective actions were successful in eliminating the risk of intake valve fracture for subject vehicles produced after October 2021. However, Ford did not take any field action to address vehicles produced during the spike period, and in the several months following the implementation of the production changes, a significant number of field failures continued to occur. It is Ford’s assessment that not all valves produced during the spike period are defective, and that failures associated with the subject defect occur at low time in service. Analysis of the failure report data demonstrates that the vast majority of failures have occurred before 20,000 miles with over half of all reported failures occurring before 5,000 miles. The rate of reported failures related to the subject defect has steadily decreased since November 2021. ODI coordinated with NHTSA’s National Center for Statistics and Analysis (NCSA) to conduct statistical analysis and predict the number of future failures associated with the subject defect. The results of this analysis, and the trends identified through the failure report data are generally consistent with Ford’s assessment that defective intake valves will likely fail at a low time in service and indicate that the majority of subject vehicles equipped with defective valves have already experienced a failure. On August 23, 2024, Ford submitted recall 24V635 for subject vehicles equipped with “Nano” engines and built within the production spike period identified above (total population 90,736 vehicles). The remedy includes an inspection at a Ford/Lincoln dealership where the lifetime engine cycles of the vehicle will be determined. If a vehicle does not meet a threshold for lifetime engine cycles, the dealership will conduct a high RPM engine cycle accumulation procedure, which aims to identify if the vehicle is equipped with defective intake valves. Any vehicle that fails the accumulation procedure will receive an engine replacement under the recall. In addition to recall 24V635, Ford has stated that it will launch customer satisfaction campaign 24N12, which will provide extended warranty coverage to the subject vehicles through the earlier of 10 years or 150,000 miles. In view of the recall action being taken by Ford, ODI is closing this Engineering Analysis. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration