2020 Ford F-150

10r80 transmission shifts from 7th & 9th gear to 2nd gear causing truck to jerk and over rev. there were two mil lights local shop was able to read and reset once and cleared codes. This just recurred and truck was not able to be driven. Ended up replacing transmission same week as this problem started. New transmission has been fine since.

I was driving and slowing down for a stop sign and the engine shut off by itself while still moving at appx 10-15mph. The display had several warning lights appear, and the message "Auto Start Stop, Shift to P, Then Restart Engine". I have the Auto Start Stop disabled on my vehicle, so there was no reason for my engine to shut off while decelerating. I searched online for potential causes and discovered that there are numerous incidents of this happening (engine shutting off while moving) to drivers that have deactivated the auto start stop on their vehicles. See link: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

* This complaint concerns a catastrophic failure of the transmission in my vehicle. This defect was first reported to a Ford dealer while still within the 5-year/60,000-mile powertrain warranty (Jan 3, 2023, at 58,679 miles; Invoice #XXX). * The condition worsened. Between July 2024 - Jan. 2026, I received 7 digital "Service Engine Soon" warnings via the Ford App. My dealer advised that the vehicle was "OK to drive" as long as the light (which never stayed on) was not flashing. I was told diagnostics could not be made unless the light was active at the dealership. Jan 16, 2026, the light came on; I was able to take the truck to the dealer. A fault code was finally captured, but the dealer reported a two-month service backlog. I could not wait that long. *Feb 2026, I established a clean engine baseline. I spent $833.15 to replace O2 sensors (EJ’s Automotive) to rule out engine−related performance issues. During this service (at 103,431 miles), an inspection confirmed metallic clutch material contamination in the transmission fluid only 10,248 miles after a 2nd professional flush. This failure occurred despite a total maintenance investment of $11,533.80 across 21 service visits. * This failure resulted in a dangerous Loss of Motive Power, creating a collision risk. The vehicle is currently grounded and completely inoperable. The dealership verbally designated the vehicle as VOR due to the confirmed diagnosis, only to contradict that status by claiming it was "driveable" after I declined a $15,000 quote for a teardown to diagnose the issue. * Since the truck can no longer tow, 2 third-party transports for a horse and a trailer relocation are necessary. The failure has also resulted in a total parasitic battery drain. The tailgate latch and door locks are inoperable, suggesting the transmission fault is interfering with module communication. This is consistent with the root cause Ford has acknowledged in TSBs 24-2101 and 25-2126 involving the CDF clutch drum sleeve. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF

My 2020 Ford F-150 5.0L Coyote V8 had its engine replaced under factory warranty on 4/30/25 by an authorized Ford dealer. The replacement engine was installed with my original 50,000 mile fuel injectors reinstalled by Ford's technician — I was not informed new injectors were not included. The vehicle is now diagnosed with a failed direct fuel injector causing a cylinder 3 misfire at approximately 10,000-12,000 miles on the replacement engine. Additional injectors show signs of imminent failure. The shop also documented the replacement engine running 2 quarts low on oil at only 10,000-12,000 miles of service. This level of oil consumption on a recently replaced engine is abnormal and unexplained. The safety concern is twofold. First, a vehicle running chronically low on oil due to abnormal consumption on a replacement engine risks catastrophic engine failure without adequate warning to the driver. Second, misfiring cylinders affect vehicle driveability and create unpredictable power delivery that constitutes a safety risk particularly at highway speeds. Symptoms including rough running and the check engine light first appeared in November 2025. The vehicle has been at an authorized Ford dealer for diagnosis since May 2026. Ford Customer Relations has declined goodwill assistance despite the failure occurring on components reinstalled by Ford's own technician during a warranty repair, symptoms originating within the warranty window, and the vehicle being only 8 days outside the 12-month parts warranty expiration. I am requesting NHTSA investigate whether Ford's practice of reusing high-mileage fuel injectors during engine replacements under warranty constitutes an unsafe practice, and whether abnormal oil consumption on replacement engines represents a systemic defect.

I own a Ford F-150 equipped with the 10R80 10-speed transmission. The truck has approximately 79,000 miles and has been diagnosed by a Ford dealership with CDF drum/cylinder and solenoid body failure. The quoted repair cost is over $10,000 for a remanned transmission replacement. This truck has shifted hard since approximately 30,000 miles, but I was led to believe it was normal behavior for the 10-speed transmission. The vehicle has been lightly used and properly maintained through Ford. It is still on its original tires and brakes, which supports that this is not a high-abuse or heavy-use vehicle. A major transmission failure at 79,000 miles under normal use is not reasonable vehicle durability. The failure involves the CDF drum/cylinder, a known failure point in the Ford 10R80 transmission. This can cause harsh shifting, delayed engagement, gear skipping, slipping, abnormal acceleration behavior, and unpredictable shifting. These conditions create a safety concern when accelerating into traffic, merging, turning across lanes, passing, or driving at highway speeds. Ford has issued technical service guidance related to the 10R80 transmission and CDF drum/cylinder failure, including diagnostic procedures for hydraulic leakage and internal repair. This confirms the issue is known and identifiable, yet owners are still facing extremely expensive failures outside the standard warranty period. Another concern is that Ford is proposing remanufactured transmission replacements rather than new replacements, despite reports of repeat CDF-related failures after remanufactured units if updated CDF components are not included. This is not normal wear and tear. This is premature failure of a known defective transmission component that affects drivability, reliability, and safety. Ford should not leave customers responsible for potentially multiple $10,000+ repair costs for a known 10R80/CDF drum failure.

The transmission was already rebuilt under warranty, had 49,700 miles. While traveling between 70-80(while passing)open road the transmission tried going into 1st gear happned a few times until went into limp mode. Just me, no trailer, nothing in the bed. The dealership nor corporate would do anything since I had turned off the truck. Even though the codes were stored.