NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
724 reports23,900 miles · Jun 14, 2022
Electrical SystemEngine
The contact owns a 2020 Ford F-150. The contact stated while driving 35 MPH and attempting to accelerate, a warning message to pull over and restart the vehicle was displayed. The vehicle independently powered down and was restarted by the contact to keep driving. The contact stated that the failure occurred twice. The contact h…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving 35 MPH and attempting to accelerate, a warning message to pull over and restart the vehicle was displayed. The vehicle independently powered down and was restarted by the contact to keep driving. The contact stated that the failure occurred twice. The contact had not taken the vehicle to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 23,900.
NHTSA ODI #11469111
Mileage unknown · Jun 12, 2022
Exterior Lighting
bolts falling out that connect the grounding wire on the passenger and driver side rear frame. causes all lights on both side to not work. No notification is given for this fault. May cause you to drive without know that you have no stop lights turn singles.
NHTSA ODI #11468858
Mileage unknown · Jun 11, 2022
EngineUnknown Or Other
I was driving and I came to a stop sign when I tried to accelerate the engine turned off and I was turning into traffic thankfully I was able to pull into the middle lane. The screen showed the auto stop start symbol and to put the truck in park and turn the key. When I restarted the truck it was driving fine. I took the truck i…
Read full complaint
I was driving and I came to a stop sign when I tried to accelerate the engine turned off and I was turning into traffic thankfully I was able to pull into the middle lane. The screen showed the auto stop start symbol and to put the truck in park and turn the key. When I restarted the truck it was driving fine. I took the truck in to dealer and they found nothing wrong with it very scary.
NHTSA ODI #11468774
Mileage unknown · May 16, 2022
Power Train
Transmission clunks randomly in various situations that are unpredictable. It will occasionally slam itself into a gear which is obviously creating an unsafe situation, especially when towing. Other times it can't figure out which gear it wants, creating yet more unsafe situations, especially when towing. Fuel mileage is excessi…
Read full complaint
Transmission clunks randomly in various situations that are unpredictable. It will occasionally slam itself into a gear which is obviously creating an unsafe situation, especially when towing. Other times it can't figure out which gear it wants, creating yet more unsafe situations, especially when towing. Fuel mileage is excessive even for a pickup truck. After scanning with BlueDriver, fuel trim numbers are significantly out of range causing excessive fuel consumption and lack of power.
NHTSA ODI #11464806
25,000 miles · May 9, 2022
Power TrainService BrakesCrashInjury
The contact owns a 2020 Ford F-150. The contact stated that the vehicle was parked due to an unknown electrical door lock malfunction. Additionally, the contact stated that the vehicle would inadvertently roll forward while stopped without input from the driver. The contact depressed the brake pedal to stop the vehicle. The cont…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that the vehicle was parked due to an unknown electrical door lock malfunction. Additionally, the contact stated that the vehicle would inadvertently roll forward while stopped without input from the driver. The contact depressed the brake pedal to stop the vehicle. The contact stated that the failure recurred while the vehicle was stopped and the gear shifter was in park(P). The contact stated that after exiting the vehicle, the vehicle rolled forward, struck, and ran over a passenger before coming to a stop. The passenger suffered head injuries and sought medical attention. A police report was not filed. The vehicle was taken to an independent mechanic and diagnosed with a defective gear shift indicator. The contact was informed that the gear shift indicator needed to be replaced. The contact was unsure if the vehicle was repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 25,000.
NHTSA ODI #11463916
Mileage unknown · May 5, 2022
Engine
This safety problem has happened twice in the last 3 months without warning. There are no check engine or service lights on of any kind. I was operating my vehicle on paved city roads driving at normal pace for the conditions. First time this incident happened I was driving approximately 25 mph beginning to scrub speed for a s…
Read full complaint
This safety problem has happened twice in the last 3 months without warning. There are no check engine or service lights on of any kind. I was operating my vehicle on paved city roads driving at normal pace for the conditions. First time this incident happened I was driving approximately 25 mph beginning to scrub speed for a stoplight. Without warning the vehicle shutoff and had no power to anything. The warning on the dash said put vehicle in park to restart. I had to park on a 45mph road with traffic and no shoulder to restart my vehicle. After this first incident I took my vehicle to the dealership and they were unable to find anything wrong. The second time this same incident happened was yesterday 5/4/22. I was turning right at approximately 10-12mph and vehicle shutoff without warning. Lost power to all systems. I had to again park the vehicle on a busy road abruptly to restart, only after having to place vehicle in park. Pending visit to dealership on Monday 5/9/22. Ford has also been contacted and incidents documented.
NHTSA ODI #11463532
Mileage unknown · Apr 26, 2022
Engine
When at a stop sign, with the auto start stop engaged, I went to accelerate and the engine stalled with the following message of "auto start stop shift to P, then restart engine". This was extremely dangerous and a safety issue that Ford needs to fix. I was in the middle of an intersection and thankful no other vehicles approa…
Read full complaint
When at a stop sign, with the auto start stop engaged, I went to accelerate and the engine stalled with the following message of "auto start stop shift to P, then restart engine". This was extremely dangerous and a safety issue that Ford needs to fix. I was in the middle of an intersection and thankful no other vehicles approaching. I had to shift to Park, turn ignition switch off and restart engine. Vary concerning in driving this vehicle anymore!
NHTSA ODI #11462367
Mileage unknown · Apr 15, 2022
Power Train
While towing and in cruise control transmission shifts erratically and will not upshift out of lower gears unless done manually. Clunks going into some gears and while downshifting
NHTSA ODI #11460918
Mileage unknown · Apr 14, 2022
Air BagsCrashInjury
MY WIFE AND I WERE STOPPED AT A STOPLIGHT IN HOT SPRINGS ARKANSAS ON MARCH 8, 2022. ANOTHER VECHICLE RAN INTO US ALMOST HEAD ON AT AN ESTIMATED 30 MPH. THERE WAS CONSIDERABLE DAMAGE TO THE FRONT END OF OUR TRUCK. THE AIR BAGS DID NOT DEPLOY. WE WERE TAKEN TO THE HOSPITAL. MY WIFE HAS SOME BROKEN BONES IN HER BACK AND HAS EXPERIE…
Read full complaint
MY WIFE AND I WERE STOPPED AT A STOPLIGHT IN HOT SPRINGS ARKANSAS ON MARCH 8, 2022. ANOTHER VECHICLE RAN INTO US ALMOST HEAD ON AT AN ESTIMATED 30 MPH. THERE WAS CONSIDERABLE DAMAGE TO THE FRONT END OF OUR TRUCK. THE AIR BAGS DID NOT DEPLOY. WE WERE TAKEN TO THE HOSPITAL. MY WIFE HAS SOME BROKEN BONES IN HER BACK AND HAS EXPERIENCED SIGNIFICANT PAIN SINCE THE ACCIDENT.
NHTSA ODI #11460779
Mileage unknown · Apr 3, 2022
Power TrainCrash
Right rear axel snapped just at the outside of the axel bearing The vehicle felt like it was shaking for about 4 seconds, at the same time the following warnings appeared, Antilock Brake Fault, Hill Start Assist Warning, Tire Pressure Warning, Hill decent control fault, Pre Collision Assist Not Available. The vehicle was travel…
Read full complaint
Right rear axel snapped just at the outside of the axel bearing The vehicle felt like it was shaking for about 4 seconds, at the same time the following warnings appeared, Antilock Brake Fault, Hill Start Assist Warning, Tire Pressure Warning, Hill decent control fault, Pre Collision Assist Not Available. The vehicle was traveling on I-293 left lane at high way speed, cruise control set. The vehicle tilted and made a near 90degree turn to the right heading towards the MerriMack River, Manchester NH. Poor steering control almost zero, brakes failed, shifted auto trans to lowest gear. Aimed for snow wind row to stop or reduce speed. came to rest at the right lane separation zone for ramp @ 6.3 mile marker. Towed to LondonDerry Ford, Londonderry NH Vehicle inspected by State Farm Insurance for body damage unable to see underside damage except snapped axel. Inspected by by Londonderry Ford for underside damage. Vehicle body damage set at an estimated 11,731. Front wall of bed box all rivets snapped. Accident Date 06 Feb. 2022 @ 07:30 vehicle mileage at time 10,672 vehicle date in service 27 Feb 2021 Filed complaint with Ford #CAS35691689 Carrie at Ford Factory claims spec. 8665676518 ext.76792. I inspected the axel at the break point on both halfs, judging from visual inspection and photo enlargement the axel appears to be a poor casting with a discoloration in the center pock marks over aprox. 80% of the face area of the break. The road conditions were dry and clear, straight road, snow plow row to right, traffic light. All lug nuts tight and in place. ** I believe it is note worthy that Ford is taking responsibility by running axel failure through Warranty and body damage through General Council. They refuse to place this in writing, they are also urging that I let them run it through Sate Lemon Law, to me it sounds like they want to hide it. Another exact same failure at AutoFair Ford Manchester NH as of 3/31/2022 sounds fishy to me. ,
NHTSA ODI #11459398
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration