NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
12 reportsClear category filterMileage unknown · Dec 19, 2025
Fuel/propulsion SystemPower TrainVehicle Speed Control
Vehicle is showing symptoms similar to common reported problems from people who owned Ford F-150 with Eco-boost. Symptoms such as: Engine had difficulty starting Transmission shifting Rattling noises coming out from the engine compartment Oil leaks coming out the tail pipe Gauge is showing engine is over heating Turbo is havin…
Read full complaint
Vehicle is showing symptoms similar to common reported problems from people who owned Ford F-150 with Eco-boost. Symptoms such as: Engine had difficulty starting Transmission shifting Rattling noises coming out from the engine compartment Oil leaks coming out the tail pipe Gauge is showing engine is over heating Turbo is having a hard time accelerating
NHTSA ODI #11706155
Mileage unknown · Jul 31, 2025
EngineFuel/propulsion System
fuel injector cracked and started spraying fuel in engine compartment and onto hot motor.
NHTSA ODI #11677473
Mileage unknown · Jul 28, 2025
Fuel/propulsion System
Check engine light turn on with the code P0087. The truck don't turn on quickly. Lose power at high demand or RPM.
NHTSA ODI #11676839
Mileage unknown · Apr 22, 2025
Fuel/propulsion SystemPower Train
Driving at highway speeds and my truck began to shake violently and very loud banging sound. Slowed down to pull over on the highway. Found driveshaft broken in half with gas dumping out of the fuel tank. Broken driveshaft damaged heat shield for gas tank, punctured gas tank and dented/broke clips on exhaust. Very lucky back dri…
Read full complaint
Driving at highway speeds and my truck began to shake violently and very loud banging sound. Slowed down to pull over on the highway. Found driveshaft broken in half with gas dumping out of the fuel tank. Broken driveshaft damaged heat shield for gas tank, punctured gas tank and dented/broke clips on exhaust. Very lucky back driveshaft didn’t hit pot hole and leaking gas didn’t start a fire. Stranded on side of road for hours. Sent my vin to the dealership and they said my was not under the recall #21S56 even tho it was built after known driveshaft issue and clearly the insulator caused the issue.
NHTSA ODI #11656117
Mileage unknown · Oct 12, 2024
Fuel/propulsion SystemPower TrainVehicle Speed Control
The transmission slips when giving it gas. I lose power when I excelerate Sometimes. Sometimes the truck excelerates when I'm not giving It throttle. Transmission jumps all over. The transmission seems to be very rough shifting back and forth
NHTSA ODI #11619502
Mileage unknown · Jun 22, 2024
EngineFuel/propulsion SystemUnknown Or Other
On or about April 2024, the "check engine" light came on in my 2020 Ford F-150. My vehicle was just becoming due for re-registration. I had the code for the check engine light checked at my parts dealer and double checked at the maintenance facility I was having services done. The check engine code was for the catalytic converte…
Read full complaint
On or about April 2024, the "check engine" light came on in my 2020 Ford F-150. My vehicle was just becoming due for re-registration. I had the code for the check engine light checked at my parts dealer and double checked at the maintenance facility I was having services done. The check engine code was for the catalytic converter. I had the catalytic converter and O2 sensors replaced at my service provider, the check engine light was extinguished and the codes had been removed, the vehicle emissions no longer reported on the service/inspection station and the vehicle passed the emissions/safety check for re-registration. In less than one month, the check engine light came on again, with the exact same codes that identify the catalytic converter failing. Both the parts dealer and the service provider tell me that it's impossible. Further checking by the service provider with Ford motor Company service center have told my service provider that my vehicle needs to have the onboard computer system erased and re-installed at my cost because only Ford has the program to do it at their service centers exclusively. This problem seems to be appearing with other Ford vehicles of the same year and engine size. I personally stood in line behind another man who was reporting a problem with his vehicle with the check engine light. Jokingly, I made the comment, "It must be a Ford" and he turned around and asked me "How did you know?" His vehicle is a 2020 Ford van that was parked outside next to my truck. It also has a 5.0 liter V8. Currently, I am awaiting an appointment at either Casa Ford or Visa Ford, the earliest opportunity for them to reprogram the onboard computer system.
NHTSA ODI #11595909
Mileage unknown · Dec 9, 2023
Fuel/propulsion System
Noticed significant gasoline leak under fuel tank when the engine was running. From the ground, looked up and saw that fuel was leaking from a black fuel hose originating at the top of fuel tank and directed going toward the engine. The fuel hose had dropped below the top of the truck frame and chaffed against a frame mounting…
Read full complaint
Noticed significant gasoline leak under fuel tank when the engine was running. From the ground, looked up and saw that fuel was leaking from a black fuel hose originating at the top of fuel tank and directed going toward the engine. The fuel hose had dropped below the top of the truck frame and chaffed against a frame mounting point wearing a hole in the hose. Suspect the hose was manufactured to long allowing the droop, or was installed incorrectly (not clamped to prevent droop), or the hose installation was just defective as the hose is to long and a clamp was not part of the vehicle design. My truck has about 23,500 miles and has only been operated on paved roads and used for either commuting or carrying light household loads.
NHTSA ODI #11559299
Mileage unknown · Sep 10, 2023
Electrical SystemEngineFuel/propulsion System
Reporting this same incident type again. My truck continues to sporadically shutoff while operating the vehicle. My truck has shutoff while driving twice in the past 2 months. Under normal driving conditions I can be driving and suddenly the engine will shutoff and I lose all power and power steering. The latest episode I was tu…
Read full complaint
Reporting this same incident type again. My truck continues to sporadically shutoff while operating the vehicle. My truck has shutoff while driving twice in the past 2 months. Under normal driving conditions I can be driving and suddenly the engine will shutoff and I lose all power and power steering. The latest episode I was turning right with traffic approaching behind with my kids in the truck as well. The error on the dash is the same every time “Auto StartStop Manual Restart Required”. I have to come to a complete stop and put the truck in park to be able to restart. Having to stop on a very busy road to restart is a major safety issue and I believe this truck will end up hurting myself or others. I have had the truck into ford more than once and they claim there is no problem even though I show pictures and video. I contacted ford directly again and they really don’t seem to care very much, from what I can tell they refuse to acknowledge I have a problem with the truck. Please help me.
NHTSA ODI #11543648
Mileage unknown · Aug 29, 2022
Fuel/propulsion System
On 8/26/22 I smelled gas after parking 2020 F150 with ~ 33,000 miles. I had filled the tank the previous day ( <20 miles driven since that time). I was in a marina parking lot at that point and dismissed the smell as perhaps someone spilling some fuel from a portable gas tank. Upon arriving home I again smelled a strong odor …
Read full complaint
On 8/26/22 I smelled gas after parking 2020 F150 with ~ 33,000 miles. I had filled the tank the previous day ( <20 miles driven since that time). I was in a marina parking lot at that point and dismissed the smell as perhaps someone spilling some fuel from a portable gas tank. Upon arriving home I again smelled a strong odor of gas and noted my fuel gauge registered 3/4 of a tank ( despite driving < 30 miles since refueling). A very brisk gas leak was evident under pressure from a fuel hose fitting. The high pressure stream abated with turning off the engine ( but a slow fuel leak was still notable.) The vehicle was towed to Ravenel Ford in Ravenel, S.C. awaiting inspection/parts. No warning lights. I did note the engine hesitated to start (which it never had done prior) before driving back home from the marina. I do not off-road with the truck and have not scraped any obstacles with the truck.
NHTSA ODI #11481731
Mileage unknown · Jun 8, 2021
Fuel/propulsion SystemPower Train
At approximately 9700 miles my truck has started malfuctioning and causing a safety risk. On takeoff the truck feels powerless until approximately 3 seconds after pressing the gas pedal. While crossing an intersection, I hit the gas which moved my truck forward very slowly in front of on-coming traffic but took approximately 3 s…
Read full complaint
At approximately 9700 miles my truck has started malfuctioning and causing a safety risk. On takeoff the truck feels powerless until approximately 3 seconds after pressing the gas pedal. While crossing an intersection, I hit the gas which moved my truck forward very slowly in front of on-coming traffic but took approximately 3 seconds to start moving at the rate of speed a vehicle normally should. I could have been T-boned from this. The main issue I have noticed is while driving between 20 and 40 mph and giving enough gas to maintain speed, the truck starts jolting back and forth until I either let my foot off the gas or floor it. It also makes a clunking noise in the rear end while this happens. I called Ford and scheduled an appointment which was 4 weeks out and they just told me to "Take it easy driving it, it will be fine." This is not a once in a while issue, this happens every single time I drive my truck and does not go away no matter how long I'm driving it for.
NHTSA ODI #11420183
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration