NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
299 reportsClear category filter77,566 miles · Sep 30, 2019
Service BrakesService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2015 FORD F-150. WHEN THE CONTACT'S WIFE WAS DRIVING 45 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. ALSO, THE LOW BRAKE FLUID WARNING INDICATOR ILLUMINATED. THE EMERGENCY BRAKE HAD TO BE ENGAGED TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO COURTESY FORD (6393 US-98, HATTIESBURG,…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD F-150. WHEN THE CONTACT'S WIFE WAS DRIVING 45 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. ALSO, THE LOW BRAKE FLUID WARNING INDICATOR ILLUMINATED. THE EMERGENCY BRAKE HAD TO BE ENGAGED TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO COURTESY FORD (6393 US-98, HATTIESBURG, MS 39402, (601) 264-5555) WHERE THE MASTER CYLINDER, BRAKE BOOSTER, AND BRAKE BOOSTER SENSOR WERE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT ASSIST. THE FAILURE MILEAGE WAS 77,566. *PM*JB
NHTSA ODI #11258978
90,000 miles · Sep 24, 2019
Service Brakes
TL* THE CONTACT OWNS A 2015 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH, THE 'LOW BRAKE FLUID' MESSAGE SUDDENLY DISPLAYED AND THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WHEN ATTEMPTING TO SLOW DOWN THE VEHICLE. THE VEHICLE WAS TAKEN TO LAWHORN FORD (2434 LAKEWAY DR, RUSSELL SPRINGS, KY) WHERE IT WAS DIAGNOSED THAT THE BRAKE S…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD F-150. WHILE DRIVING APPROXIMATELY 65 MPH, THE 'LOW BRAKE FLUID' MESSAGE SUDDENLY DISPLAYED AND THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WHEN ATTEMPTING TO SLOW DOWN THE VEHICLE. THE VEHICLE WAS TAKEN TO LAWHORN FORD (2434 LAKEWAY DR, RUSSELL SPRINGS, KY) WHERE IT WAS DIAGNOSED THAT THE BRAKE SEAL HAD RUPTURED AND THE MASTER CYLINDER AND BRAKE BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. JFT*PM MANUFACTURER STATED THAT THEY COULD NOT PROVIDE ASSISTANCE BECAUSE THERE WERE NO RECALLS FOR THE VEHICLE. *DL
NHTSA ODI #11257690
148,000 miles · Sep 23, 2019
Service Brakes
I HAVE EXPERIENCE A BRAKE FAILURE DURING THE OPERATION OF MY VEHICLE, SIMILAR TO THE DESCRIPTION WITHIN THE FINDINGS FOR FORD 16S24 ' BRAKE MASTER CYLINDER REPLACEMENT ' 2013-2014 FORD F-150 ON MY 2015 FORD F-150 WITH THE SAME MOTOR. I HAVE HAD A NON-FORD MECHANIC TAKE A LOOK AND FOUND THE SAME CONDITION DESCRIBED IS WHAT HAPPEN…
Read full complaint
I HAVE EXPERIENCE A BRAKE FAILURE DURING THE OPERATION OF MY VEHICLE, SIMILAR TO THE DESCRIPTION WITHIN THE FINDINGS FOR FORD 16S24 ' BRAKE MASTER CYLINDER REPLACEMENT ' 2013-2014 FORD F-150 ON MY 2015 FORD F-150 WITH THE SAME MOTOR. I HAVE HAD A NON-FORD MECHANIC TAKE A LOOK AND FOUND THE SAME CONDITION DESCRIBED IS WHAT HAPPENED TO MY VEHICLE, AS WELL AS HAVE THE VEHICLE NOW BEING INVESTIGATED BY AN AUTHORIZED FORD MECHANIC. I WOULD LIKE TO ENSURE THAT THE SCOPE OF THE INVESTIGATION INCLUDE EXPANSION TO 2015 VEHICLES BUILT IN THE SAME MANUFACTURING LOCATIONS, AS I BELIEVE MY SAME SITUATION AND RISK EXIST FOR MINE. FOR REFERENCE OS THE SITUATION, I HAVE ADDED THE LINK TO THE ISSUE WRITE UP. HTTPS://STATIC.NHTSA.GOV/ODI/RCL/2016/RCMN-16V345-1450.PDF
NHTSA ODI #11257328
77,000 miles · Sep 13, 2019
Service Brakes
STARTED THE VEHICLE AND IMMEDIATELY RECEIVED AN ERROR MESSAGE STATING THE BRAKE FLUID RESERVOIR HAD LOW FLUID. THE BRAKE WARNING LIGHT WAS ALSO ACTIVATED. WHEN THE BRAKE PEDAL WAS DEPRESSED IT WENT ALL THE WALL TO THE FLOOR. REFILLED THE RESERVOIR AND RESTARTED THE VEHICLE. MOVED THE VEHICLE AND PRESSED THE BRAKE PEDAL, WHIC…
Read full complaint
STARTED THE VEHICLE AND IMMEDIATELY RECEIVED AN ERROR MESSAGE STATING THE BRAKE FLUID RESERVOIR HAD LOW FLUID. THE BRAKE WARNING LIGHT WAS ALSO ACTIVATED. WHEN THE BRAKE PEDAL WAS DEPRESSED IT WENT ALL THE WALL TO THE FLOOR. REFILLED THE RESERVOIR AND RESTARTED THE VEHICLE. MOVED THE VEHICLE AND PRESSED THE BRAKE PEDAL, WHICH WENT TO THE FLOOR. RECEIVED ANOTHER BRAKE ACTIVATED AND LOW BRAKE FLUID WARNINGS AGAIN. I HAVE HAD THE VEHICLE TOWED TO BEECHMONT FORD, CINCINNATI, OH FOR DIAGNOSIS AND REPAIR. AWAITING THEIR FINDINGS.
NHTSA ODI #11255273
88,000 miles · Sep 12, 2019
Service Brakes
DRIVING, I RECEIVED A LOW BRAKE FLUID WARNING. THE NEXT BRAKING EVENT I LOST ALL BRAKE CONTROLS. I WAS NOT ABLE TO STOP. ALL TRAFFIC LIGHTS WERE GREEN AND WAS ABLE TO USE THE EMERGENCY BRAKE TO COME TO A COMPLETE STOP IN MY DRIVEWAY. ALMOST CAUSED TWO INCIDENTS BUT WAS ABLE TO SWERVE
NHTSA ODI #11255210
74,000 miles · Sep 11, 2019
Service Brakes
TL* THE CONTACT OWNS A 2015 FORD F-150. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKES SEIZED AND DID NOT STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO RED MCCOMBS FORD (833-504-1993, LOCATED AT 8333 W I-10, SAN ANTONIO, TX 78230) WHERE IT WAS DETERMINED THAT THERE WAS NO RECALL. THE VEHICLE WAS LEFT WITH THE DEALER FOR DIAGNOSTIC …
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD F-150. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKES SEIZED AND DID NOT STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO RED MCCOMBS FORD (833-504-1993, LOCATED AT 8333 W I-10, SAN ANTONIO, TX 78230) WHERE IT WAS DETERMINED THAT THERE WAS NO RECALL. THE VEHICLE WAS LEFT WITH THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 74,000.
NHTSA ODI #11254816
56,000 miles · Sep 9, 2019
Service Brakes
COMPLETE BRAKE FAILURE. WHILE MY 15 YEAR OLD SON WAS DRIVING WITH HIS LEARNERS PERMIT, WE WERE EXITING A HIGHWAY. THE WEATHER WAS CLEAR AND DRY. AS HE WAS SLOWING DOWN THE VEHICLE ON A 65MPH HWY OFF RAMP, AT APPROXAMATLY 35-40 MPH THE LOW BRAKE FLUID LIGHT CAME ON AND THE BRAKE PEDAL WENT SOFT AND ALMOST TO THE FLOOR. HE WASN'T …
Read full complaint
COMPLETE BRAKE FAILURE. WHILE MY 15 YEAR OLD SON WAS DRIVING WITH HIS LEARNERS PERMIT, WE WERE EXITING A HIGHWAY. THE WEATHER WAS CLEAR AND DRY. AS HE WAS SLOWING DOWN THE VEHICLE ON A 65MPH HWY OFF RAMP, AT APPROXAMATLY 35-40 MPH THE LOW BRAKE FLUID LIGHT CAME ON AND THE BRAKE PEDAL WENT SOFT AND ALMOST TO THE FLOOR. HE WASN'T ABLE COME TO COMPLETE STOP. WE MADE A RIGHT TURN ROLLING ONTO THE CROSS STREET AND AN ONCOMING VEHICLE HAD TO SLAM ON THEIR BRAKES TO AVOID US. I THEN TOOK OVER THE DRIVING TO GET THE VEHICLE HOME. IT WAS CLEAR THERE WERE NO POWER BRAKES AND THE BRAKE PEDAL WAS SOFT, TAKING MUTCH MORE DISTANCE TO DEPRESS THE PEDAL. ONCE WE WERE HOME I ADDED BRAKE FLUID AGAIN AND AGAIN TOTALING TWO QUARTS OF FLUID. THE FLUID WOULD ONLY LAST IN THE RESERVIOR FOR SEVERAL MINUTES THEN IT WOULD DRAIN DOWN. THERE WERE NO SIGNS OF FLUID LEAKING ANYWHERE ALONG THE ENTIRE BRAKE SYSTEM. THE VEHICLE IS NOW UNDRIVABLE. MY ASUMPTION IS THAT THE FLUID IS LEAKING INTO THE BRAKE BOOSTER. THE VEHICLE IS IN TRANSIT TO THE DEALER FOR DIAGNOSTICS.
NHTSA ODI #11254116
78,050 miles · Sep 8, 2019
Service Brakes
I WOULD LIKE TO SHARE MY WIFE'S STORY ON WHAT HAPPENED WHILE DRIVING MY 2015 F-150 3.5L ECOBOOST LAST THURSDAY 9/5/2019. AROUND 5:30PM MY CELL PHONE RINGS AND THE ID SHOWS THAT IT IS MY WIFE CALLING ME. I FIGURED SHE WAS CALLING ME TO TALK ABOUT HER DAY OR WHAT I WAS MAKING FOR DINNER BUT SHE WAS REALLY CALLING ME TO TELL ME MY …
Read full complaint
I WOULD LIKE TO SHARE MY WIFE'S STORY ON WHAT HAPPENED WHILE DRIVING MY 2015 F-150 3.5L ECOBOOST LAST THURSDAY 9/5/2019. AROUND 5:30PM MY CELL PHONE RINGS AND THE ID SHOWS THAT IT IS MY WIFE CALLING ME. I FIGURED SHE WAS CALLING ME TO TALK ABOUT HER DAY OR WHAT I WAS MAKING FOR DINNER BUT SHE WAS REALLY CALLING ME TO TELL ME MY TRUCK'S BRAKE AND FLUID LIGHT SENSOR CAME ON. SHE WAS WORRIED ABOUT DRIVING THE TRUCK ANY FURTHER AS SHE WAS COMING DOWN THE HIGHWAY. I TOLD HER THAT I WOULD GOOGLE TO SEE IF ANYONE ELSE WAS HAVING THIS ISSUE AND THAT I WOULD CALL HER RIGHT BACK. I QUICKLY SEARCHED 2015 F-150 BRAKE AND FLUID LIGHT SENSOR AND INSTANTLY FOUND SEVERAL POSTS ABOUT PEOPLE HAVING THIS ISSUE. AFTER READING A COUPLE VERY QUICKLY, MOST PEOPLE SAID THAT THEY LOST THEIR BRAKES INSTANTLY OR WITH IN MINUTES. I WAS WORRIED SO I QUICKLY CALLED HER BACK AND CALMLY ASKED HER IF SHE COULD GET OFF THE HIGHWAY OR PULL OFF ASAP. I THEN PROCEEDED TO TELL HER THAT SHE MIGHT LOSE THE BRAKES IN THE TRUCK. I TOLD HER TO CALL ME IF THE VEHICLE BECAME WORSE. AT THAT TIME SHE WAS CLOSE TO THE EXIT. AS SHE WAS APPROACHING THE OFF RAMP THE BRAKE PEDAL PUSHED ALMOST TO THE FLOOR. SHE PRESSED THE PEDAL AGAIN BEFORE GETTING TO THE YIELD SIGN AND REALIZED THAT SHE WAS LOSING THE BRAKES. LUCKILY THE TRAFFIC WAS NOT HEAVY IN THE ONCOMING TRAFFIC AND ALLOWED HER TO RUN THE YIELD SIGN WITHOUT HAVING THE ABILITY TO STOP IF NEEDED. SHE GOT IT STOPED. SHE THEN CALLED ME AGAIN TO TELL ME THAT THE TRUCK LOST ITS BRAKES AND THAT IT WAS UNABLE TO BE DRIVEN. AT THIS TIME THE BRAKE PEDAL WENT TO THE FLOOR EVERY TIME SHE PRESSED IT. WHEN I ARRIVED AT HER LOCATION THE BRAKE FLUID WAS ABOUT EMPTY. I REFILLED IT AND PRESSED THE BRAKES A FEW TIMES. WE HAD IT TOWED TO A FORD DEALERSHIP. FORD FOUND THAT THE MASTER CYLINDER FAILED. I'M STILL WAITING FOR THEM TO GET THE REPLACEMENT PART IN.
NHTSA ODI #11254026
51,000 miles · Sep 2, 2019
Service Brakes
I DEPRESSED BRAKE PEDAL TO START TRUCK. ONCE TRUCK STARTED THE PEDAL WENT ALL THE WAY TO THE FLOOR AND THE BRAKE WARNING LIGHT ON THE DASH ILLUMINATED. TRIED MOVING THE TRUCK A COUPLE FEET TO SEE IF I HAD BRAKES, AND THE TRUCK DID NOT STOP WHEN THE PEDAL WAS DEPRESSED. USED THE EMERGENCY BRAKE TO STOP. CHECKED THE MASTER CYLI…
Read full complaint
I DEPRESSED BRAKE PEDAL TO START TRUCK. ONCE TRUCK STARTED THE PEDAL WENT ALL THE WAY TO THE FLOOR AND THE BRAKE WARNING LIGHT ON THE DASH ILLUMINATED. TRIED MOVING THE TRUCK A COUPLE FEET TO SEE IF I HAD BRAKES, AND THE TRUCK DID NOT STOP WHEN THE PEDAL WAS DEPRESSED. USED THE EMERGENCY BRAKE TO STOP. CHECKED THE MASTER CYLINDER, IT WAS EMPTY. I ADDED ABOUT 10 OZ. OF BRAKE FLUID, PUMPED UP THE BRAKES AND IT WORKED. DROVE ABOUT 8 MINUTES TO WORK, BRAKES OK. I RETURNED TO THE TRUCK AFTER WORK, ABOUT 10 HOURS AND THE PEDAL WENT TO THE FLOOR AGAIN AND NO BRAKES. I FILLED MASTER CYLINDER AGAIN AND WAS ABLE TO DRIVE HOME. I DROVE VERY SLOWLY AND CAREFULLY BECAUSE I EXPECTED TO BRAKES TO FAIL AT ANY TIME. I LIVE 5 MILES FROM WORK. IF IT WAS ANY MORE I WOULD HAVE HAD THE TRUCK TOWED. I WILL HAVE IT TOWED TO THE DEALER IN THE MORNING.
NHTSA ODI #11252809
94,500 miles · Aug 31, 2019
Service Brakes
BRAKE FAILURE DUE TO BRAKE FLUID LEAKING THROUGH MASTER CYLINDER AND BEING SUCKED INTO THE EXHAUST. THE FLUID IS SUCKED OUT OF THE BRAKE SYSTEM THROUGH A VACUUM LINE IN THE MASTER CYLINDER AND BOOSTER WHICH LOWERS THE FLUID LEVEL AND LETS AIR INTO THE BRAKE LINES. THE BRAKE FLUID IS THEN BURNED IN THE EXHAUST AND CREATES WHITE …
Read full complaint
BRAKE FAILURE DUE TO BRAKE FLUID LEAKING THROUGH MASTER CYLINDER AND BEING SUCKED INTO THE EXHAUST. THE FLUID IS SUCKED OUT OF THE BRAKE SYSTEM THROUGH A VACUUM LINE IN THE MASTER CYLINDER AND BOOSTER WHICH LOWERS THE FLUID LEVEL AND LETS AIR INTO THE BRAKE LINES. THE BRAKE FLUID IS THEN BURNED IN THE EXHAUST AND CREATES WHITE SMOKE FROM THE EXHAUST PIPE. THE "LOW BRAKE FLUID" LIGHT CAME ON WHILE DRIVING ON A MAIN CITY ROAD AND THE BRAKES WENT OUT IMMEDIATELY AFTER. THE VEHICLE WOULD STOP ONLY IF THE BRAKE PEDAL WAS COMPRESSED ALL THE WAY TO THE FLOOR. ON SEVERAL OCCASIONS THE EMERGENCY BRAKE HAD TO BE USED TO BRING THE VEHICLE TO A COMPLETE STOP. AFTER THE "LOW BRAKE FLUID" LIGHT CAME ON, MORE BRAKE FLUID (32 OZ) WAS ADDED BUT IT WAS IMMEDIATELY SUCKED THROUGH THE MASTER CYLINDER AND INTO THE EXHAUST AND THE PROBLEM PERSISTED. I SCHEDULED AN APPOINTMENT TO HAVE A LOCAL FORD DEALERSHIP FLUSH THE BRAKE SYSTEM AS I ASSUMED THERE WAS AIR IN THE LINES DUE TO THE LOW FLUID LEVEL. AFTER THE DEALERSHIP FLUSHED THE BRAKE AND REPLACED ALL FLUID THE VEHICLE STILL HAD NO BRAKES. THIS IS WHEN THE PROBLEM WITH THE MASTER CYLINDER WAS DISCOVERED.
NHTSA ODI #11252595
Official recalls
13Apr 14, 2026
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150 vehicles. A loss of signal between the transmission range sensor and the powertrain control module can cause the transmission to unexpectedly downshift into second gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into second gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 24, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S28. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 15, 2026.
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2016 F-150 pick-up trucks equipped with 3.5L GTDI engines and block immersion heaters that were potentially relocated from their originally installed location. The incorrect location could put the heater too close to hot engine components, possibly resulting in a damaged cable.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the block heater's location and its cable, replacing components as necessary, free of charge. If the replacement parts are not available, dealers will disable the existing block heater cable from being used until parts become available. The recall began April 9, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S08.
Apr 8, 2019
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence & remedy
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Additional source detail variants (2)
Engine
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Equipment:electrical
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater and previously remedied under recall 18V894. During the previous repair, the block heater cable's splice connector may have been damaged.
Consequence: A damaged cable could cause a resistive short, increasing the risk of overheated or melted wiring, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the engine block heater from being used. When replacement cables become available, a second notice will be mailed and dealers will replace the engine block heater cord, free of charge. The recall began May 31, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S11.
Dec 18, 2018
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Aug 31, 2018
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence & remedy
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Additional source detail variants (2)
Seat Belts:pretensioner
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Structure:body:roof And Pillars
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford F-150 Regular Cab and SuperCrew Cab vehicles. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Consequence: A vehicle fire could result if materials ignite inside the vehicle.
Remedy: Ford will notify owners, and dealers will remove the B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall began September 28, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S27.
Oct 16, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford F-150, and 2017 F-250, F-350, F-450, and F-550 Super Duty trucks. The doors on these vehicles may have a bent or kinked actuation cable or the door latches may freeze after water gets into the latch. Either condition can result in the doors opening while driving although they appear to be closed.
Consequence & remedy
Consequence: A door that opens while driving can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the door latch actuation cables and repair if necessary, and install water shields over the door latches, free of charge. The recall began October 12, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S33.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250 and F-350 trucks equipped with a crew cab. The left rear inflatable seat belt buckle assembly may be inadequately attached to its mounting bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: If the left rear inflatable seat belt buckle separates from it's mounting bracket, the seat occupant may not be adequately restrained, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat belt assembly, replacing the attaching rivet as necessary, free of charge. Interim notices informing owners of the safety risk were mailed October 18, 2017. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 17C12.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence & remedy
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Structure:body:door
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Dec 22, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 SuperCrew trucks manufactured January 22, 2015, to March 17, 2015. The affected vehicles may be equipped with driver or front passenger seat belt anchorage assemblies whose pretensioner cable was not properly crimped. As a result, the seat belts may not properly restrain the seat occupant in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies" and 210, " Seat Belt Assembly Anchorages."
Consequence & remedy
Consequence: An occupant that is not be properly restrained is at an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver and/or front passenger side seat belt retractor(s) and pretensioner(s), free of charge. The recall began on February 12, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C17.
Sep 30, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 trucks manufactured March 18, 2014, to August 6, 2015 and equipped with Adaptive Cruise Control (ACC). While using the Adaptive Cruise Control, the vehicle may falsely detect an obstacle in its path and may unexpectedly apply the brakes.
Consequence & remedy
Consequence: A vehicle that unexpectedly brakes increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the cruise control module with updated ACC radar software, free of charge. The recall began on October 25, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S29.
May 12, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 trucks manufactured March 19, 2015, to March 30, 2015. The affected vehicles may have been built with a steering upper intermediate shaft that was improperly riveted.
Consequence & remedy
Consequence: If the intermediate shaft was improperly riveted, it could separate from the intermediate shaft flex coupling, resulting in a loss of steering control and increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will inspect the intermediate shaft and replace it, as necessary, free of charge. The recall began on May 22, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S17.
Apr 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-150 vehicles manufactured January 30, 2015, to January 31, 2015. The affected vehicles may have loose or missing underbody heat shields.
Consequence & remedy
Consequence: A missing underbody heat shield can lead to degradation or melting of the fuel or vapor lines, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the vehicle for missing underbody heat shields and fasteners, and will install the missing components as required, free of charge. The recall began on May 13, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S12.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA26001 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Jan 30, 2026 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. ODI is opening this Engineering Analysis (EA) to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified. To review the reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE25002 · Unintended Transmission Downshift And Rear Wheel Lock-up
Opened Mar 21, 2025 · Closed Jan 30, 2026
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers reported experiencing at least one wheel lockup event, during which the rear tires locked, screeched, or skidded during the transmission downshift. ODI also found that 114 of the 329 consumers reported having their vehicle’s molded lead frame or valve body assembly (which comes with a molded lead frame) replaced, 80 of which were confirmed through consumer submitted repair invoices. In its response to ODI’s Information Request, Ford provided an assessment of potential root cause of failure for the subject vehicles and how this failure is different from the failure associated with MY 2011-2014 Ford F-150 vehicles that was addressed by four safety recalls (16V-248, 19V-075, 19V-433, and 24V-444). Ford has identified that the defect in the recalled vehicle population involved lead frame supplier production issues resulting in signal loss from the Output Shaft Speed (OSS) sensor. Ford has identified that the alleged defect in the subject vehicle population involved degradation of electrical connections within the lead frame due to thermal cycling and vibration over extended time in service resulting in signal loss from the Transmission Range Sensor (TRS). Signal loss from the TRS can result in an unintended shift to neutral, unintended upshift, or unintended downshift which are regulated by a gear “shift map” based on the vehicle’s speed at the time of signal loss. According to Ford’s “shift map”, at speeds between 35-64 mph, the maximum allowable downshift would be to 2nd gear (i.e. a 6th to 2nd gear downshift event) which Ford has designated to represent the worst-case scenario for subject vehicles. Ford has also acknowledged that the worst-case scenario may also involve temporary wheel lockup. However, Ford has stated that the failure mechanism in the MY 2011-2014 F-150 vehicles—previously addressed through recalls—primarily involved OSS sensor signal loss that could result in 6th to 1st gear downshift events. This OSS-related failure mode is distinct from the TRS-related signal loss identified in the subject vehicle population. ODI has identified an additional potential safety defect associated with the alleged defect in the subject vehicles. Preliminary testing performed by NHTSA’s Vehicle Research Test Center (VRTC) showed that when the TRS experiences an intermittent signal loss, one possible outcome is a change in vehicle direction. Specifically, if a vehicle is operating in reverse up an incline when the TRS signal loss occurs, then the vehicle may shift into neutral causing the vehicle to change directions and roll forward. Based on NHTSA’s analysis of consumer data, information provided by Ford, and preliminary testing conducted by NHTSA’s VRTC, this Preliminary Evaluation is being upgraded to an Engineering Analysis (EA26001). During this Engineering Analysis, the agency plans to, among other things, perform component-level testing and vehicle testing, as well as review additional technical information to better understand the alleged defect that has been identified from this Preliminary Evaluation. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18008 · Seatbelt Pretensioner Fire
Opened Aug 3, 2018 · Closed Dec 17, 2018
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688
AQ17001 · Champion Ford Edinboro / Steering Shaft
Opened Jan 4, 2017 · Closed Jun 15, 2018
Status: closed (inferred from source dates) · Steering
NHTSA opened AQ17-001 to determine whether Champion Ford Edinboro, Inc. (Champion Ford), of Edinboro, Pennsylvania, complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ?30120(i)).NHTSA issued an information request (IR) letter to Champion Ford on January 4, 2017.Champion Ford responded to this request on January 19, 2017.Also on January 4, 2017, an IR letter was issued to Ford Motor Company (Ford) and a response was received from Ford on January 25, 2017.Finally, another IR was issued to Champion Ford on May 31, 2017, and Champion Ford's response letter was submitted to NHTSA on June 14, 2017.NHTSA's investigation indicated that Champion Ford did sell and deliver recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Champion Ford was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ?30165.Under a Settlement Agreement dated April 16, 2018, Champion Ford agreed to pay compromised civil penalties in the amount of $20,000.Champion Ford also represented in writing that it repaired all twenty-three (23) recalled vehicles identified in AQ17-001 and will strictly adhere to Ford's procedures requiring dealers to check for outstanding safety recalls prior to customer delivery.NHTSA's Recall Management Division has verified that all twenty-three (23) vehicles have been remedied of the safety recalls identified in AQ17-001.This Audit Query is closed.
RQ16001 · Brake Master Cylinder Failure
Opened Sep 28, 2016 · Closed Jul 5, 2020
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Additional source detail variants (4)
Service Brakes
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Service Brakes, Hydraulic:fluid
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Service Brakes, Hydraulic
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Service Brakes, Hydraulic:foundation Components:master Cylinder
On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 10928906 10930128 10936207 10940199 10943902 10948941 10950413 10954419 10956798 10969452 10969971 10984389 10985533 10991033 10993430 10993826 10994249 11000331 11000746 11001283 11001291 11001403 11001550 11002014 11002827 11003801 11004795 11005551 11010248 11010341 11011291 11011502 11012944 11013023 11013826 11014954 11015390 11018677 11018771 11020059 11021249 11021632 11022034 11022116 11022243 11023791 11025448 11030416 11030852 11039991 11082190 11082307 11083373 11083998 11089076 11091017 11092142 11093509 11096406 11096501 11097550 11097885 11099405 11099859 11100723 11101189 11101357 11101515 11101631 11102242 11102281 11102299 11102326 11102360 11102481 11104187 11104212 11104877 11109739 11110958 11111028 11111445 11111776 11112143 11112145 11112331 11112445 11112504 11112969 11112970 11114501 11115336 11115612 11118050 11118324 11119688 11119741 11120003 11120625 11120839 11121496 11122946 11123817 11124180 11124313 11124735 11129689 11129763 11129799 11130736 11131008 11132384 11139389 11139955 11154079 11163050 11183075 11189767 11192325 11193564 11195772 11196715 11205224 11205725 11208030 11208558 11209657 11210390 11217868 11218183 11218476 11218533 11218548 11218703 11218773 11219228 11219556 11220778 11221408 11221528 11221888 11222322 11222604 11222909 11228582 11228780 11229191 11229412 11229541 11229673 11230311 11230525 11230553 11230595 11230606 11230664 11231440 11231744 11231985 11232226 11232462 11233423 11233425 11233557 11233595 11233614 11233857 11233864 11234025 11234577 11234715 11234752 11240161 11240184 11240219 11240344 11241143 11241328 11241565 11241737 11241755 11241979 11242032 11242096 11242101 11242222 11242430 11242723 11243775 11244070 11244092 11244223 11244613 11244872 11245199 11245233 11245259 11245846 11246001 11251825 11252130 11252506 11252570 11252595 11252809 11254026 11254116 11254385 11254816 11255210 11255273 11255487 11256470 11257328 11257549 11258458 11258978 11265268 11267540 11269887 11279423 11281670 11287382 11291824 11297512 11298972 11301103 11306644 11310503 11315450 11316153 11318273 11319339 11319344 11319751
Illustration