IllustrationTHE ADVANCE TRACK KEEPS FLASHING NEEDS SERVICING HAS BEEN SERVICED BUT SHOWS NOTHING WRONG AND THE STEERING HAS LOCKED UP ONCE WHILE SITTING STILL COULD NOT TURN THE WHEEL AND AGAIN WHILE DRIVING JUST CAME OUT OF A CURVE ALL MOST LEFT THE HIGHWAY WHEN IT WENT TO TRY TO STRAIGHTEN UP
2014 Ford F-150
Owner reports · Recalls · Investigations
More warning signs than most F-150 years
Owner complaints for the 2014 Ford F-150 are substantially higher than the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1700–25K
20525–50K
21150–75K
14675–100K
167100–150K
109150K+
1,008 reports with mileage · 523 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 422 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 288 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
38 crash reports16 fire reports27 injury reports
Electronic Stability Control (esc) complaints
23 reportsSERVICE ADVANCE TRACK, ABS, BREAK LIGHTS ALL ON. BREAK PEDAL FADES TO FLOOR WHEN HELD FORD DEALER SAID MODULE FAILURE. THIS SAME TRUCK HAD RECALL FOR HYDRAULIC FAILURE WAS SERVICED IN 2016 NOW THEY WANT $1600 FOR A NEW MODULE THEN THE SERVICE MANAGER SAID PEDAL WAS NOT SPONGEY. LIKE I SAID STANDING STILL IN ANY GEAR INCLUDING…
Read full complaint
SERVICE ADVANCE TRACK, ABS, BREAK LIGHTS ALL ON. BREAK PEDAL FADES TO FLOOR WHEN HELD FORD DEALER SAID MODULE FAILURE. THIS SAME TRUCK HAD RECALL FOR HYDRAULIC FAILURE WAS SERVICED IN 2016 NOW THEY WANT $1600 FOR A NEW MODULE THEN THE SERVICE MANAGER SAID PEDAL WAS NOT SPONGEY. LIKE I SAID STANDING STILL IN ANY GEAR INCLUDING PARK PRESS THE BREAK AND HOLD IT IT FADES TO THE FLOOR REEL SAFE I'M SURE. ABS AND BREAK LIGHT ONLY GO ON WHEN YOU MOVE TRUCK.SERVICE ADVANCE TRACK ON WHEN ENGINE STARTED.
WARNING LIGHT APPEARS "SERVICE ADVANCETRAC", THEN LOST POWER STEERING. THIS HAPPENED TWICE WHILE DRIVING THE VEHICLE. HAPPENING INTERMITTENTLY. DROVE TO FORD DEALERSHIP. DIAGNOSIS WAS DEFECTIVE ELECTRONIC STEERING GEAR. FORD HAD RECALL ON THIS SAME ISSUE BY RECALL #14S09, BUT MY TRUCK WAS NOT INCLUDED IN RECALL. THIS IS A …
Read full complaint
WARNING LIGHT APPEARS "SERVICE ADVANCETRAC", THEN LOST POWER STEERING. THIS HAPPENED TWICE WHILE DRIVING THE VEHICLE. HAPPENING INTERMITTENTLY. DROVE TO FORD DEALERSHIP. DIAGNOSIS WAS DEFECTIVE ELECTRONIC STEERING GEAR. FORD HAD RECALL ON THIS SAME ISSUE BY RECALL #14S09, BUT MY TRUCK WAS NOT INCLUDED IN RECALL. THIS IS A SAFETY ISSUE AND COULD HAVE CAUSED AN AWFUL ACCIDENT. OBVIOUSLY THE EPAS STEERING GEAR IS DEFECTIVE AND VEHICLES WITH IT NEED TO BE RECALLED BEFORE SOMEONE HAS A MAJOR ACCIDENT.
WHILE I AM DRIVING WITH MY PREGNANT WIFE IN THE VEHICLE THE AIRBAG LIGHT WILL ILLUMINATE SAYING THAT THE AIRBAG IS OFF, I HAVE TO PULL OVER WHILE DRIVING TO HAVE HER GET OUT OF THE VEHICLE AND GET BACK IN FOR THE LIGHT TO TURN OFF. IT'S A NORMAL STREET IN A DEVELOPMENT OR ON THE ROAD DRIVING. DIFFERENT SPEEDS WITH FLAT ROADS, SO…
Read full complaint
WHILE I AM DRIVING WITH MY PREGNANT WIFE IN THE VEHICLE THE AIRBAG LIGHT WILL ILLUMINATE SAYING THAT THE AIRBAG IS OFF, I HAVE TO PULL OVER WHILE DRIVING TO HAVE HER GET OUT OF THE VEHICLE AND GET BACK IN FOR THE LIGHT TO TURN OFF. IT'S A NORMAL STREET IN A DEVELOPMENT OR ON THE ROAD DRIVING. DIFFERENT SPEEDS WITH FLAT ROADS, SOME HAVE BUMPS OTHERS ARE RECENTLY PAVED ASPHALT. HAPPENS INTERMITTENTLY, OVER A DOZEN TIMES AT DIFFERENT SPEEDS. MY VEHICLES VIN DOESN'T FIT THE RECALL FOR THE AIRBAG ISSUE THAT IS ALREADY AWARE BY FORD. TOOK VEHICLE TO FORD DEALERSHIP 4 TIMES FOR THIS SAME ISSUE, ONLY THONG DONE WAS A RECALIBRATION OF THE SEAT WEIGHT AND EXACTLY 2 WEEKS AND 1 DAY LATER LIGHT CAME ON AGAIN, UNABLE TO PULL OVER I DROVE HOPING TO FIND A WAY TO PULL OVER FOR THE SAFETY OF MY WIFE AND UNBORN CHILD, THE LIGHT TURNED OFF AFTER 40 SECONDS OF REALIZING IT WAS ON. A FULLY GROWN INDIVIDUAL SITTING IN THE SEAT WEIGHT 190+LBS HAS THIS HAPPENING TO THEM. I HAVE VIDEO FOOTAGE AND WILL TRY TO ATTACH IT IF POSSIBLE. MOST RECENTLY IT HAPPENED TODAY, 2/19/20 AT 3:17PM.
WHEN DRIVING THIS VEHICLE THE STEERING SEEMS TO LOCK UP MAKING A SLIGHT ADJUSTMENT GOING DOWN THE HIGHWAY WILL THROW YOU EITHER TO THE RIGHT OR TO THE LEFT IF MAKING A TURN IT WILL NOT TURN IN ALL OF A SUDDEN IT WILL RELEASE ITSELF AND SUDDENLY THROW YOU INTO A TURNS HARDER THAN WHAT YOU WISH AND IF YOU'RE NOT REAL QUICK TO REAC…
Read full complaint
WHEN DRIVING THIS VEHICLE THE STEERING SEEMS TO LOCK UP MAKING A SLIGHT ADJUSTMENT GOING DOWN THE HIGHWAY WILL THROW YOU EITHER TO THE RIGHT OR TO THE LEFT IF MAKING A TURN IT WILL NOT TURN IN ALL OF A SUDDEN IT WILL RELEASE ITSELF AND SUDDENLY THROW YOU INTO A TURNS HARDER THAN WHAT YOU WISH AND IF YOU'RE NOT REAL QUICK TO REACT YOU WILL ALMOST CRASH THIS THAT THIS IS HAPPENED SEVERAL TIMES TO US AND ALSO TO THE TECHNICIAN WHO JUST DROVE THE VEHICLE HE ALMOST WRECKED MY TRUCK BECAUSE OF STEERING LOCKED UP ON HIM ON A 90-DEGREE TURN THIS IS A VERY MUCH A SAFETY HAZARD AND A SAFETY FEATURE OTHER TRUCKS ARE THE SAME YEAR HAVE BEEN RECALLED FOR THIS AND I BELIEVE THE RECALL SHOULD BE EXPANDED THIS IS A ISSUE THAT WAS CONTINUING TO HAPPEN
MY TRUCK DOESN'T WANT TO STEER RIGHT. IT'S VERY HARD TO STEER AND SOMETIMES THE STEERING WHEEL STICKS. HEARD THEY ARE HAVING ISSUES WITH THE ELECTRONIC STEERING IN THESE TRUCKS. THE VEHICLE IS IN MOTION WHEN THIS IS HAPPENING AND IT'S WHEN YOU ARE GOING AROUND A BEND. I SHOULD NOT HAVE TO PAY TO GET THIS FIXED. THIS IS A MAJOR S…
Read full complaint
MY TRUCK DOESN'T WANT TO STEER RIGHT. IT'S VERY HARD TO STEER AND SOMETIMES THE STEERING WHEEL STICKS. HEARD THEY ARE HAVING ISSUES WITH THE ELECTRONIC STEERING IN THESE TRUCKS. THE VEHICLE IS IN MOTION WHEN THIS IS HAPPENING AND IT'S WHEN YOU ARE GOING AROUND A BEND. I SHOULD NOT HAVE TO PAY TO GET THIS FIXED. THIS IS A MAJOR SAFETY ISSUE. IT HAPPENS EVERYTIME I DRIVE.
DRIVING DOWN THE HIGHWAY, YELLOW WRENCH APPEARED ON MAIN SCREEN. TRUCK IMMEDIATELY WENT TO LIMP MODE. NO ACCELERATION AVAILABLE. DIFFICULT AND DANGEROUS TO GET TO SAFETY. TURNED OFF TRUCK AND WAITED A FEW MINUTES TO RESTART AND TRUCK SEEMED FINE. ALSO, WHEN CRESTING A HILL IN SIXTH GEAR AND SLIGHTLY LIFTING ON THE ACCELERAT…
Read full complaint
DRIVING DOWN THE HIGHWAY, YELLOW WRENCH APPEARED ON MAIN SCREEN. TRUCK IMMEDIATELY WENT TO LIMP MODE. NO ACCELERATION AVAILABLE. DIFFICULT AND DANGEROUS TO GET TO SAFETY. TURNED OFF TRUCK AND WAITED A FEW MINUTES TO RESTART AND TRUCK SEEMED FINE. ALSO, WHEN CRESTING A HILL IN SIXTH GEAR AND SLIGHTLY LIFTING ON THE ACCELERATOR, THE VEHICLE HAS A BIG THUNK THAT CAN BE FELT THROUGHOUT THE VEHICLE. SEEMS TO BE IN THE TRANSMISSION. HOWEVER, 'NO CODES' ARE GENERATED FOR THIS OR THE YELLOW WRENCH. FORD SAY POSSIBLE ELECTRONIC THROTTLE BODY, LEAD FRAME FOR THE TRANSMISSION, OR SPARK PLUGS. OUR SPARKS PLUGS ARE FORD BRAND AND NEW. THERE WAS A RECALL FOR THIS SAME ISSUE FOR THE 2011-2013 F150, BUT THIS DOESN'T INCLUDE OUR TRUCK AS IT'S A 2014. THIS IS A SAFETY ISSUE THAT DESERVES ANOTHER RECALL AND FORD AGAIN TO COVER THE REPAIRS. THIS IS HAPPENING TO TOO MANY FORD OWNERS AND SOMEONE WILL GET HURT IF THEY HAVEN'T ALREADY. THERE IS A LAW SUIT AGAINST FORD FOR SEVERAL MODELS WITH THIS SAME ISSUE. PLEASE DO THE ONLINE RESEARCH ON THIS ISSUE AND SEE IF SOMETHING CAN BE DONE. OUR TRUCK ISN'T SAFE TO DRIVE AND IT'S AT THE DEALERSHIP FOR A SECOND TIME. NO RESOLUTION THE FIRST TIME BECAUSE NO CODES ARE BEING SAVED BY THE COMPUTER. ACCORDING TO MY RESEARCH FORD KNEW OF THESE ISSUES FOR YEARS AND THEY FAILED TO TAKE CARE OF THE COMPUTER CODE ISSUE AND FIXED THE FAULTY VEHICLES THEY SOLD.
DRIVING DOWN THE HIGHWAY, TRYING TO CHANGE LANE TO EXIT THE ROAD, PRESS ON MY BRAKES TO SLOW DOWN, THEN MY BRAKES LIGHT CAME ON, SAYING IAM LOW ON BRAKE FLUID, AND MY BREAKS DONT WORK, THE PEDAL WENT AL THE WAY DOWN TO THE FLOOD. PUT ON MY HAZARDS LIGHT ON, AND LET THE TRUCK SLOW DOWN TO AN EXIT, VERY SLOW TO STOP WHILE DRIVING…
Read full complaint
DRIVING DOWN THE HIGHWAY, TRYING TO CHANGE LANE TO EXIT THE ROAD, PRESS ON MY BRAKES TO SLOW DOWN, THEN MY BRAKES LIGHT CAME ON, SAYING IAM LOW ON BRAKE FLUID, AND MY BREAKS DONT WORK, THE PEDAL WENT AL THE WAY DOWN TO THE FLOOD. PUT ON MY HAZARDS LIGHT ON, AND LET THE TRUCK SLOW DOWN TO AN EXIT, VERY SLOW TO STOP WHILE DRIVING. FOUND OUT THERE A RECALL ON MY TRUCK, CALL FORD #, THEY TELL ME THAT THE TRUCK HAD BEEN SERVICE BEFORE IN 2016, AND THERE ONLY ONE RECALL FIX PER VEHICLE. SO IAM OUT LUCK, THE BRAKE BOOSTER AND MASTER CYLINDER HAVE TO BE REPLACED AGAIN..AT MY OWN EXPENSE...
ADVANCETRAC SERVICE KEEPS COMING ON AND STEERING AND BRAKES BEGIN PULSING AND SHAKING AND CAN'T HARDLY TURN , HAS HAPPENED WHEN GOING STRAIGHT AND WHEN TURNING WHILE GOING FROM 35 TO 70 MPH ON HIGHWAY OR SIDE STREET. ONLY 19000 MILES
TRUCK DOWN SHIFTS WHILE DRIVING. MY PREGNANT WIFE AND I WERE DRIVING 70 MPH ON HIGHWAY, WHEN TRUCK DOWN SHIFTED TO 1ST GEAR AND NEARLY CAUSED US TO SLIDE OFF ROAD IN THE RAIN. FORD JUST RECALLED 2011-2013 FOR SAME PROBLEM! THEY NEED TO RECALL 2014 AS WELL! MY TRUCK WAS FIXED AT FORD DEALERSHIP.
Official recalls
826V378000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles previously repaired incorrectly under recall number 24V444. A loss of signal between the transmission output shaft speed sensor and the powertrain control module (PCM) can cause the transmission to unexpectedly downshift into first gear.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed July 8, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26S45. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
24V444000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 17, 2024
Ford Motor Company (Ford) is recalling certain 2014 F-150 vehicles. A loss of signal between the transmission output shaft speed sensor and the powertrain control module can cause the transmission to unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed July 1, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S37.
20V332000 · Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist
Jun 8, 2020
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2014-2017 F-150 pickup trucks equipped with 3.5L Ecoboost engines. The brake master cylinder may leak brake fluid into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel and feel, increased pedal effort and reduced front brake function, possibly requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and inspect the brake booster, replacing it as necessary, free of charge. Ford issued owners an interim notification on June 30, 2020. The recall began on October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S31.
17V472000 · Seat Belts; Seats
Jul 25, 2017
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence & remedy
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Additional source detail variants (2)
Seats
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
Seat Belts
Ford Motor Company (Ford) is recalling certain 2014 Ford F-150 and E-350, 2014-2015 Ford Escape, and 2015 Lincoln MKC vehicles. Improperly manufactured bolts may have been used to install certain seats, seatbacks, seatbelt buckles, or seatbelt anchors on these vehicles.
Consequence: The improperly manufactured bolts may fracture. If a seat, seatback, or seatbelt anchor attaching bolt fractures, the affected component may not be properly secured, increasing the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the affected bolts, free of charge. Interim notices informing owners of the safety risk were mailed September 8, 2017. Owners will receive a second notice when remedy parts become available in the fourth quarter of 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S17.
16V345000 · Service Brakes, Hydraulic:fluid
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence & remedy
Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.
14V710000 · Seats
Nov 7, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 and Flex vehicles manufactured March 1, 2014, to May 31, 2014. The affected vehicles were manufactured with a reduced clearance between the seat frame and the seat track assembly. This can cause the Occupant Classification System (OCS) to inaccurately register passenger weight and improperly suppress the passenger front airbag when the passenger seat is occupied by an adult passenger. Thus, these vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Improper suppression of the passenger airbag increases the risk of an injury to the seat occupant in the event of a crash necessitating deployment of the front passenger airbag.
Remedy: Ford will notify owners, and dealers will widen the gap between the seat frame and seat track assembly and recalibrate the seat OCS, free of charge. The recall began November 25, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C10.
14V709000 · Exterior Lighting:brake Lights:switch; Service Brakes, Hydraulic:pedals And Linkages
Nov 5, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
Service Brakes, Hydraulic:pedals And Linkages
Ford Motor Company (Ford) is recalling certain model year 2014 F-150 vehicles manufactured March 1, 2014, to March 13, 2014. The affected vehicles may have a brake pedal position switch that is improperly adjusted. As a result, the brake lights may illuminate with a delay or not at all. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the brake lights fail to illuminate, or illuminate after a delay, there is an increased risk of a crash.
Remedy: Ford has notified owners, and dealers will adjust the brake pedal position switch, free of charge. The recall began on November 24, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14C09. Note: Until the vehicle has been remedied, owners are advised not to use their cruise control system.
14V316000 · Steering:electric Power Assist System
Jun 12, 2014
Ford Motor Company (Ford) is recalling certain model year 2014 Ford F-150 trucks manufactured May 26, 2014 to June 19, 2014, and equipped with Electronic Power Assist Steering (EPAS). The affected vehicles may have an incorrectly installed EPAS gear motor position sensor magnet that can lead to a total loss of steering control while driving.
Consequence & remedy
Consequence: A loss of steering control while driving increases the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will replace the EPAS steering gear, free of charge. The recall began in July 2014. Note: Owners are advised not to drive their vehicles until they have been remedied. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24005 · Unintended Transmission Downshift
Opened Mar 27, 2024 · Closed Jul 29, 2024
Status: closed (inferred from source dates) · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
In September 2016, Ford Motor Company (Ford) issued safety recall 16V-248 which included certain model year (MY) 2011-2012 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions. This recall was in response to allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, increasing the risk of a crash and/or injury, and included approximately 153,581 vehicles. Ford identified the root cause of the unintended, unexpected vehicle transmission downshifting to a lower gear to be intermittent signal loss from the transmission’s Output Shaft Speed (OSS) sensor due to solder joint cracks on the OSS circuit board as a result of manufacturing process issues. The OSS sensor is mounted onto the molded lead frame and transmits changes in transmission shaft speed to the Powertrain Control Module (PCM). The remedy program described in safety recall 16V-248 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In December 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-010) to assess the scope and remedy effectiveness of safety recall 16V-248. As a result of this ODI investigation, Ford issued safety recall 19V-075 to expand the scope of 16V-248 to include MY 2011-2013 Ford F-150 vehicles equipped with 6-speed (6R80) automatic transmissions and included approximately 1,263,051 vehicles. The remedy program described in safety recall 19V-075 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring. In June 2019, Ford issued safety recall 19V-433 as the remedy program used to service MY 2013 Ford F-150 5.0L and 6.2L vehicles in accordance with safety recall 19V-075 did not contain the necessary updates to prevent unintended vehicle transmission downshifting from occurring and included approximately 107,857 vehicles. On March 27, 2024, ODI opened this Recall Query (RQ24-005) to investigate the scope of the above-described safety recalls. At the time that this investigation was opened, ODI had received 86 Vehicle Owner Questionnaires (VOQs) reporting allegations of unintended, unexpected vehicle transmission downshifting to a lower gear without warning, often accompanied by temporary rear wheel lock-up, in MY 2014 Ford F-150 vehicles. As a result of this Recall Query, Ford filled safety recall 24V-444 on June 14, 2024, to include MY 2014 Ford F-150 vehicles and expand the scope of safety recalls 16V-248, 19V-075 and 19V-433. The remedy program described in safety recall 24V-444 involved reprogramming of the PCM to prevent unintended vehicle transmission downshifting from occurring and included approximately 552,188 vehicles. In its May 2024 response to ODI’s information request, Ford concluded that a predominant root cause for the intermittent OSS signal loss has not been identified outside of the original safety recall (16V-248). Ford’s investigation also concluded that the primary causes of the defect in MY 2014 F-150 vehicles were related to the molded lead frame and the control assembly transmission main. In the May 2024 response, Ford identified 2,184 total reports that described unintended vehicle transmission downshifting and rear wheel lock-up events; 1,441 warranty claims and 743 reports from consumer complaints, field reports, consumer surveys, and lawsuits/legal claims. Note that the values presented here and in the table above represent the total number of reports which can include a single consumer with multiple reports of the same event as well as a consumer with reports of multiple distinct events. Of the 1,441 warranty claims, 551 warranty claims involved repair of the molded lead frame (38%) and 509 warranty claims involved repair of the control assembly transmission main (35%). Ford has also stated that the PCM programming used to prevent unintended vehicle transmission downshifting was implemented starting with MY 2015 vehicle #1 production and onward. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24-005). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE16003 · Master Cylinder External Leak
Opened Feb 29, 2016 · Closed Jul 26, 2016
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Additional source detail variants (4)
Service Brakes
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:fluid
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107