← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

What owners actually said

2,980 reports
Mileage unknown · May 30, 2024
Unknown Or Other

The truck I have is known to have a problem with the lead frame ford issued a recall on this vehicle however my vehicle was never fixed at all they just have it marked as no open recall and they are telling me that the vehicle is no longer covered by the warranty on the recall due to a time lapse and mileage being over. This veh…

Read full complaint

The truck I have is known to have a problem with the lead frame ford issued a recall on this vehicle however my vehicle was never fixed at all they just have it marked as no open recall and they are telling me that the vehicle is no longer covered by the warranty on the recall due to a time lapse and mileage being over. This vehicle was affected by this recall and it is a safety recall yet the vehicle was never properly fixed for this and it has ongoing issues that have to do with this recall.

NHTSA ODI #11591652

150,000 miles · May 29, 2024
Power Train

The contact owns a 2013 Ford F-150. The contact stated that while her friend was driving approximately 70 MPH, the vehicle lost motive power. The contact stated no warning light was illuminated. The contact stated that her friend pulled the vehicle off the roadway, stopped, and placed the vehicle in park (P), turned the vehicle …

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated that while her friend was driving approximately 70 MPH, the vehicle lost motive power. The contact stated no warning light was illuminated. The contact stated that her friend pulled the vehicle off the roadway, stopped, and placed the vehicle in park (P), turned the vehicle off and on. The contact stated that her friend was able to place the vehicle in drive(D), however when the accelerator pedal was depressed, the vehicle independently shifted out of drive(D) into neutral(N). The contact stated that her friend drove the vehicle to a local dealer. The dealer diagnosed the vehicle and determined that the transmission molded leadframe needed to be replaced. The dealer advised the contact's friend that the vehicle was no longer under manufacturer Customer Satisfaction Program Number: 19N01 - Transmission Molded Leadframe extended coverage (Power Train). The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 150,000.

NHTSA ODI #11591336

107,324 miles · May 28, 2024
Electrical System

The contact owns a 2013 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and independently restarted several times. The check engine warning light illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with a faulty fuse box. The faulty fuse …

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power and independently restarted several times. The check engine warning light illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with a faulty fuse box. The faulty fuse box failure caused fuse #27 to melt and burn out into the fuse box. The contact was informed that the fuse relocation kit needed to be replaced. The vehicle was repaired. The contact researched and discovered TSB: 15-0137. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 107,324.

NHTSA ODI #11591072

119,920 miles · May 24, 2024
Power Train

The contact owns a 2013 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle independently decelerated. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the speed odometer went from 75 MPH to 0 MPH in several seconds. The contact st…

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle independently decelerated. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the speed odometer went from 75 MPH to 0 MPH in several seconds. The contact stated that the engine was making an abnormally loud sound. The vehicle was taken to an independent mechanic and diagnosed with powertrain control module and powertrain control module (PCM) software failure. The contact was advised to take the vehicle to the dealer for the repair. The contact was informed that the powertrain control module needed to be replaced and the powertrain control module software needed to be reprogrammed. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed that NHTSA Campaign Number: 19V075000 (Power Train) had expired, and the repair could not be covered under the recall. The failure mileage was approximately 119,920.

NHTSA ODI #11590661

Mileage unknown · May 24, 2024
Engine

Truck threw code P2112 Throttle body plate closed. Truck immediatly went into limp mode meaning on only poorly tried to idle, no throttle. This is the SECOND time this part has gone bad on this truck. Never mind they are 600 dollars to replace, it was a very dangerous to have the truck just die during a merge onto highway man…

Read full complaint

Truck threw code P2112 Throttle body plate closed. Truck immediatly went into limp mode meaning on only poorly tried to idle, no throttle. This is the SECOND time this part has gone bad on this truck. Never mind they are 600 dollars to replace, it was a very dangerous to have the truck just die during a merge onto highway manuver. If I have to do it twice, how many hundreds of thousands of these failures exist? The first time it happened, I almost crashed. My ford dealer says he sells "alot" of this part. Part number failure is BL3Z9E926B

NHTSA ODI #11590582

Mileage unknown · May 22, 2024
Service Brakes

Master Cylinder leaked into brake booster causing complete brake failure. Had to use downshifting and emergency brake to stop. Contact Ford and they said not on recall list. Have a nice day.

NHTSA ODI #11590155

156,000 miles · May 20, 2024
Vehicle Speed Control

The contact owns a 2013 Ford F-150. The contact stated while driving 70 MPH, the contact noticed a failure with the accelerator pedal wherein the accelerator pedal failed to engage properly. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed but was not disclosed. The dealer replac…

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated while driving 70 MPH, the contact noticed a failure with the accelerator pedal wherein the accelerator pedal failed to engage properly. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed but was not disclosed. The dealer replaced the throttle body. The vehicle was repaired. The contact stated he was concerned that the vehicle was unsafe and could cause severe injuries if the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 156,000.

NHTSA ODI #11589628

55,000 miles · May 16, 2024
Power Train

The contact owns a 2013 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle unexpectedly downshifted. The check engine warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V433000 (Power Train). The contact was informed by the dealer that the vehicle would be re…

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle unexpectedly downshifted. The check engine warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V433000 (Power Train). The contact was informed by the dealer that the vehicle would be repaired under the recall. The contact stated that after arriving to the dealer, the contact was informed that the vehicle could not be repaired under the recall because the recall had expired. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and informed the contact had exceeded the year and mileage limitations. The failure mileage was approximately 55,000.

NHTSA ODI #11589093

57,000 miles · May 15, 2024
Power Train

The contact owns a 2013 Ford F-150. The contact stated that while driving at approximately 60 MPH, the transmission downshifted causing the vehicle to abruptly decelerate. The contact stated that after starting the vehicle, the transmission failed to shift out of first gear. The local dealer was notified of the failure and the c…

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated that while driving at approximately 60 MPH, the transmission downshifted causing the vehicle to abruptly decelerate. The contact stated that after starting the vehicle, the transmission failed to shift out of first gear. The local dealer was notified of the failure and the contact was informed that the transmission lead frame was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 57,000.

NHTSA ODI #11588867

120,563 miles · May 13, 2024
Power Train

The contact owns a 2013 Ford F-150. The contact stated while driving approximately 55 MPH, the speedometer suddenly went to 0, and the vehicle failed to shift gears as needed. The contact stated that the failure persisted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the lead frame …

Read full complaint

The contact owns a 2013 Ford F-150. The contact stated while driving approximately 55 MPH, the speedometer suddenly went to 0, and the vehicle failed to shift gears as needed. The contact stated that the failure persisted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the lead frame was deformed and needed to be replaced. The vehicle was not repaired by an independent mechanic or dealer. The local dealer was contacted and referred the contact to the manufacturer for assistance. The manufacturer was made aware of the failure; however, the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 120,563.

NHTSA ODI #11588463

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of