← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Vehicle Speed Control complaints

301 reports
Clear category filter
2,200 miles · Apr 3, 2014
EngineVehicle Speed Control

WHEN PULLING OUT INTO TRAFFIC FROM A STOP I EXPERIENCED A SUDDEN LOSS OF POWER FROM THE ENGINE. THE ENGINE SPUTTERED AND IT WOULD NOT ACCELERATE OR INCREAE RPM. AFTER PUMPING THE GAS PEDAL TWICE THE TURBOS FINALLY KICKED IN AND ALLOWED MWE TO ONCE AGAIN ACCELERATE. THIS LOSS OF POWER WHILE ENTERING THE ROADWAY NEARLY CAUSED A…

Read full complaint

WHEN PULLING OUT INTO TRAFFIC FROM A STOP I EXPERIENCED A SUDDEN LOSS OF POWER FROM THE ENGINE. THE ENGINE SPUTTERED AND IT WOULD NOT ACCELERATE OR INCREAE RPM. AFTER PUMPING THE GAS PEDAL TWICE THE TURBOS FINALLY KICKED IN AND ALLOWED MWE TO ONCE AGAIN ACCELERATE. THIS LOSS OF POWER WHILE ENTERING THE ROADWAY NEARLY CAUSED A COLLISION. *TR

NHTSA ODI #10577224

8,200 miles · Feb 10, 2014
Fuel/propulsion SystemVehicle Speed Control

I WAS ACCELERATING UP A HILL AT APPROXIMATELY 50 MPH WHEN A RAPID DECELERATION OCCURRED. I HAD TO QUICKLY MERGE ONTO THE SHOULDER IN ORDER TO AVOID BEING HIT FROM BEHIND. I THEN SHUT OFF THE VEHICLE, WAITED, COMPOSED MYSELF, RESTARTED THE VEHICLE, AND DROVE SAFELY TO WORK. I DID, HOWEVER, HAVE THE "CHECK ENGINE" ILLUMINATE ON M…

Read full complaint

I WAS ACCELERATING UP A HILL AT APPROXIMATELY 50 MPH WHEN A RAPID DECELERATION OCCURRED. I HAD TO QUICKLY MERGE ONTO THE SHOULDER IN ORDER TO AVOID BEING HIT FROM BEHIND. I THEN SHUT OFF THE VEHICLE, WAITED, COMPOSED MYSELF, RESTARTED THE VEHICLE, AND DROVE SAFELY TO WORK. I DID, HOWEVER, HAVE THE "CHECK ENGINE" ILLUMINATE ON MY WAY HOME AND SEEMED TO SENSE SOME STIFFNESS IN THE BRAKES. THIS SHOULD NOT HAPPEN IN A VEHICLE WITH 8000 MILES ON IT. *TR

NHTSA ODI #10563680

1,500 miles · Jan 31, 2014
EngineVehicle Speed Control

WHILE ENTERING I-275 AFTER A FOOTBALL GAME, I WAS ATTEMPTING TO MERGE INTO TRAFFIC, AND THE ACCELERATION WAS NONE EXISTENT. I WAS NEARLY RUN OFF THE ROAD BY ANOTHER DRIVER. THE ACCELERATION FINALLY KICKED BACK IN AFTER APPROXIMATELY 5-7 SECONDS. THE PROBLEM CONTINUED INTERMITTENTLY EVEN AFTER THE VEHICLE WAS REPROGRAMMED BY FORD…

Read full complaint

WHILE ENTERING I-275 AFTER A FOOTBALL GAME, I WAS ATTEMPTING TO MERGE INTO TRAFFIC, AND THE ACCELERATION WAS NONE EXISTENT. I WAS NEARLY RUN OFF THE ROAD BY ANOTHER DRIVER. THE ACCELERATION FINALLY KICKED BACK IN AFTER APPROXIMATELY 5-7 SECONDS. THE PROBLEM CONTINUED INTERMITTENTLY EVEN AFTER THE VEHICLE WAS REPROGRAMMED BY FORD. SEVERAL MONTHS AFTER THE INITIAL OCCURRENCE, WHILE ATTEMPTING TO CROSS 3 LANES OF TRAFFIC, THE SAME PROBLEM OCCURRED AGAIN AND I WAS NEARLY T-BONED BY A SEMI AFTER IT STALLED IN THE MIDDLE OF THE HIGHWAY. AFTER SEVERAL SECONDS, THE ACCELERATION KICKED IN AND I NEARLY PLOWED OVER A PEDESTRIAN. FORD SEEMS TO BE OBLIVIOUS THAT THERE IS A PROBLEM. *TR

NHTSA ODI #10562325

7,800 miles · Jan 26, 2014
EngineVehicle Speed Control

I HAD BEEN DRIVING ON THE HIGHWAY IN THE RAIN FOR APPROXIMATELY 2 HOURS, WHEN I NEEDED TO PASS A SEMI-TRUCK AND PUSHED THE ACCELERATOR PEDAL TO ACCELERATE THE TRUCK STARTED TO SHUDDER AND STALL, WITH AN ACCOMPANYING FLASHING MIL LIGHT. I LET OFF THE ACCELERATOR AND THE MIL LIGHT BECAME STEADY. I PULLED OFF TO THE SIDE OF THE R…

Read full complaint

I HAD BEEN DRIVING ON THE HIGHWAY IN THE RAIN FOR APPROXIMATELY 2 HOURS, WHEN I NEEDED TO PASS A SEMI-TRUCK AND PUSHED THE ACCELERATOR PEDAL TO ACCELERATE THE TRUCK STARTED TO SHUDDER AND STALL, WITH AN ACCOMPANYING FLASHING MIL LIGHT. I LET OFF THE ACCELERATOR AND THE MIL LIGHT BECAME STEADY. I PULLED OFF TO THE SIDE OF THE ROAD, SHUT-OFF THE TRUCK AND OPENED THE HOOD TO SEE IF THERE WAS ANY OBVIOUS CAUSE TO THE MISFIRE CONDITION...AND THERE WAS NOT. I RESTARTED THE TRUCK, BUT THE MIL LIGHT REMAINED ILLUMINATED STEADY. I DROVE CONSERVATIVELY HOME AND HOOKED UP MY CODE READER TO THE OBD-II PORT. IT SHOWED CODES OF P0300, P0305, AND P0306...THE FREEZE-FRAME DATA SHOWED THE CONDITION OCCURRED AT 65 MPH AND 2578 RPMS. I CALLED THE DEALER AND SETUP AN APPOINTMENT TO HAVE THE TRUCK INSPECTED. THE DEALER APPLIED FORD TSB 13-8-10 AS THE FIX (DON'T KNOW IF THIS WILL FIX THE MISFIRES OR NOT). MY TRUCK HAS THE 3.5L ECOBOOST MOTOR. *TR

NHTSA ODI #10561498

8,600 miles · Dec 30, 2013
EngineVehicle Speed Control

AFTER DRIVING IN RAIN FOR A COUPLE HOURS IN MY ECOBOOST F150, I WAS MERGING ONTO AN INTERSTATE WHERE TRAFFIC REQUIRED HEAVY ACCELERATION AND THE VEHICLE STALLED FROM 60-65 ABRUPTLY TO 45 MPH. THE VEHICLE SHUTTERED AND WOULD NOT ACCELERATE BACK TO HIGHWAY SPEEDS FOR NEARLY A MINUTE. THE ENGINE RAN EXTREMELY ROUGH AND WAS UNRESP…

Read full complaint

AFTER DRIVING IN RAIN FOR A COUPLE HOURS IN MY ECOBOOST F150, I WAS MERGING ONTO AN INTERSTATE WHERE TRAFFIC REQUIRED HEAVY ACCELERATION AND THE VEHICLE STALLED FROM 60-65 ABRUPTLY TO 45 MPH. THE VEHICLE SHUTTERED AND WOULD NOT ACCELERATE BACK TO HIGHWAY SPEEDS FOR NEARLY A MINUTE. THE ENGINE RAN EXTREMELY ROUGH AND WAS UNRESPONSIVE TO THROTTLE INPUT FROM DRIVER. I HAD MY FAMILY WITH ME AND WAS VERY UPSET THAT WE COULD HAVE BEEN IN A VERY BAD ACCIDENT. THE DEALERSHIP DID NOT INFORM ME OF PROBLEMS WITH THE ECOBOOST AT THE TIME OF SALE, EVEN THOUGH THIS PROBLEM HAS BEEN GOING ON SINCE THE ECOBOOST INTRODUCTION. THIS IS A SERIOUS SAFETY ISSUE AND I FIND THE NHTSA HAS FAILED TO RECALL THESE TRUCKS. THE DEALERSHIP WHERE PURCHASED IS MARLER FORD, NEAR ALEXANDRIA, LA. YOU ARE NOT TO USE MY PERSONAL INFORMATION IN ANYWAY EXCEPT TO HANDLE THIS COMPLAINT. WHICH INCLUDES BUT NOT LIMITED TO SELLING OR OTHERWISE PROVIDING THIS INFORMATION TO OUTSIDE AGENCIES. *TR

NHTSA ODI #10557668

10,590 miles · Dec 21, 2013
EngineVehicle Speed Control

THIS IS THE THIRD TIME THE VEHICLE HAS DONE THIS TO ME WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE (ECOBOOST MOTOR) THE ENGINE HAS SHUDDERED AND LOST ALL POWERS WHEN ATTEMPTING TO PASS ANOTHER VEHICLE OR ACCELERATE. ON THE FIRST INSTANCE I WAS ON A TWO LANE ROAD ATTEMPTING TO ACCELERATE TO PASS A SEMI TRUCK WHEN THE TRUCK STARTE…

Read full complaint

THIS IS THE THIRD TIME THE VEHICLE HAS DONE THIS TO ME WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE (ECOBOOST MOTOR) THE ENGINE HAS SHUDDERED AND LOST ALL POWERS WHEN ATTEMPTING TO PASS ANOTHER VEHICLE OR ACCELERATE. ON THE FIRST INSTANCE I WAS ON A TWO LANE ROAD ATTEMPTING TO ACCELERATE TO PASS A SEMI TRUCK WHEN THE TRUCK STARTED MISSING SO BAD IT CHOKED OUT AND SHUT DOWN IN THE MIDDLE OF THE ROAD WITH ONCOMING TRAFFIC I HAD TO SWERVE INTO A DITCH TO AVOID A HEAD ON COLLISION. THE SECOND TIME WAS ON A FOUR LANE DURING A 45 MINUET DRIVE WHEN I WENT TO PASS IT LOST ALL POWER CAUSING ME TO DROP TO 40 MILES AN HOUR IN THE PASSING LANE OF A HIGHWAY CAUSING MANY VEHICLES TO SWERVE TO AVOID COLLISION. THE MOST RECENT TIME WAS WHEN SAME AS THE SECOND GOING TO PASS SOMEBODY THE TRUCK LOST ALL ACCELERATION WOULD NOT GET OUT OF THE WAY OF TRAFFIC NEARLY CAUSING ANOTHER ACCIDENT. I HAVE HAD IT INTO THE DEALER SEVERAL TIMES AND I AM CONSTANTLY GETTING WE SEE THE HISTORY CODE BUT WE CAN NOT REPRODUCE THE PROBLEM. THIS PROBLEM HAS LEFT ME FEELING UNSAFE TO DRIVE MY VEHICLE AND HURTING RESALE VALUE AS WELL AS PUTTING MY SAFETY ON THE LINE. *TR

NHTSA ODI #10556924

16,000 miles · Dec 8, 2013
EngineVehicle Speed Control

UPON ACCELERATION TO PASS ON FREEWAY, ENGINE SHUDDERS AND LOSES POWER. TRANSMISSION DOWN SHIFTED TO TRY TO RECOVER, BUT ENGINE WOULD NOT RESPOND TO THROTTLE PRESS. HAD TO BACK OFF ON THROTTLE AND MOVE TO RIGHT LANE ALL THE WHILE THINKING TO TAKE THE TRUCK TO THE SHOULDER. VERY SCARY WHEN TRYING TO PASS AND NO POWER. LUCKILY I WA…

Read full complaint

UPON ACCELERATION TO PASS ON FREEWAY, ENGINE SHUDDERS AND LOSES POWER. TRANSMISSION DOWN SHIFTED TO TRY TO RECOVER, BUT ENGINE WOULD NOT RESPOND TO THROTTLE PRESS. HAD TO BACK OFF ON THROTTLE AND MOVE TO RIGHT LANE ALL THE WHILE THINKING TO TAKE THE TRUCK TO THE SHOULDER. VERY SCARY WHEN TRYING TO PASS AND NO POWER. LUCKILY I WAS NOT REAR ENDED FOR SLOWING DOWN SO FAST! *TR

NHTSA ODI #10555212

1,500 miles · Dec 5, 2013
EngineVehicle Speed Control

DRIVING DOWN HIGHWAY AT APPROXIMATELY 60-65MPH WHEN I ATTEMPTED TO ACCELERATE. VEHICLE BEGAN TO STALL/SHAKE AND LOSE POWER. I WAS UNABLE TO ACCELERATE WHILE THE VEHICLE WAS SHAKING. CHECK ENGINE LIGHT BEGAN TO FLASH ON AND OFF. *TR

NHTSA ODI #10554886

12,000 miles · Nov 16, 2013
EngineFuel/propulsion SystemVehicle Speed Control

WE BOUGHT OUR 2013 F150 XLT 4X4 V6 FLEX FUEL AT DENHAM FORD IN WETASKIWIN ALBERTA. WE TRAVELED ACROSS COUNTRY TO ONTARIO. WE HAVE CONTINUED TO DRIVE IT. APPROXIMATELY 9000 KMS FOR MILEAGE OUR TRUCK HAS STEADILY LOST ACCELERATION POWER. GOING UP BURLINGTON SKYWAY AND GARDEN CITY SKYWAY (100 KM/H MAJOR HIGHWAY) TRUCK STRUGGLE TO M…

Read full complaint

WE BOUGHT OUR 2013 F150 XLT 4X4 V6 FLEX FUEL AT DENHAM FORD IN WETASKIWIN ALBERTA. WE TRAVELED ACROSS COUNTRY TO ONTARIO. WE HAVE CONTINUED TO DRIVE IT. APPROXIMATELY 9000 KMS FOR MILEAGE OUR TRUCK HAS STEADILY LOST ACCELERATION POWER. GOING UP BURLINGTON SKYWAY AND GARDEN CITY SKYWAY (100 KM/H MAJOR HIGHWAY) TRUCK STRUGGLE TO MAINTAIN 60 KM/H UPHILL WITH PEDAL TO THE FLOOR! HAD INSTRUMENTAL PANEL PROBLEMS IMPROPER DISPLAY OF AMOUNT OF GAS OR DISTANCE TO E. DRIVESHAFT CONSTANTLY CLUNKING AND TRANSMISSION SLIPPAGE. FORD REFUSED TO REPLACE AFTER TOWING OF PROBLEMS AND CONSTANT CALL INS TO CUSTOMER SERVICE. TOOK TO LOCAL DEALER AND 7-8 TECHNICIANS STOOD ROUND SCRATCHING HEAD REPLACED FUEL PUMP DID NOT MAKE A DIFFERENCE. FORD ASK FOR PAYMENT 558.08 WE NOT HAVE FUNDS AS ALL OF OUR MONEY GOING INTO GAS TO REPAIR TRUCK AND FALSE READING ON PANEL AND FORD REFUSED TO HELP US. WE FELT USED AND SCARED OF BEING REAR ENDED BY A SEMI WAS NOT SAFE. DID DIAGNOSTIC NO CODES. BEYOND CODE PROBLEM. FIRST KNOWN PROBLEM IN NORTH AMERICA...HUGE LEMON. *TR

NHTSA ODI #10552579

11,750 miles · Nov 7, 2013
EngineFuel System, GasolineVehicle Speed Control

I WAS MERGING ONTO THE HIGHWAY WHILE IT WAS RAINING. IN ATTEMPTING TO ACCELERATE TO MERGE IN FRONT OF A SEMI MY VEHICLE STATED SHUTTERING VIOLENTLY AND LOST POWER. I COULD NOT GET PAST 40MPH. THE CHECK ENGINE LIGHT WAS FLASHING. THIS WAS AFTER THE TRUCK HAD BEEN RUNNING FOR TWO HOURS. THE SEMI ALMOST REAR ENDED ME AS I GOT …

Read full complaint

I WAS MERGING ONTO THE HIGHWAY WHILE IT WAS RAINING. IN ATTEMPTING TO ACCELERATE TO MERGE IN FRONT OF A SEMI MY VEHICLE STATED SHUTTERING VIOLENTLY AND LOST POWER. I COULD NOT GET PAST 40MPH. THE CHECK ENGINE LIGHT WAS FLASHING. THIS WAS AFTER THE TRUCK HAD BEEN RUNNING FOR TWO HOURS. THE SEMI ALMOST REAR ENDED ME AS I GOT OFF THE ROAD AS SOON AS POSSIBLE. I SHUT THE TRUCK OFF AND RESTARTED THE ENGINE AND IT RAN FINE AFTER THAT. I TOOK THE TRUCK BACK TO MY DEALER THE NEXT DAY AND THEY COULD FIND NOTHING WRONG, NOT EVEN AN ERROR CODE. THE TRUCK HAS A FORD 6 CYLINDER ECO BOOST ENGINE. *TR

NHTSA ODI #10551384

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of