← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Vehicle Speed Control complaints

301 reports
Clear category filter
26,000 miles · Sep 29, 2014
EngineVehicle Speed Control

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHEN HE ATTEMPTED TO ACCELERATE FROM A STOP, THE VEHICLE RAPIDLY ACCELERATED AS THE RPMS INCREASED TO 4000. THE CONTACT APPLIED THE BRAKES AND SHIFTED INTO NEUTRAL HOWEVER, THE VEHICLE DID NOT RESPOND AND THE RPMS REMAINED AT 4000. THE VEHICLE WAS NOT TAKEN TO A DEA…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHEN HE ATTEMPTED TO ACCELERATE FROM A STOP, THE VEHICLE RAPIDLY ACCELERATED AS THE RPMS INCREASED TO 4000. THE CONTACT APPLIED THE BRAKES AND SHIFTED INTO NEUTRAL HOWEVER, THE VEHICLE DID NOT RESPOND AND THE RPMS REMAINED AT 4000. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 26,000. UPDATED 11/20/14*CN UPDATED 08/28/2017*CT

NHTSA ODI #10639772

10,400 miles · Sep 11, 2014
Vehicle Speed Control

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 60 MPH, THE VEHICLE'S SPEED DECLINED AND WOULD NOT ACCELERATE. THE FAILURE OCCURRED TWICE. THE DEALER STATED THAT THE FAILURE WAS DUE TO HUMIDITY AND MOISTURE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 10,400.

NHTSA ODI #10632360

Mileage unknown · Aug 20, 2014
Air BagsElectrical SystemVehicle Speed Control

2013 FORD F-150. CONSUMER WRITES IN REGARDS TO AIRBAG SYSTEM, CRUISE CONTROL SYSTEM AND OTHER ELECTRICAL ISSUES. *SMD THE CONSUMER STATED HE RETURNED THE VEHICLE TO THE DEALER TWICE, FOR THE ISSUES. THE DEALER FAILED TO IDENTIFY ANY ELECTRICAL FAULTS IN THE AIR BAG SYSTEM. A MONTH LATER, DURING SERVICE ON THE AIR BAGS, THE…

Read full complaint

2013 FORD F-150. CONSUMER WRITES IN REGARDS TO AIRBAG SYSTEM, CRUISE CONTROL SYSTEM AND OTHER ELECTRICAL ISSUES. *SMD THE CONSUMER STATED HE RETURNED THE VEHICLE TO THE DEALER TWICE, FOR THE ISSUES. THE DEALER FAILED TO IDENTIFY ANY ELECTRICAL FAULTS IN THE AIR BAG SYSTEM. A MONTH LATER, DURING SERVICE ON THE AIR BAGS, THE HORN FAILED TO OPERATE. *JB

NHTSA ODI #10625680

2,805 miles · Jun 29, 2014
EnginePower TrainVehicle Speed Control

WAS ACCELERATING ENTERING INTERSTATE I95 NORTH BOUND FROM AN ON RAMP AND SUDDENLY MY VEHICLE LOST POWER AND BEGAN TO STALL AND SHUTTER. THE TRUCK RAPIDLY LOST POWER PLUS SPEED AND A TRACTOR TRAILER TRUCK ALMOST RAN IN TO THE BACK OF ME. I DEALT WITH THIS ISSUE FOR THE REMAINDER OF MY 500 MILE TRIP TO NYC (AND STILL DEALING WIT…

Read full complaint

WAS ACCELERATING ENTERING INTERSTATE I95 NORTH BOUND FROM AN ON RAMP AND SUDDENLY MY VEHICLE LOST POWER AND BEGAN TO STALL AND SHUTTER. THE TRUCK RAPIDLY LOST POWER PLUS SPEED AND A TRACTOR TRAILER TRUCK ALMOST RAN IN TO THE BACK OF ME. I DEALT WITH THIS ISSUE FOR THE REMAINDER OF MY 500 MILE TRIP TO NYC (AND STILL DEALING WITH THIS ISSUE TODAY NOW WEEKLY BASES). ONCE BACK HOME I TOOK THE TRUCK TO THE DEALERSHIP WHO WAS AWARE OF MISFIRE ISSUES WITH MY TRUCK MODEL (APPARENTLY IT IS KNOWN BY THE MANUFACTURER THAT THE TRUCK STALLS AND MISFIRES ISSUE AND SAID I HAD ALL THE LATEST UPDATES HOWEVER STILL TODAY I EXPERIENCE STALL AND MISFIRE MAINLY UNDER HARD ACCELERATION. LATELY THE ISSUE HAS WORSEN AND I AM TOLD BY THE MANUFACTURER THAT THERE IS NOTHING THAT THEY CAN OF WILL DO ABOUT IT UNTIL THEY COME UP WITH A FIX. THIS VEHICLE IS A MAJOR SAFETY RISK PERIOD. I HAVE ASKED THE MANUFACTURER OVER AND OVER TO CORRECT THE PROBLEM HOWEVER THEY SIMPLY TOLD ME THEY DON'T HAVE A FIX FOR IS AS OF YET. I AM ASKING THAT YOU LOOK INTO THIS AND INVESTIGATE MY CONCERN PLEASE DON'T WAIT UNTIL SOMEONE GOD FORBID LOOSE THEIR LIFE BECAUSE THIS IS A MAJOR SAFETY CONCERN. WE NEED TO BE MORE PROACTIVE THAN REACTIVE. THE FORD F150'S EQUIPPED WITH THE TURBO ECO BOOST ENGINE IS A MAJOR SAFETY HAZARD IT IS JUST A MATTER OF TIME BEFORE SOMEONE GETS HURT AND LOOSE THEIR LIFE BEFORE SOMETHING MIGHT BE DONE - THAT IS THE SAD PART. PLEASE I BEG YOU TO LOOK INTO MY CONCERN AND FOLLOW UP ASAP. JUST LAST NIGHT MY VEHICLE STALLED I HAVE TO CONSTANTLY DRIVE IT CAUTIOUSLY. I ONLY HAVE LESS THAN 14,000 MILES ON THE VEHICLE BECAUSE I AM SCARED TO DRIVE IT - I DON'T WANT TO SELL IT TO NO ONE ELSE BECAUSE I WOULD FEEL BAD KNOWING THE MAJOR SAFETY ISSUES THIS VEHICLE HAS - I JUST CAN'T BRING MYSELF TO PUTTING SOMEONE IN A VEHICLE THAT COULD HURT THEM. PLEASE GET BEHIND FORD AND INVESTIGATE THIS ISSUE. *TR

NHTSA ODI #10606879

15,800 miles · Jun 25, 2014
EngineFuel System, GasolineVehicle Speed Control

AFTER DRIVING FOR SEVERAL HOURS ON THE INTERSTATE WE HAD STOPPED TO RE-FUEL. UPON RE-ENTRY ONTO THE INTERSTATE THE TRUCK FAILED TO ACCELERATE, THE CHECK ENGINE LIGHT CAME ON, THE TRUCK WAS SHAKING IT TOOK 30-40 SECONDS BEFORE NORMAL OPERATION RESUMED. THIS IS THE 3RD TIME THIS HAS HAPPENED, TWICE ON OF WHICH WERE ON THE INTERST…

Read full complaint

AFTER DRIVING FOR SEVERAL HOURS ON THE INTERSTATE WE HAD STOPPED TO RE-FUEL. UPON RE-ENTRY ONTO THE INTERSTATE THE TRUCK FAILED TO ACCELERATE, THE CHECK ENGINE LIGHT CAME ON, THE TRUCK WAS SHAKING IT TOOK 30-40 SECONDS BEFORE NORMAL OPERATION RESUMED. THIS IS THE 3RD TIME THIS HAS HAPPENED, TWICE ON OF WHICH WERE ON THE INTERSTATE WHILE ATTEMPTING TO MERGE INTO TRAFFIC OR PASS VEHICLES. ALL THREE TIMES THE CONDITIONS HAVE BEEN HIGH HUMIDITY,RAIN & TRAVELING AT A RELATIVELY CONSTANT SPEED FOR AN EXTENDED PERIOD OF TIME. *TR

NHTSA ODI #10605948

14,000 miles · Jun 10, 2014
Vehicle Speed ControlCrash

TL* THE CONTACT OWNS A 2013 FORD F150. THE CONTACT STATED THAT WHILE DRIVING IN A PARKING LOT, THE VEHICLE SUDDENDLY ACCELERATED AND CRASHED INTO A PARKED VEHICLE. THE CONTACT INDICATED THAT AFTER PUTTING THE VEHICLE IN REVERSE AND BACK INTO DRIVE THE FAILURE RECURRED, CAUSING THE CONTACT TO CRASH INTO TO THE VEHICLE A SECOND TI…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F150. THE CONTACT STATED THAT WHILE DRIVING IN A PARKING LOT, THE VEHICLE SUDDENDLY ACCELERATED AND CRASHED INTO A PARKED VEHICLE. THE CONTACT INDICATED THAT AFTER PUTTING THE VEHICLE IN REVERSE AND BACK INTO DRIVE THE FAILURE RECURRED, CAUSING THE CONTACT TO CRASH INTO TO THE VEHICLE A SECOND TIME. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE DEFECT. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 14,000.

NHTSA ODI #10597373

12,000 miles · May 28, 2014
EngineFuel System, GasolineVehicle Speed Control

THE FOLLOWING OCCURRED IN A 2013 F150 PLATINUM WITH 12,000 MILES ON IT. WHILE ACCELERATING FROM A TRAFFIC LIGHT, THE CAR LOST POWER AND STUTTERED AND FELL INTO LIMP MODE. YOU COULD NOT DRIVE OVER 10 MPH. THIS HAS BEEN JUST ONE OF MANY SIMILAR INCIDENTS. I HAVE TAKEN THE CAR IN SEVERAL TIMES BUT FORD CANNOT REPLICATE THE PRO…

Read full complaint

THE FOLLOWING OCCURRED IN A 2013 F150 PLATINUM WITH 12,000 MILES ON IT. WHILE ACCELERATING FROM A TRAFFIC LIGHT, THE CAR LOST POWER AND STUTTERED AND FELL INTO LIMP MODE. YOU COULD NOT DRIVE OVER 10 MPH. THIS HAS BEEN JUST ONE OF MANY SIMILAR INCIDENTS. I HAVE TAKEN THE CAR IN SEVERAL TIMES BUT FORD CANNOT REPLICATE THE PROBLEM, SO THEY WILL NOT FIX ANYTHING. RECENTLY, THE CAR JUST MISFIRED WHILE DRIVING AROUND 40MPH, THESE INCIDENTS OCCUR SUDDENLY THEN THE CAR RECOVERS. MY CAR IS CURRENTLY IN THE SHOP, I WILL PICK IT UP TODAY, THEY SAID THEY COULD NOT REPLICATE THE PROBLEM, SO NO SERVICE WAS DONE. THE REASON IT WAS IN THE SHOP THIS TIME? I WAS DRIVING TO WORK IN THE MORNING AND THE CAR BASICALLY COLLAPSED WHILE DRIVING, ALMOST CAUSING A HUGE ACCIDENT, THIS INCIDENT WAS MORE EXTREME THAN THE OTHERS AND THE CAR WAS STUCK IN LIMP MODE FOR ABOUT 5 SECONDS, THE WOMAN BEHIND ME ALMOST SMASHED INTO ME. THIS IS A 50K TRUCK WITH 12,000 MILES ON IT. THIS TRUCK IS EXTREMELY DANGEROUS TO DRIVE. RECALL!!!!!! *TR

NHTSA ODI #10594479

2,100 miles · Apr 17, 2014
Vehicle Speed Control

WHILE ACCELERATING TO ENTER THE HOV LANE (FAR LEFT) IN HEAVY TRAFFIC THE VEHICLE ACCELERATED ON ITS OWN TO 3500 RPM. BRAKING DID NOT OVER-RIDE THE ACCELERATION. SLOWED ON IT'S OWN AFTER 15 MILES OF 70 MPH DRIVING WITHOUT TOUCHING THE GAS PEDAL. THREE MONTHS LATER, WHILE ACCELERATING QUICKLY FROM A STOP, TO SLOW, TO START IN TRA…

Read full complaint

WHILE ACCELERATING TO ENTER THE HOV LANE (FAR LEFT) IN HEAVY TRAFFIC THE VEHICLE ACCELERATED ON ITS OWN TO 3500 RPM. BRAKING DID NOT OVER-RIDE THE ACCELERATION. SLOWED ON IT'S OWN AFTER 15 MILES OF 70 MPH DRIVING WITHOUT TOUCHING THE GAS PEDAL. THREE MONTHS LATER, WHILE ACCELERATING QUICKLY FROM A STOP, TO SLOW, TO START IN TRAFFIC, THE TRUCK ACCELERATED AGAIN ON ITS OWN. TAC READ 3500 RPM WHILE PULLED OVER IN AND OUT OF GEAR (N). SHOP UNABLE TO REPLICATE ISSUE AND HAVE BEEN TOLD TO DRIVE IT. THIS IS A COUNTY OF SANTA CLARA, CALIFORNIA FLEET TRUCK.

NHTSA ODI #10583315

6,724 miles · Apr 14, 2014
Engine And Engine CoolingVehicle Speed Control

I WAS AT A COMPLETE STOP ON A MAIN STREET MAKING A LEFT TURN. TRAFFIC WAS COMING IN THE OPPOSITE DIRECTION AND I WAS WAITING FOR CLEARING WITHIN THE TRAFFIC IN ORDER TO MAKE MY LEFT TURN. THERE WAS AN OPENING IN TRAFFIC AND I STEPPED ON THE GAS TO ACCELERATE ACROSS THE LANE. AS I STEPPED ON THE GAS A MESSAGE ON MY DASHBOARD CAME…

Read full complaint

I WAS AT A COMPLETE STOP ON A MAIN STREET MAKING A LEFT TURN. TRAFFIC WAS COMING IN THE OPPOSITE DIRECTION AND I WAS WAITING FOR CLEARING WITHIN THE TRAFFIC IN ORDER TO MAKE MY LEFT TURN. THERE WAS AN OPENING IN TRAFFIC AND I STEPPED ON THE GAS TO ACCELERATE ACROSS THE LANE. AS I STEPPED ON THE GAS A MESSAGE ON MY DASHBOARD CAME ON STATING "LOW OIL PRESSURE" AND THE VEHICLE COMPLETED STALLED. I COMPLETELY LOST ALL POWER ON THE ENGINE AND ALSO THE STEERING WHEEL. THE VEHICLE DRIFTED ACROSS THE BUSY LANE AND BARELY MADE IT ACROSS THE LANE AS TRAFFIC WAS COMING DIRECTLY TOWARDS ME. MULTIPLE VEHICLES WERE COMING IN MY DIRECTION AND SOME HONKED THERE CAR HORN TO GET OUT OF THE WAY. THIS WAS EXTREMELY FRIGHTENING AS I HAD MY BABY WITH ME IN THE BACK SEAT. THE CARS WOULD HAVE CLEARLY HIT MY VEHICLE IF I HAD NOT DRIFTED ACROSS THAT LANE. THE TRUCK IS PRACTICALLY NEW AS IT BARELY HAS 6724 MILES. *TR UPDATED 10/8/2014 *JS

NHTSA ODI #10579538

12,100 miles · Apr 10, 2014
EngineVehicle Speed Control

I WAS AT A STOP SIGN TURNING INTO A MAIN STREET, I ACCELERATED TO TURN INTO THE INTERSECTION WHEN I ATTEMPTED TO ACCELERATE THE TRUCK DID NOT DO ANYTHING. IT WAS REALLY NERVE WRECKING, I STEPPED ON THE GAS LIKE 3 TIMES UNTIL THE TRUCK FINALLY REACTED. I ALMOST GOT INTO A REALLY BAD ACCIDENT WHICH WOULD OF BEEN MY FAULT BECAUSE O…

Read full complaint

I WAS AT A STOP SIGN TURNING INTO A MAIN STREET, I ACCELERATED TO TURN INTO THE INTERSECTION WHEN I ATTEMPTED TO ACCELERATE THE TRUCK DID NOT DO ANYTHING. IT WAS REALLY NERVE WRECKING, I STEPPED ON THE GAS LIKE 3 TIMES UNTIL THE TRUCK FINALLY REACTED. I ALMOST GOT INTO A REALLY BAD ACCIDENT WHICH WOULD OF BEEN MY FAULT BECAUSE OF THE CARS DEFECT. THIS IS NOT THE ONLY TIME THAT THIS HAS HAPPENED TO ME, BUT IS THE MOST RECENT. THEY REALLY NEED TO DO SOMETHING ABOUT THIS! I TOOK THE TRUCK TO THE DEALER AND WAS TOLD THAT THEY CANNOT DUPLICATE CUSTOMERS CONCERN. THIS IS A $43,000 TRUCK AND THINK THAT I SHOULD GET WHAT I HAVE PAID FOR NOT A LITTLE PIECE OF CRAP. *TR

NHTSA ODI #10578951

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of