← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Vehicle Speed Control complaints

301 reports
Clear category filter
66,000 miles · Jun 26, 2018
Power TrainVehicle Speed ControlCrash

TRUCK WAS HAVING ISSUES WITH RANDOMLY DISENGAGING FROM CRUISE CONTROL, LOSS OF POWER FROM A STOP, AND ERRATIC DOWNSHIFTING. ON THE HIGHWAY THE CRUISE CONTROL WOULD DISENGAGE, SPEEDOMETER WOULD GO TO 0 THEN BACK TO ITS ACTUAL SPEED. FROM A STOP SIGN/STOP LIGHT, WHEN THE LIGHT WOULD TURN GREEN THE TRUCK WOULD SPIT AND SPUTTER, S…

Read full complaint

TRUCK WAS HAVING ISSUES WITH RANDOMLY DISENGAGING FROM CRUISE CONTROL, LOSS OF POWER FROM A STOP, AND ERRATIC DOWNSHIFTING. ON THE HIGHWAY THE CRUISE CONTROL WOULD DISENGAGE, SPEEDOMETER WOULD GO TO 0 THEN BACK TO ITS ACTUAL SPEED. FROM A STOP SIGN/STOP LIGHT, WHEN THE LIGHT WOULD TURN GREEN THE TRUCK WOULD SPIT AND SPUTTER, SHIFTING ERRATICALLY, RPM WOULD GO UP BUT NO POWER. WHEN CRUISING AROUND 45MPH TRUCK DOWNSHIFTED FOR NO REASON CAUSING A LOUD CLUNKING SOUND, THIS HAPPENED TWICE CONSECUTIVELY. TOOK IS TO SIMMONS ROCKWELL TO GET IT DIAGNOSED, AFTER I HAD ALREADY RESEARCHED THE ISSUE AND KNEW WHAT IT WAS, AND THEY REPLACED THE MOLDED LEAD FRAME IN THE TRANSMISSION. THIS WAS EXACTLY THE ISSUE THEY HAD THAT CAUSED THE RECALL ON THE 2011/2012 MODELS. THE REPAIR COST WAS @ $500. I WAS JUST READING AN ARTICLE WHICH STATED THAT THE NHTSA MAY ORDER ANOTHER RECALL WHICH WOULD INCLUDE THE 2013 MODEL.

NHTSA ODI #11103982

118,000 miles · Jun 13, 2018
Electrical SystemPower TrainVehicle Speed Control

SUDDEN DOWNSHIFT INTO 1ST GEAR AT HIGHWAY SPEEDS. SPEEDOMETER AND DIGITAL DISPLAY STOPS WORKING.

NHTSA ODI #11101648

116,000 miles · Jun 12, 2018
Vehicle Speed Control

WHILE DRIVING 75 MPH DOWN THE INTERSTATE THE TRANSMISSION SHIFTED TO 2 GEAR AND LOCKED UP TIRES FOR A SPLIT SECOND BEFORE SHIFTING BACK UP. I WAS IN TRAFFIC AND TOOK TRUCK OFF ROAD INTO THE MEDIAN, THANKFULLY WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE BEFORE COMING TO A COMPLETE STOP. THE TRANSMISSION BASICALLY HAS A MIND OF IT…

Read full complaint

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

NHTSA ODI #11101440

150,000 miles · May 22, 2018
Electrical SystemVehicle Speed Control

MY 2013 FORD F150 WILL SHIFT INTO DIFFERENT GEARS WHILE DRIVING CAUSING THE TRUCK TO LOCK UP. I WAS DRIVING 65 MPH DOWN THE INTERSTATE THIS MORNING WHEN IT SHIFTED INTO 1ST GEAR CAUSING MY TIRES TO LOCK UP AND SKID ALL OVER THE ROAD. LUCKILY I WAS ABLE TO GET IT OFF THE ROAD BEFORE CRASHING. I HAVE HEARD THIS IS THE OUTPUT SPEED…

Read full complaint

MY 2013 FORD F150 WILL SHIFT INTO DIFFERENT GEARS WHILE DRIVING CAUSING THE TRUCK TO LOCK UP. I WAS DRIVING 65 MPH DOWN THE INTERSTATE THIS MORNING WHEN IT SHIFTED INTO 1ST GEAR CAUSING MY TIRES TO LOCK UP AND SKID ALL OVER THE ROAD. LUCKILY I WAS ABLE TO GET IT OFF THE ROAD BEFORE CRASHING. I HAVE HEARD THIS IS THE OUTPUT SPEED SENSOR WHICH HAS HAPPENED TO MILLIONS OF OTHER F150'S. WHY HAS THIS NOT BEEN RECALLED?? THIS IS A MAJOR SAFETY HAZARD! HTTPS://WWW.SLASHGEAR.COM/FORD-FACES-1M-RECALL-EXPANSION-OVER-WORRYING-TRANSMISSION-FLAW-02513360/

NHTSA ODI #11097282

46,000 miles · May 16, 2018
Power TrainVehicle Speed Control

MY TRUCK DOWNSHIFTS WITHOUT CAUSE, SOMETIMES TO 1ST GEAR, AND ON ONE OCCASION MY WHEELS SKIDDED (WHICH WAS WITNESSED BY MY NEIGHBOR WHO WAS WALKING HIS DOG AND WAS STARTLED BY THE SKID). THE SPEEDOMETER GOES TO ZERO EVEN WHILE MOVING - I HAVE VIDEO FROM MY CELL PHONE OF THIS HAPPENING WHILE GOING APPROXIMATELY 75 MPH ON THE FREE…

Read full complaint

MY TRUCK DOWNSHIFTS WITHOUT CAUSE, SOMETIMES TO 1ST GEAR, AND ON ONE OCCASION MY WHEELS SKIDDED (WHICH WAS WITNESSED BY MY NEIGHBOR WHO WAS WALKING HIS DOG AND WAS STARTLED BY THE SKID). THE SPEEDOMETER GOES TO ZERO EVEN WHILE MOVING - I HAVE VIDEO FROM MY CELL PHONE OF THIS HAPPENING WHILE GOING APPROXIMATELY 75 MPH ON THE FREEWAY. WHEN THIS HAPPENS ALL OTHER GAUGES GO TO DASHES, INCLUDING THE MILEAGE, MPG, ETC. THE TRANSMISSION WILL SLIP INTO 2ND AND 5TH GEARS AND WILL NOT GO TO ANY OTHER GEARS. IT SOMETIMES REMAINS IN 3RD GEAR EVEN AT A DEAD STOP. TURNING THE TRUCK COMPLETELY OFF SOMETIMES "RESETS" THINGS, BUT ONLY TEMPORARILY. I HAVE CONTACTED A DEALER ABOUT THIS AND THEY LOOKED UP MY VIN AND TOLD ME THERE ARE NO RECALLS FOR MY TRUCK YEAR - EVEN THOUGH THE SAME TYPES OF THINGS WERE OCCURRING WITH 2011-12 F150'S, AND THOSE ARE THE SUBJECT OF A RECALL. THIS IS A SAFETY ISSUE: IT HAPPENS WITHOUT WARNING, SOMETIMES ON THE FREEWAY TRAVELING AT HIGH SPEEDS, SOMETIMES WHILE SITTING AT A STOP LIGHT AND IT SHIFTS TO 3RD GEAR AND HARDLY WILL GET GOING. I CALLED FORD CUSTOMER SERVICE AND EXPLAINED EVERYTHING AND THEY SAID THEY WOULD REPORT TO NHTSA BUT SINCE IT IS OUT OF WARRANTY AND THERE IS NO RECALL, I WOULD MOST LIKELY BE RESPONSIBLE FOR THE COST OF REPAIR. I POINTED OUT A LETTER SENT BY NHTSA TO FORD ON JANUARY 18, 2018 ADDRESSING ISSUES WITH MY TRUCK MODEL AND YEAR, BUT THAT DID NOT CHANGE ANYTHING IN THE REPRESENTATIVE'S MIND. I BELIEVE THERE NEEDS TO BE CONSUMER PROTECTION ON THIS, BOTH FROM A SAFETY AND FINANCIAL ASPECT, BY NHTSA. I HAVE VIDEO OF WHAT HAPPENED ON THE FREEWAY WITH THE TRUCK DOWNSHIFTING TO 5TH GEAR AND REMAINING THERE, AND WHEN TRAFFIC SLOWED THE TRUCK DOWNSHIFTED TO 2ND GEAR AND WOULD NOT SHIFT TO ANY OTHER GEAR. I HAD TO PULL OFF THE FREEWAY WITH HAZARD LIGHTS FLASHING AND TURN OFF THE TRUCK AND RESTART IT TO TRY TO "RESET" THINGS.

NHTSA ODI #11094111

100,000 miles · May 8, 2018
Power TrainVehicle Speed Control

MY TRANSMISSION HAS BEEN ACTING ERRATICALLY FOR THE PAST 30 DAYS. AT FIRST THE VEHICLE WOULD LOSE ACCELERATION AND THEN THE RPMS WOULD JUMP 2000, AFTER A COUPLE SECONDS I WOULD HEAR A LOUD THUMP AS THE TRANSMISSION REENGAGED; THE SPEEDOMETER ALSO REGISTERED 0 A COUPLE TIMES WHEN THIS HAPPENED. OTHER TIMES THE TRANSMISSION WOULD …

Read full complaint

MY TRANSMISSION HAS BEEN ACTING ERRATICALLY FOR THE PAST 30 DAYS. AT FIRST THE VEHICLE WOULD LOSE ACCELERATION AND THEN THE RPMS WOULD JUMP 2000, AFTER A COUPLE SECONDS I WOULD HEAR A LOUD THUMP AS THE TRANSMISSION REENGAGED; THE SPEEDOMETER ALSO REGISTERED 0 A COUPLE TIMES WHEN THIS HAPPENED. OTHER TIMES THE TRANSMISSION WOULD REFUSE TO LEAVE FIRST GEAR OR I WOULD LOSE POWER WHILE IN FIRST GEAR FOR APPROXIMATELY 10 SECONDS. THE WORST ISSUE HAPPENED WHEN I WAS DRIVING THE VEHICLE AT APPROXIMATELY 35 MPH WHEN THE TRANSMISSION SHIFTED INTO 1ST GEAR AND LOCKED UP MY REAR TIRES! THANKFULLY I DIDN'T GET REAR ENDED, OR WORSE, BEEN DRIVING ON THE HIGHWAY; THERE IS NO WAY I COULD HAVE CONTROLLED THE VEHICLE AT HIGH SPEEDS AND COULD HAVE SERIOUSLY INJURED MYSELF OR OTHER DRIVERS. UNFORTUNATELY THESE TRANSMISSION ISSUES ARE INTERMITTENT AND DO NOT GENERATE ERROR CODES. I'VE BEEN TO TWO FORD DEALERS, THE FIRST COULD NOT REPLICATE THE ISSUE AND THE SECOND WAS ABLE TO DETERMINE THE ISSUE IS CAUSED BY A FAULTY ELECTRONIC CONTROL ASSEMBLY IN THE TRANSMISSION; THEY HAD TO SEARCH SERVICE BULLETINS IN ORDER TO FIGURE OUT WHAT IS HAPPENING. WHILE THIS SEEMS TO BE A COMMON COMPLAINT WITH FORD OWNERS, 2013 VEHICLES ARE NOT INCLUDED IN THE RECALL AND THEY WANT TO CHARGE ME $1412.75 TO FIX THE ISSUE. IN ADDITION, THIS IS A MAJOR SAFETY ISSUE.

NHTSA ODI #11092474

137,000 miles · Apr 13, 2018
Vehicle Speed Control

WHILE DRIVING ON THE CITY STREET THE TRANSMISSION JUMPED FROM HIGHER GEAR TO A LOWER GEAR FOR NO REASON. TRANSMISSION SEEMS TO BE UNABLE TO DECIDE WHAT GEAR IT SHOULD BE IN AFTER STOPPING AT RED LIGHT. TRANSMISSION WOULD BE IN A HIGH GEAR AND ALMOST UNABLE TO TAKE OFF FROM A DEAD STOP. AFTER TURNING VEHICLE OFF AND CRANKING U…

Read full complaint

WHILE DRIVING ON THE CITY STREET THE TRANSMISSION JUMPED FROM HIGHER GEAR TO A LOWER GEAR FOR NO REASON. TRANSMISSION SEEMS TO BE UNABLE TO DECIDE WHAT GEAR IT SHOULD BE IN AFTER STOPPING AT RED LIGHT. TRANSMISSION WOULD BE IN A HIGH GEAR AND ALMOST UNABLE TO TAKE OFF FROM A DEAD STOP. AFTER TURNING VEHICLE OFF AND CRANKING UP AGAIN IT SEEMED TO WORK FINE. THEN WHEN PULLING OUT ONTO THE HIGHWAY FROM A SIDE ROAD I ATTEMPTED TO GO AND MY TRUCK WOULD BARELY MOVE, I WAS ALMOST HIT BY AN ONCOMING VEHICLE BECAUSE MY TRUCK WOULD NOT GO INTO THE PROPER GEAR AND TAKE OFF AS DESIGNED TO. I AM AFRAID TO DRIVE IT ANYMORE BECAUSE I MAY GO TO TAKE OFF AND NOT BE ABLE TO AND GET HIT BY ONCOMING TRAFFIC. I ALSO AM AFRAID I MAY BE GOING DOWN THE ROAD AND THE TRANSMISSION JUMP INTO A LOWER GEAR AND CAUSE ME TO LOSE CONTROL AND HAVE A WRECK. THIS IS A VERY DANGEROUS PROBLEM TO HAVE.

NHTSA ODI #11084946

132,986 miles · Apr 4, 2018
Power TrainSteeringVehicle Speed Control

135,987 MI. 2013 FORD F 150 ECONOBOOST POWERSTEERING ASSIT WENT OUT! NOTICE A TRACTION FAULT COUPLE DAYS AGO AND IT WENT AWAY AFTER I SHUT OFF MY TRUCK. THE STEERING NEVER DID THIS AND IT HAPPENED IN A PARKING LOT MAKING A SHARP LEFT TURN! AND THEN WHILE TRYING TO DRIVE OUT OF THE PARKING LOT TURNING OUT TO THE INTERSECTION NO …

Read full complaint

135,987 MI. 2013 FORD F 150 ECONOBOOST POWERSTEERING ASSIT WENT OUT! NOTICE A TRACTION FAULT COUPLE DAYS AGO AND IT WENT AWAY AFTER I SHUT OFF MY TRUCK. THE STEERING NEVER DID THIS AND IT HAPPENED IN A PARKING LOT MAKING A SHARP LEFT TURN! AND THEN WHILE TRYING TO DRIVE OUT OF THE PARKING LOT TURNING OUT TO THE INTERSECTION NO POWER STEERING???? JUST LAST YEAR I HAD TO REPLACE MY THROTTLE BODY BECAUSE MY TRUCK WOULD GO LIMP WHILE DRIVING! WHY ISN'T THERE A RECAL ON THE STEERING FOR THIS YEAR?

NHTSA ODI #11083333

103,000 miles · Mar 28, 2018
Air BagsPower TrainVehicle Speed Control

WITHOUT WARNING MY REAR WHEELS & DRIVETRAIN LOCKED UP WHILE DRIVING. MY VEHICLE SUDDENLY LOST CONTROL AND I HAD TO DRIVE INTO THE GRASSY SHOULDER AT AROUND 35 MPH TO AVOID BEING IN TRAFFIC. AS THE PROBLEM WAS OCCURING, THE SPEEDOMETER WENT TO 0 MPH AND THE AIRBAG LIGHT ILLUMINATED. THE VEHICLE MILEAGE IN THE CLUSTER SHOWED ALL D…

Read full complaint

WITHOUT WARNING MY REAR WHEELS & DRIVETRAIN LOCKED UP WHILE DRIVING. MY VEHICLE SUDDENLY LOST CONTROL AND I HAD TO DRIVE INTO THE GRASSY SHOULDER AT AROUND 35 MPH TO AVOID BEING IN TRAFFIC. AS THE PROBLEM WAS OCCURING, THE SPEEDOMETER WENT TO 0 MPH AND THE AIRBAG LIGHT ILLUMINATED. THE VEHICLE MILEAGE IN THE CLUSTER SHOWED ALL DASHES. THE TRANSMISSION FELT LIKE IT WAS DISCONNECTED FROM THE ENGINE, AND TRANSMISSION WAS STUCK IN 5TH GEAR AT LOW VEHICLE SPEEDS. I CYCLED THE IGNITION, AND TRUCK DROVE NORMALLY AFTER THAT. THIS IS AN INTERMITTENT PROBLEM AND VERY DANGEROUS TO DRIVE WITH AS VEHICLE WILL LOSE POWER AND TRANSMISSION CAN SHIFT TO 1ST GEAR AT HIGH VEHICLE SPEEDS. MY VEHICLE HAS THE 6R80 FAULTY TRANSMISSION WITH THE SAME TYPE OF 6R80 MOLDED LEAD FRAME DEFECT PROBLEM REPORTED IN PREVIOUS F150 MODEL YEARS. UPON CONTACTING DEALERSHIP THEY SEEMED LIKE THEY NEVER HEARD OF THE ISSUE BEFORE. FORD SHOULD ISSUE A RECALL FOR ALL VEHICLES WITH P0722 OUTPUT SHAFT SPEED SENSOR DIAGNOSTIC TROUBLE CODES. A SIMPLE ELECTRICAL ISSUE ON A $100 PART SHOULD NOT CAUSE THIS TYPE OF DANGEROUS REACTION. SEE FORD TSB 13-4-9 AND 13-2-3 AND RECALL #16V248000 THAT SHOULD APPLY TO ALL 2013 F-150'S TOO.

NHTSA ODI #11081841

42,642 miles · Mar 20, 2018
Vehicle Speed Control

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH AND PULLING A CAMPER, THE VEHICLE DECELERATED WITHOUT WARNING. THE CONTACT PULLED OVER TO OBSERVE THE VEHICLE AND DROVE HOME. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND D…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH AND PULLING A CAMPER, THE VEHICLE DECELERATED WITHOUT WARNING. THE CONTACT PULLED OVER TO OBSERVE THE VEHICLE AND DROVE HOME. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 42,642. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11080362

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of