← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Vehicle Speed Control complaints

301 reports
Clear category filter
150,000 miles · Mar 20, 2019
Power TrainVehicle Speed Control

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN). WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STATED THAT THE BATTERY CABLE WAS REMOVED AND THEN RE-INSTALLED, AND THE VEHICLE FUNCTIONED NORMALLY. AFTER DRIVING 5…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN). WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STATED THAT THE BATTERY CABLE WAS REMOVED AND THEN RE-INSTALLED, AND THE VEHICLE FUNCTIONED NORMALLY. AFTER DRIVING 5 MILES AT 35 MPH, THE VEHICLE STARTED TO DECELERATE AND LOST POWER. THE VEHICLE WAS TAKEN TO LANDERS FORD SOUTH (95 GOODMAN RD E, SOUTHAVEN, MS 38671, (662) 349-4300) WHERE IT WAS DIAGNOSED THAT THE SPEED SHAFT SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ODI #11190240

65,000 miles · Mar 18, 2019
Power TrainVehicle Speed Control

I HAVE BEEN HAVING SAME ISSUE AS EVERYONE ELSE , AS MY 2013 F150 HAS SHIFTING UP AND DOWN ERRATICALLY. DRIVING AT STEADY SPEEDS AND ALL OF A SUDDEN SHIFTS UP AND DOWN FROM 1ST TO 5TH AND 6TH GEAR AND BACK DOWN AGAIN SUDDENLY AND UNEXPECTEDLY. WHICH AS EVERYONE ELSE HAS STATED IT IS A MAJOR SAFETY PROBLEM AND FORD IS NOT STANDIN…

Read full complaint

I HAVE BEEN HAVING SAME ISSUE AS EVERYONE ELSE , AS MY 2013 F150 HAS SHIFTING UP AND DOWN ERRATICALLY. DRIVING AT STEADY SPEEDS AND ALL OF A SUDDEN SHIFTS UP AND DOWN FROM 1ST TO 5TH AND 6TH GEAR AND BACK DOWN AGAIN SUDDENLY AND UNEXPECTEDLY. WHICH AS EVERYONE ELSE HAS STATED IT IS A MAJOR SAFETY PROBLEM AND FORD IS NOT STANDING BEHIND THEIR PRODUCT. FORD KNOWS OF THIS PROBLEM AS THEY HAVE RECALLED CERTAIN YEARS BUT NOT 2013 WHICH IS APPARENTLY JUST AS MUCH OF AN ISSUE , NOW THAT I HAVE TAKEN MY TRUCK IN FOR SERVICE IT WILL MY RESPONSIBILITY TO PAY AT LEAST $1000 TO REPAIR MAYBE MORE IF MORE PROBLEMS ARE FOUND. THIS IS NOT AN ISOLATED PROBLEM AS THERE IS AN ISSUE THAT SPANS MANY YEARS AND MODELS OF VEHICLES. THE CONSUMER SHOULD NOT HAVE DEAL THIS AS THIS A MANUFACTURING ISSUE THAT HAS SPANNED YEARS AND MANY MODELS AND IS A MAJOR SAFETY ISSUE FOR ME AND THAT UNSUSPECTING VICTIM IN TRAFFIC ACCIDENTS.

NHTSA ODI #11189770

95,563 miles · Mar 14, 2019
Electrical SystemPower TrainVehicle Speed Control

FORD F150 SUPERCREW 5.0 V8 6 SPEED AUTO TRANSMISSION. ERRATIC SHIFTING WHILE DRIVING. SOMETIMES WILL STAY IN 5TH GEAR AT A STOP WONT SHIFT DOWN, SOMETIMES WHEN PULLING OUT IN 1ST GEAR WILL NOT SHIFT UP. BOUNCES BACK AND FORTH BETWEEN 1ST GEAR AND THIRD OR 5TH WHILE DRIVING. SHUTTING OFF VEHICLE AND RESTARTING SOMETIMES SOLVES IS…

Read full complaint

FORD F150 SUPERCREW 5.0 V8 6 SPEED AUTO TRANSMISSION. ERRATIC SHIFTING WHILE DRIVING. SOMETIMES WILL STAY IN 5TH GEAR AT A STOP WONT SHIFT DOWN, SOMETIMES WHEN PULLING OUT IN 1ST GEAR WILL NOT SHIFT UP. BOUNCES BACK AND FORTH BETWEEN 1ST GEAR AND THIRD OR 5TH WHILE DRIVING. SHUTTING OFF VEHICLE AND RESTARTING SOMETIMES SOLVES ISSUE BUT BECOMING MORE FREQUENT, RECALL FOR REPROGRAMMING SPEED OUTPUT SENSOR WAS PERFORMED WITH NO RESOLUTION. APPEARS TO BE THE LEAD FRAME MODULE ISSUE THAT WAS RECALLED IN 2011-2012 FORD F150 BUT NOT RECALLED OR EXTENDED WARRANTY ON 2013 MODELS. VERY VERY DANGEROUS, CANNOT DRIVE THIS VEHICLE!

NHTSA ODI #11186740

76,000 miles · Mar 8, 2019
EnginePower TrainVehicle Speed Control

WHILE DRIVING AT 70MPH NOTICED MY TRUCK HAD DOWN SHIFTED INTO 5TH GEAR, I SLOWED TO PULL OVER AND NOTED THE AIRBAG LIGHT WAS ON, THE WRENCH INDICATOR AND SPEEDOMETER WAS AT ZERO. MY TRUCK SUDDENLY DOWN SHIFTED TO 1ST GEAR AT APPROXIMATELY 25-30 MPH. I WAS ABLE TO STOP SAFELY AT THE SHOULDER AND TURNED THE IGNITION OFF AND RESTAR…

Read full complaint

WHILE DRIVING AT 70MPH NOTICED MY TRUCK HAD DOWN SHIFTED INTO 5TH GEAR, I SLOWED TO PULL OVER AND NOTED THE AIRBAG LIGHT WAS ON, THE WRENCH INDICATOR AND SPEEDOMETER WAS AT ZERO. MY TRUCK SUDDENLY DOWN SHIFTED TO 1ST GEAR AT APPROXIMATELY 25-30 MPH. I WAS ABLE TO STOP SAFELY AT THE SHOULDER AND TURNED THE IGNITION OFF AND RESTARTED. MY TRUCK STARTED NORMALLY. I WENT TO FORD HUNTINGTON BEACH AND DESCRIBED THE SITUATION. AFTER EVALUATING DEALER STATED TRANS FLUID FULL, POSS LEAD FRAME DAMAGE AND VALVES GETTING STUCK. $1600! I INFORMED THE DEALER OF THE PENDING RECALL FOR THE TRANSMISSION ON THIS VEHICLE AND WAS INFORMED THAT IT ONLY COVERED A SOFTWARE UPGRADE. DAMAGE CAUSED BY A KNOWN FAULT SHOULD BE COVERED BY THE MANUFACTURER.

NHTSA ODI #11185451

86,000 miles · Mar 6, 2019
Electronic Stability Control (esc)Unknown Or OtherVehicle Speed Control

I TOOK MY TRUCK INTO RED MCCOMBS FORD IN SAN ANTONIO, TX BECAUSE I HAD ISSUES WITH MY TRANSMISSION. I CAN BE DRIVING AND IT WOULD REV UP TO 4K RPM WITHOUT MY FOOT ON THE ACCELERATION. THERE ARE TIMES WHEN I'M DRIVING AND IT DROPS INTO 1ST AND JARS ME WHEN IT BOGS DOWN. TOOK IT IN AND WE PAID ALMOST $1000 FOR REPAIRS TO FIX IT SI…

Read full complaint

I TOOK MY TRUCK INTO RED MCCOMBS FORD IN SAN ANTONIO, TX BECAUSE I HAD ISSUES WITH MY TRANSMISSION. I CAN BE DRIVING AND IT WOULD REV UP TO 4K RPM WITHOUT MY FOOT ON THE ACCELERATION. THERE ARE TIMES WHEN I'M DRIVING AND IT DROPS INTO 1ST AND JARS ME WHEN IT BOGS DOWN. TOOK IT IN AND WE PAID ALMOST $1000 FOR REPAIRS TO FIX IT SINCE I FEARED FOR MY SAFETY. IT FELT LIKE I HAD NO CONTROL OF MY VEHICLE. THAT WAS IN SEPT 2018..HERE WE ARE MARCH 2019 HAVING THE SAME ISSUES. I TRIED TAKING IT IN, BUT THEY DID NOT HAVE THE OFFER OF A LOANER VEHICLE WHILE THEY FIXED AGAIN, SO I HAVE HAD NO CHOICE BUT TO DRIVE MY TRUCK STILL. I LOVE MY TRUCK...BUT THIS IS SCARY DRIVING LIKE THIS. I DON'T HAVE A CHOICE BECAUSE I HAVE TO GET TO WORK DAILY. I NEED A RELIABLE VEHICLE PER I HAD MAJOR SURGERY LAST SEPT AND HAVE HAD 2 EMERGENCY ROOM TRIPS SINCE AND CANNOT AFFORD TO GET IN A WRECK OR HAVE MY TRUCK GO OUT WITH MY HEALTH ISSUES. I'M AFRAID ALL THE JERKING IS GOING TO CAUSE ME ISSUES WITH MY BACK AND SAFETY OF MY FAMILY. I HAVE HAD TO PULL OVER AND RESTART TRUCK TO GET IT TO QUIT REVVING UP, AND NOT REAR ENDING SOMEONE.

NHTSA ODI #11184509

50,000 miles · Mar 4, 2019
EnginePower TrainVehicle Speed Control

WIDELY REPORTED- PLEASE READ CAREFULLY! VERY SIMILAR TO EXISTING RECALL*, BUT NOT THE SAME. POTENTIALLY DEADLY. CURRENT RECALL DOES NOT ADDRESS THE SUDDEN UP-SHIFTS MENTIONED HERE. 2013 FORD F-150 MFG DEFECT: MOLDED LEADFRAME ASSY IN 6R80 TRANSMISSION SYMPTOMS: INTERMITTENT LOSS OF SPEED SIGNAL CAUSES SUDDEN/UNEXPECTED SLAMMI…

Read full complaint

WIDELY REPORTED- PLEASE READ CAREFULLY! VERY SIMILAR TO EXISTING RECALL*, BUT NOT THE SAME. POTENTIALLY DEADLY. CURRENT RECALL DOES NOT ADDRESS THE SUDDEN UP-SHIFTS MENTIONED HERE. 2013 FORD F-150 MFG DEFECT: MOLDED LEADFRAME ASSY IN 6R80 TRANSMISSION SYMPTOMS: INTERMITTENT LOSS OF SPEED SIGNAL CAUSES SUDDEN/UNEXPECTED SLAMMING UPSHIFT FROM 1ST GEAR TO 5TH WHEN ACCELERATING FROM A STOP, CAUSING A COMPLETE AND UNEXPECTED LOSS OF ALL ACCELERATION. INDICATIONS: 5TH GEAR SUDDENLY INDICATED ON DISPLAY, DASHES REPLACE NUMBERS ON SPEED/MILEAGE RELATED DISPLAYS (MPG, ODOMETER). SPEEDOMETER MAY READ 0, AIRBAG SYMBOL POPS ON, LARGE ORANGE WRENCH SYMBOL MAY BRIEFLY APPEAR. PRESSING ON ACCELERATOR DOES NOT CAUSE DOWNSHIFT. MOTOR MAY STALL. REMAINS IN 5TH GEAR WITHOUT SOME OTHER CORRECTIVE ACTION. TURNING ENGINE OFF AND BACK ON WILL RESET THE COMPUTER, AND VEHICLE OPERATES NORMALLY UNTIL NEXT OCCURRENCE. DANGERS: THIS COULD BE FATAL WHEN PULLING OUT INTO ONCOMING TRAFFIC, BOTH FROM THE SIDE (PULLING OUT IN FRONT OF ONCOMING TRAFFIC FROM SIDE STREET) OR FROM REAR (SUDDEN, UNEXPECTED LOSS OF SPEED/ NO BRAKE LIGHTS). FORD CANNOT FIX THIS BY RE-PROGRAMMING THE VEHICLE TO IGNORE THE FAULTY SENSOR ANY MORE THAN YOU CAN IGNORE AN ONCOMING CEMENT TRUCK OR TRAIN. REPAIR IS APPROXIMATELY $800. IF NOT RECALLED, OWNERS MAY TRY TO LIVE WITH THE RISKS OR TRADE TO AN UNKNOWING PERSON, ENDANGERING LIVES OF OTHERS. *THIS DEFECTIVE PART IS ALSO THE ROOT CAUSE OF FORD RECALL #19S07, INVOLVING SUDDEN VIOLENT DOWN-SHIFTS (NOT UPSHIFTS). FORD IS AVOIDING THE PROBLEM BY RE-PROGRAMMING THE ECU TO IGNORE THE INTERMITTENT SPEED SIGNALS, ALLOWING THE TRANSMISSION TO FAIL MORE GRACEFULLY, DEFECTS TO BE REPAIRED AT OWNER'S EXPENSE. THIS APPROACH WILL NOT WORK FOR THE UP-SHIFT PROBLEM. THE DEFECTIVE PART SHOULD BE IMMEDIATELY REPLACED AT FORD'S EXPENSE TO CORRECT BOTH PROBLEMS.

NHTSA ODI #11184012

59,470 miles · Mar 1, 2019
EnginePower TrainVehicle Speed Control

TODAY MY WIFE WAS DRIVING MY TRUCK WITH OUR TWO KIDS DOWN INTERSTATE I79 AT 70 MILES PER HOUR AND THE TRUCK SHIFTED ITSELF TOO FIRST GEAR LOCKED UP THE REAR TIRES AND ABOUT MADE THEM WRECK. I HAD TOO LEAVE MY JOB TO GET THEM OFF THE SIDE OF THE ROAD AND DRIVE MY TRUCK BACK TOO WORK THIS IS NOT ONLY A ISSUE BUT IT COULD GET SOMEO…

Read full complaint

TODAY MY WIFE WAS DRIVING MY TRUCK WITH OUR TWO KIDS DOWN INTERSTATE I79 AT 70 MILES PER HOUR AND THE TRUCK SHIFTED ITSELF TOO FIRST GEAR LOCKED UP THE REAR TIRES AND ABOUT MADE THEM WRECK. I HAD TOO LEAVE MY JOB TO GET THEM OFF THE SIDE OF THE ROAD AND DRIVE MY TRUCK BACK TOO WORK THIS IS NOT ONLY A ISSUE BUT IT COULD GET SOMEONE SERIOUSLY HURT

NHTSA ODI #11183553

69,147 miles · Feb 25, 2019
Electrical SystemPower TrainVehicle Speed Control

TAKATA RECALL. I PUT MY TRUCK IN DRIVE AND AS SOON AS I GET OVER 2-5 MPH IT SHIFTS FROM 1ST GEAR TO 3RD. WHEN THIS HAPPENS I LOSS THE SPEEDOMETER AND MY TURN SIGNALS WILL NOT TURN OFF. CHECK ENGINE LIGHT COMES ON WITH A BIG WRENCH IN THE CENTER OF MY GAUGES. WILL NOT DOWN SHIFT BELOW 3RD AND WILL NOT GO INTO 6TH. ALSO THE ODOMET…

Read full complaint

TAKATA RECALL. I PUT MY TRUCK IN DRIVE AND AS SOON AS I GET OVER 2-5 MPH IT SHIFTS FROM 1ST GEAR TO 3RD. WHEN THIS HAPPENS I LOSS THE SPEEDOMETER AND MY TURN SIGNALS WILL NOT TURN OFF. CHECK ENGINE LIGHT COMES ON WITH A BIG WRENCH IN THE CENTER OF MY GAUGES. WILL NOT DOWN SHIFT BELOW 3RD AND WILL NOT GO INTO 6TH. ALSO THE ODOMETER,MPG, AND TRIPS ALL GO BLANK.CODE P0720. OUTPUT SPEED SENSOR CIRCUIT. I'M TOLD BY FORD AND A TRANSMISSION SHOP THAT IT'S IN THE TRANSMISSION! TRUCK JUST HIT 69147 MILES AND I HAVEN'T OWNED IT THREE WEEKS YET.

NHTSA ODI #11182454

66,621 miles · Feb 18, 2019
EngineService BrakesVehicle Speed Control

1. LOSS OF BRAKES RESULTING IN PEDAL GOING ALL WAY TO FLOOR AT 35 MPH CITY. RECALL 16S24 BUT FORD DEALERSHIP IS SAYING MY VEHICLE IS NOT INCLUDED 2. LOSS OF ENGINE POWER WHILE ATTEMPTING TO MERGE ONTO HIGHWAY AT 65 MPH, THIS HAS OCCURRED THREE TIMES. 3. RECALL 19S07: BROUGHT INTO DEALERSHIP, STATED THEY DON'T HAVE THE SOFTWAR…

Read full complaint

1. LOSS OF BRAKES RESULTING IN PEDAL GOING ALL WAY TO FLOOR AT 35 MPH CITY. RECALL 16S24 BUT FORD DEALERSHIP IS SAYING MY VEHICLE IS NOT INCLUDED 2. LOSS OF ENGINE POWER WHILE ATTEMPTING TO MERGE ONTO HIGHWAY AT 65 MPH, THIS HAS OCCURRED THREE TIMES. 3. RECALL 19S07: BROUGHT INTO DEALERSHIP, STATED THEY DON'T HAVE THE SOFTWARE YET TO REMEDY THE PROBLEM OF SUDDEN POWER TRAIN DOWNSHIFT PRIME FORD 857 PORTLAND RD SACO MAINE 04072 SERVICE MANAGER :STACEY DRUMMEY 207-571-5035

NHTSA ODI #11180730

102,429 miles · Feb 16, 2019
Power TrainVehicle Speed Control

VEHICLE IS DOWN SHIFTING TO GEARS WHILE THE CAR IS IN MOTION, CAUSING THE VEHICLE TO COME TO A ABRUPT STOP. I WAS GOING 55 MPH AND THE VEHICLE DOWN SHIFTED WITHOUT NOTICE, CAUSING THE VEHICLE TO SWERVE INTO ON COMING TRAFFIC. THIS HAS HAPPEN SEVERAL TIMES, I DO NOT FEEL SAFE OPERATING THE VEHICLE. TOOK IT TO THE DEALERSHIP AND W…

Read full complaint

VEHICLE IS DOWN SHIFTING TO GEARS WHILE THE CAR IS IN MOTION, CAUSING THE VEHICLE TO COME TO A ABRUPT STOP. I WAS GOING 55 MPH AND THE VEHICLE DOWN SHIFTED WITHOUT NOTICE, CAUSING THE VEHICLE TO SWERVE INTO ON COMING TRAFFIC. THIS HAS HAPPEN SEVERAL TIMES, I DO NOT FEEL SAFE OPERATING THE VEHICLE. TOOK IT TO THE DEALERSHIP AND WAS TOLD THAT THERE WAS NOTHING THAT THEY COULD DO TO FIX THE ISSUE, DUE TO THE ENGINEERS HAD NOT CAME UP WITH A SOLUTION. I WAS GIVEN AN ESTIMATION DATE OF JUNE OF WHEN FORD WOULD HAVE A SYSTEM UPGRADE. MEANWHILE, I STUCK WITH A TRUCK PAYMENT FOR A VEHICLE I CANNOT SAFELY DRIVE.

NHTSA ODI #11180453

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of