← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Vehicle Speed Control complaints

301 reports
Clear category filter
99,000 miles · Apr 10, 2020
EnginePower TrainVehicle Speed Control

OIL AND RADIATOR FLUID LEAKS CAUSING ENGINE SMOKING AND NAUSEATING ODOR WHEN HEATER TURNED ON WHILE ENGINE COLD OR COLD EXTERIOR TEMPS. COMPLETE LOSS OF ENGINE AND DRIVE POWER RANDOMLY LASTING 15-60SECS, THEN ALL NUMBERS IE: GAS MILAGE, SPEED, MILEAGE BECOME DASHES, SPEEDOMETER QUITS WORKING, ON HIGHWAYS AND CITY STREET. PULLIN…

Read full complaint

OIL AND RADIATOR FLUID LEAKS CAUSING ENGINE SMOKING AND NAUSEATING ODOR WHEN HEATER TURNED ON WHILE ENGINE COLD OR COLD EXTERIOR TEMPS. COMPLETE LOSS OF ENGINE AND DRIVE POWER RANDOMLY LASTING 15-60SECS, THEN ALL NUMBERS IE: GAS MILAGE, SPEED, MILEAGE BECOME DASHES, SPEEDOMETER QUITS WORKING, ON HIGHWAYS AND CITY STREET. PULLING OVER SHUTTING OFF AND RESTART WILL RESET UNTIL NEXT RANDOM EPISODE. ROUGH JERKS AND OCCASIONALLY A BANG WITH JERKS (FEEL LIKE IT COMES FROM THE AXELS) USUALLY AT LOW SPEEDS. MORE OFTEN IN PARKING LOTS BUT IN TRAFFIC JAMS ON HIGHWAYS. ONCE TRANSMISSION RECALL COMPLETE IT RAN FANTASTIC FOR A WEEK AND A HALF. NOW IT'S WORSE THAN EVER AND ENGINE LIGHT COMES ON FOR A DAY AND THEN GOES OFF.

NHTSA ODI #11320748

167,000 miles · Feb 29, 2020
EngineUnknown Or OtherVehicle Speed Control

I AM HAVING TROUBLE WITH MY ECO BOOST BECAUSE WHEN I START MY TRUCK I HAVE A LOUD RATTLING SOUND THEN MY TRUCK LOSES POWER AND SHAKES ALOT LIKE A COMPRESSION LEAK

NHTSA ODI #11312279

111,737 miles · Feb 14, 2020
Power TrainVehicle Speed Control

I RECENTLY PURCHASED THIS VEHICLE USED LESS THAN A WEEK AGO. I HAVE ONLY DRIVEN IT FOR ABOUT 75 MILES. WHILE DRIVING DOWN A BUSY STREET AT 45 MILES AN HOUR THE TRUCK DOWN SHIFTED TO FIRST GEAR AND SIMULTANEOUSLY THE SPEEDOMETER STOPPED WORKING. I KEPT CONTROL OF THE VEHICLE BUT IF A VEHICLE WOULD HAVE BEEN FOLLOWING CLOSELY IT I…

Read full complaint

I RECENTLY PURCHASED THIS VEHICLE USED LESS THAN A WEEK AGO. I HAVE ONLY DRIVEN IT FOR ABOUT 75 MILES. WHILE DRIVING DOWN A BUSY STREET AT 45 MILES AN HOUR THE TRUCK DOWN SHIFTED TO FIRST GEAR AND SIMULTANEOUSLY THE SPEEDOMETER STOPPED WORKING. I KEPT CONTROL OF THE VEHICLE BUT IF A VEHICLE WOULD HAVE BEEN FOLLOWING CLOSELY IT IS POSSIBLE IF NOT LIKELY TO HAVE REAR ENDED ME. I CHECKED THE VIN AND IT STATES NO OPEN RECALLS. EVIDENTLY THE VEHICLE WAS SERVICED FOR ONE OF THE PAST RECALLS WHICH CLEARLY DESCRIBES THIS SAME EVENT AS AN ISSUE. I WILL CONTACT THE DEALERSHIP GREY DANIELS FORD IN BRANDON MS WHERE IT WAS PURCHASED FOR INSPECTION.

NHTSA ODI #11309097

13,447 miles · Feb 3, 2020
Power TrainVehicle Speed Control

UNEXPECTEDLY DOWNSHIFTING INTO FIRST GEAR WHILE IN MOTION, SPEED OMETER AND MILEAGE GOES TO ZERO, RPMS STARTS TO RUN HIGH, AND THE TOOL LIGHT ON THE DASH BOARD COMES ON, IN CITY STREETS AND ON HIGHWAY DRIVING. I HAVE TO STOP AND SHUT DOWN THE VEHICLE AND WAIT A FEW MINUTES. WHEN I START UP THE VEHICLE AND PUT IT IN DRIVE GEAR T…

Read full complaint

UNEXPECTEDLY DOWNSHIFTING INTO FIRST GEAR WHILE IN MOTION, SPEED OMETER AND MILEAGE GOES TO ZERO, RPMS STARTS TO RUN HIGH, AND THE TOOL LIGHT ON THE DASH BOARD COMES ON, IN CITY STREETS AND ON HIGHWAY DRIVING. I HAVE TO STOP AND SHUT DOWN THE VEHICLE AND WAIT A FEW MINUTES. WHEN I START UP THE VEHICLE AND PUT IT IN DRIVE GEAR THE TRANSMISSION JERKS.

NHTSA ODI #11306713

87,222 miles · Jan 28, 2020
Power TrainVehicle Speed Control

I TOOK MY TRUCK IN ALMOST A YEAR AGO IN MARCH TO HAVE RECALL ON TRANSMISSION DOWNSHIFT REPAIRED. JUST IN THE LAST MONTH I HAVE HAD TO BRING MY TRUCK IN 3 TIMES. TWICE MY TRUCK DOWNSHIFTED WHILE ON THE SH-130 TOLLWAY GOING 80MPH AND DOWN SHIFTING TO 40 MPH ALMOST CAUSING ME TO WRECK OR BE STRUCK BY ANOTHER VEHICLE. AGAIN TODAY I …

Read full complaint

I TOOK MY TRUCK IN ALMOST A YEAR AGO IN MARCH TO HAVE RECALL ON TRANSMISSION DOWNSHIFT REPAIRED. JUST IN THE LAST MONTH I HAVE HAD TO BRING MY TRUCK IN 3 TIMES. TWICE MY TRUCK DOWNSHIFTED WHILE ON THE SH-130 TOLLWAY GOING 80MPH AND DOWN SHIFTING TO 40 MPH ALMOST CAUSING ME TO WRECK OR BE STRUCK BY ANOTHER VEHICLE. AGAIN TODAY I WAS DRIVING MY VEHICLE ON HWY AND ENGINE LIGHT CAME ON. SAME EFFECT EXCEPT THIS TIME MY TRUCK REFUSED TO MOVE WITHOUT TURNING IT OFF IN THE MIDDLE OF TRAFFIC. THIS IS 3XS MY LIFE HAS BEEN IN JEOPARDY IN A SHORT PERIOD OF TIME. I HAVE TAKEN IT TO FORD DEALERSHIP WHERE THEY INSISTED TRANSMISSION DOWNSHIFT ISSUE WAS REPAIRED AND SUGGESTED A TUNE UP WAS BEST OPTION. HUNDREDS OF DOLLARS OUT AND AGAIN I'M IN SAME SITUATION I WAS. 3 X NEAR WRECKING OR DEATH AND ALL IN UNDER A MONTH. INITIAL DATE OF SERVICE 1/3/20 SERVICED AGAIN 1/21/20. NOW NEED SERVICE AGAIN. I HAVE KEPT UP WITH SCHEDULED MAINTENANCE ON VEHICLE AND IT DOES NOT HAVE VERY MANY MILES ON IT.

NHTSA ODI #11302690

Mileage unknown · Jan 6, 2020
Power TrainVehicle Speed Control

ON 10 AUG 2019 I TOOK MY FORD IN FOR TRANSMISSION RECALL, REPROGRAMMING TO PREVENT UNCONTROLLED DOWNSHIFTING. I HAD NEVER HAD HAD ANY PROBLEMS WITH DOWNSHIFTING PRIOR TO THIS DATE. ONCE RECALL WAS DONE WITHIN A WEEK MY TRUCK DRASTICALLY DOWNSHIFTED TWICE BEFORE TAKING IT BACK TO THE DEALER WHO PERFORMED THE RECALL. THEY SAID …

Read full complaint

ON 10 AUG 2019 I TOOK MY FORD IN FOR TRANSMISSION RECALL, REPROGRAMMING TO PREVENT UNCONTROLLED DOWNSHIFTING. I HAD NEVER HAD HAD ANY PROBLEMS WITH DOWNSHIFTING PRIOR TO THIS DATE. ONCE RECALL WAS DONE WITHIN A WEEK MY TRUCK DRASTICALLY DOWNSHIFTED TWICE BEFORE TAKING IT BACK TO THE DEALER WHO PERFORMED THE RECALL. THEY SAID THERE WAS NO PROBLEM WITH MY TRUCK AND TOLD ME MY WHEELS LOCKING WAS NOT A SIGN OF DOWNSHIFTING. NOW I CONTINUE TO HAVE DOWNSHIFTING ISSUES AND ALSO AM THROWING A P0720 CODE. I JUST KNOW THAT THE DOWNSHIFTING BROKE THE LEADFRAME AND I LOOKING AT A HUGE BILL. NOW VEHICLE GOES INTO LIMP MODE WHERE I HAVE TO STOP AND RESTART MY CAR TO GET SPEEDOMETER TO SHOW.

NHTSA ODI #11297526

115,000 miles · Dec 23, 2019
Power TrainVehicle Speed Control

THIS HAS HAPPENED 5 TIMES. WHEN STARTING TO TAKE OFF IN LOW SPEEDS, 20-30 MPH, THE TRANSMISSION WILL SLIP INTO NEUTRAL THEN INTO FIRST SLOWING THE TRUCK DOWN RAPIDLY. ALSO, WHILE TRAVELLING AT HIGHWAY SPEEDS ON CRUISE CONTROL, THE VEHICLE WILL DROP TO 5TH GEAR AND THE SPEEDOMETER WILL DROP TO 0, THE ODOMETER AND ALL DISPLAY PANE…

Read full complaint

THIS HAS HAPPENED 5 TIMES. WHEN STARTING TO TAKE OFF IN LOW SPEEDS, 20-30 MPH, THE TRANSMISSION WILL SLIP INTO NEUTRAL THEN INTO FIRST SLOWING THE TRUCK DOWN RAPIDLY. ALSO, WHILE TRAVELLING AT HIGHWAY SPEEDS ON CRUISE CONTROL, THE VEHICLE WILL DROP TO 5TH GEAR AND THE SPEEDOMETER WILL DROP TO 0, THE ODOMETER AND ALL DISPLAY PANEL SHOWS NOTHING, THE CRUISE WILL NOT WORK, AND THE AIRBAG LIGHT COMES ON.

NHTSA ODI #11290972

81,000 miles · Dec 11, 2019
EnginePower TrainVehicle Speed Control

TRUCK BEING DRIVEN APX 55 MPH AND NO CHANGE FROM ME TRUCK HAS SUDDEN SLOWDOWN WITH SPEEDOMETER DROP TO 40S THEN RECOVERS AS TRUCK SPEEDS UP ON IT'S OWN. SAME DAY AS TRYING TO PARK, IN DRIVE, PRESSING ON GAS ENGINE REVS BUT DOES NOT MOVE. TODAY (7 DAYS LATER) ACCELERATING FROM STOP TRANSMISSION STICKS IN LOW GEAR. HAS HAD POWERTR…

Read full complaint

TRUCK BEING DRIVEN APX 55 MPH AND NO CHANGE FROM ME TRUCK HAS SUDDEN SLOWDOWN WITH SPEEDOMETER DROP TO 40S THEN RECOVERS AS TRUCK SPEEDS UP ON IT'S OWN. SAME DAY AS TRYING TO PARK, IN DRIVE, PRESSING ON GAS ENGINE REVS BUT DOES NOT MOVE. TODAY (7 DAYS LATER) ACCELERATING FROM STOP TRANSMISSION STICKS IN LOW GEAR. HAS HAD POWERTRAIN RECALL APPLIED.

NHTSA ODI #11288554

155,800 miles · Nov 18, 2019
Electronic Stability Control (esc)EngineVehicle Speed Control

I HAVE A F150 4-WHEEL ECO BOOST V6. I RECENTLY HAD MY VEHICLE IN FOR AN OIL CHANGE AND AT THAT TIME DECIDED TO HAVE THE RECALL DONE FOR THE SOFTWARE UPDATE. THE NEXT FEW DAYS I NOTICED THAT THERE WAS SOME HESITATION WITH THE GEARS SHIFTING AND THE TRANSMISSION AT TIMES WOULD DROP. I CONTACTED THE DEALERSHIP TO BRING MY TRUCK BAC…

Read full complaint

I HAVE A F150 4-WHEEL ECO BOOST V6. I RECENTLY HAD MY VEHICLE IN FOR AN OIL CHANGE AND AT THAT TIME DECIDED TO HAVE THE RECALL DONE FOR THE SOFTWARE UPDATE. THE NEXT FEW DAYS I NOTICED THAT THERE WAS SOME HESITATION WITH THE GEARS SHIFTING AND THE TRANSMISSION AT TIMES WOULD DROP. I CONTACTED THE DEALERSHIP TO BRING MY TRUCK BACK IN AT THAT TIME THEY COULD NOT FIND ANYTHING WRONG BUT AN OIL PRESSURE SENSOR. SOME DAYS LATER I WAS DRIVING ON THE FEEDER ROAD GETTING READY TO ENTER THE HIGHWAY. AS SOON AS I ENTERED MY SPEEDOMETER STOP WORKING AND THE TRANSMISSION DROPPED INTO 1ST GEAR. THERE WAS A CAR BEHIND ME THAT ALMOST COLLIDED WITH MY TRUCK. MY FAMILY WAS IN THE CAR AT THE TIME AND THIS COULD HAVE BEEN A SERIOUS ACCIDENT. THE NEXT DAY I BROUGHT MY TRUCK BACK INTO THE DEALERSHIP AND THEY DID A QUICK DIAGNOSIS. THEY STATED THAT I HAD TRANSMISSION ISSUES AND THAT I NEEDED TO LOOK INTO GETTING ANOTHER VEHICLE THROUGH THEM AND TRADING MY TRUCK OUT. I WAS UPSET BY THE RESPONSE SO I TOOK MY VEHICLE TO A LOCAL TRANSMISSION SHOP WHERE THEY THOROUGHLY INSPECTED THE TRUCK. THE FINDINGS WERE THAT THE OSS SENSOR WAS FAULTY AND IT PULL UP A P0270 CODE. THE SHOP ADVISED ME THAT THIS WAS A WARRANTY AND SAFETY ISSUE AND THAT I IMMEDIATELY TAKE IT BACK TO THE DEALERSHIP TO HAVE IT REPAIRED. WHEN I RETURN TO THE DEALERSHIP THEY AT THAT TIME ACKNOWLEDGE THAT IT WAS A WARRANTY ISSUE AND COULD BE FIX, BUT THEY COULD NOT EVEN LOOK AT IT FOR 2-WEEKS AND WOULD NOT EVEN PROVIDE A LOANER AFTER STATING MY SAFETY CONCERNS. I THEN CONTACT FORD MOTOR COMPANY AND THEY COULD NOT ASSIST UNTIL THE DEALERSHIP LOOKED AT MY TRUCK. I DID STATE TO THEM THE TIME ISSUE AT THE DEALERSHIP BUT WAS TOLD THEY HAVE NO CONTROL OVER WHAT THEY DO. I'M STUCK WITH DRIVING A UNSAFE VEHICLE FOR AN ISSUE OUTSIDE OF MY CONTROL AND NO ONE AT FORD IS TAKING THE MATTER SERIOUSLY. THIS COULD CAUSE A FATAL OR SEVERE INJURY.

NHTSA ODI #11280803

108,000 miles · Oct 14, 2019
Vehicle Speed Control

ENGINE LOOSES ALL POWER YET IS STILL RUNNING VERY POORLY. ENGINE SPUTTERS AND WILL NOT RESPOND TO THROTTLE. DASHBOARD DISPLAY SHOWS A WRENCH. PROBLEM OCCURS WITHOUT ANY WARNING. ENGINE WILL USUALLY RESTART AFTER APPROXIMATELY 30 SECONDS AND RUN NORMALY UNTIL NEXT FAILURE. PROBLEM MAY OCCUR MULTIPLE TIMES IN A DAY. MY AUTO DIAGN…

Read full complaint

ENGINE LOOSES ALL POWER YET IS STILL RUNNING VERY POORLY. ENGINE SPUTTERS AND WILL NOT RESPOND TO THROTTLE. DASHBOARD DISPLAY SHOWS A WRENCH. PROBLEM OCCURS WITHOUT ANY WARNING. ENGINE WILL USUALLY RESTART AFTER APPROXIMATELY 30 SECONDS AND RUN NORMALY UNTIL NEXT FAILURE. PROBLEM MAY OCCUR MULTIPLE TIMES IN A DAY. MY AUTO DIAGNOSTIC TOOL GIVES P2111 CODE WHICH INDICATES A THROTTLE BODY PROBLEM. PROBLEM HAS OCCURED WHEN STOPPED OR MOVING AT ANY SPEED. CHECK ENGINE LIGHT MAY OR MAY NOT COME ON ( NOT CONSISTENT). I CONTACTED FORD MOTOR CO. CUSTOMER SERVICE DEPARTMENT CONCERNING THIS ISSUE AFTER READING ABOUT A "CUSTOMER SATISFACTION PROGRAM" 13N03 RELATING TO THIS ISSUE IN WHICH FORD OFFERS TO REPLACE THE FAULTY PART AT NO CHARGE AS AN EXTENDED WARRANTY IN LIEU OF A FACTORY RECALL ACCORDING TO THE NHTSA. I WAS TOLD THAT THEY (FORD) MAY NOT HELP WITH THIS ISSUE. I WAS TOLD THEY WOULD HAVE TO REVIEW MY COMPLAINT AND WOULD GET BACK TO ME.

NHTSA ODI #11268379

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of