← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Service Brakes complaints

320 reports
Clear category filter
48,000 miles · Feb 25, 2016
Service Brakes

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKES FAILED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL ALL THE WAY TO THE FLOOR AND HAD TO PLACE THE VEHICLE IN PARK TO STOP. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER AND BOOSTER PUMP NEEDED TO …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKES FAILED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL ALL THE WAY TO THE FLOOR AND HAD TO PLACE THE VEHICLE IN PARK TO STOP. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER AND BOOSTER PUMP NEEDED TO BE REPLACED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

NHTSA ODI #10838510

24,088 miles · Jan 4, 2016
Service Brakes

LOW BRAKE FLUID WARNING LIGHT CAME ON AND BRAKE PEDAL WENT TO FLOOR. NO VISIBLE LEAKS. I STOPPED THE VEHICLE AND ADDED FLUID, NEXT MORNING RESERVOIR WAS EMPTY AGAIN, NO FLUID ON THE GROUND UNDER VEHICLE. I TOOK THE TRUCK TO THE FORD DEALER FOR WARRANTY REPAIR. THE MILEAGE WAS 24088. DEALER STATED "BOOSTER WAS FULL OF BRAKE …

Read full complaint

LOW BRAKE FLUID WARNING LIGHT CAME ON AND BRAKE PEDAL WENT TO FLOOR. NO VISIBLE LEAKS. I STOPPED THE VEHICLE AND ADDED FLUID, NEXT MORNING RESERVOIR WAS EMPTY AGAIN, NO FLUID ON THE GROUND UNDER VEHICLE. I TOOK THE TRUCK TO THE FORD DEALER FOR WARRANTY REPAIR. THE MILEAGE WAS 24088. DEALER STATED "BOOSTER WAS FULL OF BRAKE FLUID" AND REPLACED BOOSTER PUMP AND MASTER CYLINDER. I HAVE NOTED OTHER ONLINE COMPLAINTS FOR THE SAME FAILURE ON THIS SAME MODEL AND YEAR OF TRUCK. I FEEL AN INVESTIGATION SHOULD BE OPENED DUE TO THE SEVERITY OF THE NATURE OF THIS TYPE OF FAILURE.

NHTSA ODI #10817706

18,070 miles · Dec 11, 2015
Service BrakesCrash

ON 5/1/15, WHILE BACKING OUT OF MY DRIVEWAY, AS I ATTEMPTED TO BRAKE, THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR, AND THERE WAS NO STOPPING POWER. WHILE ATTEMPTING TO PUMP THE BRAKE AND USE THE PARKING BRAKE, MY VEHICLE CROSSED THE STREET, WENT UP THE CURB, AND STRUCK MY NEIGHBOR'S LANDSCAPE WALL, DAMAGING IT SEVERELY. TOTAL…

Read full complaint

ON 5/1/15, WHILE BACKING OUT OF MY DRIVEWAY, AS I ATTEMPTED TO BRAKE, THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR, AND THERE WAS NO STOPPING POWER. WHILE ATTEMPTING TO PUMP THE BRAKE AND USE THE PARKING BRAKE, MY VEHICLE CROSSED THE STREET, WENT UP THE CURB, AND STRUCK MY NEIGHBOR'S LANDSCAPE WALL, DAMAGING IT SEVERELY. TOTAL DISTANCE TRAVELLED WAS APPROXIMATELY 2.5 TRUCK LENGTHS BEFORE IMPACTING THE NEIGHBOR'S WALL. UPON INSPECTION BY MYSELF AND LATER MY INSURANCE INVESTIGATOR, THE BRAKE FLUID RESERVOIR WAS EMPTY, BUT THERE WERE NO OBVIOUS SIGNS OF LEAKAGE. NO PUDDLES OR VISIBLE BRAKE FLUID. TRUCK WAS TOWED TO LOCAL DEALER WHO DIAGNOSED THE PROBLEM AS 'BRAKE FAILURE DUE TO LEAK FAULTY BRAKE MASTER CYLINDER'. WITHIN A FEW DAYS, THE BRAKES AGAIN DID NOT FEEL RIGHT WITH A STRANGE PEDAL FEEL. GRADUALLY, THE WORSENING PEDAL FEEL WAS ACCOMPANIED BY A METALLIC SCRAPING OR GRINDING NOISE. A SECOND TRIP TO A DEALER REVEALED A FAILED BRAKE BOOSTER DUE TO BRAKE FLUID INGESTION, WHICH ALSO EXPLAINED WHY THERE WAS NO VISIBLE EVIDENCE OF A LEAK AFTER THE CRASH. THE BRAKE BOOSTER OPERATES AT A VACUUM, SO AS THE MASTER CYLINDER LEAKED CATASTROPHICALLY, THE BOOSTER SUCKED IN THE FLUID, CAUSING IT TO ULTIMATELY FAIL AS WELL. BOTH THE BRAKE MASTER CYLINDER AND THE BRAKE BOOSTER WERE REPLACED UNDER WARRANTY. I AM SURPRISED THAT THERE AS BEEN NO ACTION ON THIS ISSUE YET - THE COMPLETE FAILURE OF THE MOST IMPORTANT SAFETY SYSTEM OF A 2.5+ TON VEHICLE - AS THERE ARE NUMEROUS NEARLY IDENTICAL FAILURE MODES WITH THIS MODEL AND YEAR. I TRULY HOPE NOBODY IS KILLED BY THIS; IT WAS TRULY TERRIFYING TO BE WITHOUT BRAKES WHILE MOVING IN REVERSE IN A MASSIVE VEHICLE.

NHTSA ODI #10809601

13,000 miles · Nov 4, 2015
Service Brakes

VEHICLE HAD BEEN PARKED FOR LESS THAN ONE HOUR. RETURNED AND STARTED VEHICLE. DEPRESSED BRAKE PEDAL TO SHIFT AND PEDAL WENT TO THE FLOOR AND THE LOW FLUID LIGHT ILLUMINATED. NO BRAKING ACTION. STOPPED VEHICLE AND CHECKED BRAKE FLUID LEVEL. RESERVOIR HAD LESS THAN ONE QUARTER INCH OF FLUID. CHECKED UNDER AND AROUND VEHICLE AND FO…

Read full complaint

VEHICLE HAD BEEN PARKED FOR LESS THAN ONE HOUR. RETURNED AND STARTED VEHICLE. DEPRESSED BRAKE PEDAL TO SHIFT AND PEDAL WENT TO THE FLOOR AND THE LOW FLUID LIGHT ILLUMINATED. NO BRAKING ACTION. STOPPED VEHICLE AND CHECKED BRAKE FLUID LEVEL. RESERVOIR HAD LESS THAN ONE QUARTER INCH OF FLUID. CHECKED UNDER AND AROUND VEHICLE AND FOUND NO EVIDENCE OF FLUID LEAK. ADDED 24 OZ. OF FLUID TO RESERVOIR. BRAKES STILL VERY MUSHY WITH VERY LITTLE BRAKING ACTION. DROVE 11 MILES VERY SLOWLY AND PARKED VEHICLE IN DRIVEWAY. RESEVOIR AGAIN ALMOST EMPTY WITH NO VISIBLE LEAKS. VEHICLE TOWED TO DEALERSHIP. DEALERSHIP SAID THEY HAD NOT HEARD OF THIS PROBLEM BEFORE. APPEARS THE MASTER CYLINDER AND BOOSTER ARE BOTH BAD. TRUCK HAD JUST ROLLED OVER 13,000 MI. WHEN PROBLEM OCCURRED. I HAVE READ AT LEAST 15 SIMILAR REPORTS ON THIS PROBLEM GOING BACK AS FAR AS 2011 F-150 VEHICLES. THIS IS A POTENTIALLY DEADLY PROBLEM.

NHTSA ODI #10788369

22,000 miles · Oct 23, 2015
Service Brakes

LOW BRAKE FLUID WARNING CAME ON WHILE DRIVING. PULLED INTO GAS STATION, SAW BRAKE FLUID RESERVOIR WAS NEAR EMPTY. THERE WAS NO SIGNS OF A LEAK. BOUGHT AND REFILLED BRAKE FLUID AND DROVE TO DEALERSHIP-1 MILE AWAY- BRAKE FLUID RESERVOIR WAS 1/2 FULL. SERVICE REPRESENTATIVE, KNEW RIGHT OFF HAND WHAT THE ISSUE WAS, BRAKE MASTER CYLI…

Read full complaint

LOW BRAKE FLUID WARNING CAME ON WHILE DRIVING. PULLED INTO GAS STATION, SAW BRAKE FLUID RESERVOIR WAS NEAR EMPTY. THERE WAS NO SIGNS OF A LEAK. BOUGHT AND REFILLED BRAKE FLUID AND DROVE TO DEALERSHIP-1 MILE AWAY- BRAKE FLUID RESERVOIR WAS 1/2 FULL. SERVICE REPRESENTATIVE, KNEW RIGHT OFF HAND WHAT THE ISSUE WAS, BRAKE MASTER CYLINDER FAILURE BLEEDING INTO THE RESERVOIR. LUCKILY I WAS ABLE TO GET TO ASERVICE C ENTER. TOOK DAYS TO GET PARTS. SEEMS LIKE A KNOWN ISSUE WITH FORD AND THEY'RE AVOIDING A RECALL...

NHTSA ODI #10785526

32,000 miles · Oct 19, 2015
Service Brakes

ON OCTOBER19 2015 IN YUMA, AZ., I WAS DROPPING DAUGHTER OFF AT SCHOOL AT APPROXIMATELY 720 A.M. ON MY WAY WORK WHEN MY "CHECK BRAKE FLUID" WARNING LIGHT ILLUMINATED, EVERYTHING SEEMED NORMAL BUT AS I WAS DRIVING I STARTED TO NOTICE THAT THE BRAKE PEDAL STARTED TO FEEL MUSHY AND AS I CONTINUED DRIVING AT 55 MILES PER HOUR I WAS C…

Read full complaint

ON OCTOBER19 2015 IN YUMA, AZ., I WAS DROPPING DAUGHTER OFF AT SCHOOL AT APPROXIMATELY 720 A.M. ON MY WAY WORK WHEN MY "CHECK BRAKE FLUID" WARNING LIGHT ILLUMINATED, EVERYTHING SEEMED NORMAL BUT AS I WAS DRIVING I STARTED TO NOTICE THAT THE BRAKE PEDAL STARTED TO FEEL MUSHY AND AS I CONTINUED DRIVING AT 55 MILES PER HOUR I WAS COMING UP TO A MAJOR INTERSECTION AND AS I TRIED TO DECELERATE BY PRESSING THE BRAKE PEDAL THE PEDAL WENT STRAIGHT TO THE FLOORBOARD AND I WAS NOT SLOWING DOWN, BUT 5 MINUTES PRIOR MY BRAKES WORKED FINE. I HAD TO SHARPLY VEER OF TO THE RIGHT TO AVOID SLAMMING INTO ANOTHER VEHICLE THAT WAS SLOWING DOWN, DRIVING OVER THE CURB AND HAVING TO MANUALLY DOWNSHIFT AND UTILIZING THE EMERGENCY BRAKE TO AVOID CRASHING INTO A PARKED BUS. AS I HAVE BEEN READING THIS SEEMS TO BE A RECURRING ISSUE WITH THIS VEHICLE AND A VERY DANGEROUS ISSUE THAT NEEDS TO BE ADDRESSED, I AM THANKFUL THAT I DID NOT HAVE MY DAUGHTER IN THE VEHICLE AT THAT TIME AND AM VERY LUCKY THAT NOBODY WAS HURT OR GOD FORBID WORSE. THE F-150 WAS TOWED TO THE DEALERSHIP AND AMAZINGLY THE SERVICE REP TOLD ME WHAT WAS WRONG BEFORE EVEN LOOKING AT THE TRUCK WHICH TELLS ME THAT THEY ARE AWARE OF THE PROBLEM. JUST LIKE EVERYBODY ELSE HERE THAT THIS HAS HAPPENED TOO, WHEN I CHECK MY BRAKE FLUID, GO FIGURE IT WAS EMPTY EVEN THOUGH IT WAS SERVICED ABOUT A MONTH AGO. THE TRUCK HAS 32,000 MILES ON IT. FORD NEEDS TO DO SOMETHING ABOUT THIS. VERY, VERY DANGEROUS

NHTSA ODI #10783423

Mileage unknown · Oct 5, 2015
Service Brakes

RAPID LOSS OF BRAKE FLUID WHILE DRIVING RESULTING IN BRAKE FAILURE. WARNING LIGHT CAME ON. ADDING NEW FLUID RESULTED IN IMMEDIATE LOSS OF FLID.

NHTSA ODI #10779854

61,000 miles · Sep 25, 2015
Service Brakes

TRAVELLING AT 60 MPH ON INTERSTATE 5 SOUTH BOUND AT 0445 HRS I OBSERVED BRAKE LIGHTS APPROXIMATELY 1/4 MILE AHEAD. AS I APPLIED BRAKES THE PEDAL WAS SPONGY AND BRAKE FLUID WARNING LIGHT CAME ON. WHILE IN HEAVY TRAFFIC THE BRAKES FAILED. I WAS ABLE TO EXIT FREEWAY BY DOWN SHIFTING AND USING EMERGENCY BRAKE.I GOT TO A LOCAL RETAI…

Read full complaint

TRAVELLING AT 60 MPH ON INTERSTATE 5 SOUTH BOUND AT 0445 HRS I OBSERVED BRAKE LIGHTS APPROXIMATELY 1/4 MILE AHEAD. AS I APPLIED BRAKES THE PEDAL WAS SPONGY AND BRAKE FLUID WARNING LIGHT CAME ON. WHILE IN HEAVY TRAFFIC THE BRAKES FAILED. I WAS ABLE TO EXIT FREEWAY BY DOWN SHIFTING AND USING EMERGENCY BRAKE.I GOT TO A LOCAL RETAILER AND PURCHASED 1 12 OZ BOTTLES OF BRAKE FLUID AND PUT IT IN THE EMPTY RESERVOIR. AFTER PUMPING THE BRAKES I CHECKED THE FLUID LEVEL AND IT WAS EMPTY AGAIN. I PURCHASED 2 MORE 12 OZ BOTTLES AND ADDED THEM TO THE RESERVOIR. PUMPED THE BRAKES AND EVERYTHING SEEMED FINE. DECIDED TO GO HOME (SLOWLY) INSTEAD OF WORK. AFTER ABOUT 15 MILES THE BRAKE FLUID WARNING LIGHT COMES BACK ON. PULLED OVER AND BOUGHT TWO MORE 12 OZ BOTTLES TO PUT INTO MY NOW EMPTY RESERVOIR. DROVE 7 MILES TO MY HOME AND THE LOW WARNING COMES BACK ON. OPENED THE HOOD TO CHECK BRAKE FLUID LEVEL AND ONCE AGAIN IT IS EMPTY. LOOKED THROUGH ENGINE COMPARTMENT AND THE UNDERSIDE OF MY TRUCK AND THERE ARE NO VISIBLE FLUID LEAKS. THIS IS A HUGE PROBLEM TO LIFE AND LIMB. I SEE I'M NOT THE ONLY PERSON WITH THIS ISSUE YET NOTHING AS FAR AS I CAN TELL IS BEING DONE ABOUT IT. DOES SOMEONE HAVE TO BE INJURED OR KILLED? 60 OZ OF BRAKE FLUID JUST TO DRIVE 22 MILES SAFELY IS NOT REASONABLE BY ANY STRETCH OF THE IMAGINATION. FORTUNATELY MY WIFE OR ONE OF MY CHILDREN WEREN'T USING MY TRUCK WHEN THIS HAPPENED OR THE OUTCOME COULD HAVE BEEN VERY DIFFERENT. WAITING TO HEAR BACK FROM MY LOCAL DEALER.

NHTSA ODI #10776834

36,000 miles · Sep 8, 2015
Service Brakes

ON 8/26/15 DROVE TRUCK TO TOWN HAD NO PROBLEMS. PARKED TRUCK AT HOUSE, SHORT TIME LATER WENT TO LEAVE AND LOW BREAK FLUID LIGHT WAS ON, CHECK UNDER THE HOOD AND IT WAS UNDER THE MIN MARK FOUND NO LEAKS. I WENT TO THE STORE PURCHASED A BOTTLE OF BREAK FLUID. ON 9/6/15 SAME THING HAPPENED AGAIN, LIGHT CAME ON CHECKED AROUND RES…

Read full complaint

ON 8/26/15 DROVE TRUCK TO TOWN HAD NO PROBLEMS. PARKED TRUCK AT HOUSE, SHORT TIME LATER WENT TO LEAVE AND LOW BREAK FLUID LIGHT WAS ON, CHECK UNDER THE HOOD AND IT WAS UNDER THE MIN MARK FOUND NO LEAKS. I WENT TO THE STORE PURCHASED A BOTTLE OF BREAK FLUID. ON 9/6/15 SAME THING HAPPENED AGAIN, LIGHT CAME ON CHECKED AROUND RESERVOIR AND UNDER TRUCK AND CANNOT FIND A LEAK. WENT TO STORE PURCHASED ANOTHER BOTTLE. FOUND NUMEROUS COMPLAINTS ONLINE HERE AND OTHER SITES ABOUT NO BREAKS WITH NO FLUID IN RESERVOIR AND NO LEAKS FOUND. I HAVE CONTACTED FORD DIRECTLY ABOUT INSPECTING AND REPAIRING UNDER WARRANTY.

NHTSA ODI #10762049

32,000 miles · Aug 20, 2015
Service Brakes

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT STATED THAT THE LOW BRAKE FLUID LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE ATTEMPTING TO ENGAGE THE BRAKES, THE BRAKE PEDAL SANK TO THE FLOOR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER NEEDED TO BE REPLACED. …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT STATED THAT THE LOW BRAKE FLUID LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. WHILE ATTEMPTING TO ENGAGE THE BRAKES, THE BRAKE PEDAL SANK TO THE FLOOR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000.

NHTSA ODI #10750065

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of