← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Service Brakes complaints

320 reports
Clear category filter
44,700 miles · May 3, 2017
Service Brakes

BRAKES FAILED. WAS DRIVING TO WORK WHEN I NEED TO STOP FOR RED LIGHT AND PEDAL WENT TO THE FLOOR AND I ALMOST WENT THRU THE INTERSECTION ON HIGHWAY ROUTE 100. THIS WAS DO TO THE MASTER CYLINDER AND BRAKE BOOSTER FRAILER. I KNOW THERE IS A RECALL FOR THIS BUT MY MODEL AND VIN # IS NOT INCLUDED. IT HAS SINCE BEEN REPAIRED BY THE D…

Read full complaint

BRAKES FAILED. WAS DRIVING TO WORK WHEN I NEED TO STOP FOR RED LIGHT AND PEDAL WENT TO THE FLOOR AND I ALMOST WENT THRU THE INTERSECTION ON HIGHWAY ROUTE 100. THIS WAS DO TO THE MASTER CYLINDER AND BRAKE BOOSTER FRAILER. I KNOW THERE IS A RECALL FOR THIS BUT MY MODEL AND VIN # IS NOT INCLUDED. IT HAS SINCE BEEN REPAIRED BY THE DEALER AT A COST TO ME AND NOT UNDER ANY RECALL LIKE THE OTHER MODELS

NHTSA ODI #10983273

50,000 miles · Apr 24, 2017
EngineService BrakesUnknown Or Other

"TAKATA RECALL" MY FORD F150 TRUCK 2013 WAS PURCHASED IN 2014 BRAND NEW. IN 2017 JANUARY I HAD THE SPARKS PLUGS CHANGED AND NOW AGAIN IN APRIL 2017 MY MECHANIC HAS SAID THAT THE SPARKS PLUG NEEDS TO BE CHANGED. I BELIEVE AND GATHERING FROM WHAT MY MECHANICS IS SAYING THERE IS A PROBLEM WITH THE COIL? WHICH IS WHY THE SPARKS PLUG…

Read full complaint

"TAKATA RECALL" MY FORD F150 TRUCK 2013 WAS PURCHASED IN 2014 BRAND NEW. IN 2017 JANUARY I HAD THE SPARKS PLUGS CHANGED AND NOW AGAIN IN APRIL 2017 MY MECHANIC HAS SAID THAT THE SPARKS PLUG NEEDS TO BE CHANGED. I BELIEVE AND GATHERING FROM WHAT MY MECHANICS IS SAYING THERE IS A PROBLEM WITH THE COIL? WHICH IS WHY THE SPARKS PLUG IN BLACK FOR THE SECOND TIME. THIS ALL STARTED FROM A PROBLEM WITH THE BRAKES THE TRIED FLUSHING THE BREAKS AND SAME THING THAN THEY LOOKED INTO THE ENGINE AND CHANGED THE SPARKS PLUG (JAN) NOW IN APRIL SAME ISSUE. NEED HELP THIS IS COSTING ME MONEY.

NHTSA ODI #10980339

78,000 miles · Apr 3, 2017
Electrical SystemElectronic Stability Control (esc)Engine

WHILE DRIVING DOWN THE HIGHWAY, THE VEHICLE FLASHED SERVICE ADVANCE TRAC, DOWN HILL DESCENT CONTROL FAULT, TRAILER BRAKE MODULE FAIL AND A COUPLE MORE CODES. ALL ELECTONICS IN VEHICLE WENT BLANK, INCLUDING ALL CONTROLS/GAUGES. BEFORE DOING SO, LAST CODE READ, SHIFT TO PARK. ALMOST CAUSED ME TO HAVE AN ACCIDENT, BECAUSE THE POWER…

Read full complaint

WHILE DRIVING DOWN THE HIGHWAY, THE VEHICLE FLASHED SERVICE ADVANCE TRAC, DOWN HILL DESCENT CONTROL FAULT, TRAILER BRAKE MODULE FAIL AND A COUPLE MORE CODES. ALL ELECTONICS IN VEHICLE WENT BLANK, INCLUDING ALL CONTROLS/GAUGES. BEFORE DOING SO, LAST CODE READ, SHIFT TO PARK. ALMOST CAUSED ME TO HAVE AN ACCIDENT, BECAUSE THE POWER STEERING WENT OUT AND NEARLY PULLED ME INTO ANOTHER VEHICLE. THE ACCELERATION IS BAD TOO, FEELS LIKE IT IS NOT FIRING ALL CYLINDERS AGAIN. HAVE ALREADY TAKEN IN FOR A NUMBER OF ISSUES, INCLUDING CRANKSHAFT SENSOR ISSUES(WAS LOSING POWER TO DRIVELINE); BRAKES LOCKING UP (HAVE REPLACED THE ROTORS AND PADS SIX TIMES AND LAST TIME I REPLACED BOTH CALIBERS AS WELL; POWER STEERING HAS BEEN REPLACED ONCE BEFORE, FRONT AXLES AND BEARINGS REPLACED. AS WELL AS, AC PROBLEMS. WHEN THE FIRST ISSUES AROSE, I WAS TOLD BY SERVICE TECH AT DEALERSHIP I NEEDED A NEW ENGINE, (LATER HE COMPLETELY DENIED TELLING ME THIS) INSTEAD THEY FIXED SOME THINGS AND GAVE IT BACK TO ME. PROBLEMS HAVE CONTINUED SINCE, LIKE I SAID HAVE TAKEN IT IN AT LEAST 6 TIMES TO A DEALER AND ONCE TO AN INDEPENDENT MECHANIC. AT FIRST THE PROBLEMS WERE COVERED BY WARRENTY, NOW THEY ARE NOT, THERE IS ONLY 78,000MILES ON THE TRUCK AND HAS BEEN IN SHOP AT LEAST 6 TIMES AND IS ONLY 4 YRS OLD. NOT SURE WHAT TO DO, AS THE PROBLEMS RESEMBLE RECALL ISSUES, BUT DEALERSHIP SAYS THEY AREN'T PART OF ANY RECALLS. CONCERNED FOR MY SAFETY ON THE ROAD.

NHTSA ODI #10970131

52,000 miles · Apr 1, 2017
Service Brakes

THE RIGHT FRONT BREAK KEEPS OVER HEATING EVEN AFTER REPEATED REPLACEMENT OF CALIPERS ROTORS AND PADS. THE SYSTEM LOCKED UP AND CAUSED HEAT DAMAGE TO THE FLEXIBLE LINE CONNECTING THE METAL LINE TO CALIPER AND ALL BREAK COMPONENTS. THIS OCURRED LESS THAN 5000 MILES AFTER COMPLETE BREAK REPLACEMENT ON ALL TIRES. THE MECHANIC STATE…

Read full complaint

THE RIGHT FRONT BREAK KEEPS OVER HEATING EVEN AFTER REPEATED REPLACEMENT OF CALIPERS ROTORS AND PADS. THE SYSTEM LOCKED UP AND CAUSED HEAT DAMAGE TO THE FLEXIBLE LINE CONNECTING THE METAL LINE TO CALIPER AND ALL BREAK COMPONENTS. THIS OCURRED LESS THAN 5000 MILES AFTER COMPLETE BREAK REPLACEMENT ON ALL TIRES. THE MECHANIC STATED THAT THE DRIVER FRONT STILL HAD 99% OF ITS PAD. AFTER REPLACING ALL COMPONENTS IT DID IT AGAIN IN LESS THAN 100 MILES. THE SHOP REPLACED THE CALIPER AND PADS SAYING THAT IT MUST HAVE BEEN A BAD CALIPER BUT NEW ONE ALREADY TO HOT TO TOUCH AFTER ONLY 50 MILES. THEIR \MUST BE A PRESSURE PROBLEM AS THE DRIVER SIDE IS COOL TO THE TOUCH AND PASSENGER SIDE YOU CAN FEEL THE HEAT AT HOOD LEVEL. THE TRUCK WAS MADE 2-13 DEARBORN PLANT. I HAVE NOTICED A EXCESSIVE WEAR ON THIS SIDE OF THE VEHICLE SINCE I HAVE OWNER IT. BOUGHT IT NEW. PROBLEM OCCURRED ON THE HIGHWAY

NHTSA ODI #10969886

102,000 miles · Feb 9, 2017
Service Brakes

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHEN THE BRAKE PEDAL WAS DEPRESSED, THE BRAKES FAILED TO RESPOND. THE FAILURE OCCURRED INTERMITTENCY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000.

NHTSA ODI #10950458

53,000 miles · Feb 5, 2017
Service BrakesCrash

PROBLEM WITH MASTER CYLINDER POWER BOOSTER PUMP, VEHICLE FAILS TO STOP WHILE MOVING AT SHORT DISTANCE AND LOW SPEED 15 MILES OR LESS HIGHWY AND CITY. VEHICLE STOPS WHILE MOVING AT LONG DISTANCE AND HIGH SPEED 15 MILES OR MORE HIGHWAY AND CITY. BRAKE PEDALS VIBRATE AND GO TO BOTTOM AT LOW SPEEDS 15 MILES OR LESS HIGHWAY AND…

Read full complaint

PROBLEM WITH MASTER CYLINDER POWER BOOSTER PUMP, VEHICLE FAILS TO STOP WHILE MOVING AT SHORT DISTANCE AND LOW SPEED 15 MILES OR LESS HIGHWY AND CITY. VEHICLE STOPS WHILE MOVING AT LONG DISTANCE AND HIGH SPEED 15 MILES OR MORE HIGHWAY AND CITY. BRAKE PEDALS VIBRATE AND GO TO BOTTOM AT LOW SPEEDS 15 MILES OR LESS HIGHWAY AND CITY.

NHTSA ODI #10949678

Mileage unknown · Jan 16, 2017
Service Brakes

1ST OCCURRENCE I WAS DRIVING IN TOWN, MODERATE TRAFFIC AND I DEPRESSED THE BRAKE PEDAL AND IT WAS ROCK SOLID AND I COULD BARELY SLOW THE VEHICLE WITH BOTH FEET PRESSING AS HARD AS I COULD AND THE BRAKE WARNING LIGHTS CAME ON. I TURNED THE VEHICLE OFF THEN WHEN I RESTARTED SEVERAL MINUTES LATER, THE ISSUE WENT AWAY. A COUPLE OF D…

Read full complaint

1ST OCCURRENCE I WAS DRIVING IN TOWN, MODERATE TRAFFIC AND I DEPRESSED THE BRAKE PEDAL AND IT WAS ROCK SOLID AND I COULD BARELY SLOW THE VEHICLE WITH BOTH FEET PRESSING AS HARD AS I COULD AND THE BRAKE WARNING LIGHTS CAME ON. I TURNED THE VEHICLE OFF THEN WHEN I RESTARTED SEVERAL MINUTES LATER, THE ISSUE WENT AWAY. A COUPLE OF DAYS LATER, I RECEIVED THE BRAKE BOOSTER RECALL NOTICE AND TOOK THE VEHICLE IN FOR REPAIR AT THE LOCAL DEALER. A COUPLE OF WEEKS AFTER THE BOOSTER RECALL REPAIR I HAD THE SAME ISSUE ON A RURAL ROAD NEARLY CAUSING AN ACCIDENT. I TOOK THE TRUCK TO THE DEALER IMMEDIATELY WITH ALL OF THE WARNING LIGHT ILLUMINATED AND ISSUE STILL OCCURRING. THE FORD DEALER SAID IT NEEDED THE VACUUM PUMP REPLACED SO I TOLD THEM TO GO AHEAD, THEY CHARGED APPROXIMATELY $360 FOR THE REPAIR. YESTERDAY, AFTER TURNING OFF OF A RURAL ROAD TO A MORE DEVELOPED SHOPPING AREA, I LOST BRAKING FUNCTION WITH THE SAME SYMPTOMS AS PREVIOUSLY DESCRIBED AT A TRAFFIC LIGHT AND HAD TO USE THE PARKING BRAKE TO DECELERATE. I AGAIN PARKED THE VEHICLE, TURNED OFF THE IGNITION AND AFTER ABOUT 30 MINUTES, THE BRAKES WERE WORKING AGAIN.I HAVE MADE AN APPOINTMENT WITH THE DEALER TO HAVE THIS DIAGNOSED AGAIN IN 2 DAYS. THANK GOODNESS MY THIS HASN'T OCCURRED WHILE TOWING MY BOAT. THE ISSUE HAS OCCURRED IN BOTH CITY AND HIGHWAY DRIVING AND ALWAYS WHILE THE VEHICLE IS IN MOTION. ONLY ONCE DID THE BRAKE WARNING LIGHTS COME ON BEFORE LOSS OF BRAKING. THE ISSUE DID NOT OCCUR WHILE TURNING. *TR

NHTSA ODI #10945490

80,000 miles · Nov 30, 2016
Service Brakes

DRIVER SIDE BRAKE PADS WERE INSTALLED BACKWARDS CAUSING INCORRECT WEAR

NHTSA ODI #10928844

50,000 miles · Nov 28, 2016
Service Brakes

TWO DAYS AFTER PURCHASING THIS TWO YEAR OLD USED LIMITED EDITION F150 THE POWER BRAKE ASSIST FAILED; WEATHER CONDITION WAS RAIN. RETURNED IT TO DEALERSHIP WHO DID NOTHING AS THEY COULD NOT DUPLICATE THE PROBLEM. THIS HAS HAPPENED SEVERAL TIMES SINCE PURCHASING THE TRUCK, AND REPORTED TO THE DEALERSHIP, AND IS A MAJOR CONCERN T…

Read full complaint

TWO DAYS AFTER PURCHASING THIS TWO YEAR OLD USED LIMITED EDITION F150 THE POWER BRAKE ASSIST FAILED; WEATHER CONDITION WAS RAIN. RETURNED IT TO DEALERSHIP WHO DID NOTHING AS THEY COULD NOT DUPLICATE THE PROBLEM. THIS HAS HAPPENED SEVERAL TIMES SINCE PURCHASING THE TRUCK, AND REPORTED TO THE DEALERSHIP, AND IS A MAJOR CONCERN TO ME AS I TOW A 26' TRAVEL TRAILER WITH IT. RATE OF SPEED WHEN APPLYING BRAKES WAS @15MPH OR LESS, AND EACH TIME THE ROADS WERE WET. CALLED FORD TODAY AND ESTABLISHED CASE # CAS-11141043 FOR THIS REPEAT CONDITION AFTER DEALERSHIP SAID THERE WERE NO RECALLS OR TSBS AND THAT IT WAS UNCERTAIN IF IT'S UNDER WARRANTY. TODAY WAS THE MOST RECENT INCIDENT AND THE TRUCK IS BACK AT THE DEALERSHIP NOW.

NHTSA ODI #10928311

96,000 miles · Nov 21, 2016
Service Brakes

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 30 MPH, THE BRAKES FAILED AND THERE WAS NO PEDAL MOVEMENT AT ALL. THE CONTACT HAD TO SHIFT THE VEHICLE INTO MANUAL IN ORDER TO SLOW DOWN. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS TAKEN TO A LOCAL DEALER, BUT THE DIAGNOSIS WAS UNKN…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 30 MPH, THE BRAKES FAILED AND THERE WAS NO PEDAL MOVEMENT AT ALL. THE CONTACT HAD TO SHIFT THE VEHICLE INTO MANUAL IN ORDER TO SLOW DOWN. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS TAKEN TO A LOCAL DEALER, BUT THE DIAGNOSIS WAS UNKNOWN. THE FAILURE MILEAGE WAS 96,000.

NHTSA ODI #10927180

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of