IllustrationTHE FRONT END STARTED VIBRATING, NO WARNING LIGHTS CAME ON. I DROVE ANOTHER 2 MILES STRAIGHT TO THE ADVANTAGE FORD IN STUART FL. THEY INFORMED ME THAT THE ENTIRE BRAKE SYSTEM WAS BROKEN, MY WORDS NOT THEIRS.
2013 Ford F-150
Owner reports · Recalls · Investigations
More warning signs than most F-150 years
Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
3300–25K
32125–50K
46250–75K
39775–100K
454100–150K
251150K+
2,215 reports with mileage · 765 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
77 crash reports35 fire reports53 injury reports
Service Brakes complaints
320 reportsWHILE STOPPED, WITH MY FOOT ON THE BRAKE, IN A PARKING LOT WAITING FOR TRAFFIC TO CLEAR SO I COULD ENTER THE STREET THERE WAS A RATHER LOUD POP SUCH AS A BLOON BURSTING. THE BRAKE PEDDLE BECAME EXTREMELY RIDGED AND THE VEHICLE BEGAN MOVING FORWARD. IT NEARLY CAUSED ME TO CRASH INTO THE CARS AHEAD OF ME. I HAVE BEEN A VEHICLE SER…
Read full complaint
WHILE STOPPED, WITH MY FOOT ON THE BRAKE, IN A PARKING LOT WAITING FOR TRAFFIC TO CLEAR SO I COULD ENTER THE STREET THERE WAS A RATHER LOUD POP SUCH AS A BLOON BURSTING. THE BRAKE PEDDLE BECAME EXTREMELY RIDGED AND THE VEHICLE BEGAN MOVING FORWARD. IT NEARLY CAUSED ME TO CRASH INTO THE CARS AHEAD OF ME. I HAVE BEEN A VEHICLE SERVICE TECHNICIAN FOR NEAR 45 YEARS SO I WAS KEENLY AWARE OF WHAT HAD HAPPENED. I PUSHED THE BRAKE PEDDLE WITH BOTH MY FEET AND MANAGED TO STOP IT. I CONTACTED THE FORD DEALERSHIP SAID THEY COULDN'T REPAIR MY VEHICLE BECAUSE OF ITS MANUFACTURE DATE. I REMOVED THE DEFECTIVE PART AND IT WAS JUST AS THE RECALL ON THE MASTER BRAKE CYLINDER STATED. THE PROBLEM EFFECTS MORE 2013 VEHICLES THAN IS COVERED BY THE RECALL. I HAVE ATTACHED A PHOTO SHOWING THE BRAKE FLUID IN MY FAILED BRAKE BOOSTER AS PROOF.
THE BRAKE MASTER CYLINDER WENT OUT WHILE I WAS DRIVING AND I NEARLY HIT THE CAR IN FRONT OF ME. WHEN I TOOK THE TRUCK INTO THE SHOP, I WAS TOLD THAT THE MASTER CYLINDER HAD A LEAK AND WOULD NOT CONSISTENTLY HOLD PRESSURE SO IT HAD TO BE REPLACED. AFTER DOING SOME RESEARCH, I FOUND A RECALL BY FORD WITH RECALL ID 16S24 FOR THIS E…
Read full complaint
THE BRAKE MASTER CYLINDER WENT OUT WHILE I WAS DRIVING AND I NEARLY HIT THE CAR IN FRONT OF ME. WHEN I TOOK THE TRUCK INTO THE SHOP, I WAS TOLD THAT THE MASTER CYLINDER HAD A LEAK AND WOULD NOT CONSISTENTLY HOLD PRESSURE SO IT HAD TO BE REPLACED. AFTER DOING SOME RESEARCH, I FOUND A RECALL BY FORD WITH RECALL ID 16S24 FOR THIS EXACT SAME PROBLEM AND WHEN I WAS TOLD WHAT NEEDED REPLACED, IT WAS ALMOST WORD FOR WORD WHAT THIS RECALL STATED. I FOUND THIS INFORMATION AFTER I HAD ALREADY GOTTEN THE MASTER CYLINDER REPLACED SO I CALLED FORD TO SPEAK WITH THEIR RECALL DEPARTMENT. I WAS TOLD THAT THIS ISSUE WAS NOT COVERED BY THE RECALL BECAUSE MY TRUCK WAS MANUFACTURED AFTER THE DATE OF WHAT WAS DEFINED IN THE RECALL. IT SEEMS TO ME THAT A TRUCK BUILT IN THE SAME YEAR THAT HAD MASTER CYLINDERS AFFECTED WOULD BE COVERED BY THE RECALL. THIS REPAIR COST $663.57. LOSING BRAKE PRESSURE COULD HAVE CAUSED SERIOUS INJURY HAD I BEEN ON THE HIGHWAY OR NEEDING TO COME TO AN ABRUPT STOP. A PICTURE OF THE REPAIR INVOICE IS ATTACHED BUT A BETTER COPY CAN BE PROVIDED UPON REQUEST.
TL* THE CONTACT OWNED A 2013 FORD F-150. THE CONTACT STATED WHEN HER HUSBAND WAS DRIVING THE VEHICLE AT APPROXIMATELY 70 MPH, THE VEHICLE GAUGES AND RPMS UNEXPECTEDLY WENT INTO A LOWER GEAR. THE STEERING WHEEL THEN CEASED AND THE VEHICLE WAS UNABLE TO BE CONTROLLED, ALONG WITH THE BRAKE PEDAL FAILED TO OPERATE WHILE SHUTTERING A…
Read full complaint
TL* THE CONTACT OWNED A 2013 FORD F-150. THE CONTACT STATED WHEN HER HUSBAND WAS DRIVING THE VEHICLE AT APPROXIMATELY 70 MPH, THE VEHICLE GAUGES AND RPMS UNEXPECTEDLY WENT INTO A LOWER GEAR. THE STEERING WHEEL THEN CEASED AND THE VEHICLE WAS UNABLE TO BE CONTROLLED, ALONG WITH THE BRAKE PEDAL FAILED TO OPERATE WHILE SHUTTERING AND THE LASTLY THE VEHICLE CRASHED INTO A WALL. THE SIDE AIRBAGS DID DEPLOY BUT THE FRONTAL AIRBAGS DID NOT. THE VEHICLE WAS TOWED TO A IMPOUND LOT AFTER BEING TOTALED. A POLICE REPORT WAS TAKEN. THE CONTACTS SPOUSE WAS THE ONLY PERSON INJURED IN THE CRASH. THE HUSBAND SUSTAINED A BACK INJURY, NUMBNESS, TINGLING IN HIS LEGS, AND A CONCUSSION. THE SPOUSE WAS TAKEN TO THE EMERGENCY ROOM FOR HIS INJURIES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
BRAKES FAILED WHILE DRIVING ON THE INTERSTATE.DIAGNOSED AS BAD MASTER CYLINDER AND BRAKE BOOSTER.
2013 FORD F-150 PLATINUM TRUCK. I GOT IN MY TRUCK AND PULLED OUT OF A PARKING LOT. I WAS ABOUT TO TURN AND GET ON THE INTERSTATE. A CAR WAS IN FRONT OF ME AND WHEN I MASHED THE BRAKES THE PETAL WAS STIFF. THERE WAS A NOISE COMING FROM THE BRAKES. IT SEEMED. I WAS ABLE TO MOVE TO THE SIDE OF THE RODE BEFORE STRIKING THE REAR OF T…
Read full complaint
2013 FORD F-150 PLATINUM TRUCK. I GOT IN MY TRUCK AND PULLED OUT OF A PARKING LOT. I WAS ABOUT TO TURN AND GET ON THE INTERSTATE. A CAR WAS IN FRONT OF ME AND WHEN I MASHED THE BRAKES THE PETAL WAS STIFF. THERE WAS A NOISE COMING FROM THE BRAKES. IT SEEMED. I WAS ABLE TO MOVE TO THE SIDE OF THE RODE BEFORE STRIKING THE REAR OF THE CAR AND COME TO A STOP. I THEN PROCEEDED SLOWLY TO AN EMPTY PARKING LOT. I GOT OUT AND WALKED AROUND THE VEHICLE AND LOOKED UNDER THE HOOD. NO LEAKS THAT I COULD SEE AND THE BRAKE RESERVOIR WAS FULL. I DROVE AROUND THE PARKING LOT AND MASHED THE BRAKES SEVERAL TIME AND THEN IT WENT BACK TO WORKING. THIS HAS BEEN HAPPENING ON SEVERAL OCCASIONS. I SEE A RECALL BUT IT IS NOT FOR MY VIN. WHY? THIS IS A VERY SERIOUS SAFETY HAZARD SO WHY IS FORD NOT TAKING THIS SERIOUS. I HAVE BEEN IN THE FIRE SERVICE FOR 31 YEARS AND HAVE SEEN THE OUTCOME OF BRAKE FAILURE. THIS IS NOT GOOD.
TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 60 MPH ON THE HIGHWAY, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT WAS ABLE TO PULL OFF THE HIGHWAY AND DOWNSHIFT TO AN EVENTUAL ROLLING STOP. THE CONTACT RESTARTED THE VEHICLE AND PUMPED THE BRAKES PEDAL. THE BRAKE PEDAL EVENTUALLY STARTED TO LOOSEN UP …
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 60 MPH ON THE HIGHWAY, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT WAS ABLE TO PULL OFF THE HIGHWAY AND DOWNSHIFT TO AN EVENTUAL ROLLING STOP. THE CONTACT RESTARTED THE VEHICLE AND PUMPED THE BRAKES PEDAL. THE BRAKE PEDAL EVENTUALLY STARTED TO LOOSEN UP AND THE BRAKES WORKED NORMALLY. BENNA FORD SUPERIOR (3022 TOWER AVE, SUPERIOR, WI 54880, (715) 394-8669) STATED THAT THERE WERE NO RECALLS AND REFERRED THE CONTACT TO THE MANUFACTURER. THE MANUFACTURER PROVIDED A CASE NUMBER AND SCHEDULED AN APPOINTMENT WITH THE SAME DEALER FOR DIAGNOSTIC TESTING. THE CONTACT CHECKED WITH AN INDEDENDENT MECHANIC AND WAS INFORMED THAT THE BRAKE BOOSTER COULD BE THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,600.
I WAS DRIVING DOWN THE HIGHWAY AT 60 MPH A CAR PULL OVER INTO LANE IN FRONT OF ME? I STEPPED ON THE BRAKES AND THEY WERE AS HARD AS A ROCK, LUCKILY I STEERED TO THE AIDE OF THE HIGHWAY AND DOWN SHIFTED TILL THE TRUCK CAME TO A ROLLING STOP, THE BRAKE AND THE PARKING BRAKE LIGHT ARE ON AND THE BRAKES WERE STILL AS HARD AS A ROCK…
Read full complaint
I WAS DRIVING DOWN THE HIGHWAY AT 60 MPH A CAR PULL OVER INTO LANE IN FRONT OF ME? I STEPPED ON THE BRAKES AND THEY WERE AS HARD AS A ROCK, LUCKILY I STEERED TO THE AIDE OF THE HIGHWAY AND DOWN SHIFTED TILL THE TRUCK CAME TO A ROLLING STOP, THE BRAKE AND THE PARKING BRAKE LIGHT ARE ON AND THE BRAKES WERE STILL AS HARD AS A ROCK , I TRIED SHUTTING THE TRUCK OFF AND RESTARTING, AND STILL THE SAME RESULT, I PUT THE TRUCK IN DRIVE AFTER AWHILE AND KEPT MESSING WITH IT PUSHING AS HARD AS COULD ON THE BRAKE PEDAL AND I GOT A LITTLE BIT OF BRAKES , AFTER DRIVING A FEW MILES THEY STARTED WORKING AGAIN, NOW I'M AFRAID WAITING WONDERING IF IT'S NOT GONNA WORK AGAIN, IT'S DANGEROUS, IT'S MY MAIN VEHICLE AND MOST OF MY FAMILY RANDOMLY USES IT. I'VE HAD A LOT OF PROBLEMS WITH THIS TRUCK.
EXTREMELY HARD BRAKE PEDAL, VEHICLE WILL NOT STOP EASILY IN NORMAL BRAKING CONDITIONS, IF PEDAL IS PUMPED REPEATEDLY RED BRAKE LIGHT AND CHECK BRAKE SYSTEM WARNING APPEAR. IF KEY IS CYCLED ON THEN OFF WARNINGS GO AWAY BUT BRAKE PEDAL FEELS THE SAME. AFTER EXTENSIVE RESEARCH I FOUND VACUUM PUMP (NON ELECTRIC) LEAKING OIL. I REPLA…
Read full complaint
EXTREMELY HARD BRAKE PEDAL, VEHICLE WILL NOT STOP EASILY IN NORMAL BRAKING CONDITIONS, IF PEDAL IS PUMPED REPEATEDLY RED BRAKE LIGHT AND CHECK BRAKE SYSTEM WARNING APPEAR. IF KEY IS CYCLED ON THEN OFF WARNINGS GO AWAY BUT BRAKE PEDAL FEELS THE SAME. AFTER EXTENSIVE RESEARCH I FOUND VACUUM PUMP (NON ELECTRIC) LEAKING OIL. I REPLACED IT AND THE SAME ISSUES STILL HAPPEN. I'VE FOUND 2 RECALLS THAT DON'T APPLY TO MY TRUCK. ONE RECALL STATES THE MASTER CYLINDER SEAL IS LEAKING WHICH CAUSES THE BRAKE PEDAL TO GO TO THE TO FLOOR. THE OTHER IS A STIFF PEDAL BUT THAT ONE WAS FOR AN ELECTRIC VACUUM PUMP ISSUE. PLEASE HELP BEFORE FORD KILLS ME. ALSO. I ASKED MY LOCAL DEALERSHIP (BELL FORD) FOR TSBS REGARDING THIS AND WAS DENIED THE INFORMATION. THIS SHOULD BE CLASSIFIED AS A SAFETY RECALL THAT NEVER EVER EXPIRES!!!!!!!!!
TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING, THE BRAKES SEIZED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKE PADS AND ROTORS WERE REPLACED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE PISTON, ROTORS, BRAKE LINE, BRAKE PADS, AND BRAKE …
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING, THE BRAKES SEIZED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKE PADS AND ROTORS WERE REPLACED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC WHERE THE PISTON, ROTORS, BRAKE LINE, BRAKE PADS, AND BRAKE FLUID WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO BIG COUNTRY FORD LINCOLN (500 W COMMERCE ST, BROWNWOOD, TX 76801, (325) 643-1651), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 94,000.
Official recalls
319V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.
19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Feb 11, 2019
Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.
Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.
16V345000 · Service Brakes, Hydraulic:fluid
May 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.
Consequence & remedy
Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ17010 · Unexpected Transmission Downshift
Opened Dec 25, 2017 · Closed Oct 22, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
PE16003 · Master Cylinder External Leak
Opened Feb 29, 2016 · Closed Jul 26, 2016
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Additional source detail variants (4)
Service Brakes
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:fluid
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
Service Brakes, Hydraulic:foundation Components:master Cylinder
On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107
PE13018 · Reduced Power During Hard Acceleration
Opened May 22, 2013 · Closed Apr 7, 2014
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling
On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of
Additional source detail variants (2)
Engine And Engine Cooling
On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of
Engine
On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of