← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
62,000 miles · Jan 29, 2019
Power Train

WHILE DRIVING AT A SPEED OF 60MPH ON THE FREEWAY, THE TRANSMISSION SLIPPED OUT OF GEAR AND REVVED VERY HIGH. LEAVING ME STRANDED IN THE MIDDLE OF THE FREEWAY. ALL OF A SUDDEN THE TRUCK WENT BACK INTO GEAR, ALMOST CAUSING ME TO GET REAR-ENDED. THIS HAPPENED TWO OTHER TIMES WHILE DRIVING. ANOTHER TIME WHILE DRIVING, ALL THE GAUGES…

Read full complaint

WHILE DRIVING AT A SPEED OF 60MPH ON THE FREEWAY, THE TRANSMISSION SLIPPED OUT OF GEAR AND REVVED VERY HIGH. LEAVING ME STRANDED IN THE MIDDLE OF THE FREEWAY. ALL OF A SUDDEN THE TRUCK WENT BACK INTO GEAR, ALMOST CAUSING ME TO GET REAR-ENDED. THIS HAPPENED TWO OTHER TIMES WHILE DRIVING. ANOTHER TIME WHILE DRIVING, ALL THE GAUGES WENT BLANK. I COULD NOT SEE MY SPEED OR ANY OTHER INDICATOR. AFTER PULLING OVER, I TURNED MY TRUCK OFF AND RESTARTED IT WITH NO ISSUES. I NOW HAVE MY TRUCK IN THE SHOP, AND THE LIST OF ISSUES KEEPS GROWING. I ONLY HAVE 62,000 MILES AND ALREADY SEEING SOME MAJOR ISSUES.

NHTSA ODI #11172767

87,000 miles · Jan 29, 2019
Power Train

WHILE IN MOTION ON THE HIGHWAY AND CITY STREETS THE TRANSMISSION DOWNSHIFTS FROM HIGH GEAR TO LOW GEAR. THIS CAUSES THE VEHICLE TO DRAMATICALLY DECELERATE AND OVER REV THE MOTOR. A CODE DOES NOT APPEAR WHEN THE EVENT HAPPENS. OCCASIONALLY A CODE APPEARS THAT LOOKS LIKE A WRENCH. WHEN THIS CODE APPEARS THE SPEEDOMETER QUITS WORKI…

Read full complaint

WHILE IN MOTION ON THE HIGHWAY AND CITY STREETS THE TRANSMISSION DOWNSHIFTS FROM HIGH GEAR TO LOW GEAR. THIS CAUSES THE VEHICLE TO DRAMATICALLY DECELERATE AND OVER REV THE MOTOR. A CODE DOES NOT APPEAR WHEN THE EVENT HAPPENS. OCCASIONALLY A CODE APPEARS THAT LOOKS LIKE A WRENCH. WHEN THIS CODE APPEARS THE SPEEDOMETER QUITS WORKING. THE CODE WILL NOT STAY ON LONG ENOUGH TO HAVE IT CHECKED OUT.. I HAVE TAKEN IT TO THE SERVICE DEPARTMENT. THEY HAVE DONE A BUMP START AND CHANGED TRANSMISSION FLUID / FILTERS. IT WAS GOOD FOR A MONTH THEN STARTED AGAIN.

NHTSA ODI #11172716

93,596 miles · Jan 28, 2019
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 50 MPH, THE VEHICLE SHIFTED INTO FIRST GEAR ON ITS OWN, THE BRAKES SEIZED, AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO FOUR SEASONS FORD (601 DUNCAN HILL RD, HENDERSONVILLE, NC 28792, 828-693-4281) WHERE IT WAS DIAGNOSED THAT THE OUTPUT SPEED …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 50 MPH, THE VEHICLE SHIFTED INTO FIRST GEAR ON ITS OWN, THE BRAKES SEIZED, AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO FOUR SEASONS FORD (601 DUNCAN HILL RD, HENDERSONVILLE, NC 28792, 828-693-4281) WHERE IT WAS DIAGNOSED THAT THE OUTPUT SPEED SENSOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 93,596. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11172662

87,000 miles · Jan 28, 2019
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE TRANSMISSION ERRONEOUSLY DOWNSHIFTED INTO THIRD GEAR, WHICH CAUSED THE SPEED TO DECREASE. AFTER THE FAILURE OCCURRED, THE TRANSMISSION ONLY SHIFTED INTO FIFTH GEAR AND THE VEHICLE WOULD ONLY ACCELERATE FROM A STAND…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE TRANSMISSION ERRONEOUSLY DOWNSHIFTED INTO THIRD GEAR, WHICH CAUSED THE SPEED TO DECREASE. AFTER THE FAILURE OCCURRED, THE TRANSMISSION ONLY SHIFTED INTO FIFTH GEAR AND THE VEHICLE WOULD ONLY ACCELERATE FROM A STANDING START IN THIRD GEAR. AS A RESULT, THE VEHICLE WOULD STALL AND THE SPEEDOMETER WOULD NOT OPERATE. AFTER RESTARTING THE ENGINE, THE VEHICLE OPERATED NORMALLY. BUBBA OUSALET FORD LINCOLN (246 N. BROADWAY ST, JENNINGS, LA) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 87,000. *TT CONSUMER STATED LEAD FRAME WAS REPLACED IT WAS RECALLED IN 2011,2012, 2013.*JB

NHTSA ODI #11172623

96,000 miles · Jan 28, 2019
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE CONTACT STATED THAT THIS WAS THE THIRD TIME THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO PARKWAY FORD LINCOLN (311 COMMERCIAL PKWY, DOVER, OH 44622) WHERE IT WAS DIAGNOSED THAT THE MOLDED LEAD FRAME FAILED AND NEEDED REPLACEMENT.…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE CONTACT STATED THAT THIS WAS THE THIRD TIME THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO PARKWAY FORD LINCOLN (311 COMMERCIAL PKWY, DOVER, OH 44622) WHERE IT WAS DIAGNOSED THAT THE MOLDED LEAD FRAME FAILED AND NEEDED REPLACEMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

NHTSA ODI #11172476

103,000 miles · Jan 24, 2019
Power Train

OUTPUT SPEED SENSOR FAILURE CAUSING TRANSMISSION TO GET STUCK IN GEAR. OCCASIONALLY IT WILL SHIFT DOWN IN GEAR AS YOU ARE ACCELERATING CAUSING A STALLING EFFECT TO THE TRUCK. HAS HAPPENED SEVERAL TIMES TO MY YOUNG SON WHILE DRIVING ON THE HIGHWAY AT FULL SPEED. SPEEDOMOTER WILL ALSO GO COMPLETELY DEAD. USUALLY PULLING OVER CUTTI…

Read full complaint

OUTPUT SPEED SENSOR FAILURE CAUSING TRANSMISSION TO GET STUCK IN GEAR. OCCASIONALLY IT WILL SHIFT DOWN IN GEAR AS YOU ARE ACCELERATING CAUSING A STALLING EFFECT TO THE TRUCK. HAS HAPPENED SEVERAL TIMES TO MY YOUNG SON WHILE DRIVING ON THE HIGHWAY AT FULL SPEED. SPEEDOMOTER WILL ALSO GO COMPLETELY DEAD. USUALLY PULLING OVER CUTTING OFF THE TRUCK, WAITING AND RESTARTING WILL TAKE IT OUT OF THE 5TH OR 1ST GEAR IT IS STUCK IN. SOMETIMES THIS TAKES SEVERAL TRIES. VERY UNSAFE ON THE SIDE OF A BUSY ROAD! HAD 2 TRANSMISSION SHOPS RUN DIAGNOSTICS AND IT IS THE FAULTY SPEED SENSOR REQUIRING ENTIRE LEAD FRAME TO BE REPLACED. BOTH SHOPS TOLD ME TO REACH OUT TO FORD BEFORE I PAY TO HAVE IT REPAIRED WITH THEM. SAME PROBLEM AS PREVIOUS FORD TRUCK MODELS '11 AND '12 THAT FORD HAS RECALLED BUT FORD WILL TAKE NO LIABILITY FOR THIS MALFUNCTION. CALLED 2 FORD DEALERSHIPS THAT BOTH PLAYED DUMB TO THE WELL DOCUMENTED PROBLEM. CALLED FORD ITSELF AND SPOKE TO A CSR I PRESUME IN ANOTHER COUNTRY FROM THE BROKEN ENGLISH THAT SAID ONLY THERE IS NO RECALL...ABSOLUTELY NO HELP OR INFORMATION FROM FORD. I AM HAVING THIS REPAIRED ON MY OWN DIME AS IT IS THREATENING THE LIFE OF MY SON AND EVERYONE ELSE ON THE ROAD. SHAME ON FORD!

NHTSA ODI #11171909

99,860 miles · Jan 24, 2019
Power Train

WE WERE DRIVING AT 60 MPH AND ALL OF A SUDDEN IT DOWN SHIFTED INTO FIRST GEAR EXPECTANTLY LOCKING UP THE REAR TIRES AND ALMOST CAUSING US TO CRASH. TURNED THE TRUCK OFF THEN BACK ON AND IT TOOK ME TO WORK. LATER THAT DAY WENT TO LUNCH AND THE TRANSMISSION WILL SLIP AND NOT GO ANYWHERE, TURN IT OFF THEN BACK ON AND IT WILL GO AGA…

Read full complaint

WE WERE DRIVING AT 60 MPH AND ALL OF A SUDDEN IT DOWN SHIFTED INTO FIRST GEAR EXPECTANTLY LOCKING UP THE REAR TIRES AND ALMOST CAUSING US TO CRASH. TURNED THE TRUCK OFF THEN BACK ON AND IT TOOK ME TO WORK. LATER THAT DAY WENT TO LUNCH AND THE TRANSMISSION WILL SLIP AND NOT GO ANYWHERE, TURN IT OFF THEN BACK ON AND IT WILL GO AGAIN NOT FAR, BUT WILL GO AND HAS NO POWER THE DASH GOES DEAD THE SPEEDOMETER GOES TO JUST ------------- THIS A HUGE WRENCH COMES UP ON THE DASH. TOOK IT TO FORD AND THE SAY THE TRANS IS BROKEN. I NOTICE MANY OTHER FORDS ARE RECALLED FOR THIS .. PLEASE EXPAND THIS TO THE 13 YEAR MODEL AS I CANT AFFORD 4,000$ WHEN THE RECKER CAME TO GET IT, HE DROVE IT UP ONTO THE FLATBED, HE PUT IT IN PARK AND PROCEEDED TO GET OUT AND IT ROLLED DOWN THE RECKER (IN PARK) PLEASE HELP, SOMEBODY'S GONNA DIE SOON!!

NHTSA ODI #11171834

80,000 miles · Jan 24, 2019
Power Train

WHEN STARTING THE TRUCK AND PUTTING INTO DRIVE, THE TRANSMISSION WILL SHIFT INTO 5TH GEAR AND REMAIN THERE. I HAVE TO PULL OVER, STOP THE VEHICLE, PLACE THE TRANSMISSION INTO PARK AND RESTART THE ENGINE TO CLEAR THIS ERROR. ALSO, WHILE DRIVING ON THE HIGHWAY YESTERDAY, MY TRUCK SUDDENLY SHIFTED INTO THIRD GEAR. I THEN RECOVER…

Read full complaint

WHEN STARTING THE TRUCK AND PUTTING INTO DRIVE, THE TRANSMISSION WILL SHIFT INTO 5TH GEAR AND REMAIN THERE. I HAVE TO PULL OVER, STOP THE VEHICLE, PLACE THE TRANSMISSION INTO PARK AND RESTART THE ENGINE TO CLEAR THIS ERROR. ALSO, WHILE DRIVING ON THE HIGHWAY YESTERDAY, MY TRUCK SUDDENLY SHIFTED INTO THIRD GEAR. I THEN RECOVERED SHORTLY INTO FIFTH GEAR BEFORE GOING INTO 6TH GEAR. THE SHIFTING IS NOW INTERMITTENTLY WONKY.

NHTSA ODI #11171777

25,000 miles · Jan 23, 2019
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE GEAR SHIFTED FROM HIGH TO LOW GEAR WITHOUT WARNING AND THE VEHICLE JERKED. THE VEHICLE WAS TAKEN TO PLANET FORD HD TRUCK SHOP (888-501-9013, LOCATED AT 20332 HOLZWARTH RD, SPRING, TX 77388) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. TH…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE GEAR SHIFTED FROM HIGH TO LOW GEAR WITHOUT WARNING AND THE VEHICLE JERKED. THE VEHICLE WAS TAKEN TO PLANET FORD HD TRUCK SHOP (888-501-9013, LOCATED AT 20332 HOLZWARTH RD, SPRING, TX 77388) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE CONTACT WAS REFERRED TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000.

NHTSA ODI #11171596

72,450 miles · Jan 23, 2019
Power TrainVehicle Speed Control

THE FRIGHTENING ISSUE I EXPERIENCED ON JANUARY 7, 2019 IS IDENTICAL TO THE REPORTS I HAVE SINCE READ REGARDING THIS VEHICLE AND THE FREQUENT ISSUES THAT LED TO THE RECALL FOR 2010-2012 FORD F-150'S FOR UNEXPECTED TRANSMISSION DOWNSHIFTS [NHTSA RECALL NO. / MFR RECALL NO. : 16V-248 / 16S19]. WHILE DRIVING 65-70 MPH ON THE INTE…

Read full complaint

THE FRIGHTENING ISSUE I EXPERIENCED ON JANUARY 7, 2019 IS IDENTICAL TO THE REPORTS I HAVE SINCE READ REGARDING THIS VEHICLE AND THE FREQUENT ISSUES THAT LED TO THE RECALL FOR 2010-2012 FORD F-150'S FOR UNEXPECTED TRANSMISSION DOWNSHIFTS [NHTSA RECALL NO. / MFR RECALL NO. : 16V-248 / 16S19]. WHILE DRIVING 65-70 MPH ON THE INTERSTATE, SPEEDOMETER SUDDENLY AND RAPIDLY FLUCTUATED BETWEEN 40 AND 70, THEN TRANSMISSION ABRUPTLY DROPPED FROM 6TH/5TH GEAR TO 1ST GEAR. AS A RESULT, MY WHEELS LOCKED AND CAUSED THE VEHICLE TO SKID INTO THE LANE TO MY RIGHT, FORCING OTHER CARS TO SWERVE OUT OF MY WAY TO AVOID A HIGH SPEED COLLISION. IT HAPPENED SO FAST, AND WITHOUT WARNING, THAT IT WAS DIFFICULT TO UNDERSTAND WHAT WAS ACTUALLY OCCURRING. ONCE STOPPED (IN THE MIDDLE OF THE INTERSTATE), I DROVE TO THE MEDIAN, TURNED THE ENGINE OFF, SAT FOR A FEW MINUTES TO GATHER MY THOUGHTS, RESTARTED THE VEHICLE AND DROVE IT SLOWLY TO MY FORD DEALERSHIP (NOT ON THE HIGHWAY). AFTER INSPECTING MY TRUCK, THE FORD DEALERSHIP VERIFIED THE ISSUE AND STATED THE FOLLOWING (WRITTEN REPORT ATTACHED): RAN KOEC GOT CODE P0720 OSS SENSOR CIRCUIT FAULT, RAN PINPOINT TESTS, FOUND OPEN IN OSS SENSOR WHICH IS PART OF THE MOLDED LEAD FRAME ATTACHED TO THE VALVE BODY, REMOVED THE VALVE BODY, DISSASEMBLED, CLEANED AND INSPECTED THE VALUE BODY, ALL VALVES AND BORES ARE OK, REASSEMBLED VALVE BODY WITH NEW MOLDED LEAD FRAME ASSEMBLY AND NEW REVISED SEPARATOR PLATE GASKET, INSTALLED NEW CLUTCH FEED TUBE SEALS AND SEAL BETWEEN VALVE BODY AND FLUID PUMP, INSTALLED NEW FLUID FILTER AND PAN GASKET, FILLED TRANSMISSION WITH NEW FLUID REPROGRAMMED PCM AND CLEARED DTCS, VERIFIED REPAIRS. DESPITE PARALLELS TO THE PREVIOUS RECALL ISSUE, FORD INFORMED ME IT IS NOT COVERED (THERE IS NOTHING I COULD HAVE DONE TO PREVENT IT) AND THE TOTAL COST TO ME WAS $1,418.83. PLEASE EXPAND THE RECALL - IT WILL SAVE LIVES.

NHTSA ODI #11171588

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of