← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
89,100 miles · Jan 16, 2020
EnginePower TrainSeats

1. ENGINE DOESN'T RUN SMOOTH AT HIGHWAY SPEED.. 2. POWERTRAIN, TRANSMISSION - RECEIVED A RECALL 19V-075 FOR SOFTWARE UPDATE NOTICE 6/25/2019. TOOK THE F150 TO GATEWAY FORD DEALERSHIP FOR THE UPDATE. THE NEXT TIME TRIED TO ACCELERATE (8/16/19) THE TRANSMISSION SHIFTER ERADICABLE THE DASH ICONS FLASHED AND THE PICKUP STALLE…

Read full complaint

1. ENGINE DOESN'T RUN SMOOTH AT HIGHWAY SPEED.. 2. POWERTRAIN, TRANSMISSION - RECEIVED A RECALL 19V-075 FOR SOFTWARE UPDATE NOTICE 6/25/2019. TOOK THE F150 TO GATEWAY FORD DEALERSHIP FOR THE UPDATE. THE NEXT TIME TRIED TO ACCELERATE (8/16/19) THE TRANSMISSION SHIFTER ERADICABLE THE DASH ICONS FLASHED AND THE PICKUP STALLED AS TO BE IN LOW GEAR, I SHUT OFF THE IGNITION AFTER PULLING TO THE SIDE OF THE ROAD, RESTARTED IT AFTER A BIT AND CONTINUED ON MY WAY. THIS HAS HAPPENED AGAIN, NOT SURE OF DATES. AS I WAS TRAVELING OUT OF SOUTH DAKOTA I CONTACTED GATEWAY, THEY SAID TO TAKE THE PICKUP TO ANOTHER FORD DEALERSHIP AND THEY WOULD FIX IT. TOOK IT TO AUTO NATION FORD IN CORPUS CHRISTI, TX. THEY WOULDN'T FIX IT . THEY SAID THE UPDATE WAD ALREADY DONE. THE PICKUP DROVE AND WORKED GOOD PRIOR TO THE RECALL UPDATE AND NOW IT WILL SHIFT RADICALLY AND DASH ICON FLASHING WHEN ACCELERATING RAPIDLY. IN ADDITION THE DRIVERS SEAT IS WEARING OUT. IT SHOULD REAR BETTER THAN THAT. THE PICKUP ONLY HAS 90,178 MILES ON IT AND SHOULD LAST ME LONGER THAN THAT. ONE MORE ISSUE. THE POSITIVE BATTERY POST CONTINUALLY CORRODES. I'VE CLEANED IT MANY TIMES AND STILL CORRODES. PLEASE HAVE SOMEONE ADDRESS THESE ISSUES ON MY F150. I THINK THERE SHOULD BE NO COST TO ME PER YOUR ADVERTISING ON TV. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #11299683

154,000 miles · Jan 13, 2020
Power Train

MY TRUCK SUDDENLY DOWNSHIFTED FROM 6 GEAR TO 1ST GEAR, AND ALMOST CAUSED ME TO CRASH. I LOOKED ONLINE TO SEE IF OTHER 2013 FORD F150 OWNERS HAVE HAD THIS HAPPEN TO THEM AND SAW THERE WAS A SAFETY RECALL ON MY TRUCK (NHTSA RECALL #19V-075). ON 1/6/2020 I TOOK MY TRUCK TO TOMBALL FORD DEALERSHIP AND THEY CONFIRMED I NEEDED THE REP…

Read full complaint

MY TRUCK SUDDENLY DOWNSHIFTED FROM 6 GEAR TO 1ST GEAR, AND ALMOST CAUSED ME TO CRASH. I LOOKED ONLINE TO SEE IF OTHER 2013 FORD F150 OWNERS HAVE HAD THIS HAPPEN TO THEM AND SAW THERE WAS A SAFETY RECALL ON MY TRUCK (NHTSA RECALL #19V-075). ON 1/6/2020 I TOOK MY TRUCK TO TOMBALL FORD DEALERSHIP AND THEY CONFIRMED I NEEDED THE REPAIRS LISTED IN RECALL 19V-075. THE SERVICE ADVISOR REACHED OUT TO FORD TO MAKE SURE THE REPAIRS WOULD BE COVERED FREE OF CHARGE. I WAS THEN INFORMED THAT FORD DENIED MY CLAIM AND WOULD NOT OFFER ANY ASSISTANCE TOWARD THE RECALL, DUE TO MY TRUCK HAVING 154,000 MILES. I WAS THEN CHARGED $1,328.31 TO HAVE THE REPAIRS PERFORMED BY TOMBALL FORD.

NHTSA ODI #11298976

141,320 miles · Jan 10, 2020
Power Train

WAS PULLING ONTO THE HIGHWAY WITH MY DAUGHTER IN THE BACKSEAT SHIFTING FROM 3RD GEAR TO 4TH I EXPERIENCED A SUDDEN DOWN SHIFT TO 1ST GEAR THEN ERRATIC SHIFTING THEN THE YELLOW WRENCH LIGHT CAME ON "LIMP MODE" AND I ONLY HAD 1ST 2ND AND 3RD GEARS TO GET HOME I DROPPED THE CAR OFF AT A FORD DEALERSHIP THINKING THAT THE 19S07 RECAL…

Read full complaint

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

NHTSA ODI #11298453

Mileage unknown · Jan 6, 2020
Power TrainVehicle Speed Control

ON 10 AUG 2019 I TOOK MY FORD IN FOR TRANSMISSION RECALL, REPROGRAMMING TO PREVENT UNCONTROLLED DOWNSHIFTING. I HAD NEVER HAD HAD ANY PROBLEMS WITH DOWNSHIFTING PRIOR TO THIS DATE. ONCE RECALL WAS DONE WITHIN A WEEK MY TRUCK DRASTICALLY DOWNSHIFTED TWICE BEFORE TAKING IT BACK TO THE DEALER WHO PERFORMED THE RECALL. THEY SAID …

Read full complaint

ON 10 AUG 2019 I TOOK MY FORD IN FOR TRANSMISSION RECALL, REPROGRAMMING TO PREVENT UNCONTROLLED DOWNSHIFTING. I HAD NEVER HAD HAD ANY PROBLEMS WITH DOWNSHIFTING PRIOR TO THIS DATE. ONCE RECALL WAS DONE WITHIN A WEEK MY TRUCK DRASTICALLY DOWNSHIFTED TWICE BEFORE TAKING IT BACK TO THE DEALER WHO PERFORMED THE RECALL. THEY SAID THERE WAS NO PROBLEM WITH MY TRUCK AND TOLD ME MY WHEELS LOCKING WAS NOT A SIGN OF DOWNSHIFTING. NOW I CONTINUE TO HAVE DOWNSHIFTING ISSUES AND ALSO AM THROWING A P0720 CODE. I JUST KNOW THAT THE DOWNSHIFTING BROKE THE LEADFRAME AND I LOOKING AT A HUGE BILL. NOW VEHICLE GOES INTO LIMP MODE WHERE I HAVE TO STOP AND RESTART MY CAR TO GET SPEEDOMETER TO SHOW.

NHTSA ODI #11297526

5,000 miles · Jan 1, 2020
Power Train

MY VEHICLE WAS DOWN SHIFTING WHEN I WAS IN 5 AND 6 GEAR. I TOOK IT TO A LOCAL DEALERSHIP (WHICH TOOK 3 MONTHS). THEY SAID THAT THERE WAS SOMETHING WRONG WITH MY TRUCK BUT DIDN'T KNOW HOW TO FIX IT. I TOOK IT TO ANOTHER DEALERSHIP, AND THEY FOUND A RECALL NOTICE. THEY TRY TO FIX THE ISSUE WITH REPROGRAMING. HOWEVER, IT NEVER …

Read full complaint

MY VEHICLE WAS DOWN SHIFTING WHEN I WAS IN 5 AND 6 GEAR. I TOOK IT TO A LOCAL DEALERSHIP (WHICH TOOK 3 MONTHS). THEY SAID THAT THERE WAS SOMETHING WRONG WITH MY TRUCK BUT DIDN'T KNOW HOW TO FIX IT. I TOOK IT TO ANOTHER DEALERSHIP, AND THEY FOUND A RECALL NOTICE. THEY TRY TO FIX THE ISSUE WITH REPROGRAMING. HOWEVER, IT NEVER CORRECTED THE ISSUES. I WAS TOLD BY THE DEALERSHIP THAT FORD HAD TO FIGURE OUT HOW TO FIX THE PROBLEM. I NOW AVOID GOING OVER ANY BIG HILLS, BRIDGES AND HIGHWAYS TO PREVENT MY VEHICLE FROM DOWNSHIFTING. IN THIS WHOLE PROCESS MY VEHICLE HASN'T BEEN RECORDING THE CORRECT MILEAGE AND NOW I HAVE HIGHER MILES THEN I SHOULD. I BOUGHT MY VEHICLE A LITTLE MORE THEN A YEAR AGO AND NEARLY HAS 30,000 MILES ON IT. I ONLY DRIVE TO AND FROM WORK A TOTAL OF 12 MILES A DAY FOR 5 DAYS. THIS ERROR IN PROGRAMING I FEEL HAS CAUSE OTHER DAMAGE TO MY VEHICLE BESIDES THE DOWNSHIFTING AND ADDING EXTRA MILES. IF FORD COULD HAVE CORRECTED THIS PROBLEM IN TIMELY MANNER IT COULD HAVE SAVE THE TRUCK, BUT DUE THE DEALERSHIPS HAVING NO CLUE HOW TO FIX IT. MY TRUCK IS NICE PAPER WEIGHT.

NHTSA ODI #11292483

Mileage unknown · Jan 1, 2020
Power Train

FORD IS NOT COMING OUT WITH NEW SOFTWARE FOR THIS RECALL. IT WAS SUPPOSED TO BE COMPLETED IN 2019

NHTSA ODI #11292419

133,000 miles · Dec 30, 2019
Power Train

I WAS DRIVING ON A HIGHWAY GOING APPROXIMATELY 60 MPH WHEN IT UNEXPECTEDLY DOWNSHIFTED. MY MOMENTUM VIOLENTLY JERKED ME FORWARD, THE TIRES SQUEELED, AND THE RPM GAUGE WENT UP TO OVER 6,000. ANOTHER ISSUE IS THAT IT OCCASIONALLY WILL NOT SHIFT OUT OF FIRST GEAR. I WILL BE STARTING FROM A STOP AND I'LL BE GOING ABOUT 10-15MPH …

Read full complaint

I WAS DRIVING ON A HIGHWAY GOING APPROXIMATELY 60 MPH WHEN IT UNEXPECTEDLY DOWNSHIFTED. MY MOMENTUM VIOLENTLY JERKED ME FORWARD, THE TIRES SQUEELED, AND THE RPM GAUGE WENT UP TO OVER 6,000. ANOTHER ISSUE IS THAT IT OCCASIONALLY WILL NOT SHIFT OUT OF FIRST GEAR. I WILL BE STARTING FROM A STOP AND I'LL BE GOING ABOUT 10-15MPH AND IF I DON'T LET OFF THE THROTTLE THE ENGINE WILL JUST REV UP PAST 4000 RPMS.

NHTSA ODI #11291996

115,000 miles · Dec 23, 2019
Power TrainVehicle Speed Control

THIS HAS HAPPENED 5 TIMES. WHEN STARTING TO TAKE OFF IN LOW SPEEDS, 20-30 MPH, THE TRANSMISSION WILL SLIP INTO NEUTRAL THEN INTO FIRST SLOWING THE TRUCK DOWN RAPIDLY. ALSO, WHILE TRAVELLING AT HIGHWAY SPEEDS ON CRUISE CONTROL, THE VEHICLE WILL DROP TO 5TH GEAR AND THE SPEEDOMETER WILL DROP TO 0, THE ODOMETER AND ALL DISPLAY PANE…

Read full complaint

THIS HAS HAPPENED 5 TIMES. WHEN STARTING TO TAKE OFF IN LOW SPEEDS, 20-30 MPH, THE TRANSMISSION WILL SLIP INTO NEUTRAL THEN INTO FIRST SLOWING THE TRUCK DOWN RAPIDLY. ALSO, WHILE TRAVELLING AT HIGHWAY SPEEDS ON CRUISE CONTROL, THE VEHICLE WILL DROP TO 5TH GEAR AND THE SPEEDOMETER WILL DROP TO 0, THE ODOMETER AND ALL DISPLAY PANEL SHOWS NOTHING, THE CRUISE WILL NOT WORK, AND THE AIRBAG LIGHT COMES ON.

NHTSA ODI #11290972

128,073 miles · Dec 19, 2019
EnginePower Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 80 MPH, THE VEHICLE DOWNSHIFTED ON ITS OWN WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO LUTHER FAMILY FORD (LOCATED AT 3302 36TH ST S, FARGO, ND 58104, (701) 282-2350) WHERE IT WAS DIAGNOSED THAT UNKNOWN ENGINE COMPONENTS NEEDED TO BE REPLACED…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 80 MPH, THE VEHICLE DOWNSHIFTED ON ITS OWN WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO LUTHER FAMILY FORD (LOCATED AT 3302 36TH ST S, FARGO, ND 58104, (701) 282-2350) WHERE IT WAS DIAGNOSED THAT UNKNOWN ENGINE COMPONENTS NEEDED TO BE REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN). THE CONTACT STATED THAT THE RECALL REPAIR WAS COMPLETED IN JUNE OF 2019. THE VEHICLE WAS NOT REPAIRED FOR THE RECENT FAILURE. THE CONTACT WAS UNABLE TO COMMUNICATE WITH THE MANUFACTURER ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 128,073.

NHTSA ODI #11290172

81,000 miles · Dec 11, 2019
EnginePower TrainVehicle Speed Control

TRUCK BEING DRIVEN APX 55 MPH AND NO CHANGE FROM ME TRUCK HAS SUDDEN SLOWDOWN WITH SPEEDOMETER DROP TO 40S THEN RECOVERS AS TRUCK SPEEDS UP ON IT'S OWN. SAME DAY AS TRYING TO PARK, IN DRIVE, PRESSING ON GAS ENGINE REVS BUT DOES NOT MOVE. TODAY (7 DAYS LATER) ACCELERATING FROM STOP TRANSMISSION STICKS IN LOW GEAR. HAS HAD POWERTR…

Read full complaint

TRUCK BEING DRIVEN APX 55 MPH AND NO CHANGE FROM ME TRUCK HAS SUDDEN SLOWDOWN WITH SPEEDOMETER DROP TO 40S THEN RECOVERS AS TRUCK SPEEDS UP ON IT'S OWN. SAME DAY AS TRYING TO PARK, IN DRIVE, PRESSING ON GAS ENGINE REVS BUT DOES NOT MOVE. TODAY (7 DAYS LATER) ACCELERATING FROM STOP TRANSMISSION STICKS IN LOW GEAR. HAS HAD POWERTRAIN RECALL APPLIED.

NHTSA ODI #11288554

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of