← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
104,000 miles · Mar 10, 2020
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT THE VEHICLE DOWNSHIFTED TO FIRST GEAR THEN A HIGHER GEAR AND THEN SHIFTED BACK TO FIRST GEAR INDEPENDENTLY. THE GEAR ALSO SHIFTED TO FIFTH AND SIXTH GEAR THEN BACK TO FIRST. THE VEHICLE THEN SHIFTED TO FIFTH AND REMAINED IN FIFTH GEAR. THE CONTACT STATED THAT THE VE…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT THE VEHICLE DOWNSHIFTED TO FIRST GEAR THEN A HIGHER GEAR AND THEN SHIFTED BACK TO FIRST GEAR INDEPENDENTLY. THE GEAR ALSO SHIFTED TO FIFTH AND SIXTH GEAR THEN BACK TO FIRST. THE VEHICLE THEN SHIFTED TO FIFTH AND REMAINED IN FIFTH GEAR. THE CONTACT STATED THAT THE VEHICLE SHIFTED INTO FIRST GEAR WHILE SLOWING DOWN. THE CONTACT STATED THAT THE VEHICLE SHIFTED CORRECTLY UP TO FOURTH GEAR AFTER WHICH THE VEHICLE FAILED TO SHIFT GEARS IN THE CORRECT SEQUENCE. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

NHTSA ODI #11317329

152,000 miles · Mar 6, 2020
Power TrainSeat BeltsInjury

MY TRANSMISSION DOWNSHIFTED FROM 5TH GEAR TO 1ST GEAR IN NOV 2018. THE TRANSMISSION THEN WOULD NO LONGER SHIFT DUE TO THE DAMAGE IT CAUSED. I HAD THE TRANSMISSION REBUILT BY FORD. SOON AFTER THE REPAIRS FORD RELEASED A SAFETY RECALL FOR THE EXACT PROBLEM. I TOOK THE VEHICLE IN AND THEY PERFORMED THE RECALL SERVICE. I ASKED ABOUT…

Read full complaint

MY TRANSMISSION DOWNSHIFTED FROM 5TH GEAR TO 1ST GEAR IN NOV 2018. THE TRANSMISSION THEN WOULD NO LONGER SHIFT DUE TO THE DAMAGE IT CAUSED. I HAD THE TRANSMISSION REBUILT BY FORD. SOON AFTER THE REPAIRS FORD RELEASED A SAFETY RECALL FOR THE EXACT PROBLEM. I TOOK THE VEHICLE IN AND THEY PERFORMED THE RECALL SERVICE. I ASKED ABOUT REIMBURSEMENT FOR THE PRIOR REPAIRS AND WAS TOLD YES IT WOULD BE COVERED BECAUSE IT WAS CAUSED BY THE RECALL. THE TRUCK CONTINUED TO RANDOMLY SHIFT TO NEUTRAL OR SKIP GEARS. I TOOK IT BACK IN. THEY SAID IT WAS CAUSED BY THE REAR MAIN SEAL, THIS HAS NOTHING TO DO WITH SHIFTING. THE TRANSMISSION HAS NEVER LEAKED. THE ISSUES CONTINUED ON UNTIL ON FEBRUARY 27TH THE TRANSMISSION DROPPED TO 1ST GEAR ON THE HIGHWAY (65 MPH) NEARLY CAUSING A MAJOR ACCIDENT AND THROWING ME AGAINST THE STEERING WHEEL. I JUST CONTACTED FORD RECALL DEPARTMENT AND INQUIRED ABOUT FULL REIMBURSEMENT AND TO NOTIFY THEM THAT THIS HAPPENED AGAIN. THEY SAID THEY WOULD NOT REIMBURSE ME ANY $ AND IGNORED MY COMPLAINT ABOUT THE TRANSMISSION DOWNSHIFTING LIKE THAT AGAIN. I AM NOW SITTING WITH A SORE BACK, $4,000 REPAIR COST AND A TRUCK THAT MAY PUT MY LIFE AND ANY PASSENGERS LIFE IN DANGER WHILE IN THE VEHICLE.

NHTSA ODI #11316536

80,000 miles · Mar 5, 2020
Power TrainCrashInjury

TL* THE CONTACT CALLED TO FILE A SAFETY COMPLAINT HOWEVER HE DOES NOT REMEMBER DETAILS AS HE BLACKED OUT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE ATTEMPTED TO MAKE A TURN ON A CURVE WAS ALL HE COULD RECALL OF THE INCIDENT. THE CONTACT STATED PER THE POLICE REPORT THE VEHICLE CRASHED INTO A CORNER POST AND …

Read full complaint

TL* THE CONTACT CALLED TO FILE A SAFETY COMPLAINT HOWEVER HE DOES NOT REMEMBER DETAILS AS HE BLACKED OUT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE ATTEMPTED TO MAKE A TURN ON A CURVE WAS ALL HE COULD RECALL OF THE INCIDENT. THE CONTACT STATED PER THE POLICE REPORT THE VEHICLE CRASHED INTO A CORNER POST AND A FENCE. THE CONTACT STATED THAT THE AIR BAGS DEPLOYED. THE CONTACT STATED PER THE POLICE REPORT THERE WERE NO SKID MARKS TO INDICATE THAT THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS DEEMED A TOTAL LOSS. THE VEHICLE WAS TOWED TO A TOW LOT. THE CONTACT WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL AS HE WAS UNCONSCIOUS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN) AFTER THE FAILURE AND HE BELIEVES THIS WAS A CAUSE OF THE VEHICLE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA ODI #11316431

Mileage unknown · Feb 20, 2020
Power Train

DRIVING MY TRUCK IT DOWNSHIFTS TO LOW GIRL THE ONLY WAY I CAN GET IT OUT OF LOW GEAR IS PULL OVER STOP CUTTING ENGINE OFF AND STEAL SOME TIME AND DON'T COME OUT THEN. THIS IS VERY DANGEROUS WHILE DRIVING THE VEHICLE

NHTSA ODI #11310399

58,000 miles · Feb 18, 2020
EngineFuel/propulsion SystemPower Train

WE OWN A FORD F-150 3.5 L ECOBOOST V-6 KING RANCH PICKUP TRUCK. TRUCK WAS PURCHASED IN 2014 NEW. HAVE SERIOUS CONCERNS AS THE VEHICLE HAS SO MANY CURRENT ISSUES. FROM DAY ONE OF PURCHASE AND WHILE STILL IN THE DEALERSHIP PARKING LOT, UPON START UP THERE WAS A VERY LOUD CLATTERING SOUND. SALES REP SAID IT WAS BECAUSE IT WAS C…

Read full complaint

WE OWN A FORD F-150 3.5 L ECOBOOST V-6 KING RANCH PICKUP TRUCK. TRUCK WAS PURCHASED IN 2014 NEW. HAVE SERIOUS CONCERNS AS THE VEHICLE HAS SO MANY CURRENT ISSUES. FROM DAY ONE OF PURCHASE AND WHILE STILL IN THE DEALERSHIP PARKING LOT, UPON START UP THERE WAS A VERY LOUD CLATTERING SOUND. SALES REP SAID IT WAS BECAUSE IT WAS COLD AND IT HAD BEEN SITTING. PURCHASED VEHICLE, HAD PROBLEMS IMMEDIATELY WITH DANGEROUS LAG IN ACCELERATION (WHICH WE STILL DO), AN AVERAGE OF 12 MPG IF WE WERE LUCKY AND VERY SERIOUS ENGINE MISFIRES WITH MAJOR DECREASE IN POWER ACCOMPANIED BY SPUTTERING WHOLE VEHICLE SHUDDERING WHILE TRYING TO MERGE ON THE HIGHWAY OR WITH HARD ACCELERATION. VERY DANGEROUS, ESPECIALLY IF IN THE FAST LANE, WHICH WE WERE. WE STARTED TO LIMP OVER SEVERAL LANES OF TRAFFIC TO THE SHOULDER AND THE TRUCK REGAINED POWER. MANY MISFIRES LIKE THIS, ALL EXPLAINED TO THE FORD SERVICE TECH AND VERIFIED ON THE TRUCKS COMPUTER. SO MANY IN FACT IT WAS NECESSARY TO REPLACE ALL SPARK PLUGS AT LESS THAN 57K MILES. WE JUST PICKED OUR TRUCK UP TODAY, FEB 18TH, 2020, AFTER IT WAS IN THE SHOP AGAIN, THIS TIME FOR 12 DAYS, TO FIX THIS MISFIRE PROBLEM AGAIN AND NUMEROUS OTHER ISSUES WITH THE FRONT HUBS STAYING LOCKED IN 4 WD WHILE IN 2 WHEEL DRIVE AND SWITCHING IN AND OUT, TIMING CHAIN REPLACED, AND THE ECOBOOST TURBO TUBES REPLACED AS THEY WERE CRACKED, IWE REPLACED, AND LEFT FRONT ACTUATOR. ALSO ABOUT 3 WEEKS AGO IT HAD TRANSFER CASE MOTOR REPLACED AS WELL AS NUMEROUS SWITCHES, ALL WHICH DID NOT CORRECT THE PROBLEMS. MY HUSBAND AND I DECIDED TO TAKE IT ON THE HIGHWAY TO SEE IF THE LAG MISFIRE PROBLEM WAS FIXED. WHEN HE HIT THE GAS THERE WAS A SCREECHY SOUND FROM THE TOP OF THE ENGINE, POWER SERIOUSLY DECREASED ONCE AGAIN ON THE HIGHWAY AND THE CHECK ENGINE LIGHT WAS BACK ON. I SENT AN EMAIL TO FORD AND AUFFENBERG FORD IN REF TO THESE CONTINUING PROBLEMS.

NHTSA ODI #11310006

111,737 miles · Feb 14, 2020
Power TrainVehicle Speed Control

I RECENTLY PURCHASED THIS VEHICLE USED LESS THAN A WEEK AGO. I HAVE ONLY DRIVEN IT FOR ABOUT 75 MILES. WHILE DRIVING DOWN A BUSY STREET AT 45 MILES AN HOUR THE TRUCK DOWN SHIFTED TO FIRST GEAR AND SIMULTANEOUSLY THE SPEEDOMETER STOPPED WORKING. I KEPT CONTROL OF THE VEHICLE BUT IF A VEHICLE WOULD HAVE BEEN FOLLOWING CLOSELY IT I…

Read full complaint

I RECENTLY PURCHASED THIS VEHICLE USED LESS THAN A WEEK AGO. I HAVE ONLY DRIVEN IT FOR ABOUT 75 MILES. WHILE DRIVING DOWN A BUSY STREET AT 45 MILES AN HOUR THE TRUCK DOWN SHIFTED TO FIRST GEAR AND SIMULTANEOUSLY THE SPEEDOMETER STOPPED WORKING. I KEPT CONTROL OF THE VEHICLE BUT IF A VEHICLE WOULD HAVE BEEN FOLLOWING CLOSELY IT IS POSSIBLE IF NOT LIKELY TO HAVE REAR ENDED ME. I CHECKED THE VIN AND IT STATES NO OPEN RECALLS. EVIDENTLY THE VEHICLE WAS SERVICED FOR ONE OF THE PAST RECALLS WHICH CLEARLY DESCRIBES THIS SAME EVENT AS AN ISSUE. I WILL CONTACT THE DEALERSHIP GREY DANIELS FORD IN BRANDON MS WHERE IT WAS PURCHASED FOR INSPECTION.

NHTSA ODI #11309097

58,800 miles · Feb 4, 2020
Power TrainCrash

WHILE DRIVING 65 MPH MY 2013 F150 DOWNSHIFTED INTO FIRST GEAR AND LOCKED THE REAR TIRES CAUSE ME TO SPIN OUT OF CONTROL. THIS CAUSED MINOR BODY DAMAGE TO THE VEHICLES REAR BUMPER, FROM HITTING SOMETHING OFF THE SIDE OF THE ROAD. I CALLED MULTIPLE DEALERSHIPS AND EXPLAINED WHAT HAPPENED AT THE BEGINNING OF FEBUARY 2020. THEY E…

Read full complaint

WHILE DRIVING 65 MPH MY 2013 F150 DOWNSHIFTED INTO FIRST GEAR AND LOCKED THE REAR TIRES CAUSE ME TO SPIN OUT OF CONTROL. THIS CAUSED MINOR BODY DAMAGE TO THE VEHICLES REAR BUMPER, FROM HITTING SOMETHING OFF THE SIDE OF THE ROAD. I CALLED MULTIPLE DEALERSHIPS AND EXPLAINED WHAT HAPPENED AT THE BEGINNING OF FEBUARY 2020. THEY EXPLAINED THAT THEY COULD GET ME INTO FIX THE PROBLEM FOR ABOUT 20 DAYS AT MINIMUM AND EVEN THEN THEY WOULD HAVE TO KEEP IT LONGER TO FIX IT IF THERE WAS SOMETHING WRONG. I EXPLAINED THAT I ALMOST ROLLED THE VEHICLE AFTER SPINNING OUT OF CONTROL AND ASKED IF THEY COULD GET IT IN SOONER, THE ANSWER WAS CONTINUOUSLY NO FROM ALL OF THE DEALERS. I ASKED THEM IF I SHOULD STILL DRIVE THE VEHICLE AND THEY SAID IT SHOULDN'T BE A PROBLEM TO DO SO, I THEN STATED SO YOU WANT ME TO CONTINUE TO DRIVE THE VEHICLE EVEN THOUGH THIS HAPPENED AND POTENTIALLY GET INTO AN ACCIDENT AND INJURY MYSELF AND OR SOMEONE ELSE OR PERMANENTLY DAMAGE THE VEHICLES POWERTRAIN. THEY STILL SAID THAT IT SHOULD BE OK TO DRIVE THE VEHICLE. WELL IT LOCKED UP AGAIN CAUSING ANOTHER SPIN OUT AND I ALMOST HIT A SCHOOL BUS. HOW IS THIS LEGAL? I EVEN CALLED FORD EXTENDED CARE FOR HELP AND THEY TOLD ME THAT THIS IS A RECALL AND EVEN THOUGH I HAVE PREMIUM CARE IT ONLY COVERS A 10 DAY RENTAL FOR THINGS OTHER THEN A RECALL AND TO CALL THE DEALERS BACK FOR FURTHER DETAILS. SO I CALLED THE DEALERS BACK AND THE DEALERS TOLD ME THERE RENTALS ARE ALL BOOK FOR THE NEXT 2 WEEKS. A VEHICLE THAT ALMOST KILLED ME AND OTHER PEOPLE BECAUSE OF THIS MECHANICAL FLAW SHOULDN'T BE LEGAL TO SELL. AND HOW AM I SUPPOSED TO GO TO WORK AND GET MY KIDS AROUND FOR THE NEXT MONTH, WHEN FORD WILL DO NOTHING TO HELP. HOW IS IT THAT THEY WOULD LET ME AND OTHERS DRIVE THESE VEHICLE AND IT NOT BE MANDATED THEY BE PICKED UP FROM PEOPLES HOMES AND FIXED. THIS IS CRIMINAL OF FORD AND IT WAS A GOING TO KILL SOMEONE.

NHTSA ODI #11306897

13,447 miles · Feb 3, 2020
Power TrainVehicle Speed Control

UNEXPECTEDLY DOWNSHIFTING INTO FIRST GEAR WHILE IN MOTION, SPEED OMETER AND MILEAGE GOES TO ZERO, RPMS STARTS TO RUN HIGH, AND THE TOOL LIGHT ON THE DASH BOARD COMES ON, IN CITY STREETS AND ON HIGHWAY DRIVING. I HAVE TO STOP AND SHUT DOWN THE VEHICLE AND WAIT A FEW MINUTES. WHEN I START UP THE VEHICLE AND PUT IT IN DRIVE GEAR T…

Read full complaint

UNEXPECTEDLY DOWNSHIFTING INTO FIRST GEAR WHILE IN MOTION, SPEED OMETER AND MILEAGE GOES TO ZERO, RPMS STARTS TO RUN HIGH, AND THE TOOL LIGHT ON THE DASH BOARD COMES ON, IN CITY STREETS AND ON HIGHWAY DRIVING. I HAVE TO STOP AND SHUT DOWN THE VEHICLE AND WAIT A FEW MINUTES. WHEN I START UP THE VEHICLE AND PUT IT IN DRIVE GEAR THE TRANSMISSION JERKS.

NHTSA ODI #11306713

87,222 miles · Jan 28, 2020
Power TrainVehicle Speed Control

I TOOK MY TRUCK IN ALMOST A YEAR AGO IN MARCH TO HAVE RECALL ON TRANSMISSION DOWNSHIFT REPAIRED. JUST IN THE LAST MONTH I HAVE HAD TO BRING MY TRUCK IN 3 TIMES. TWICE MY TRUCK DOWNSHIFTED WHILE ON THE SH-130 TOLLWAY GOING 80MPH AND DOWN SHIFTING TO 40 MPH ALMOST CAUSING ME TO WRECK OR BE STRUCK BY ANOTHER VEHICLE. AGAIN TODAY I …

Read full complaint

I TOOK MY TRUCK IN ALMOST A YEAR AGO IN MARCH TO HAVE RECALL ON TRANSMISSION DOWNSHIFT REPAIRED. JUST IN THE LAST MONTH I HAVE HAD TO BRING MY TRUCK IN 3 TIMES. TWICE MY TRUCK DOWNSHIFTED WHILE ON THE SH-130 TOLLWAY GOING 80MPH AND DOWN SHIFTING TO 40 MPH ALMOST CAUSING ME TO WRECK OR BE STRUCK BY ANOTHER VEHICLE. AGAIN TODAY I WAS DRIVING MY VEHICLE ON HWY AND ENGINE LIGHT CAME ON. SAME EFFECT EXCEPT THIS TIME MY TRUCK REFUSED TO MOVE WITHOUT TURNING IT OFF IN THE MIDDLE OF TRAFFIC. THIS IS 3XS MY LIFE HAS BEEN IN JEOPARDY IN A SHORT PERIOD OF TIME. I HAVE TAKEN IT TO FORD DEALERSHIP WHERE THEY INSISTED TRANSMISSION DOWNSHIFT ISSUE WAS REPAIRED AND SUGGESTED A TUNE UP WAS BEST OPTION. HUNDREDS OF DOLLARS OUT AND AGAIN I'M IN SAME SITUATION I WAS. 3 X NEAR WRECKING OR DEATH AND ALL IN UNDER A MONTH. INITIAL DATE OF SERVICE 1/3/20 SERVICED AGAIN 1/21/20. NOW NEED SERVICE AGAIN. I HAVE KEPT UP WITH SCHEDULED MAINTENANCE ON VEHICLE AND IT DOES NOT HAVE VERY MANY MILES ON IT.

NHTSA ODI #11302690

148,000 miles · Jan 22, 2020
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE AIR BAGS WARNING LIGHT ILLUMINATED, THE VEHICLE INDEPENDENTLY DOWNSHIFTED TO 1ST GEAR, AND THE WHEEL STARTED TO SLIDE. THE CONTACT MANAGED TO VEER TO THE SHOULDER OF THE ROAD. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON AND THE VEHICL…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE AIR BAGS WARNING LIGHT ILLUMINATED, THE VEHICLE INDEPENDENTLY DOWNSHIFTED TO 1ST GEAR, AND THE WHEEL STARTED TO SLIDE. THE CONTACT MANAGED TO VEER TO THE SHOULDER OF THE ROAD. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON AND THE VEHICLE OPERATED AS INTENDED. THE VEHICLE WAS TAKEN TO (MIKE FERRELL FORD LINCOLN, INC.1705 W 3RD AVE, WILLIAMSON, WV 25661) WHERE IT WAS DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 19V433000 (POWER TRAIN) AS A POSSIBLE SOLUTION TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.

NHTSA ODI #11301062

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of