← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
2,969 miles · Aug 18, 2013
Fuel/propulsion SystemPower Train

I DROVE MY F150 FOR A SHORT DISTANCE OF MAYBE 3 MILES, SHUT IT OFF, ENTERED THE POST OFFICE FOR APPROXIMATELY 5 MINUTES, DROVE THE TRUCK ACROSS THE STREET FOR A DISTANCE OF MAYBE 1/4 MILE, SHUT IT OFF AND WENT INTO A BUSINESS FOR MAYBE 5 MINUTES. UPON STARTING THE TRUCK TO RETURN HOME IT WOULD NOT SHIFT INTO DRIVE. I LOOKED AT…

Read full complaint

I DROVE MY F150 FOR A SHORT DISTANCE OF MAYBE 3 MILES, SHUT IT OFF, ENTERED THE POST OFFICE FOR APPROXIMATELY 5 MINUTES, DROVE THE TRUCK ACROSS THE STREET FOR A DISTANCE OF MAYBE 1/4 MILE, SHUT IT OFF AND WENT INTO A BUSINESS FOR MAYBE 5 MINUTES. UPON STARTING THE TRUCK TO RETURN HOME IT WOULD NOT SHIFT INTO DRIVE. I LOOKED AT THE INSTRUMENT PANEL AND SAW THE RPMS TO BE OVER 3000. I DID NOT HEAR THE ENGINE REVVING DUE TO AC BLOWER NOISE. I CHECKED THE ACCELERATOR TO SEE IF ANYTHING WAS TOUCHING IT AND NOTHING WAS NEAR THE ACCELERATOR. I SHUT THE TRUCK OFF, RESTARTED, AND IT PERFORMED NORMALLY. OTHER ISSUES: 1) SEVERAL MONTHS AGO THE RADIO WOULD NOT TURN ON WHILE DRIVING AND WHEN I SHUT THE TRUCK OFF THE OUTSIDE TEMPERATURE DISPLAY ALONG WITH THE DATE/TIME DISPLAY WAS FLASHING SYMBOLS INSTEAD OF DISPLAYING ALPHA-NUMERIC CHARACTERS. UPON RESTARTING THE TRUCK THE DISPLAY RETURNED TO NORMAL AND THE RADIO FUNCTIONED NORMALLY. 2) WHEN APPLYING FULL THROTTLE THE ENGINE BASICALLY STALLS WHICH CAN BE SOMEWHAT HAZARDOUS WHEN ENTERING AN INTERSTATE HIGHWAY WITH A SHORT ENTRANCE RAMP AND HEAVY TRAFFIC. I MENTION ALL OF THESE ITEMS BECAUSE IN MY OPINION THEY WOULD POINT TO COMPUTER ISSUES ON THE ECOBOOST. *TR

NHTSA ODI #10535974

10,985 miles · Aug 13, 2013
EnginePower Train

I WAS TRAVELING ON THE HIGHWAY BEHIND A TRUCK TOWING A BIG CAMPER. WHEN I GOT A CHANCE TO TRY AND PASS HIM I GOT OVER TO GO AROUND HIM AND WENT TO ACCELERATE AND MY TRUCK LOST ALL POWER (CHECK ENGINE LIGHT STARTED FLASHING) AND I HAD TO APPLY BRAKE HARD TO SLOW BACK DOWN TO GET BACK BEHIND THE TRUCK. LUCKILY THERE WAS NOT ANYONE…

Read full complaint

I WAS TRAVELING ON THE HIGHWAY BEHIND A TRUCK TOWING A BIG CAMPER. WHEN I GOT A CHANCE TO TRY AND PASS HIM I GOT OVER TO GO AROUND HIM AND WENT TO ACCELERATE AND MY TRUCK LOST ALL POWER (CHECK ENGINE LIGHT STARTED FLASHING) AND I HAD TO APPLY BRAKE HARD TO SLOW BACK DOWN TO GET BACK BEHIND THE TRUCK. LUCKILY THERE WAS NOT ANYONE BEHIND ME SO I WAS ABLE TO GET BACK OVER. I HAD TO PULL OVER AND SET AND THE CHECK ENGINE LIGHT FINALLY WENT OUT AND TRUCK STARTED RUNNING FINE. I TOOK MY TRUCK INTO FORD AND THEY SAY NOTHING IS WRONG WITH IT. THIS IS A 2013 F150 WITH THE ECOBOOST 3.5 ENGINE WITH LESS THAN 11K MILES. I'M AFRAID TO EVEN DRIVE IT NOW. *TR

NHTSA ODI #10535229

12,000 miles · Aug 11, 2013
EnginePower Train

WHILE ATTEMPTING TO PASS A SEMI TRUCK AFTER DRIVING A CONSTANT SPEED OF 65 IN ARIZONAS HUMID MONSOON SEASON, UNDER HARD ACCELERATION MY F150 HAD A SUDDEN LOSS OF POWER ALONG WITH A VERY STRANGE SHUDDER AND LOUD REVVING SOUND. AFTER I LET OFF THE ACCELERATOR AND PULLED BEHIND THE SEMI I WAS ATTEMPTING TO PASS (DUE TO ON COMING TR…

Read full complaint

WHILE ATTEMPTING TO PASS A SEMI TRUCK AFTER DRIVING A CONSTANT SPEED OF 65 IN ARIZONAS HUMID MONSOON SEASON, UNDER HARD ACCELERATION MY F150 HAD A SUDDEN LOSS OF POWER ALONG WITH A VERY STRANGE SHUDDER AND LOUD REVVING SOUND. AFTER I LET OFF THE ACCELERATOR AND PULLED BEHIND THE SEMI I WAS ATTEMPTING TO PASS (DUE TO ON COMING TRAFFIC), THE TRUCK RAN NORMAL. THE DEALERSHIP WAS UNABLE DUPLICATE THE ISSUE. THE CONDITIONS WERE DIFFERENT THE DAY OF TEST DRIVE AND THE TRUCK WAS NOT DRIVEN AT HIGHWAY SPEEDS FOR NEARLY AS LONG. THIS COULD BE A VERY SERIOUS ISSUE THAT NEEDS RESOLVED IMMEDIATELY. *TR

NHTSA ODI #10534782

7,000 miles · Jul 30, 2013
EngineFuel/propulsion SystemPower Train

I PURCHASED MY 2013 FORD F-150 ECOBOOST IN DECEMBER 2012. THE FIRST INCIDENT OCCURRED IN APPROXIMATELY MARCH 2013. IT WAS RAINING. I WAS ACCELERATING FROM A STOP LIGHT WHERE I HAD MADE A COMPLETE STOP. I COULD NOT GAIN SPEED VERY WELL. THE ENGINE LIGHT WAS FLASHING. THE ENGINE WAS SPUTTERING/POPPING AND THE WHOLE TRUCK WAS SHAKI…

Read full complaint

I PURCHASED MY 2013 FORD F-150 ECOBOOST IN DECEMBER 2012. THE FIRST INCIDENT OCCURRED IN APPROXIMATELY MARCH 2013. IT WAS RAINING. I WAS ACCELERATING FROM A STOP LIGHT WHERE I HAD MADE A COMPLETE STOP. I COULD NOT GAIN SPEED VERY WELL. THE ENGINE LIGHT WAS FLASHING. THE ENGINE WAS SPUTTERING/POPPING AND THE WHOLE TRUCK WAS SHAKING VIOLENTLY. THE SAME HAS OCCURRED EVER SINCE ON MORE THAN A DOZEN OCCASIONS AND AT VARIOUS SPEEDS. HOWEVER, EACH TIME WAS WHILE IT WAS RAINING. NEVER HAS HAD A PROBLEM IN FAIR WEATHER. I EXPERIENCE A TOTAL LOSS OF POWER, MANY TIMES WHEN ON THE INTERSTATE OR WHILE TRYING TO OVERCOME A VEHICLE. THE FRONT-END LURCHES, I LOSE SPEED DRAMATICALLY, THE ENGINE SHAKES VIOLENTLY WHEN I ACCELERATE. THE ENGINE SPUTTERS AND SOUNDS LIKE IT DOESN'T KNOW WHETHER TO CHOKE OUT OR BLOW UP. THE ENGINE LIGHT FLASHES FOR APPROXIMATELY 1 MINUTE EACH TIME. ALMOST SOUNDS LIKE A MISFIRE. HAPPENS SEVERAL TIMES DURING ONE TRIP OFTEN, BUT ALWAYS WHEN IT RAINS. CONTINUOUS OCCURRENCES AND BEGINNING TO BECOME MORE FREQUENT. HAVE TAKEN MY TRUCK TO 2 DEALERSHIPS, NEITHER OF WHICH CAN DETECT ANY DTCS OR ANY OTHER PROBLEM. OFFER NO ADVICE OTHER THAN TO KEEP DRIVING IT UNTIL THE ENGINE LIGHT STAYS ON PERMANENTLY. THEY HAVE NO IDEA WHAT CAUSES THE PROBLEM. I AM REALLY AFRAID THAT THE PROBLEM MAY RESULT IN A MOTOR VEHICLE ACCIDENT. HAVE NOT HAD ONE YET, BUT HAVE A HAD A COUPLE OF INCIDENTS WHERE I HAD TO PULL OVER TO AVOID AN ACCIDENT. PROBLEM IS SO PERSISTENT THAT I AM CONSIDERING TRADING VEHICLES, ESPECIALLY SINCE I HAVE BEEN OFFERED NO REMEDY FOR THE PROBLEM. I HAVE ALSO FILED A COMPLAINT WITH FORD MOTOR CO. ON 07/30/2013. *TR

NHTSA ODI #10532667

Mileage unknown · Jul 15, 2013
Power Train

WHILE DRIVING SOUTH ON HWY 87 SOUTH TOWARD SOUTHPORT, NC NEAR SANDYFIELD, CLOSE TO THE HYW 11 INTERSECTION, I PERFORMED A HARD ACCELERATION TO PASS A SLOW MOVING VEHICLE WHEN I EXPERIENCED A SUDDEN LOSS OF POWER IMMEDIATELY FOLLOWED BY SHAKING. IF THE VEHICLE I WAS PASSING WAS GOING FASTER THAN 50 MPH I WOULD NOT HAVE MADE IT AR…

Read full complaint

WHILE DRIVING SOUTH ON HWY 87 SOUTH TOWARD SOUTHPORT, NC NEAR SANDYFIELD, CLOSE TO THE HYW 11 INTERSECTION, I PERFORMED A HARD ACCELERATION TO PASS A SLOW MOVING VEHICLE WHEN I EXPERIENCED A SUDDEN LOSS OF POWER IMMEDIATELY FOLLOWED BY SHAKING. IF THE VEHICLE I WAS PASSING WAS GOING FASTER THAN 50 MPH I WOULD NOT HAVE MADE IT AROUND HIM. WHILE I DID NOT STOP, I DID SLOW THE VEHICLE TO UNDER 50 MPH TO WHICH THE ENGINE LIGHT STOPPED FLASHING AS DID THE SHAKING. THE WEATHER WAS PARTLY SUNNY WITH HIGH HUMIDITY. ROAD CONDITIONS WERE DRY.

NHTSA ODI #10525464

2,230 miles · Jul 14, 2013
EnginePower Train

I WAS TRYING TO PASS ANOTHER CAR WHEN MY ENGINE STALLED. I WAS GOING ABOUT 45 TO 50 MPH WHEN I WENT TO ACCELERATE AROUND THE CAR AND MY ENGINE COMPLETELY STALLED AND LOST POWER. THE TRANSMISSION LIGHT APPEARED. IT HAD BEEN RAINING ALOT AND WAS HUMID AND WET ALTHOUGH NOT ACTIVELY RAINING AT TIME OF MALFUNCTION. I DRIVE A NEW FOR…

Read full complaint

I WAS TRYING TO PASS ANOTHER CAR WHEN MY ENGINE STALLED. I WAS GOING ABOUT 45 TO 50 MPH WHEN I WENT TO ACCELERATE AROUND THE CAR AND MY ENGINE COMPLETELY STALLED AND LOST POWER. THE TRANSMISSION LIGHT APPEARED. IT HAD BEEN RAINING ALOT AND WAS HUMID AND WET ALTHOUGH NOT ACTIVELY RAINING AT TIME OF MALFUNCTION. I DRIVE A NEW FORD F150 V6 WITH ECOBOOST TECHNOLOGY. *TR

NHTSA ODI #10524765

1,600 miles · Jun 26, 2013
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE FRONT END OF THE VEHICLE BEGAN TO VIBRATE VIOLENTLY WHILE THE CONTACT WAS HAULING A CAPACITY OF OVER TWO THOUSAND POUNDS. THE MALFUNCTION RECURRED WHENEVER THE CONTACT WAS DRIVING 10 MPH OR LESS. THE VEHICLE WAS TAKEN TO AN AU…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE FRONT END OF THE VEHICLE BEGAN TO VIBRATE VIOLENTLY WHILE THE CONTACT WAS HAULING A CAPACITY OF OVER TWO THOUSAND POUNDS. THE MALFUNCTION RECURRED WHENEVER THE CONTACT WAS DRIVING 10 MPH OR LESS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 1,600.

NHTSA ODI #10521899

4,087 miles · Jun 23, 2013
Electrical SystemEnginePower Train

THIS IS THE 5TH INCIDENT WITH THE SAME PROBLEM, BUT WORST NOW. I HAD THIS TRUCK AT THE FORD DEALERSHIP ON MONDAY JUNE 17,2013. THEY SAID IT WILL BE HARD TO DIAGNOSIS WITHOUT A FAULT CODE. HOW IS IT THEY CAN TELL ME HOW FAST I HAVE BEEN DRIVING FOR THE PAST MONTH, BUT THE INBOARD COMPUTER CANNOT TELL FORD TECHNICIANS WHAT IS WRO…

Read full complaint

THIS IS THE 5TH INCIDENT WITH THE SAME PROBLEM, BUT WORST NOW. I HAD THIS TRUCK AT THE FORD DEALERSHIP ON MONDAY JUNE 17,2013. THEY SAID IT WILL BE HARD TO DIAGNOSIS WITHOUT A FAULT CODE. HOW IS IT THEY CAN TELL ME HOW FAST I HAVE BEEN DRIVING FOR THE PAST MONTH, BUT THE INBOARD COMPUTER CANNOT TELL FORD TECHNICIANS WHAT IS WRONG.THE ENGINE CUT OFF AGAIN FOR THE 5TH TIME, BUT THIS TIME IT WOULD NOT START. THE INSTRUMENT SHOWED 2 ICON'S THIS TIME, A ( WRENCH AND CHECK OIL ), I'M SORRY BUT THE WRENCH INDICATES I BELIEVE SOMETHING TO DO WITH A REAR END ON A 4 X 4 TRUCK, SORRY THIS IS ONLY A 2 WHEEL DRIVE VEHICLE. I TRIED THE ( 2 ) RECOMMENDATION IN THE INSTRUCTION BOOK AND WHEN TURNED THE IGNITION TO START IT ONLY TRIED FOR LESS THAN 3 SECONDS, THEN THE POWER TO THE IGNITION WENT BLANK. I TRIED FOR 30 MINUTES, THEN CALLED FORD ROAD SIDE ASSISTANT FOR A TOW TRUCK, WHICH WAS DISPATCHED WITHIN A HOUR. I HAD ALREADY CALLED FORD FRIDAY JUNE 21,2013 FOR AN APPOINTMENT FOR # 3 & 4 WITH THE ENGINE CUTTING OFF. I THEN CALLED SATURDAY MORNING AND ASKING THEN FOR A BETTER APPOINTMENT, THEY GAVE ME ONE FOR MONDAY 6-23,2013 INSTEAD OF TUESDAY 6-24-2013.I BADLY NEED TRANSPORTATION THIS NEXT WEEK, I'M GOING TO ASK FORD FOR AMBULANCE SERVICE THIS NEXT COMING FRIDAY JUNE 28,2013, I AM A DISABLED SENIOR VETERAN AND HAVING HIP INJECTIONS NEXT FRIDAY OUT OF TOWN AT THE VETERANS HOSPITAL AND NEED A CARE GIVER,SINCE I WON'T BE ABLE TO DRIVE AFTER THE PROCEDURE.FORD THIS IS BEGINNING TO BE A VERY SERIOUS CONDITION WHEN DRIVING AND PROBABLY CAUSE ACCIDENTS VERY SOON. LETS GET THE PROBLEM FIXED OR ORDER ME A NEW TRUCK BECAUSE OF NORTH CAROLINA LEMON LAW. *TR

NHTSA ODI #10521245

3,991 miles · Jun 21, 2013
Electrical SystemEnginePower Train

THIS IS THE 2ND TIME TODAY , I'VE HAD THIS PROBLEM AND IS THE 4TH EPISODE OF THE SAME PROBLEM. THIS IS A FLEX FUEL 2013 FORD F-150.THIS IS BEGINNING TO BE A BIG CONCERN,AS STATED I WAS ONLY GOING ABOUT 10 MPH,SINCE I WAS IN A SHOPPING CENTER GETTING READY TO PARK. THE ENGINE USUAL CRANKS AFTER I COME TO A COMPLETE START AND TURN…

Read full complaint

THIS IS THE 2ND TIME TODAY , I'VE HAD THIS PROBLEM AND IS THE 4TH EPISODE OF THE SAME PROBLEM. THIS IS A FLEX FUEL 2013 FORD F-150.THIS IS BEGINNING TO BE A BIG CONCERN,AS STATED I WAS ONLY GOING ABOUT 10 MPH,SINCE I WAS IN A SHOPPING CENTER GETTING READY TO PARK. THE ENGINE USUAL CRANKS AFTER I COME TO A COMPLETE START AND TURN THE IGNITION OFF. I NEED THIS FIXED ASAP. I'VE GOT A TRIP PLANNED. *TR

NHTSA ODI #10521143

3,970 miles · Jun 21, 2013
Electrical SystemEnginePower Train

THIS IS THE 3RD TIME THAT THIS NEW F-150 TRUCK ENGINE SUDDENLY HAS CUT OFF. I WAS AT THE FORD DEALERSHIP IN BELMONT, N.C ON MONDAY JUNE 17,2013. THEY SAID THEY COULD NOT FIND ANYTHING WRONG. THEY THEN SAID THEY PUT IN A NEW UPDATE CODE. I NOW HAVE ONLY DROVE ABOUT ANOTHER 50 MILES SINCE MONDAY. IT CUT OFF AGAIN WHILE I WAS DRI…

Read full complaint

THIS IS THE 3RD TIME THAT THIS NEW F-150 TRUCK ENGINE SUDDENLY HAS CUT OFF. I WAS AT THE FORD DEALERSHIP IN BELMONT, N.C ON MONDAY JUNE 17,2013. THEY SAID THEY COULD NOT FIND ANYTHING WRONG. THEY THEN SAID THEY PUT IN A NEW UPDATE CODE. I NOW HAVE ONLY DROVE ABOUT ANOTHER 50 MILES SINCE MONDAY. IT CUT OFF AGAIN WHILE I WAS DRIVING ABOUT 30 MPH ON A BUSY CHARLOTTE, NC STREET. I THOUGHT MY NUCKLES WERE GOING TO PART SINCE I HAD TO CONTROL THE VEHICLE AND NOT CAUSE AN ACCIDENT. I AM SCHEDULE TO TAKE IN BACK TO KEITH HAWTHORNE FORD ON TUESDAY, JUNE 25,2013--THERE PHONE NUMBER 704-825-5186-SERVICE PERSON- WILL *TR

NHTSA ODI #10521075

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of