← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
66,700 miles · Jul 7, 2016
Power Train

WHILE DRIVING THE VEHICLE AT 50MPH THE TRUCK SUDDENLY SHIFTED FROM 5TH GEAR TO 1ST GEAR CAUSING THE REAR WHEELS TO LOOSE TRACTION AND LOSS OF CONTROL INTO ON COMING CARS IN A TURN LANE. AFTER A FEW SECONDS NOTICING THE RPM'S REACHED 6800 THE TRUCK SHIFTED TO 3RD GEAR AND I WAS ABLE TO AVOID IMPACT. NO TROUBLE LIGHTS OR ANY IND…

Read full complaint

WHILE DRIVING THE VEHICLE AT 50MPH THE TRUCK SUDDENLY SHIFTED FROM 5TH GEAR TO 1ST GEAR CAUSING THE REAR WHEELS TO LOOSE TRACTION AND LOSS OF CONTROL INTO ON COMING CARS IN A TURN LANE. AFTER A FEW SECONDS NOTICING THE RPM'S REACHED 6800 THE TRUCK SHIFTED TO 3RD GEAR AND I WAS ABLE TO AVOID IMPACT. NO TROUBLE LIGHTS OR ANY INDICATIONS WERE GIVEN. I'M FILING A COMPLAINT TO SEE IF ANY OTHER OWNERS OF THIS YEAR TRUCK ARE HAVING THIS PROBLEM. THERE IS A RECALL 16S19 FOR 2011-2012 FORD TRUCKS BUT WHEN ASKING FORD ABOUT MY 2013 DOING THE SAME THING I GET SHUNNED. THE DAMAGE CAUSED BY THE DOWN SHIFT HAS RESULTED IN THE TRUCK NEEDING A COMPLETE NEW TRANSMISSION WHICH WAS STATED BY FORD'S FIELD SERVICE REP. MY TRUCK HAS BEEN SITTING AT THE DEALER SINCE APRIL 18TH AND IS STILL NOT DRIVABLE AFTER 2 DIFFERENT ATTEMPTS TO FIXING THE PROBLEM.

NHTSA ODI #10883292

104,100 miles · Jun 25, 2016
Fuel System, GasolinePower Train

THROTTLE WAS COMPLETELY LOST. TRUCK WOULD ONLY RUN AROUND 5 MPH MAXIMUM. WOULD NOT TAKE THROTTLE AT ALL. THIS IS A VERY DANGEROUS CONDITION WHEN IN A HIGH TRAFFIC AND MULTI LANE SETTING WHERE ALL THE OTHER VEHICLES ARE RUNNING AT HIGH SPEEDS. IT IS ALSO VERY DANGEROUS WHEN PULLING A 7000 LB TRAILER WITH NO OR EXTREMELY LIMIT…

Read full complaint

THROTTLE WAS COMPLETELY LOST. TRUCK WOULD ONLY RUN AROUND 5 MPH MAXIMUM. WOULD NOT TAKE THROTTLE AT ALL. THIS IS A VERY DANGEROUS CONDITION WHEN IN A HIGH TRAFFIC AND MULTI LANE SETTING WHERE ALL THE OTHER VEHICLES ARE RUNNING AT HIGH SPEEDS. IT IS ALSO VERY DANGEROUS WHEN PULLING A 7000 LB TRAILER WITH NO OR EXTREMELY LIMITED PULL OFFS FOR EMERGENCIES SUCH AS THIS. IT CREATES A VERY REAL POSSIBILITY OF DEATH. THIS OCCURRED ON A LOCAL ROAD IN FITZGERALD, GA TRAVELING STRAIGHT WITH LIGHT TRAFFIC CONDITIONS FORTUNATELY. I DROVE THE TRUCK IN TO FITZGERALD FORD FROM ABOUT 3 TO 4 MILES AWAY AT THE ABOVE MENTIONED SPEED. THE DEALERSHIP DIAGNOSED THE PROBLEM AS A FAULTY THROTTLE BODY, AND IT WAS REPLACED AT A COST TO ME OF $248.12. MY WIFE'S CAR ALSO HAD THIS PROBLEM WITH THE EXACT SAME PART. IT WAS REPLACED BY THE SAME DEALERSHIP AND PAID FOR BY US. MY WIFE [XXX] SUBSEQUENTLY RECEIVED CORRESPONDENCE FROM FORD THAT INDICATED THE THROTTLE BODY WARRANTY HAD BEEN EXTENDED, AND THAT COST THAT WE PREVIOUSLY PAID WAS REFUNDED TO US. HER CAR WHICH WE STILL OWN IS A 2010 FORD FUSION SEL. THE VIN IS [XXX]. THE INCIDENT WITH MY TRUCK OCCURRED YESTERDAY, JUNE 24, 2016. THE DIAGNOSIS, REPAIR AND PAYMENT FOR THE REPAIR ALSO TOOK PLACE YESTERDAY. IS THERE ANY DIFFERENCE BETWEEN THE EXTENSION OF THE CAR THROTTLE BODY WARRANTY AND THE TRUCK? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10876560

50,000 miles · Jun 22, 2016
Power Train

I WAS PARKED ON A INCLINE WITH THE ENGINE OFF AND THE TRANSMISSION IN DRIVE. I WENT TO STEP OUT OF THE VEHICLE WHEN IT STARTED TO ROLL BACKWARDS. THE TRUCK WAS ROLLING BACKWARDS AND THE DOOR WAS PUSHING ME DOWN THE HILL WITH IT. LUCKILY I WAS ABLE TO GET BACK IN THE TRUCK AND STOP THE VEHICLE. ANOTHER TIME I WAS PARKED IN A PARK…

Read full complaint

I WAS PARKED ON A INCLINE WITH THE ENGINE OFF AND THE TRANSMISSION IN DRIVE. I WENT TO STEP OUT OF THE VEHICLE WHEN IT STARTED TO ROLL BACKWARDS. THE TRUCK WAS ROLLING BACKWARDS AND THE DOOR WAS PUSHING ME DOWN THE HILL WITH IT. LUCKILY I WAS ABLE TO GET BACK IN THE TRUCK AND STOP THE VEHICLE. ANOTHER TIME I WAS PARKED IN A PARKING LOT WITH THE ENGINE OFF AND THE TRANSMISSION IN DRIVE AND AFTER AWHILE THE VEHICLE STARTED TO ROLL FORWARD. AFTER BOTH INCIDENTS I ASKED MY FORD DEALER AND THEY STATED THAT IT WAS NORMAL FOR THE TRUCK TO ROLL WHEN THE TRANSMISSION WAS IN DRIVE. THE FIRST TIME I COULD'VE BEEN SERIOUSLY HURT AND THE SECOND TIME SOMEONE IN THE PARKING LOT COULD'VE BEEN SERIOUSLY HURT.

NHTSA ODI #10875786

49,060 miles · Jun 9, 2016
Power TrainSteering

WHEN I TURN ON AND PLACE THE TRUCK IN DRIVE, MY STEERING WHEEL LOCKS UP TO WHERE I CANT USE STEERING WHEEL, I GET A ERROR ON DASH STATING "ASSIST POWER STEERING FAILURE. I PLACE TRUCK IN PARK AND TURN VEHICLE OFF, AND RESTART AND PROBLEM SEEMS FINE, UNTIL STEERING WHEEL LOCKS UP WHILE DRIVING AND I GET THIS SAME ERROR. FORD DEAL…

Read full complaint

WHEN I TURN ON AND PLACE THE TRUCK IN DRIVE, MY STEERING WHEEL LOCKS UP TO WHERE I CANT USE STEERING WHEEL, I GET A ERROR ON DASH STATING "ASSIST POWER STEERING FAILURE. I PLACE TRUCK IN PARK AND TURN VEHICLE OFF, AND RESTART AND PROBLEM SEEMS FINE, UNTIL STEERING WHEEL LOCKS UP WHILE DRIVING AND I GET THIS SAME ERROR. FORD DEALER IS CHARGING ME $2000 TO FIX THIS PROBLEM. THIS COULD CAUSE A MAJOR CRASH. I BELIEVE FORD SHOULD HAVE THIS RECALLED AND PAY FOR THIS.

NHTSA ODI #10873343

42,000 miles · Jun 6, 2016
Power Train

WHILE ACCELERATING TO MERGE INTO TRAFFIC ON THE INTERSTATE THE TRUCK SHUTTERED VIOLENTLY AND LOST ALL POWER TO THE DRIVE TRAIN. MOTOR WAS STILL RUNNING BUT TRANSMISSION WOULD NOT ENGAGE FOR APPROXIMATELY 10-15 SECONDS. TAPPED ACCELERATOR 2 TIMES AND MOTOR WOULD REV UP BUT TRANSMISSION DID NOT ENGAGE AGAIN UNTIL THIRD ATTEMPT. …

Read full complaint

WHILE ACCELERATING TO MERGE INTO TRAFFIC ON THE INTERSTATE THE TRUCK SHUTTERED VIOLENTLY AND LOST ALL POWER TO THE DRIVE TRAIN. MOTOR WAS STILL RUNNING BUT TRANSMISSION WOULD NOT ENGAGE FOR APPROXIMATELY 10-15 SECONDS. TAPPED ACCELERATOR 2 TIMES AND MOTOR WOULD REV UP BUT TRANSMISSION DID NOT ENGAGE AGAIN UNTIL THIRD ATTEMPT. I HAVE MY TRUCK SERVICED REGULARLY, THIS IS NOT A LOW TRANSMISSION FLUID ISSUE AND SEEMS TO BE THE SAME ISSUE REPORTED BY OTHER F150 OWNERS ACROSS THE COUNTRY. THIS IS A SAFETY ISSUE, I WAS ALMOST HIT IN THE REAR AFTER THIS HAPPENED. THE SERVICE LIGHT CAME ON WHEN THIS ISSUE OCCURRED; HOWEVER, AFTER GOING TO THE DEALER AND SHUTTING THE ENGINE OFF THE SERVICE LIGHT DID NOT REAPPEAR WHEN STARTED AGAIN.

NHTSA ODI #10872701

32,000 miles · May 17, 2016
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 35 MPH, THE TRANSMISSION DOWNSHIFTED INDEPENDENTLY AND THE RPMS INCREASED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT COULD NOT BE DIAGNOSED OR DUPLICATED. THE MANUFACTURER WAS NO…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 35 MPH, THE TRANSMISSION DOWNSHIFTED INDEPENDENTLY AND THE RPMS INCREASED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT COULD NOT BE DIAGNOSED OR DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. UPDATED 07/14/16*LJ THE CONSUMER STATED THE TRANSMISSION/COMPUTER WAS REPROGRAMMED BY THE DEALER. THE PROBLEM RECURRED SEVERAL TIMES. UPDATED 07/19/16. *JB

NHTSA ODI #10865343

28,000 miles · May 16, 2016
Power Train

VEHICLES HAS SEVERAL TIMES AFTER BEING AT A STOP, VEHICLE WILL NOT ENGAGE TRANSMISSION. VEHICLE WILL ACCELERATE ENGINE RPM'S, BUT IS LIKE IT IS NEUTRAL AND SPEEDOMETER GOES TO 0. VEHICLE WILL ROLL, BUT STOPS IN MIDDLE OF ROAD, INTERSECTION OR SHOULDER IF ENOUGH SPEED BEFORE IT STOPS. BROUGHT VEHICLE IN 2 TIMES AND KINSEL FORD DE…

Read full complaint

VEHICLES HAS SEVERAL TIMES AFTER BEING AT A STOP, VEHICLE WILL NOT ENGAGE TRANSMISSION. VEHICLE WILL ACCELERATE ENGINE RPM'S, BUT IS LIKE IT IS NEUTRAL AND SPEEDOMETER GOES TO 0. VEHICLE WILL ROLL, BUT STOPS IN MIDDLE OF ROAD, INTERSECTION OR SHOULDER IF ENOUGH SPEED BEFORE IT STOPS. BROUGHT VEHICLE IN 2 TIMES AND KINSEL FORD DEALERSHIP CAN'T GET IT DUPLICATE PROBLEM. CALLED FORD MOTOR AND THEY TOLD ME THEY CAN'T HELP ME UNTIL A CERTIFIED TECHNICIAN SEES IT. WAS TOLD I NEED TO DRIVE VEHICLE UNTIL IT DOES THIS AGAIN AND CALL ROADSIDE ASSISTANCE AND DON'T RESTART SO CODES WON'T CLEAR. I FEEL THIS WAS UNSAFE BECAUSE VEHICLE CAN STALL IN A INTERSECTION AND CAUSE A CAUSE A WRECK. FORD TOLD ME THEY COULDN'T HELP ME UNTIL THEY COULD ACTUALLY SEE THIS PROVE. I HAVE TO HAVE A VEHICLE AND DRIVE IT UNTIL IT DOES IT SO I CAN GET THIS FIXED.

NHTSA ODI #10865145

40,600 miles · May 12, 2016
Power Train

TRUCK SHIFTS UP & DOWN BY SELF. JERKS HARD WHEN SHIFTING. WHEN STOPPED SPEEDO GOES TO 30 TO 50 AND SHOWS IN 3RD GEAR. AT START IN THIS SITUATION IT JUMPS VIOLENTLY FORWARD. WHEN TRYING TO MERGE WITH TRAFFIC WILL NOT SHIFT OUT OF 1ST GEAR. RESTART AND TAKE BACK ROADS AS IT IS NOT SAFE IN TRAFFIC OR WHERE THERE ARE PEDESTRIANS AT …

Read full complaint

TRUCK SHIFTS UP & DOWN BY SELF. JERKS HARD WHEN SHIFTING. WHEN STOPPED SPEEDO GOES TO 30 TO 50 AND SHOWS IN 3RD GEAR. AT START IN THIS SITUATION IT JUMPS VIOLENTLY FORWARD. WHEN TRYING TO MERGE WITH TRAFFIC WILL NOT SHIFT OUT OF 1ST GEAR. RESTART AND TAKE BACK ROADS AS IT IS NOT SAFE IN TRAFFIC OR WHERE THERE ARE PEDESTRIANS AT A CROSS WALK. PHIL LONG FORD DENVER IS WAITING TO HEAR FROM FORD. FORD HAS STARTED A CASE REPORT ON THIS VEHICLE BUT HAS NOT RESPONDED. I AM CONCERNED THIS IS A BIG SAFETY PROBLEM. THIS APPEARS TO HAPPEN WHEN THE TRANSMISSION TEMPERATURE GOES UP OVER 200 DEGREES F. THE PROBLEMS HAPPEN WHILE STOPPED, STOPPING, STARTING HIGHWAYS OR SECONDARY ROADS, THIS HAPPENED 2 TIMES WITHIN THE LAST MONTH.

NHTSA ODI #10864560

77,000 miles · May 4, 2016
Power Train

WHILE DRIVING 75 MPH THE TRANSMISSION DROPPED INTO A LOW GEAR ENOUGH TO MAKE THE TIRES BARK, THEN WITHIN SECONDS WHILE ASSESSING WHAT HAPPENED IT HAPPENED AGAIN. I PUT THE VEHICLE IN NEUTRAL AND COASTED TO THE SHOULDER. IF A CAR HAD BEEN FOLLOWING WITHIN 3 OR 4 CAR LENGTHS THERE WOULD HAVE BEEN A COLLISION. THE ACTION WAS SEVERE…

Read full complaint

WHILE DRIVING 75 MPH THE TRANSMISSION DROPPED INTO A LOW GEAR ENOUGH TO MAKE THE TIRES BARK, THEN WITHIN SECONDS WHILE ASSESSING WHAT HAPPENED IT HAPPENED AGAIN. I PUT THE VEHICLE IN NEUTRAL AND COASTED TO THE SHOULDER. IF A CAR HAD BEEN FOLLOWING WITHIN 3 OR 4 CAR LENGTHS THERE WOULD HAVE BEEN A COLLISION. THE ACTION WAS SEVERE AND ABRUPT. THE MOTOR NEVER SHUT OFF, BUT THE TRANSMISSION SHIFTED INTO A LOWER GEAR TWICE BEFORE I WAS ABLE TO PUT IT IN NEUTRAL AND WORK MY WAY TO THE SHOULDER.

NHTSA ODI #10862932

34,000 miles · Apr 7, 2016
EnginePower TrainVehicle Speed Control

MY TRUCK HAS BEEN EXPERIENCING HESITATION UPON ACELLERATION AND IS MAKING NOISES AND MY CHECK ENGINE LIGHT WAS ON. I TOOK IT TO THE DEALERSHIP ON FEBRUARY 2, 2016 BE FIXED AND AT FIRST IT WAS COVERED UNDER WARRANTY. I TOOK IT BACK ON FEBRUARY 16, 2016 BC I HAD TO HAVE A FORD RENTAL PER FORD. THE TRUCK WAS REPAIRED BUT THEN IT W…

Read full complaint

MY TRUCK HAS BEEN EXPERIENCING HESITATION UPON ACELLERATION AND IS MAKING NOISES AND MY CHECK ENGINE LIGHT WAS ON. I TOOK IT TO THE DEALERSHIP ON FEBRUARY 2, 2016 BE FIXED AND AT FIRST IT WAS COVERED UNDER WARRANTY. I TOOK IT BACK ON FEBRUARY 16, 2016 BC I HAD TO HAVE A FORD RENTAL PER FORD. THE TRUCK WAS REPAIRED BUT THEN IT WASN'T COVERED PER FORD AND I HAD TO PAY OVER $400 TO GET IT FIXED. MY CHECK ENGINE LIGHT CAME ON AGAIN AND IT HAD TO GO BACK TO THE DEALERSHIP BUT THIS TIME IT WAS COVERED UNDER WARRANTY. I JUST GOT MY TRUCK BACK ON APRIL 11,2016 AND TODAY ON APRIL 14, 2016 THE LIGHT IS BACK ON. I AM WAITING ON A CALL BACK FROM THE FORD DEALERSHIP TO FIND OUT WHAT TO DO NEXT.

NHTSA ODI #10853995

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of