← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
97,000 miles · Feb 8, 2018
Power Train

WHILE DRIVING ON THE HIGHWAY, THE REAR AXEL BROKE AT THE WELD. WE WERE ABLE TO GET OFF THE HIGHWAY SAFELY AND TO A BRAKE MATERS. WE WERE TOLD THAT THIS SHOULD NOT HAVE HAPPENED AND THAT IT WAS A DEFECT IN THE WELDING. WE HAD FORD TOW IT TO BELL FORD IN PHOENIX AND CONTACTED FORD CORPORATE TO REQUEST AN INVESTIGATION. FORD IGNORE…

Read full complaint

WHILE DRIVING ON THE HIGHWAY, THE REAR AXEL BROKE AT THE WELD. WE WERE ABLE TO GET OFF THE HIGHWAY SAFELY AND TO A BRAKE MATERS. WE WERE TOLD THAT THIS SHOULD NOT HAVE HAPPENED AND THAT IT WAS A DEFECT IN THE WELDING. WE HAD FORD TOW IT TO BELL FORD IN PHOENIX AND CONTACTED FORD CORPORATE TO REQUEST AN INVESTIGATION. FORD IGNORED OUR CLAIM AND CLOSED IT OUT, WITHOUT EVEN DOING AN INVESTIGATION. THE SERVICE DEPT AT BELL FORD PROVIDED HORRIBLE CUSTOMER SERVICE AND DID NOTHING TO ASSIST US WITH OUR CLAIM EITHER. WE HAD THE VEHICLE TOWED ELSEWHERE TO BE FIXED, AS WE COULD NOT AFFORD THE $2,700.00 BELL FORD WANTED TO CHARGE US.

NHTSA ODI #11071694

84,000 miles · Feb 6, 2018
Power Train

'ERRACTIC SHIFTING' THREE TIMES I WAS DRIVING AT 50 TO 60 MILES PER HOUR AND SUDDENLY THE ERRATIC SHIFTING (TRUCK DOWN SHIFT WITH ANY WARNING) AND THE REAR TIRES LOCKED UP IMMEDIATELY. (WHEN THIS HAPPENS THE SPEEDOMETER AND THE RPM IS ERRACTIC TOO) IT IS TOO DANGEROUS IF ANOTHER CAR WOULD HAVE COME NEAR ME WOULD HAVE CRASHED. …

Read full complaint

'ERRACTIC SHIFTING' THREE TIMES I WAS DRIVING AT 50 TO 60 MILES PER HOUR AND SUDDENLY THE ERRATIC SHIFTING (TRUCK DOWN SHIFT WITH ANY WARNING) AND THE REAR TIRES LOCKED UP IMMEDIATELY. (WHEN THIS HAPPENS THE SPEEDOMETER AND THE RPM IS ERRACTIC TOO) IT IS TOO DANGEROUS IF ANOTHER CAR WOULD HAVE COME NEAR ME WOULD HAVE CRASHED. THESE TIMES I HAD TIME TO PUT THE EMERGENCY LIGHTS. TURN OFF THE TRUCK AND TURN IT ON AGAIN, (SOMETHIMES YOU HAVE TO DO IT SEVERAL TIMES TO MAKE THE TRUCK WORK AGAIN) AND ANOTHER PROBLEM IS SOMETHIMES THE GEAR NOT ENGAGE, THE ENGINE REVS BUT IT RUNS ALMOST NOTHING) DON'T FEEL SAFE DRIVING THIS TRUCK.

NHTSA ODI #11067334

75,000 miles · Feb 6, 2018
Power Train

INITIAL START OFF STARTS IN 5TH GEAR 50% OF THE TIME. THE ONLY WAY TO GET IT BACK TO 1ST IS TO SHUT THE TRUCK OFF, THIS USUALLY TAKES SEVERAL IGNITION CYCLES TO CORRECT THE ISSUE. ERRATIC SHIFTING THROUGHOUT DRIVING THE VEHICLE 100% OF THE TIME. THE VEHICLE SHIFTS BETWEEN 6TH AND 4TH FOR NO REASON DURING A NORMAL DRIVE ON …

Read full complaint

INITIAL START OFF STARTS IN 5TH GEAR 50% OF THE TIME. THE ONLY WAY TO GET IT BACK TO 1ST IS TO SHUT THE TRUCK OFF, THIS USUALLY TAKES SEVERAL IGNITION CYCLES TO CORRECT THE ISSUE. ERRATIC SHIFTING THROUGHOUT DRIVING THE VEHICLE 100% OF THE TIME. THE VEHICLE SHIFTS BETWEEN 6TH AND 4TH FOR NO REASON DURING A NORMAL DRIVE ON THE INTERSTATE 75% OF OPERATION. HARD DOWN SHIFTING AT SPEEDS ABOVE 50MPH. OFTEN WHILE GOING DOWN THE INTERSTATE AT OVER 50MPH THE TRUCK WILL SHIFT INTO 1ST OR 2ND LOCKING UP THE TIRES. THE ONLY WAY TO GET IT OUT OF THE LOWER GEAR IS TO SHUT THE CAR OFF AND TURN IT ON. I HAVE SLID SIDEWAYS ON THE HIGHWAY AND ALMOST BEEN HIT IN THE BACK SEVERAL TIMES. THE DEALERSHIP I PURCHASED THE TRUCK FROM WILL NOT EVEN TOUCH THE VEHICLE FOR LESS THAN $115 FOR A DIAGNOSTICS FEE. THEY SAID IF IT IS THE TSB13-04-09 AS THEY SUSPECT IT WILL BE $1,029.00 TO REPAIR IN ADDITION TO THE DIAGNOSTICS FEE. A LOCAL TRANSMISSION FACILITY HAS QUOTED $615.00 TO REPAIR. I HAVE ALMOST WRECKED SEVERAL TIMES AND HAVE HAD TO STOP THE TRAFFIC ON THE INTERSTATE AT LEAST ONCE A WEEK, MOST OF THE TIME TWICE A WEEK. THIS TOO IS DANGEROUS FOR NOT ONLY ME BUT THE ENTIRE INTERSTATE AS THE TRAFFIC HALTS DUE TO THE FORD TRANSMISSION. I HAVE VIDEO OF THE TRANSMISSION SHIFTING DOWN AND UP SHIFTING.

NHTSA ODI #11067213

59,000 miles · Feb 2, 2018
Power Train

JUST UNDER 60K MILES AND TRUCK JUMPS GEAR AT RANDOM FROM 1ST TO 5TH WHILE COMING TO A STOP OR WHILE AT A STOP AND VICE VERA WHILE ACCELERATING THROUGH 4TH-5TH GEARS THE TRUCK WILL DROP INTO 1ST GEAR RESULTING IN A TEMPORARY LOSS OF CONTROL. HAD IT HAPPEN TO ME 6 TIMES OVER SEVERAL WEEKS UNTIL THE DEALERSHIP WAS ABLE TO DIAGNOSE …

Read full complaint

JUST UNDER 60K MILES AND TRUCK JUMPS GEAR AT RANDOM FROM 1ST TO 5TH WHILE COMING TO A STOP OR WHILE AT A STOP AND VICE VERA WHILE ACCELERATING THROUGH 4TH-5TH GEARS THE TRUCK WILL DROP INTO 1ST GEAR RESULTING IN A TEMPORARY LOSS OF CONTROL. HAD IT HAPPEN TO ME 6 TIMES OVER SEVERAL WEEKS UNTIL THE DEALERSHIP WAS ABLE TO DIAGNOSE AND OBTAIN THE MOLDED LEAD FRAME TO REPLACE. TWICE WHILE ON A CITY STREET AT A STOP SIGN MAKING AN UPHILL TURN, SEVERAL TIMES WHILE ATTEMPTING TO EXIT A PARKING LOT. FORD HAS ACKNOWLEDGED THIS PROBLEM BY ISSUING A RECALL FOR 2011-2012 F150S AND ISSUING A TSB FOR 2013S BUT WILL NOT INCLUDE 2013S AS PART OF THE RECALL. THESE RECALLS INCLUDE # 16N02 AND #12C23. THIS ISSUE WAS AN EXPENSE OF NEARLY $500 TO ME, FORTUNATELY IT DID NOT CAUSE AN ACCIDENT AND COST A LOT MORE. FORD'S RESPONSE TO ME WAS TO KEEP MY RECEIPTS IN CASE THY ADD 2013S TO THE RECALL LIST I MAY THEN BE REIMBURSED. UNSAFE AND UNFORTUNATE!

NHTSA ODI #11066667

37,000 miles · Jan 30, 2018
Power Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 60 MPH, THE TRANSMISSION MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE SWITCHED FROM SIXTH GEAR TO FIRST GEAR AT ONCE, WHICH CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE. OCCASIONALLY, WHILE THE VEHI…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 60 MPH, THE TRANSMISSION MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE SWITCHED FROM SIXTH GEAR TO FIRST GEAR AT ONCE, WHICH CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE. OCCASIONALLY, WHILE THE VEHICLE WAS STATIONARY, IT WOULD NOT ACCELERATE FORWARD. CROWN FORD IN FAYETTEVILLE, NORTH CAROLINA WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THERE WAS NO RECALLS ON THE VEHICLE. THE FAILURE MILEAGE WAS 37,000.

NHTSA ODI #11065875

66,800 miles · Jan 30, 2018
Power Train

TRANSMISSION DOWN SHIFTS ERRATICALLY AND SOMETIMES WILL NOT ENGAGE WHILE DOWNSHIFTING. TRYING TO SHIFT MANUALLY WHILE VEHICLE IS MOVING WILL NOT FIX THE ISSUE. TWICE THIS HAS HAPPENED WHILE ENTERING TRAFFIC BUT BOTH TIMES I WAS ABLE TO PULL OVER, TURN THE TRUCK OFF, PUT THE TRANSMISSION IN THE PARK POSITION AND RESTART THE TRUC…

Read full complaint

TRANSMISSION DOWN SHIFTS ERRATICALLY AND SOMETIMES WILL NOT ENGAGE WHILE DOWNSHIFTING. TRYING TO SHIFT MANUALLY WHILE VEHICLE IS MOVING WILL NOT FIX THE ISSUE. TWICE THIS HAS HAPPENED WHILE ENTERING TRAFFIC BUT BOTH TIMES I WAS ABLE TO PULL OVER, TURN THE TRUCK OFF, PUT THE TRANSMISSION IN THE PARK POSITION AND RESTART THE TRUCK, FIXING THE PROBLEM. VEHICLE IS IN THE SHOP TODAY FOR AN $800 REPAIR THAT IS NOT COVERED BY WARRANTY AND WAS TOLD THAT FORD HAS ISSUED A BULLETIN FOR THIS BUT WILL NOT ASSUME THE COST OF THE REPAIR.

NHTSA ODI #11065835

41,000 miles · Jan 29, 2018
Power Train

I HAVE HAD SEVERAL OCCASIONS WHERE THE VEHICLE APPEARED TO SLIP INTO A LOWER GEAR. AT LOW TO NORMAL SPEED, THIS CAUSED WHEEL SPIN AND TIRE SCREECHING. IN ADDITION, THE TRANSMISSION SEEMED SLUGGISH UPON THE OCCURRENCE AND RESISTED A RESPONSE FROM THE ACCELERATOR. THESE OCCURRENCES ALL HAPPENED IN CITY STREET DRIVING AT LOW TO …

Read full complaint

I HAVE HAD SEVERAL OCCASIONS WHERE THE VEHICLE APPEARED TO SLIP INTO A LOWER GEAR. AT LOW TO NORMAL SPEED, THIS CAUSED WHEEL SPIN AND TIRE SCREECHING. IN ADDITION, THE TRANSMISSION SEEMED SLUGGISH UPON THE OCCURRENCE AND RESISTED A RESPONSE FROM THE ACCELERATOR. THESE OCCURRENCES ALL HAPPENED IN CITY STREET DRIVING AT LOW TO MODERATE SPEEDS WHILE THE VEHICLE WAS IN MOTION

NHTSA ODI #11065707

55,000 miles · Jan 26, 2018
Power Train

UPON ACCELERATION, GENERALLY FROM A STOP, THE VEHICLE WILL, THUD, LOSE POWER AND CEASE TO ACCELERATE DESPITE PEDAL BEING PUSHED. IT ALSO TENDS TO BE ACCOMPANIED BY THE SPEEDOMETER JUMPING. NO WARNINGS OR MESSAGES ARE DISPLAYED IN THE VEHICLE. AFTER PRESSING THE PEDAL SEVERAL TIMES AND NEARLY ROLLING TO A STOP, CONTROL OVER ACC…

Read full complaint

UPON ACCELERATION, GENERALLY FROM A STOP, THE VEHICLE WILL, THUD, LOSE POWER AND CEASE TO ACCELERATE DESPITE PEDAL BEING PUSHED. IT ALSO TENDS TO BE ACCOMPANIED BY THE SPEEDOMETER JUMPING. NO WARNINGS OR MESSAGES ARE DISPLAYED IN THE VEHICLE. AFTER PRESSING THE PEDAL SEVERAL TIMES AND NEARLY ROLLING TO A STOP, CONTROL OVER ACCELERATION WILL EVENTUALLY RESUME. THE LOSS OF CONTROL OVER ACCELERATION CAUSES A SAFETY RISK, ESPECIALLY WHEN PULLING OUT INTO TRAFFIC. THIS ISSUE DOES NOT OCCUR CONSISTENTLY, BUT WAS HAPPENING WITH SOME REGULARITY APPROXIMATELY 1 MONTH AGO AS WELL.

NHTSA ODI #11065291

118,000 miles · Jan 25, 2018
Power Train

TRUCK HAS LEAKING RADIATOR HOSES. WENT TO LOCAL FORD DEALERSHIP FOR REPLACEMENT PARTS. WAS TOLD THAT I AM NUMBER 70 IN LINE FOR THOSE PARTS. RADIATOR FLUID ALWAYS LOW, CONSTANTLY REFILLING IT. THIS IS DANGEROUS DUE TO THE AMOUNT OF FLUID THAT LEAKS OUT ON A DAILY BASIS. VERY NERVOUS ABOUT DRIVING TRUCK, FEAR THAT IT MAY BRE…

Read full complaint

TRUCK HAS LEAKING RADIATOR HOSES. WENT TO LOCAL FORD DEALERSHIP FOR REPLACEMENT PARTS. WAS TOLD THAT I AM NUMBER 70 IN LINE FOR THOSE PARTS. RADIATOR FLUID ALWAYS LOW, CONSTANTLY REFILLING IT. THIS IS DANGEROUS DUE TO THE AMOUNT OF FLUID THAT LEAKS OUT ON A DAILY BASIS. VERY NERVOUS ABOUT DRIVING TRUCK, FEAR THAT IT MAY BREAKDOWN ON ME AND LEAVE ME STRANDED ON SIDE OF ROAD. CONCERNED ABOUT THE BACKLOG AND WAITING SO LONG FOR PARTS. IS THIS A PROBLEM WITH ALL F150 RADIATOR HOSES, AND IF SO SHOULDN'T FORD ISSUE A RECALL AND FIX THE PROBLEM. I AM WORRIED T4HAT I AM GOING TO BREAKDOWN ON THE SIDE OF A ROAD LATE AT NIGHT IN 0' WEATHER AND TRY TO FIND A TOWN TRUCK. I ONLY HAVE ONE VEHICLE AND NOT ABLE TO RENT A CAR FOR SEVERAL WEEKS WHILE MY GARAGE WAITS FOR THE PARTS.

NHTSA ODI #11064853

48,000 miles · Jan 21, 2018
Power Train

IN THE LAST COUPLE OF WEEKS THE TRANSMISSION IS SHIFTING ERRATICALLY, LAST WEEK IT SHIFTED FROM 1ST TO 5TH, TRUCK WENT LIMP HAD TO STOP IN THE MIDDLE OF THE ROAD DUE TO LOSS OF POWER SHIFT INTO NEUTRAL AND GO BACK TO D. TODAY WHILE DRIVING ON THE HIGHWAY THE TRANMISSION SHIFTED DOWN TO 1ST GEAR CAUSING THE TRUCK TO SKID DUE TO T…

Read full complaint

IN THE LAST COUPLE OF WEEKS THE TRANSMISSION IS SHIFTING ERRATICALLY, LAST WEEK IT SHIFTED FROM 1ST TO 5TH, TRUCK WENT LIMP HAD TO STOP IN THE MIDDLE OF THE ROAD DUE TO LOSS OF POWER SHIFT INTO NEUTRAL AND GO BACK TO D. TODAY WHILE DRIVING ON THE HIGHWAY THE TRANMISSION SHIFTED DOWN TO 1ST GEAR CAUSING THE TRUCK TO SKID DUE TO THE SUDDEN DOWNSHIFT WHILE I WAS AT AROUND 50MPH. MIND YOU I WAS JUST GETTING ON THE HIGHWAY WHEN THIS HAPPENED NEEDLESS TO SAY IT WAS SCARY. I HAD PULL INTO THE SHOULDER TO REGROUP MYSELF, TURN THE VEHICLE OFF AND THEN GET ON THE ROAD AGAIN.

NHTSA ODI #11063944

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of