← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Power Train complaints

1,335 reports
Clear category filter
112,000 miles · Dec 20, 2018
Power Train

TRUCK ERRATICALLY SHIFTED TO FIRST GEAR WHILE TRAVELING AT 55MPH CAUSING REAR WHEELS TO LOCK UP AS IF I SLAMMED ON MY BRAKES. THERE IS A LARGE WRENCH ICON ON THE DISPLAY WHICH CAUSES THE SPEEDOMETER TO READ 0 MPH WHILE THE VEHICLE IS IN MOTION AND ODOMETER READING IS DASHES "-------.--" TRUCK WILL ALSO GET STUCK IN FIRST GEAR WH…

Read full complaint

TRUCK ERRATICALLY SHIFTED TO FIRST GEAR WHILE TRAVELING AT 55MPH CAUSING REAR WHEELS TO LOCK UP AS IF I SLAMMED ON MY BRAKES. THERE IS A LARGE WRENCH ICON ON THE DISPLAY WHICH CAUSES THE SPEEDOMETER TO READ 0 MPH WHILE THE VEHICLE IS IN MOTION AND ODOMETER READING IS DASHES "-------.--" TRUCK WILL ALSO GET STUCK IN FIRST GEAR WHILE ACCELERATING FROM A STOP WHICH NEARLY CAUSED ME TO BE INVOLVED IN AN ACCIDENT BECAUSE I COULD NOT ACCELERATE AS I WAS EXPECTING TO. TRUCK WILL ALSO GET STUCK IN FIFTH GEAR WHILE AT A STOP. DASHES AND WRENCH CLEAR WHEN TRUCK IS SHUT DOWN AND RESTARTED. ERRATIC BEHAVIOR IS COMPLETELY RANDOM AND MAKES ME FEEL COMPLETELY UNSAFE DRIVING MY VEHICLE.

NHTSA ODI #11162619

49,450 miles · Dec 19, 2018
Power Train

IN FEB 2018 TRUCK BEGAN RANDOM HARD SHIFT AND LOSS OF POWER WHEN TAKING OFF FROM A LIGHT, NO CHECK ENGINE LIGHT. IN AUGUST 2018 AT 70 MPH, HAD A MOMENTARY LOCK UP OF REAR WHEEL, CAUSING THE WHEELS TO CHIRP ON THE ROAD AND RELEASE, SLOWED TO A STOP, PLACED IN NUETRAL NO CHECK ENGINE LIGHT ALL SEEMED NORMAL. ACCELERATED TO 65 MPH …

Read full complaint

IN FEB 2018 TRUCK BEGAN RANDOM HARD SHIFT AND LOSS OF POWER WHEN TAKING OFF FROM A LIGHT, NO CHECK ENGINE LIGHT. IN AUGUST 2018 AT 70 MPH, HAD A MOMENTARY LOCK UP OF REAR WHEEL, CAUSING THE WHEELS TO CHIRP ON THE ROAD AND RELEASE, SLOWED TO A STOP, PLACED IN NUETRAL NO CHECK ENGINE LIGHT ALL SEEMED NORMAL. ACCELERATED TO 65 MPH AT STEADY SPEED OBSERVED SPEEDOMETER INDICATION MOMENTARILY DROP TO 50 MPH AND BACK TO 60 MPH, SHORTLY AFTER THE FUEL ECONOMY ON THE COMPUTER AVERAGE DROP FROM 18.5 MPG TO 17.5 MPG. NO CHECK ENGINE LIGHT. IN DECEMBER 2018 AFTER STOPPING IN IDLE, MOVED TRUCK FROM PARK TO DRIVE, FELT NO POWER TO MOVE OBSERVED I WAS IN 5TH GEAR. PLACED IN PARK, SHUT OFF AND RESTARTED VEHICLE WITH NO ISSUES, NO CHECK ENGINE LIGHT. SPOKE TO DEALER AND THEY STATED THAT WITH NO CHECK ENGINE LIGHT OR CODE THEY WOULD HAVE TO DRIVE UNTIL ISSUE WAS REPEATED. I HAVE ORDERED AND WILL REPLACE THE LEAD FRAME ASSEMBLY AS THAT APPEARS TO BE THE MOST PROBABLE CAUSE, AND CLEAN AND INSPECT ALL CONNECTIONS TO TRANSMISSION. THIS WAS THE SAME ISSUE THE RECALL ON 2012 COVERED ON THE SAME TRANSMISSION, FORD DID NOT INCLUDE 2013 IN THIS RECALL.

NHTSA ODI #11162391

71,000 miles · Dec 18, 2018
Power TrainVehicle Speed Control

MY 2013 FORD F-150 XLT WITH 71,000 MILES IS HAVING TRANSMISSION ISSUES AND PROBLEMS WITH SHIFTING AND COMPLETELY LOSING POWER WHILE DRIVING. THIS ISSUE HAS STARTED INTERMITTANTLY ABOUT A MONTH AGO. WHILE I'M DRIVING, A GIANT WRENCH APPEARS ON THE DASHBOARD WHICH IS THEN FOLLOWED BY LOSS OF POWER AND ACCELERATION. THE VEHICLE IS …

Read full complaint

MY 2013 FORD F-150 XLT WITH 71,000 MILES IS HAVING TRANSMISSION ISSUES AND PROBLEMS WITH SHIFTING AND COMPLETELY LOSING POWER WHILE DRIVING. THIS ISSUE HAS STARTED INTERMITTANTLY ABOUT A MONTH AGO. WHILE I'M DRIVING, A GIANT WRENCH APPEARS ON THE DASHBOARD WHICH IS THEN FOLLOWED BY LOSS OF POWER AND ACCELERATION. THE VEHICLE IS THEN STUCK INTO A SINGLE GEAR AND THE SPEEDOMETER AND MILEAGE COMPUTER GO BLANK SO I NO LONGER KNOW HOW FAST I'M TRAVELLING. MY VEHICLE ISSUE SEEMS VERY SIMILAR TO THE 2011-2012 FORD F-150 TRANSMISSION DOWNSHIFTING RECALL FROM BELOW. 'FEDERAL SAFETY REGULATORS ARE INVESTIGATING WHETHER TO REOPEN AND EXPAND A PREVIOUS FORD RECALL BY MORE THAN A MILLION VEHICLES FOR UNEXPECTED DOWNSHIFTING. THE INITIAL 2016 RECALL AFFECTED MORE THAN 153,000 FORD F-150, FORD EXPEDITION, LINCOLN NAVIGATOR AND FORD MUSTANG VEHICLES FROM THE 2011-12 MODEL YEARS. A SECOND RECALL WOULD INCREASE THAT NUMBER TO AN ESTIMATED 1,375,577 VEHICLES AFFECTED, AND EXPAND INTO THE 2013 MODEL YEAR."

NHTSA ODI #11162336

103,000 miles · Dec 18, 2018
Power TrainVehicle Speed Control

PUT THE FORD F150 INTO GEAR, WOULD NOT SHIFT UP FROM 1ST GEAR. SAME ISSUE WE HAVE BEEN HAVING AND HAVE TAKEN TO THE DEALERSHIP AND THEY CANNOT FIND ANY PROBLEMS WITH THE TRANSMISSION. HAD TO TURN OFF TRUCK AND RESTART

NHTSA ODI #11162228

63,500 miles · Dec 17, 2018
Power Train

ON HIGHWAY, SPEED(60 MPH), GAUGES ON DASH BEGAN SWINGING WILDLY, TRANSMISSION BEGAN SHIFTING UP AND DOWN RAPIDLY AND THEN DOWN SHIFTED TO 1ST GEAR AT 60 MPH. THE REAR TIRES STARTED SCREAMING AND THREW ME SIDEWAYS INTO THE NEXT LANE AND ONTO SHOULDER OF ROAD. I HAD BEEN ON HIGHWAY FOR APPROX. 20 MINUTES BEFORE FAULT HAPPENED. I R…

Read full complaint

ON HIGHWAY, SPEED(60 MPH), GAUGES ON DASH BEGAN SWINGING WILDLY, TRANSMISSION BEGAN SHIFTING UP AND DOWN RAPIDLY AND THEN DOWN SHIFTED TO 1ST GEAR AT 60 MPH. THE REAR TIRES STARTED SCREAMING AND THREW ME SIDEWAYS INTO THE NEXT LANE AND ONTO SHOULDER OF ROAD. I HAD BEEN ON HIGHWAY FOR APPROX. 20 MINUTES BEFORE FAULT HAPPENED. I RESTARTED AND VEHICLE SEEMED TO OPERATE. I ATTEMPTED TO TRAVEL TO FORD DEALER WHEN AFTER ANOTHER 20 MINUTES FAULT RESUMED THROWING TRUCK OFF HIGHWAY AND LUCKILY ONTO EXIT ROAD. I AGAIN RESTARTED TRUCK AND PROCEEDED AT 20 MPH TO NEARBY DEALER. MY FORD DEALER FOUND INTERMITTENT LOSS OF OSS SIGNAL FROM THE LEAD FRAME. EXACT PROBLEM AND REPAIR AS IN RECALL #16N02 BUT MY TRUCK WAS JUST OUT OF RECALL RANGE. I BELIEVE THIS SAFETY RECALL SHOULD BE EXTENDED TO INCLUDE 2013 TRUCKS WITH THE SAME UNSAFE CONDITION. I HAD SOME DRIVE TRAIN WARRANTY LEFT SO REPAIR COST ME ONLY $100.00 BUT RECALL WOULD HAVE EXTENDED MY TRANSMISSION WARRANTY TO 150,000 MILES.

NHTSA ODI #11162080

80,000 miles · Dec 16, 2018
Power Train

AT LEAST ONCE A WEEK THE TRANSMISSION BEHAVES ERRATICALLY. WHEN ACCELERATION FROM A STOP ALL POWER IS LOST. A BIG WRENCH LIGHT COMES ON ON THE DASHBOARD. I AM FORCED TO COAST OR LIMP OUT OF TRAFFIC. USUALLY IT WILL STOP IF I SHUT THE TRUCK OFF AND RESTART IT. ANOTHER PROBLEM I HAVE EXPERIENCE IS SUDDEN DOWNSHIFTING INTO FIRST GE…

Read full complaint

AT LEAST ONCE A WEEK THE TRANSMISSION BEHAVES ERRATICALLY. WHEN ACCELERATION FROM A STOP ALL POWER IS LOST. A BIG WRENCH LIGHT COMES ON ON THE DASHBOARD. I AM FORCED TO COAST OR LIMP OUT OF TRAFFIC. USUALLY IT WILL STOP IF I SHUT THE TRUCK OFF AND RESTART IT. ANOTHER PROBLEM I HAVE EXPERIENCE IS SUDDEN DOWNSHIFTING INTO FIRST GEAR WHILE TRAVELING AT SPEEDS IN EXCESS OF 40 MPH. AGAIN I NEED TO PULL OVER AND SHUT THE TRUCK OFF AND RESTART IT TO CORRECT THE PROBLEM. ANOTHER POWERTRAIN ISSUE I HAVE EXPERIENCED, HOWEVER NOT AS DANGEROUS. IS ALL OF A SUDDEN ALL THE GAGES WILL GO BLANK. NO SPEEDOMETER, TACHOMETER, OR ODOMETER. SOMETIMES I'LL SEE THE BIG YELLOW WRENCH. AGAIN, TO FIX THIS I NEED TO SHUT THE TRUCK OFF AND RESTART IT. I HAVE A 2013 FORD F-150 XLT WITH 3.5 ECOBOOST APPROXMITTLY 80,000 MILES. I EXPERIENCE AT LEAST ONE OF THESE THREE PROBLEMS AT LEAST ONCE A WEEK AND SEEMS TO BE GETTING WORSE.

NHTSA ODI #11161871

72,000 miles · Dec 15, 2018
Power Train

TRANSMISSION WOULD SLIP OUT OF GEAR PERIODICALLY. DASH WOULD ALSO RESET.

NHTSA ODI #11161503

60,000 miles · Dec 14, 2018
Power TrainVehicle Speed Control

MY 2013 FORD F-150 ECOBOOST GETS STUCK IN 1ST GEAR SOMETIMES WHILE TRYING TO MOVE FROM A STOP. IT HAS ALSO SKIPPED 1ST AND 2ND GEAR AND GOTTEN STUCK IN 3RD GEAR AND BARELY ABLE TO MOVE MORE THAN 5 MPH. IT HAS HAPPENED FROM A DEAD STOP AS WELL AS WHILE DRIVING 40 PLUS MILES PER HOUR. TYPICALLY PULLING OVER AND TURNING THE TRUCK …

Read full complaint

MY 2013 FORD F-150 ECOBOOST GETS STUCK IN 1ST GEAR SOMETIMES WHILE TRYING TO MOVE FROM A STOP. IT HAS ALSO SKIPPED 1ST AND 2ND GEAR AND GOTTEN STUCK IN 3RD GEAR AND BARELY ABLE TO MOVE MORE THAN 5 MPH. IT HAS HAPPENED FROM A DEAD STOP AS WELL AS WHILE DRIVING 40 PLUS MILES PER HOUR. TYPICALLY PULLING OVER AND TURNING THE TRUCK OFF AND BACK ON FIXES IT. I AM AFRAID IT WILL HAPPEN AGAIN AND CAUSE AN ACCIDENT.

NHTSA ODI #11161314

89,900 miles · Dec 14, 2018
Electrical SystemPower TrainVehicle Speed Control

TRUCK SUDDENLY DROPS FROM 6TH GEAR TO 1 ST GEAR AND BARKS THE REAR TIRES WHILE TRAVELING AT 60MPH ALSO THE INSTRUMENT PANEL GOES COMPLETELY OUT EXCEPT FOR THE RPM GAUGE IT ALSO DOWN SHIFTS FROM 6TH TO 5TH AND THEN WILL NOT UPSHIFT AND ONLY DOWN SHIFTS TO 3RD GEAR ALSO IT HAS STUCK IN 1ST GEAR WHEN TAKING IFF FROM A RED LIGHT. IT…

Read full complaint

TRUCK SUDDENLY DROPS FROM 6TH GEAR TO 1 ST GEAR AND BARKS THE REAR TIRES WHILE TRAVELING AT 60MPH ALSO THE INSTRUMENT PANEL GOES COMPLETELY OUT EXCEPT FOR THE RPM GAUGE IT ALSO DOWN SHIFTS FROM 6TH TO 5TH AND THEN WILL NOT UPSHIFT AND ONLY DOWN SHIFTS TO 3RD GEAR ALSO IT HAS STUCK IN 1ST GEAR WHEN TAKING IFF FROM A RED LIGHT. IT HAS DONE EVERYTHING WHILE TRAVELING DOWN THE HIGHWAY EXCEPT FOR THE 1ST GEAR ISSUE THAT HAPPENED FROM A STOPED POSITION WHEN I STARTED TO TAKE OFF. PROBLEM DOES HAPPEN ALL THE TIME AND WHEN YOU PULL OVER AND PLACE THE VEHICLE IN PARK AND TURN THE ENGINE OFF AND RESTART THE ENGINE THE PROBLEM GOES AWAY AND THEN IT STARTS IT AGAIN TOOK THE TRUCK TO LOCAL DEALERSHIP AND WAS TOLD IT WOULD COST 985.00 TO FIX THIS PROBLEM WHEN IT IS THE SAME PROBLEM THAT WAS RECALLED ON THE PREVIOUS YEARS TRUCK SAME PROBLEM ON THE 2011 AND 2012 ALSO HAVE READ THE PROBLEM IS STILL ACCOURING ON THE 2014 MODELS AS WELL

NHTSA ODI #11161293

66,000 miles · Dec 7, 2018
Power Train

THE TRUCK WAS SHIFTING BETWEEN 5TH AND 6TH GEAR SPORADICALLY WHILE DRIVING 65 MILES PER HOUR ON THE FREEWAY. THEN SUDDEN WHILE DRIVING AT THAT SAME SPEED IT SHIFTED TO 1ST OR 2ND GEAR LOCKING UP THE TIRES. THIS CAUSED OTHER VEHICLES TO HAVE TO SLAM ON THEIR BRAKES ALMOST CAUSING A PILE UP. THE TRUCK SUDDENLY SHIFTED BACK TO 6TH …

Read full complaint

THE TRUCK WAS SHIFTING BETWEEN 5TH AND 6TH GEAR SPORADICALLY WHILE DRIVING 65 MILES PER HOUR ON THE FREEWAY. THEN SUDDEN WHILE DRIVING AT THAT SAME SPEED IT SHIFTED TO 1ST OR 2ND GEAR LOCKING UP THE TIRES. THIS CAUSED OTHER VEHICLES TO HAVE TO SLAM ON THEIR BRAKES ALMOST CAUSING A PILE UP. THE TRUCK SUDDENLY SHIFTED BACK TO 6TH GEAR AND BEGAN SHIFTING BACK AND FORTH AGAIN BETWEEN 5TH AND 6TH GEAR UNTIL I COULD EXIT THE FREEWAY. UPON EXIT THE VEHICLE SHIFTED FROM 4TH OR 5TH GEAR TO 1ST GEAR WHEN EXITING LOCKING UP THE TIRES AGAIN.

NHTSA ODI #11156767

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of