← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Fuel System, Gasoline complaints

29 reports
Clear category filter
104,100 miles · Jun 25, 2016
Fuel System, GasolinePower Train

THROTTLE WAS COMPLETELY LOST. TRUCK WOULD ONLY RUN AROUND 5 MPH MAXIMUM. WOULD NOT TAKE THROTTLE AT ALL. THIS IS A VERY DANGEROUS CONDITION WHEN IN A HIGH TRAFFIC AND MULTI LANE SETTING WHERE ALL THE OTHER VEHICLES ARE RUNNING AT HIGH SPEEDS. IT IS ALSO VERY DANGEROUS WHEN PULLING A 7000 LB TRAILER WITH NO OR EXTREMELY LIMIT…

Read full complaint

THROTTLE WAS COMPLETELY LOST. TRUCK WOULD ONLY RUN AROUND 5 MPH MAXIMUM. WOULD NOT TAKE THROTTLE AT ALL. THIS IS A VERY DANGEROUS CONDITION WHEN IN A HIGH TRAFFIC AND MULTI LANE SETTING WHERE ALL THE OTHER VEHICLES ARE RUNNING AT HIGH SPEEDS. IT IS ALSO VERY DANGEROUS WHEN PULLING A 7000 LB TRAILER WITH NO OR EXTREMELY LIMITED PULL OFFS FOR EMERGENCIES SUCH AS THIS. IT CREATES A VERY REAL POSSIBILITY OF DEATH. THIS OCCURRED ON A LOCAL ROAD IN FITZGERALD, GA TRAVELING STRAIGHT WITH LIGHT TRAFFIC CONDITIONS FORTUNATELY. I DROVE THE TRUCK IN TO FITZGERALD FORD FROM ABOUT 3 TO 4 MILES AWAY AT THE ABOVE MENTIONED SPEED. THE DEALERSHIP DIAGNOSED THE PROBLEM AS A FAULTY THROTTLE BODY, AND IT WAS REPLACED AT A COST TO ME OF $248.12. MY WIFE'S CAR ALSO HAD THIS PROBLEM WITH THE EXACT SAME PART. IT WAS REPLACED BY THE SAME DEALERSHIP AND PAID FOR BY US. MY WIFE [XXX] SUBSEQUENTLY RECEIVED CORRESPONDENCE FROM FORD THAT INDICATED THE THROTTLE BODY WARRANTY HAD BEEN EXTENDED, AND THAT COST THAT WE PREVIOUSLY PAID WAS REFUNDED TO US. HER CAR WHICH WE STILL OWN IS A 2010 FORD FUSION SEL. THE VIN IS [XXX]. THE INCIDENT WITH MY TRUCK OCCURRED YESTERDAY, JUNE 24, 2016. THE DIAGNOSIS, REPAIR AND PAYMENT FOR THE REPAIR ALSO TOOK PLACE YESTERDAY. IS THERE ANY DIFFERENCE BETWEEN THE EXTENSION OF THE CAR THROTTLE BODY WARRANTY AND THE TRUCK? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10876560

15,800 miles · Jun 25, 2014
EngineFuel System, GasolineVehicle Speed Control

AFTER DRIVING FOR SEVERAL HOURS ON THE INTERSTATE WE HAD STOPPED TO RE-FUEL. UPON RE-ENTRY ONTO THE INTERSTATE THE TRUCK FAILED TO ACCELERATE, THE CHECK ENGINE LIGHT CAME ON, THE TRUCK WAS SHAKING IT TOOK 30-40 SECONDS BEFORE NORMAL OPERATION RESUMED. THIS IS THE 3RD TIME THIS HAS HAPPENED, TWICE ON OF WHICH WERE ON THE INTERST…

Read full complaint

AFTER DRIVING FOR SEVERAL HOURS ON THE INTERSTATE WE HAD STOPPED TO RE-FUEL. UPON RE-ENTRY ONTO THE INTERSTATE THE TRUCK FAILED TO ACCELERATE, THE CHECK ENGINE LIGHT CAME ON, THE TRUCK WAS SHAKING IT TOOK 30-40 SECONDS BEFORE NORMAL OPERATION RESUMED. THIS IS THE 3RD TIME THIS HAS HAPPENED, TWICE ON OF WHICH WERE ON THE INTERSTATE WHILE ATTEMPTING TO MERGE INTO TRAFFIC OR PASS VEHICLES. ALL THREE TIMES THE CONDITIONS HAVE BEEN HIGH HUMIDITY,RAIN & TRAVELING AT A RELATIVELY CONSTANT SPEED FOR AN EXTENDED PERIOD OF TIME. *TR

NHTSA ODI #10605948

12,000 miles · May 28, 2014
EngineFuel System, GasolineVehicle Speed Control

THE FOLLOWING OCCURRED IN A 2013 F150 PLATINUM WITH 12,000 MILES ON IT. WHILE ACCELERATING FROM A TRAFFIC LIGHT, THE CAR LOST POWER AND STUTTERED AND FELL INTO LIMP MODE. YOU COULD NOT DRIVE OVER 10 MPH. THIS HAS BEEN JUST ONE OF MANY SIMILAR INCIDENTS. I HAVE TAKEN THE CAR IN SEVERAL TIMES BUT FORD CANNOT REPLICATE THE PRO…

Read full complaint

THE FOLLOWING OCCURRED IN A 2013 F150 PLATINUM WITH 12,000 MILES ON IT. WHILE ACCELERATING FROM A TRAFFIC LIGHT, THE CAR LOST POWER AND STUTTERED AND FELL INTO LIMP MODE. YOU COULD NOT DRIVE OVER 10 MPH. THIS HAS BEEN JUST ONE OF MANY SIMILAR INCIDENTS. I HAVE TAKEN THE CAR IN SEVERAL TIMES BUT FORD CANNOT REPLICATE THE PROBLEM, SO THEY WILL NOT FIX ANYTHING. RECENTLY, THE CAR JUST MISFIRED WHILE DRIVING AROUND 40MPH, THESE INCIDENTS OCCUR SUDDENLY THEN THE CAR RECOVERS. MY CAR IS CURRENTLY IN THE SHOP, I WILL PICK IT UP TODAY, THEY SAID THEY COULD NOT REPLICATE THE PROBLEM, SO NO SERVICE WAS DONE. THE REASON IT WAS IN THE SHOP THIS TIME? I WAS DRIVING TO WORK IN THE MORNING AND THE CAR BASICALLY COLLAPSED WHILE DRIVING, ALMOST CAUSING A HUGE ACCIDENT, THIS INCIDENT WAS MORE EXTREME THAN THE OTHERS AND THE CAR WAS STUCK IN LIMP MODE FOR ABOUT 5 SECONDS, THE WOMAN BEHIND ME ALMOST SMASHED INTO ME. THIS IS A 50K TRUCK WITH 12,000 MILES ON IT. THIS TRUCK IS EXTREMELY DANGEROUS TO DRIVE. RECALL!!!!!! *TR

NHTSA ODI #10594479

5,500 miles · May 19, 2014
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2013 FORD F-150. THE VEHICLE WAS BEING REFUELED WHEN THE METAL STOPPER WITHIN THE FUEL TANK DID NOT ENGAGE AND FUEL SPILLED OUT OF THE FUEL TANK. THE CONTACT WAS UNABLE TO INSERT THE FUEL PUMP NOZZLE BECAUSE THE CAPLESS ENTRY POINT WAS BLOCKED BY THE METAL PIECE IN THE FUEL TANK. THE DEALER INFORMED TH…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE VEHICLE WAS BEING REFUELED WHEN THE METAL STOPPER WITHIN THE FUEL TANK DID NOT ENGAGE AND FUEL SPILLED OUT OF THE FUEL TANK. THE CONTACT WAS UNABLE TO INSERT THE FUEL PUMP NOZZLE BECAUSE THE CAPLESS ENTRY POINT WAS BLOCKED BY THE METAL PIECE IN THE FUEL TANK. THE DEALER INFORMED THE CONTACT TO FORCE THE NOZZLE INTO THE FUEL TANK. THE CONTACT DID NOT HEED THE DEALER'S SUGGESTION. THE CONTACT WAS PLANNING TO HAVE THE FAILURE DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 5,500.

NHTSA ODI #10592549

29,700 miles · Apr 29, 2014
EngineFuel System, GasolinePower Train

UPON ACCELERATING FROM A STOP 4OR 5 LOUD KNOCKING SOUNDS WERE HEARD AND FELT, AND ENGINE POWER LOSS WAS EXPERIENCED. I LET OFF THROTTLE TO REDUCE KNOCKING SOUND,WHICH SOUNDED LIKE TURBO WASTEGATE POSSIBLY, AND ENGINE SHOOK AND HAD REDUCED POWER FOR SEVERAL MILES. TEMPERATURE OUTSIDE WAS WARM AND DRY. I HAD BEEN DRIVING VEHICLE …

Read full complaint

UPON ACCELERATING FROM A STOP 4OR 5 LOUD KNOCKING SOUNDS WERE HEARD AND FELT, AND ENGINE POWER LOSS WAS EXPERIENCED. I LET OFF THROTTLE TO REDUCE KNOCKING SOUND,WHICH SOUNDED LIKE TURBO WASTEGATE POSSIBLY, AND ENGINE SHOOK AND HAD REDUCED POWER FOR SEVERAL MILES. TEMPERATURE OUTSIDE WAS WARM AND DRY. I HAD BEEN DRIVING VEHICLE FOR OVER AN HOUR BEFORE PROBLEM. IT HAS HAD REDUCED POWER AND MINOR SHAKING BEFORE,BUT NOTHING LIKE THIS. FORTUNATELY NO OTHER VEHICLES WERE COMING. I DO NOTICE WASTEGATE POPPING OFF ON SHORT,STEEP HILLS MORE LATELY. I HAVE THE ECOBOOST ENGINE. HAVE NOT BEEN TO DEALER YET, BUT HAVE APPT SOON. *JS

NHTSA ODI #10585604

600 miles · Jan 22, 2014
EngineFuel System, Gasoline

VEHICLE WILL NOT START WHEN PARKED ON A DECLINE OF APPROXIMATELY 8% AND FUEL LEVEL BELOW 1/4 OF TANK OR LESS THAN 100 MILES ON FUEL WARNING INDICATOR. LOW FUEL WARNING LIGHT COMES ON AND VEHICLE WILL NOT START UNTIL ON LEVEL GROUND. I AM NOT COMFORTABLE TRAVELING OFF-ROAD OR IN MOUNTAINS IF FUEL LEVEL IS BELOW 1/4 TANK AS THIS…

Read full complaint

VEHICLE WILL NOT START WHEN PARKED ON A DECLINE OF APPROXIMATELY 8% AND FUEL LEVEL BELOW 1/4 OF TANK OR LESS THAN 100 MILES ON FUEL WARNING INDICATOR. LOW FUEL WARNING LIGHT COMES ON AND VEHICLE WILL NOT START UNTIL ON LEVEL GROUND. I AM NOT COMFORTABLE TRAVELING OFF-ROAD OR IN MOUNTAINS IF FUEL LEVEL IS BELOW 1/4 TANK AS THIS ISSUE MAY CAUSE VEHICLE TO STALL RESULTING IN AN ACCIDENT OR BEING STRANDED. *TR

NHTSA ODI #10560931

11,750 miles · Nov 7, 2013
EngineFuel System, GasolineVehicle Speed Control

I WAS MERGING ONTO THE HIGHWAY WHILE IT WAS RAINING. IN ATTEMPTING TO ACCELERATE TO MERGE IN FRONT OF A SEMI MY VEHICLE STATED SHUTTERING VIOLENTLY AND LOST POWER. I COULD NOT GET PAST 40MPH. THE CHECK ENGINE LIGHT WAS FLASHING. THIS WAS AFTER THE TRUCK HAD BEEN RUNNING FOR TWO HOURS. THE SEMI ALMOST REAR ENDED ME AS I GOT …

Read full complaint

I WAS MERGING ONTO THE HIGHWAY WHILE IT WAS RAINING. IN ATTEMPTING TO ACCELERATE TO MERGE IN FRONT OF A SEMI MY VEHICLE STATED SHUTTERING VIOLENTLY AND LOST POWER. I COULD NOT GET PAST 40MPH. THE CHECK ENGINE LIGHT WAS FLASHING. THIS WAS AFTER THE TRUCK HAD BEEN RUNNING FOR TWO HOURS. THE SEMI ALMOST REAR ENDED ME AS I GOT OFF THE ROAD AS SOON AS POSSIBLE. I SHUT THE TRUCK OFF AND RESTARTED THE ENGINE AND IT RAN FINE AFTER THAT. I TOOK THE TRUCK BACK TO MY DEALER THE NEXT DAY AND THEY COULD FIND NOTHING WRONG, NOT EVEN AN ERROR CODE. THE TRUCK HAS A FORD 6 CYLINDER ECO BOOST ENGINE. *TR

NHTSA ODI #10551384

400 miles · Nov 3, 2013
EngineFuel System, Gasoline

WHILE MAKING A LEFT HAND TURN ACROSS TRAFFIC I FLOORED THE GAS PEDAL AND ALL POWER WAS LOST ALMOST RESULTING IN A CRASH. THE NEXT TIME WAS ON THE HIGHWAY WHILE TRYING TO PASS ANOTHER VEHICLE TOTAL LOSS OF POWER. UNABLE TO PASS ALMOST REAR ENDED, LUCKILY ABLE TO GET OFF THE ROAD. TODAY NOVEMBER 3RD 2013 9:00 AM TRAVELING 40 MPH O…

Read full complaint

WHILE MAKING A LEFT HAND TURN ACROSS TRAFFIC I FLOORED THE GAS PEDAL AND ALL POWER WAS LOST ALMOST RESULTING IN A CRASH. THE NEXT TIME WAS ON THE HIGHWAY WHILE TRYING TO PASS ANOTHER VEHICLE TOTAL LOSS OF POWER. UNABLE TO PASS ALMOST REAR ENDED, LUCKILY ABLE TO GET OFF THE ROAD. TODAY NOVEMBER 3RD 2013 9:00 AM TRAVELING 40 MPH ON FLAT GROUND CLEAR SKY ABOUT 45 DEGREES I FLOORED IT AND THE TRUCK DID NOTHING IT DID SHAKE ALITTLE AND I KEPT MY FOOT TO THE FLOOR FOR ABOUT 1/2 A MILE AND IT NEVER REGAINED ANY POWER. THEN I SMELLED SOMETHING BURNING. NO CHECK ENGINE LIGHTS EVER CAME ON AND MY FUEL ECONOMY GET WORST EVERY DAY. THE TRUCK FEELS LIKE SOMETHING IS DRAGGING IT DOWN ALL THE TIME. POOR FUEL ECONOMY MIXED WITH UNRELIABILITY IS GOING TO EQUAL DISASTER. FORD IS LUCKY NO ONE HAS BEEN HURT OR KILLED YET.THE TRUCK WILL BE TOWED TO THE DEALER IN THE MORNING I SIMPLY WILL NOT RISK MY LIFE WHILE FORD SITS ON THERE THUMBS. FIX THE PROBLEM BEFORE SOMEONE IS HURT!!!! *TR

NHTSA ODI #10550672

700 miles · Oct 20, 2013
EngineFuel System, GasolineVehicle Speed Control

WHEN FIRST ACCELERATING EARLY IN THE MORNING THE TRUCK ACCELERATES SUDDENLY WHEN 1ST TAKING OFF. THIS REALLY BECAME A PROBLEM WHEN SOMEONE STEPPED IN FRONT OF ME, THE TRUCK TOOK OFF AND THEN I HAD TO STOP SUDDENLY. I HAVE REPORTED TO FORD AND TAKEN IT IN TWICE, BUT THEY INSIST NO ONE HAS HAD THIS PROBLEM. THE MOTOR'S RPM FLUCTUA…

Read full complaint

WHEN FIRST ACCELERATING EARLY IN THE MORNING THE TRUCK ACCELERATES SUDDENLY WHEN 1ST TAKING OFF. THIS REALLY BECAME A PROBLEM WHEN SOMEONE STEPPED IN FRONT OF ME, THE TRUCK TOOK OFF AND THEN I HAD TO STOP SUDDENLY. I HAVE REPORTED TO FORD AND TAKEN IT IN TWICE, BUT THEY INSIST NO ONE HAS HAD THIS PROBLEM. THE MOTOR'S RPM FLUCTUATES ABOUT 200-300, THEN SETTLES DOWN.THE VISIBILITY HAS BEEN A PROBLEM SINCE DAY ONE. FORD REPLACED THE WIPER BLADES, BUT THE PROBLEM IS STILL THERE. I HAVE BACK TO THE DEALER 3 TIMES AND ALL THEY SAY IS "WE CAN DUPLICATE THE PROBLEM". *TR

NHTSA ODI #10548587

1,240 miles · Oct 15, 2013
EngineFuel System, GasolinePower Train

3.5L ECOBOOST ENGINE. WENT TO MERGE ON HIGHWAY, PRESSED ACCELERATOR, ENGINE STUMBLED, PRESSED FURTHER ON ACCELERATOR, ENGINE STUMBLED, LOSS OF POWER, CHECK ENGINE LIGHT FLASHING, VIOLENT SHAKING WHEN TRYING TO ACCELERATE TO SAFE SPEED ON -RAMP, LIGHT WENT OUT AFTER A PERIOD OF 1 - 2 MINUTES. HAD TO PULL OFF SIDE OF ROAD TO AVOID…

Read full complaint

3.5L ECOBOOST ENGINE. WENT TO MERGE ON HIGHWAY, PRESSED ACCELERATOR, ENGINE STUMBLED, PRESSED FURTHER ON ACCELERATOR, ENGINE STUMBLED, LOSS OF POWER, CHECK ENGINE LIGHT FLASHING, VIOLENT SHAKING WHEN TRYING TO ACCELERATE TO SAFE SPEED ON -RAMP, LIGHT WENT OUT AFTER A PERIOD OF 1 - 2 MINUTES. HAD TO PULL OFF SIDE OF ROAD TO AVOID TRAFFIC AS I WAS UNABLE TO ACCELERATE. THIS WAS THE SECOND INCIDENT FOR THIS TRUCK. FORD ENGINEERING TO MY SERVICE DEPARTMENT THAT THERE WAS NO FIX BUT THEY WERE AWARE OF THE ISSUE. *TR

NHTSA ODI #10547899

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of