← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
2,600 miles · Jun 14, 2013
Engine

6/11/13 DRIVING IN MODERATE RAIN IN 75 DEGREES WITH CRUISE CONTROL ON I ATTEMPTED TO ACCELERATE TO PASS. TRUCK LOST POWER AND BEGAN TO SHUDDER RATHER VIOLENTLY. CHECK ENGINE LIGHT BEGAN TO FLASH. INCIDENT LASTED 20-30 SECONDS. THIS OCCURRED AGAIN ON 6/13/13 IN SIMILAR CONDITIONS. I TOOK THE VEHICLE TO A DEALER IN MASSENA NY…

Read full complaint

6/11/13 DRIVING IN MODERATE RAIN IN 75 DEGREES WITH CRUISE CONTROL ON I ATTEMPTED TO ACCELERATE TO PASS. TRUCK LOST POWER AND BEGAN TO SHUDDER RATHER VIOLENTLY. CHECK ENGINE LIGHT BEGAN TO FLASH. INCIDENT LASTED 20-30 SECONDS. THIS OCCURRED AGAIN ON 6/13/13 IN SIMILAR CONDITIONS. I TOOK THE VEHICLE TO A DEALER IN MASSENA NY. THEY PULLED A P-306 CODE (#6 CYLINDER MISFIRE) AND RAN AN OASIS REPORT. THE REPORT SHOWED MY EXACT SYMPTOMS AS AN ECOBOOST ISSUE. THEY ASSURED ME IT WAS NOT GOING TO DAMAGE THE VEHICLE SO I DROVE IT BACK TO HOME IN VIRGINIA. I HAVE AN APPT WITH MY LOCAL NORFOLK VA DEALER ON 6/17/13. MY BUILD DATE IS 03/03/13. *TR

NHTSA ODI #10519802

3,750 miles · Jun 14, 2013
Electrical SystemEnginePower Train

ON THIS NEW F-150 WITH ECO BOOST ENGINE ,THE ENGINE NOW HAS SHUT DOWN 2 TIMES THE LAST 2 DAYS ON JUNE 12 AND 13, 2013. THE ENGINE OIL LIGHT CAME ON. I WAS ONLY GOING 20 MPH WHEN THIS HAPPENED BOTH TIMES SINCE I WAS STOPPING AT THE STOP SIGN 3 BLOCKS FROM MY HOUSE. ON THE HIGHWAY WITH THE ENGINE IN CRUISE CONTROL AT SPEED OF 60…

Read full complaint

ON THIS NEW F-150 WITH ECO BOOST ENGINE ,THE ENGINE NOW HAS SHUT DOWN 2 TIMES THE LAST 2 DAYS ON JUNE 12 AND 13, 2013. THE ENGINE OIL LIGHT CAME ON. I WAS ONLY GOING 20 MPH WHEN THIS HAPPENED BOTH TIMES SINCE I WAS STOPPING AT THE STOP SIGN 3 BLOCKS FROM MY HOUSE. ON THE HIGHWAY WITH THE ENGINE IN CRUISE CONTROL AT SPEED OF 60-65 MPH THE TRANSMISSION GOES FROM 6 TH GEAR TO 5TH GEAR ALOT. *TR

NHTSA ODI #10519763

16,800 miles · Jun 13, 2013
EngineVehicle Speed Control

WHEN ACCELERATING THE ENGINE SHUT OFF WITHOUT WARNING. AFTER THE DEALER PROVIDED SERVICE FOR THIS ISSUE, THE ENGINE SHUT OFF WHILE DECELERATING TO A STOP AND AGAIN WHILE ACCELERATING FROM THIS STOP. MOST RECENTLY THE ENGINE HAS BEEN VERY SLUGGISH AT TIMES WHILE ATTEMPTING TO ACCELERATE. *TR

NHTSA ODI #10519707

10,503 miles · Jun 13, 2013
EnginePower Train

WHILE TRAVELING AT HIGHWAY SPEED ON I-69 IN MICHIGAN BETWEEN LANSING AND FLINT, I ATTEMPTED TO MERGE INTO THE PASSING LANE TO ALLOW MERGING TRAFFIC FROM THE ON-RAMP ONTO THE EXPRESSWAY. IN ORDER TO CHANGE LANES, I USED FIRM ACCELERATION TO AVOID CONTACT WITH THE FASTER VEHICLES IN THE PASSING LANE. THE STEERING WHEEL STARTED S…

Read full complaint

WHILE TRAVELING AT HIGHWAY SPEED ON I-69 IN MICHIGAN BETWEEN LANSING AND FLINT, I ATTEMPTED TO MERGE INTO THE PASSING LANE TO ALLOW MERGING TRAFFIC FROM THE ON-RAMP ONTO THE EXPRESSWAY. IN ORDER TO CHANGE LANES, I USED FIRM ACCELERATION TO AVOID CONTACT WITH THE FASTER VEHICLES IN THE PASSING LANE. THE STEERING WHEEL STARTED SHAKING VIOLENTLY WHILE THE CHECK ENGINE LIGHT FLASHED. ALL FORWARD ACCELERATION WAS IMPOSSIBLE THE ENGINE SPUTTERED FOR 45-60 SECONDS AFTER THE EVENT UNTIL POWER WAS RESTORED. ONE WEEK AFTER I TOOK DELIVERY OF THE TRUCK, THIS PROBLEM BEGAN ON A SIMILAR TRIP ON THE WAY TO TOLEDO AROUND THE DUNDEE EXIT ON I-23. THE VEHICLE ONLY HAD 400 MILES ON IT AT THE TIME. THIS WAS IN EARLY MAY 2013. I TOOK THE VEHICLE TO THE DEALER WHO PERFORMED THE TSB REPLACING THE CHARGED AIR COOLER AND UPDATING THE SOFTWARE IN THE ENGINE CONTROL MODULE. THIS CAN BE REPEATED ON ANY TRIP OF SIGNIFICANT DURATION ON A RAINY DAY. THE TSB DID ABSOLUTELY NOTHING TO ADDRESS THIS PROBLEM, AND I FEAR FOR MY SAFETY AS WELL AS MY FAMILY'S SAFETY. I DO NOT LET ME WIFE DRIVE THE CAR BECAUSE SHE WOULD NOT BE AS WELL EQUIPPED TO DEAL WITH AN EVENT LIKE THIS. I FEEL CHEATED BY FORD, AND I AM NOT SATISFIED WITH THEIR ATTEMPTS OF FIXING THIS. FURTHERMORE, I KNOW EVERY TIME THIS HAPPENS THE ENGINE IS TAKING IN LARGE AMOUNTS OF WATER THROUGH THE INTAKE, AND THIS IS CATASTROPHIC FOR ENGINE LIFE AND LONGEVITY. PLEASE PURSUE RECALL EFFORTS NOW ON THIS HORRIBLE ENGINE. *TR

NHTSA ODI #10519631

10,600 miles · Jun 11, 2013
EngineFuel/propulsion SystemPower Train

VEHICLE LOST POWER WHEN TRYING TO PASS ANOTHER VEHICLE. NOTE I WAS IN A 75 MPH AREA TRYING TO PASS A VEHICLE THAT HAD TRASH FLYING OFF TRUCK. IN ANY CASE WHEN I PUNCHED THE ACCELERATOR THE VEHICLE DID A NOSE DIVE AS IT LOST POWER. IT TOOK ABOUT 2 SECONDS FOR THE VEHICLE TO RESTORE TO NORMAL OPERATION. *TR

NHTSA ODI #10516223

550 miles · Jun 7, 2013
Engine

MY VEHICLE IS A 2013 FORD F-150 ECOBOOST. I WAS TRAVELING ON THE INTERSTATE AND MY CHECK ENGINE LIGHT CAME ON AND THE TRUCK SHUDDERED VIOLENTLY. WHILE THIS WAS OCCURRING THE VEHICLE HAD LITTLE POWER. I WAS IN THE LEFT HAND LANE, AND WAS PINNED BETWEEN A TRACTOR TRAILER ON MY RIGHT AND A CAR BEHIND ME. THE VEHICLE SHUDDERED FO…

Read full complaint

MY VEHICLE IS A 2013 FORD F-150 ECOBOOST. I WAS TRAVELING ON THE INTERSTATE AND MY CHECK ENGINE LIGHT CAME ON AND THE TRUCK SHUDDERED VIOLENTLY. WHILE THIS WAS OCCURRING THE VEHICLE HAD LITTLE POWER. I WAS IN THE LEFT HAND LANE, AND WAS PINNED BETWEEN A TRACTOR TRAILER ON MY RIGHT AND A CAR BEHIND ME. THE VEHICLE SHUDDERED FOR APPROX. 8 TO 10 SECONDS THEN STOPPED. I WAS THEN ABLE TO ACCELERATE AND PASS THE TRUCK. WEATHER CONDITIONS: RAINING TEMP: BETWEEN 75 AND 80 DEGREES TIME: 7:00 A.M. *TR

NHTSA ODI #10515760

600 miles · Jun 6, 2013
Electrical SystemEnginePower Train

TRAVELING ON THE INTERSTATE DURING HEAVY RAINS. TRAFFIC IN MY LANE STOPPED. I TRIED TO CHANGE LANES AND ACCELERATE BRISKLY. WHEN I TRIED TO ACCELERATE, THE VEHICLE STARTED TO SHUTTER AND THE ENGINE POWER DIED. IT SEEMED TO GO INTO LIMP MODE. THE CHECK ENGINE LIGHT FLASHED SEVERAL TIMES. THE VEHICLE WOULD NOT ACCELERATE AND LEFT …

Read full complaint

TRAVELING ON THE INTERSTATE DURING HEAVY RAINS. TRAFFIC IN MY LANE STOPPED. I TRIED TO CHANGE LANES AND ACCELERATE BRISKLY. WHEN I TRIED TO ACCELERATE, THE VEHICLE STARTED TO SHUTTER AND THE ENGINE POWER DIED. IT SEEMED TO GO INTO LIMP MODE. THE CHECK ENGINE LIGHT FLASHED SEVERAL TIMES. THE VEHICLE WOULD NOT ACCELERATE AND LEFT ME HANGING IN THE TRAVEL LANE WITH FASTER TRAFFIC ALMOST CAUSING A CRASH. VEHICLE IS ONE WEEK OLD AND HAS APPROXIMATELY 600 MILES ON IT. THE ENGINE IS THE FORD ECOBOOST 3.5L V6. THE VEHICLE HAD TO BE TURNED OFF AND RESTARTED TO GET IT TO DRIVE NORMAL AGAIN. *TR

NHTSA ODI #10515575

950 miles · Jun 6, 2013
Engine

ON 5/22/13, WHILE TRAVELING ON I-81 VEHICLE HWY MILEAGE DROPPED FROM 20.3 TO APPROX 16 MPG. ON 5/23 WHILE DRIVING TO FORD DEALERSHIP IN HOULTON, MAINE I WAS PASSING A VEHICLE AT 30MPH INA 45 ZONE AND THE ENGINE ALMOST SHUT DOWN. I HAD TO PULL BACK BECAUSE OF APPROACHING TRAFFIC. AT THE FORD DEALER, THEIR COMPUTER CHECK SHOWED…

Read full complaint

ON 5/22/13, WHILE TRAVELING ON I-81 VEHICLE HWY MILEAGE DROPPED FROM 20.3 TO APPROX 16 MPG. ON 5/23 WHILE DRIVING TO FORD DEALERSHIP IN HOULTON, MAINE I WAS PASSING A VEHICLE AT 30MPH INA 45 ZONE AND THE ENGINE ALMOST SHUT DOWN. I HAD TO PULL BACK BECAUSE OF APPROACHING TRAFFIC. AT THE FORD DEALER, THEIR COMPUTER CHECK SHOWED THE ENGINE DROPPED THE #6 CYLINDER (THAT'S WHAT THEY TOLD ME). THEY SAID IT WAS A ECOBOOST PROBLEM AND WOULD HAVE TO CALL THE FACTORY ENGINEERS. TWO WEEKS LATER, I HAVE NOT HEARD FROM FORD OR THE FORD DEALER. I ORDERED & THEY BUILT THE TRUCK IN APRIL 2013. IT WAS DELIVERED 4/26 AT CHEROKEE FORD, WOODSTOCK, GA. I BOUGHT THE ECOBOOST ENGINE BECAUSE OF THE EPA HWY MILEAGE RATING OF 21 MPG AND PAID $1050.00 EXTRA TO GET IT. I HAVE ALWAYS GO BETTER THAN THE RATED MPG ON MY VEHICLES, SO THIS IS NOT DRIVING HABITS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10515418

1,200 miles · Jun 4, 2013
Engine

2013 FORD F-150 XLT V6 ECOBOOST DISPLAYING SHUTTERING AND VIOLENT SHAKING UPON 1ST START UP OF THE DAY AND SOMETIMES 2ND START UP OF THE DAY IF IT'S BEEN A WHILE BETWEEN STARTS IN ST LOUIS, MO. FEELS LIKE AN OLD VEHICLE START UP NOT ANYTHING LIKE A BRAND NEW $42K TRUCK SHOULD SOUND LIKE. MY WIFE ALSO STATES IT SHUTTERS WHILE DRI…

Read full complaint

2013 FORD F-150 XLT V6 ECOBOOST DISPLAYING SHUTTERING AND VIOLENT SHAKING UPON 1ST START UP OF THE DAY AND SOMETIMES 2ND START UP OF THE DAY IF IT'S BEEN A WHILE BETWEEN STARTS IN ST LOUIS, MO. FEELS LIKE AN OLD VEHICLE START UP NOT ANYTHING LIKE A BRAND NEW $42K TRUCK SHOULD SOUND LIKE. MY WIFE ALSO STATES IT SHUTTERS WHILE DRIVING ON THE HIGHWAY SOMETIMES. I TOOK TO DEALER (SUNSET FORD) AND LET THEM KEEP IT OVERNIGHT SO THEY WOULD START AND CHECK IN THE MORNING. OF COURSE THEY HAD THE NERVE TO SAY IT DID NOT DO ANYTHING WHEN THEY STARTED IT. WELL AFTER READING VARIOUS POSTS ABOUT HOW THEY SEEM TO NOT WANT TO FIX THE PRODUCT THEY SELL I WAS UPSET. SO WHEN I WENT UP THERE I HAD THE SERVICE MANAGER GO WITH ME OUTSIDE TO START IT LATER THAT DAY AFTER THEY ALREADY STARTED IT AND IT DID THE SAME THING I TOOK IT IN THERE FOR. IT'S LIKE THEY DIDN'T EVEN DO THEIR JOB PROPERLY. HE HEMMED AND HAWED AND STATED TO BRING IT BACK UP FOR ANOTHER SERVICE APT LATER IN THE WEEK. I HAVE YET TO DO SO B/C MY TIME IS TOO VALUABLE FOR THEM TO GIVE ME THE RUN AROUND BUT IT STILL ALWAYS SHUTTERS AND SHAKES SOMETIMES VIOLENTLY UPON START UP. DON'T KNOW WHAT TO DO OTHER THAN TRADE IT BACK IN FOR ANOTHER TRUCK BRAND FOR SOMEONE ELSE TO DEAL WITH. IT'S A SHAME B/C I REALLY LIKE FORDS MY GRANDFATHER RETIRED FROM THERE. I GUESS LIKE EVERY OTHER COMPANY THEY JUST KEEP GETTING LEANER AND MEANER. GOOD FOR THEIR POCKET BOOKS I GUESS BUT NOT FOR THE EVERYDAY MAN OR WOMAN. *TR

NHTSA ODI #10515075

7,000 miles · Jun 4, 2013
EngineVehicle Speed Control

WHILE DRIVING NORTH ON I-95 IN GEORGIA AT 65 MPH, I ATTEMPTED TO ACCELERATE. THE TRUCK BEGAN TO SHAKE VIOLENTLY, LOSE POWER, AND THE CHECK ENGINE LIGHT ILLUMINATED. THE WEATHER AT THE TIME WAS 70 DEGREES WITH MODERATE RAIN. I HAD BEEN DRIVING FOR APPROXIMATELY ONE HOUR AT THE TIME OF THE INCIDENT. I HAD TO PULL OVER TO THE EMERG…

Read full complaint

WHILE DRIVING NORTH ON I-95 IN GEORGIA AT 65 MPH, I ATTEMPTED TO ACCELERATE. THE TRUCK BEGAN TO SHAKE VIOLENTLY, LOSE POWER, AND THE CHECK ENGINE LIGHT ILLUMINATED. THE WEATHER AT THE TIME WAS 70 DEGREES WITH MODERATE RAIN. I HAD BEEN DRIVING FOR APPROXIMATELY ONE HOUR AT THE TIME OF THE INCIDENT. I HAD TO PULL OVER TO THE EMERGENCY LANE AND SHUT OFF THE MOTOR. THE ENGINE RESTARTED OK. I DID NOT ATTEMPT ANY MORE HARD ACCELERATIONS. I HAD NO MORE STALL PROBLEMS. I TOOK THE TRUCK TO THE DEALER WHERE THEY FOUND A MISFIRE CODE, BUT HAD NO EXPLANATION OR FIX TO PREVENT THE PROBLEM FROM HAPPENING AGAIN. THIS IS AN ECOBOOST VEHICLE. *TR

NHTSA ODI #10515004

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of