← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
2,849 miles · Jun 27, 2013
EngineVehicle Speed Control

REDUCED ENGINE POWER DURING HARD ACCELERATIONS. EXPERIENCING MISFIRES AT HIGHWAY SPEEDS AND WHEN PULLING OUT INTO INTERSECTION. WAS ALMOST HIT BY ONCOMING VEHICLE IN INTERSECTION BECAUSE TRUCK LOST POWER AND SPEED IN THE MIDDLE OF THE INTERSECTION, TRUCK WAS CALLED ON FAST TO MAKE A LEFTHAND TURN AT THE GAP IN TRAFFIC AND LOST…

Read full complaint

REDUCED ENGINE POWER DURING HARD ACCELERATIONS. EXPERIENCING MISFIRES AT HIGHWAY SPEEDS AND WHEN PULLING OUT INTO INTERSECTION. WAS ALMOST HIT BY ONCOMING VEHICLE IN INTERSECTION BECAUSE TRUCK LOST POWER AND SPEED IN THE MIDDLE OF THE INTERSECTION, TRUCK WAS CALLED ON FAST TO MAKE A LEFTHAND TURN AT THE GAP IN TRAFFIC AND LOST POWER. VEHICLE WAS PURCHASED NEW ON APRIL 13, 2013. FORD DEALERSHIP RAN DIAGNOSTICS AND DETERMINED PROBLEM WAS DUE TO OASIS SPECIAL MESSAGE NUMBER 32227, "INTERMITTENT STUMBLE/MISFIRE ON ACCELERATION". FORD SAID THERE IS NO FIX YET "ENGINEERING IS INVESTIGATING, CONTINUE MONITORING FOR UPDATES". *TR

NHTSA ODI #10522084

4,087 miles · Jun 23, 2013
Electrical SystemEnginePower Train

THIS IS THE 5TH INCIDENT WITH THE SAME PROBLEM, BUT WORST NOW. I HAD THIS TRUCK AT THE FORD DEALERSHIP ON MONDAY JUNE 17,2013. THEY SAID IT WILL BE HARD TO DIAGNOSIS WITHOUT A FAULT CODE. HOW IS IT THEY CAN TELL ME HOW FAST I HAVE BEEN DRIVING FOR THE PAST MONTH, BUT THE INBOARD COMPUTER CANNOT TELL FORD TECHNICIANS WHAT IS WRO…

Read full complaint

THIS IS THE 5TH INCIDENT WITH THE SAME PROBLEM, BUT WORST NOW. I HAD THIS TRUCK AT THE FORD DEALERSHIP ON MONDAY JUNE 17,2013. THEY SAID IT WILL BE HARD TO DIAGNOSIS WITHOUT A FAULT CODE. HOW IS IT THEY CAN TELL ME HOW FAST I HAVE BEEN DRIVING FOR THE PAST MONTH, BUT THE INBOARD COMPUTER CANNOT TELL FORD TECHNICIANS WHAT IS WRONG.THE ENGINE CUT OFF AGAIN FOR THE 5TH TIME, BUT THIS TIME IT WOULD NOT START. THE INSTRUMENT SHOWED 2 ICON'S THIS TIME, A ( WRENCH AND CHECK OIL ), I'M SORRY BUT THE WRENCH INDICATES I BELIEVE SOMETHING TO DO WITH A REAR END ON A 4 X 4 TRUCK, SORRY THIS IS ONLY A 2 WHEEL DRIVE VEHICLE. I TRIED THE ( 2 ) RECOMMENDATION IN THE INSTRUCTION BOOK AND WHEN TURNED THE IGNITION TO START IT ONLY TRIED FOR LESS THAN 3 SECONDS, THEN THE POWER TO THE IGNITION WENT BLANK. I TRIED FOR 30 MINUTES, THEN CALLED FORD ROAD SIDE ASSISTANT FOR A TOW TRUCK, WHICH WAS DISPATCHED WITHIN A HOUR. I HAD ALREADY CALLED FORD FRIDAY JUNE 21,2013 FOR AN APPOINTMENT FOR # 3 & 4 WITH THE ENGINE CUTTING OFF. I THEN CALLED SATURDAY MORNING AND ASKING THEN FOR A BETTER APPOINTMENT, THEY GAVE ME ONE FOR MONDAY 6-23,2013 INSTEAD OF TUESDAY 6-24-2013.I BADLY NEED TRANSPORTATION THIS NEXT WEEK, I'M GOING TO ASK FORD FOR AMBULANCE SERVICE THIS NEXT COMING FRIDAY JUNE 28,2013, I AM A DISABLED SENIOR VETERAN AND HAVING HIP INJECTIONS NEXT FRIDAY OUT OF TOWN AT THE VETERANS HOSPITAL AND NEED A CARE GIVER,SINCE I WON'T BE ABLE TO DRIVE AFTER THE PROCEDURE.FORD THIS IS BEGINNING TO BE A VERY SERIOUS CONDITION WHEN DRIVING AND PROBABLY CAUSE ACCIDENTS VERY SOON. LETS GET THE PROBLEM FIXED OR ORDER ME A NEW TRUCK BECAUSE OF NORTH CAROLINA LEMON LAW. *TR

NHTSA ODI #10521245

2,600 miles · Jun 21, 2013
Engine

PULLING OUT INTO THE HIGHWAY WITH TRAFFIC COMING, I TRIED TO ACCELERATE AND THE ENGINE LOST POWER. TO AVOID BEING STRUCK BY ONCOMING TRAFFIC, I STEERED VEHICLE ONTO THE SHOULDER OF THE HIGHWAY. I HAVE HAD SEVERAL OTHER INSTANCES OF WHERE I LOST POWER, THE ENGINE DID NOT RESPOND WHILE TRYING TO PASS OTHER VEHICLES. IT WAS NOT H…

Read full complaint

PULLING OUT INTO THE HIGHWAY WITH TRAFFIC COMING, I TRIED TO ACCELERATE AND THE ENGINE LOST POWER. TO AVOID BEING STRUCK BY ONCOMING TRAFFIC, I STEERED VEHICLE ONTO THE SHOULDER OF THE HIGHWAY. I HAVE HAD SEVERAL OTHER INSTANCES OF WHERE I LOST POWER, THE ENGINE DID NOT RESPOND WHILE TRYING TO PASS OTHER VEHICLES. IT WAS NOT HUMID OR RAINING AT THE TIME THESE INCIDENTS OCCURRED. TOOK VEHICLE TO THE DEALER, IT WAS THERE FOR TWO DAYS. THEY COULD NOT FIND OR RECREATED THE PROBLEM. *TR

NHTSA ODI #10521149

3,991 miles · Jun 21, 2013
Electrical SystemEnginePower Train

THIS IS THE 2ND TIME TODAY , I'VE HAD THIS PROBLEM AND IS THE 4TH EPISODE OF THE SAME PROBLEM. THIS IS A FLEX FUEL 2013 FORD F-150.THIS IS BEGINNING TO BE A BIG CONCERN,AS STATED I WAS ONLY GOING ABOUT 10 MPH,SINCE I WAS IN A SHOPPING CENTER GETTING READY TO PARK. THE ENGINE USUAL CRANKS AFTER I COME TO A COMPLETE START AND TURN…

Read full complaint

THIS IS THE 2ND TIME TODAY , I'VE HAD THIS PROBLEM AND IS THE 4TH EPISODE OF THE SAME PROBLEM. THIS IS A FLEX FUEL 2013 FORD F-150.THIS IS BEGINNING TO BE A BIG CONCERN,AS STATED I WAS ONLY GOING ABOUT 10 MPH,SINCE I WAS IN A SHOPPING CENTER GETTING READY TO PARK. THE ENGINE USUAL CRANKS AFTER I COME TO A COMPLETE START AND TURN THE IGNITION OFF. I NEED THIS FIXED ASAP. I'VE GOT A TRIP PLANNED. *TR

NHTSA ODI #10521143

3,000 miles · Jun 21, 2013
EngineFire

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, HE NOTICED FLAMES COMING FROM UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A FIRE REPORT WAS FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE PARKED, HE NOTICED FLAMES COMING FROM UNDER THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A FIRE REPORT WAS FILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 3,000. *TR

NHTSA ODI #10521100

3,970 miles · Jun 21, 2013
Electrical SystemEnginePower Train

THIS IS THE 3RD TIME THAT THIS NEW F-150 TRUCK ENGINE SUDDENLY HAS CUT OFF. I WAS AT THE FORD DEALERSHIP IN BELMONT, N.C ON MONDAY JUNE 17,2013. THEY SAID THEY COULD NOT FIND ANYTHING WRONG. THEY THEN SAID THEY PUT IN A NEW UPDATE CODE. I NOW HAVE ONLY DROVE ABOUT ANOTHER 50 MILES SINCE MONDAY. IT CUT OFF AGAIN WHILE I WAS DRI…

Read full complaint

THIS IS THE 3RD TIME THAT THIS NEW F-150 TRUCK ENGINE SUDDENLY HAS CUT OFF. I WAS AT THE FORD DEALERSHIP IN BELMONT, N.C ON MONDAY JUNE 17,2013. THEY SAID THEY COULD NOT FIND ANYTHING WRONG. THEY THEN SAID THEY PUT IN A NEW UPDATE CODE. I NOW HAVE ONLY DROVE ABOUT ANOTHER 50 MILES SINCE MONDAY. IT CUT OFF AGAIN WHILE I WAS DRIVING ABOUT 30 MPH ON A BUSY CHARLOTTE, NC STREET. I THOUGHT MY NUCKLES WERE GOING TO PART SINCE I HAD TO CONTROL THE VEHICLE AND NOT CAUSE AN ACCIDENT. I AM SCHEDULE TO TAKE IN BACK TO KEITH HAWTHORNE FORD ON TUESDAY, JUNE 25,2013--THERE PHONE NUMBER 704-825-5186-SERVICE PERSON- WILL *TR

NHTSA ODI #10521075

9,000 miles · Jun 19, 2013
EngineVehicle Speed Control

MAY 22, 2013- WHILE DRIVING SOUTH ON I-55 AND MERGING ONTO I-12, I WAS TRAVELING APPROXIMATELY 35 MPH WHEN I GAVE THE TRUCK GAS TO ACCELERATE INTO ONCOMING INTERSTATE TRAFFIC OF 70+ MPH. MY TRUCK COMPLETELY WENT LIMP AND I COULD NOT ACCELERATE AT ALL WITH THE CHECK ENGINE LIGHT COMING ON. I WAS IN REAL TROUBLE AT THIS POINT SO…

Read full complaint

MAY 22, 2013- WHILE DRIVING SOUTH ON I-55 AND MERGING ONTO I-12, I WAS TRAVELING APPROXIMATELY 35 MPH WHEN I GAVE THE TRUCK GAS TO ACCELERATE INTO ONCOMING INTERSTATE TRAFFIC OF 70+ MPH. MY TRUCK COMPLETELY WENT LIMP AND I COULD NOT ACCELERATE AT ALL WITH THE CHECK ENGINE LIGHT COMING ON. I WAS IN REAL TROUBLE AT THIS POINT SO I PULLED OFF WITH ONE TIRE IN THE GRASS TO AVOID A SERIOUS ACCIDENT AND POTENTIALLY BEING KILLED. APPROXIMATELY 1 MINUTE LATER THE TRUCK REGAINED POWER AND I CONTINUED TO MY DESTINATION WITH THE CHECK ENGINE LIGHT GOING BACK OFF. MAY 23, 2013- I CALLED FORD DEALERSHIP WHERE I BOUGHT MY VEHICLE AND THEY EXPLAINED TO ME THAT NOTHING WAS WRONG IF THE WARNING LIGHT WENT OFF. STATING THE SYSTEM DOES THIS AS AN ENVIRONMENTAL PRECAUTION? MAY 28, 2013- I WAS TRAVELING IN GALVESTON, TX AT 25 MPH WHEN THE CHECK ENGINE LIGHT CAME ON AGAIN. I DID ATTEMPT TO GIVE IT GAS TO SEE IF THE SAME PROBLEM WAS OCCURRING AND IT ONCE AGAIN WOULD NOT RESPOND WITH THE CHECK ENGINE LIGHT STAYING ON PERMANENTLY THIS TIME. I PARKED MY TRUCK FOR WORK UNTIL JUNE 11, 2013. I TOOK A PICTURE OF MY DASH TO DOCUMENT THE WARNING LIGHT. CALLED FORD DEALERSHIP @ 7:20 A.M. ON 6/10/13 EXPLAINING MY SITUATION. HE STATED THAT OVER THE PHONE IT SOUNDS LIKE THE INNER COOLER. HE EXPLAINED TO ME THAT IT IS NOT DANGEROUS AND NOT TO WORRY. HE SAID THE PART WAS AN UPDATED PART AND THEY WOULD HAVE TO RUN DIAGNOSTICS TO KNOW THE PROBLEM FOR SURE. DROPPED TRUCK OFF AT FORD DEALERSHIP @ 11:10 A.M. ON 6/12/13. RECEIVED PHONE CALL FROM FORD @ 3:20 ON 6/13/2012. THEY TOLD ME THAT IT WAS NOT MY INNER COOLER BECAUSE MY TRUCK HAS THIS SO CALLED UPDATED INNER COOLER AND THEY REPLACED MY CATALYTIC CONVERTER. THEY ASSURED ME THIS WAS FIXED AND WOULD NOT HAPPEN AGAIN SINCE THE SYSTEM WAS UPDATED. THE POWER LOSS HAPPENED TWO MORE TIMES SINCE AND HAS ME REALLY WORRIED TO DRIVE IT. *TR

NHTSA ODI #10520738

2,781 miles · Jun 19, 2013
Engine

2013 F150 ECO BOOST PROBLEM WITH APPROXIMATELY 2781 MILES DROVE THRU THE TOWN ALBERT LEA, MN AT ABOUT 1100 HOURS ON 5/28/13 (CST) AT ABOUT 30 MPH. ENTERED THE ON RAMP (CLOVERLEAF STYLE RAMP) TO I-35 SOUTHBOUND. ATTEMPTED TO ACCELERATE TO 60 MPH DUE TO SHORT ON RAMP/MERGE LANE. ENGINE LOST POWER (APPROX. 80%???) THEN WENT INT…

Read full complaint

2013 F150 ECO BOOST PROBLEM WITH APPROXIMATELY 2781 MILES DROVE THRU THE TOWN ALBERT LEA, MN AT ABOUT 1100 HOURS ON 5/28/13 (CST) AT ABOUT 30 MPH. ENTERED THE ON RAMP (CLOVERLEAF STYLE RAMP) TO I-35 SOUTHBOUND. ATTEMPTED TO ACCELERATE TO 60 MPH DUE TO SHORT ON RAMP/MERGE LANE. ENGINE LOST POWER (APPROX. 80%???) THEN WENT INTO A SHAKING/SHUTTERING MODE. ENGINE WARNING LIGHT FLASHED INTERMITTENTLY. ATTEMPTED TO MERGE WITH SEVERAL SEMI'S ON I-35 (THE REASON FOR QUICK ACCELERATION PLUS THE SORT MERGE LANE). BACKED OFF ON THE GAS PEDAL WHEN ENGINE POWER DECREASED AND IN APPROXIMATELY 20 SECONDS THE ENGINE RECOVERED AND NEVER HESITATED AGAIN. THE WEATHER TEMPERATURE WAS APPROX. 60 DEGREES F WITH A HEAVY MIST AND MODERATE FOG. THE BOTTOM LINE: IF ANY ONE OF THE TRUCKERS HAD HICUPPED OR HAD BEEN DISTRACTED DURING OUR TERRIFYING MERGE WE WOULD BE WRITING THIS INFO FROM A HOSPITAL BED (OR NOT WRITING FROM A MORGUE). DEALER RAN DIAGNOSTIC WITH NO INDICATIONS OF ANY FAILURE IN SPITE OF ENGINE WARNING FLASHING DURING POWER LOSS OR SHAKING (DEATH RATTLE???). DATE OF MANUFACTURE APPEARS TO BE DECEMBER 2012. *TR

NHTSA ODI #10520611

8,300 miles · Jun 14, 2013
Engine

WHILE RUNNING APPROXIMATELY 45 MPH I ACCELERATED HARD TO MAKE A PASS AND THE TRUCK JUST LOST ALL POWER. IT STARTED SPUTTERING AND I FELL BACK INTO LINE. THE CHECK ENGINE LIGHT CAME ON AND IT CONTINUED TO RUN ROUGH SO I PULLED OFF THE ROAD. AS I DID THIS IT "CAUGHT UP" AND STARTED RUNNING SMOOTH AGAIN AND THE CHECK ENGINE LIGHT…

Read full complaint

WHILE RUNNING APPROXIMATELY 45 MPH I ACCELERATED HARD TO MAKE A PASS AND THE TRUCK JUST LOST ALL POWER. IT STARTED SPUTTERING AND I FELL BACK INTO LINE. THE CHECK ENGINE LIGHT CAME ON AND IT CONTINUED TO RUN ROUGH SO I PULLED OFF THE ROAD. AS I DID THIS IT "CAUGHT UP" AND STARTED RUNNING SMOOTH AGAIN AND THE CHECK ENGINE LIGHT WENT OFF. LATER IN THE DAY I TRIED IT AGAIN AND IT STARTED TO DO THE SAME THING SO I QUICKLY LET OFF. BOTH OF THESE TIMES IT WAS RAINING. LATER AFTER THE RAIN STOPPED I TRIED IT AGAIN WITH NO PROBLEM. IT ONLY HAPPENED WHEN IT RAINS. I TOOK IT TO THE FORD DEALERSHIP AND THEY TOLD ME THERE WAS A FIX BUT MY TRUCK WAS MADE BEFORE INCLUDED DATE. DON'T KNOW THAT DATE. TOLD ME ALSO THAT NO CODE WAS REGISTERED ON THE COMPUTER EVEN THOUGH THE CHECK ENGINE LIGHT CAME ON. TRUCK BATTERY KEEPS GOING DEAD TOO AND IT HAS NOW BEEN IN THE DEALERSHIP FOR 8 DAYS STRAIGHT AND I STILL DON'T HAVE ANY ANSWERS. TRUCK HAS BEEN IN SHOP 10 DAYS IN PAST MONTH. *TR

NHTSA ODI #10519888

13,200 miles · Jun 14, 2013
EnginePower TrainVehicle Speed Control

6/08/13 WHILE TRAVELING FROM KINGSVILLE TO RIO HONDO AT 6 AM FOR A FISHING TRIP, I ACCELERATED HARD TO PASS A SEMI-TRUCK. MY F150 SHUDDERED VIOLENTLY IN THE BACK END, AND I FELT A SIGNIFICANT LOSS OF POWER. THE CHECK ENGINE LIGHT BLINKED EXCESSIVELY BEFORE EXTINGUISHING. THE TRUCK RESUMED NORMAL OPERATION FAIRLY QUICKLY, WIT…

Read full complaint

6/08/13 WHILE TRAVELING FROM KINGSVILLE TO RIO HONDO AT 6 AM FOR A FISHING TRIP, I ACCELERATED HARD TO PASS A SEMI-TRUCK. MY F150 SHUDDERED VIOLENTLY IN THE BACK END, AND I FELT A SIGNIFICANT LOSS OF POWER. THE CHECK ENGINE LIGHT BLINKED EXCESSIVELY BEFORE EXTINGUISHING. THE TRUCK RESUMED NORMAL OPERATION FAIRLY QUICKLY, WITHIN 5 SEC. I CONTINUED TO MY DESTINATION WITH NO FURTHER PROBLEMS, MAKING SURE TO LIMIT MY SPEED AND MAKE NO MORE HARD ACCELERATIONS. THE WEATHER WAS RAINY AND WET CONDITIONS. I INTENDED ON INVESTIGATING THIS ISSUE ONCE I RETURNED HOME. 6/09/13 THE TRUCK HAD BEEN PARKED AND NOT DRIVEN UNTIL MY DEPARTURE ON SUN, 2 PM. ON MY WAY HOME I WAS FORCED TO ACCELERATE QUICKLY ON HWY 77 ON RAMP FROM FM 107 TO KEEP UP WITH TRAFFIC. THE TRUCK ONCE AGAIN SHUDDERED VIOLENTLY AND THE A/C BEGAN BLOWING HOT AIR, THE LOSS OF POWER WAS MUCH MORE SIGNIFICANT THAN THE LAST EPISODE AND I WAS FORCED TO PULL ONTO SIDE OF HWY 77 TO AVOID BEING STRUCK BY TRAFFIC BEHIND ME. THE ENGINE LIGHT BLINKED AND CONTINUED TO STAY ON. THE TRUCK RESUMED NORMAL OPERATION; HOWEVER THE LENGTH OF TIME BEFORE THAT HAPPENED WAS MUCH LONGER THAN BEFORE. I WAS CERTAIN I WAS GOING TO BE STRANDED AND IT WAS NECESSARY FOR ME TO TAKE EMERGENCY MEASURES. THE WEATHER WAS HOT AND DRY. *TR

NHTSA ODI #10519810

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of