← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
19,000 miles · Oct 1, 2013
Engine

SHUDDER/MISFIRE. THE MISFIRE OCCURS AT VARIOUS SPEEDS GOING UPHILL OR ON A FLAT SURFACE. THE TRUCK IS CURRENTLY AT FORD DEALER SHIP WHO IS TRYING TO RESOLVE THE ISSUE. ACCORDING TO THE DEALERS TECH THE MISFIRE CAN OCCURS AT LOW RPMS. NEW SPARK PLUG COILS AND THREE SETS OF NEW SPARK PLUGS HAVE BEEN INSTALLED. APPARENTLY IT K…

Read full complaint

SHUDDER/MISFIRE. THE MISFIRE OCCURS AT VARIOUS SPEEDS GOING UPHILL OR ON A FLAT SURFACE. THE TRUCK IS CURRENTLY AT FORD DEALER SHIP WHO IS TRYING TO RESOLVE THE ISSUE. ACCORDING TO THE DEALERS TECH THE MISFIRE CAN OCCURS AT LOW RPMS. NEW SPARK PLUG COILS AND THREE SETS OF NEW SPARK PLUGS HAVE BEEN INSTALLED. APPARENTLY IT KEEPS BLOWING SPARK PLUGS.AS OF YET NO SOLUTION HAS BEEN FOUND TO THE PROBLEM. *TR

NHTSA ODI #10546343

4,500 miles · Sep 30, 2013
EngineFuel System, GasolineVehicle Speed Control

WHILE TRYING TO MERGE INTO TRAFFIC I PRESSED THE ACCELERATOR TO THE FLOOR TO GET THE TRUCK UP TO THE SPEED OF TRAFFIC FLOW.I HAD NO RESPONSE FROM THE ENGINE FOR APPROX 1 TO 2 SECONDS. THIS PUT ME IN A VERY DANGEROUS SITUATION AS I HAD TO GET ON THE BRAKES HARD TO SLOW THE VEHICLE ON THE ON RAMP TO KEEP FROM GETTING HIT BY THE FA…

Read full complaint

WHILE TRYING TO MERGE INTO TRAFFIC I PRESSED THE ACCELERATOR TO THE FLOOR TO GET THE TRUCK UP TO THE SPEED OF TRAFFIC FLOW.I HAD NO RESPONSE FROM THE ENGINE FOR APPROX 1 TO 2 SECONDS. THIS PUT ME IN A VERY DANGEROUS SITUATION AS I HAD TO GET ON THE BRAKES HARD TO SLOW THE VEHICLE ON THE ON RAMP TO KEEP FROM GETTING HIT BY THE FASTER TRAFFIC ON THE HIGHWAY. IN ADDITION THE TRAFFIC BEHIND ME HAD TO RAPIDLY SLOW DOWN TO KEEP FROM HITTING ME.WE TOOK THE VEHICLE INTO THE FORD DEALERSHIP ON MONDAY 30 SEPT 2013. THIS WAS RUIDOSO FORD IN RUIDOSO NEW MEXICO. THEY CHECKED THE VEHICLE AND SAID THERE WAS NO PROBLEM WITH IT AND THAT THEY KNEW OF NO OTHER PROBLEMS OF THIS TYPE ON 2013 F-150 FX-4 PICKUP TRUCKS. I AM STILL IN THE TALKING STAGES WITH THEM ABOUT THIS PROBLEM AS I FEEL THEY HAVE MADE LITTLE EFFORT TO SOLVE IT AND THE RESEARCH I HAVE DONE INDICATES THAT FORD MOTOR CORPORATION IS AWARE OF THIS PROBLEM. (THIS PROBLEM HAS HAPPENED TO ME SEVERAL TIMES SINCE I PURCHASED THIS VEHICLE, I THOUGHT THAT AFTER THE BREAK IN PERIOD, AS THE TRUCK WAS NEW WHEN PURCHASED THIS PROBLEM WOULD GO AWAY BUT IT HAS NOT. ALSO THIS TRUCK DOES NOT GET THE GAS MILEAGE THAT IT IS CLAIMED TO GET. *TR

NHTSA ODI #10546335

720 miles · Sep 30, 2013
EngineFuel System, GasolineVehicle Speed Control

FORD F-150 ECOBOOST LOSS OF POWER. - TRYING TO PASS A SEMI ON THE HIGHWAY WHEN THE VEHICLE STUMBLED AFTER A DOWNSHIFT, LOST POWER, CHECK ENGINE LIGHT FLASHED, AND THE VEHICLE STARTED TO SHUDDER. TRIED TO PULL OFF OF SIDE OF ROAD BUT ONCE I WAS ABLE TO GET OVER TO THE MEDIAN, THE LIGHT STOPPED FLASHING AND THE SHUDDER WENT AWAY A…

Read full complaint

FORD F-150 ECOBOOST LOSS OF POWER. - TRYING TO PASS A SEMI ON THE HIGHWAY WHEN THE VEHICLE STUMBLED AFTER A DOWNSHIFT, LOST POWER, CHECK ENGINE LIGHT FLASHED, AND THE VEHICLE STARTED TO SHUDDER. TRIED TO PULL OFF OF SIDE OF ROAD BUT ONCE I WAS ABLE TO GET OVER TO THE MEDIAN, THE LIGHT STOPPED FLASHING AND THE SHUDDER WENT AWAY AS DID THE LIGHT. IT WAS IN THE MID 60S, I HAD TRAVELED ABOUT 120 MILES ON THE HIGHWAY AT ABOUT 70 MPH IN OHIO ON I-75 SOUTH OF TOLEDO. IT HAD BEEN RAINING OFF AND ON ALL DAY. *TR

NHTSA ODI #10546149

2,400 miles · Sep 27, 2013
Engine

I PURCHASED A 2013 FORD 150 SUPERCREW CAB 4X4 WITH THE 3.5L V6 MOTOR 4 WEEKS AGO. ALL HAS BEEN WELL UNTIL THE FIRST RAIN LAST WEEK. I WAS ON THE FREEWAY BEHIND A SLOW VEHICLE, I WENT TO PASS THEY VEHICLE AHEAD OF ME ON A FOUR LANE FREEWAY, AND MY TRUCK STUMBLED AND LOST POWER INSTANTLY AS I PUT MY FOOT DOWN. I HAD MYSELF, WIFE, …

Read full complaint

I PURCHASED A 2013 FORD 150 SUPERCREW CAB 4X4 WITH THE 3.5L V6 MOTOR 4 WEEKS AGO. ALL HAS BEEN WELL UNTIL THE FIRST RAIN LAST WEEK. I WAS ON THE FREEWAY BEHIND A SLOW VEHICLE, I WENT TO PASS THEY VEHICLE AHEAD OF ME ON A FOUR LANE FREEWAY, AND MY TRUCK STUMBLED AND LOST POWER INSTANTLY AS I PUT MY FOOT DOWN. I HAD MYSELF, WIFE, AND TWO CHILDREN 1 AND 2.5 IN THE TRUCK. IT WAS VERY SCARY. THE CHECK ENGINE LIGHT WAS ON AND WITH NO POWER AS SAFELY AS I COULD I MOVED BACK INTO THE SLOW LANE OF TRAFFIC AND OFF THE FREEWAY AROUND OTHER PASSING VEHICLES. I CANNOT BELIEVE THIS. I HAVE 2,400 MILES ON THE VEHICLE. I TURNED IT OFF. RESTARTED AND NO CHECK ENGINE LIGHT. IT RAN FINE, I SCAREDLY PULLED BACK ON FREEWAY AND WENT 50 MPH TO MY DESTINATION. I REPORTED ISSUE TO FORD AND TOOK TRUCK IN. NO ISSUE IS SHOWN AND VEHICLE IS RUNNING FINE. THEY KEPT MY VEHICLE OVERNIGHT TO DIAGNOSE NO ISSUE. HELP! PLEASE! *TR

NHTSA ODI #10545749

Mileage unknown · Sep 24, 2013
Engine

I PURCHASED MY TRUCK BRAND NEW IN APRIL OF 2013. IT IS A 2013 FORD F-150 FX4 SUPER CREW ECOBOOST. MONDAY (9-23-13) I WAS DRIVING ON INTERSTATE I-75 AT APPROX. 70MPH, I HIT THE ACCELERATOR TO PASS A VEHICLE AND WHEN I DID, MY TRUCK DROPPED DOWN TO 2ND OR 3RD GEAR, BEGAN TO SHAKE VIOLENTLY, LOST POWER (HP), AND THE CHECK ENGINE LI…

Read full complaint

I PURCHASED MY TRUCK BRAND NEW IN APRIL OF 2013. IT IS A 2013 FORD F-150 FX4 SUPER CREW ECOBOOST. MONDAY (9-23-13) I WAS DRIVING ON INTERSTATE I-75 AT APPROX. 70MPH, I HIT THE ACCELERATOR TO PASS A VEHICLE AND WHEN I DID, MY TRUCK DROPPED DOWN TO 2ND OR 3RD GEAR, BEGAN TO SHAKE VIOLENTLY, LOST POWER (HP), AND THE CHECK ENGINE LIGHT CAME ON. I PULLED OVER, TURNED OFF THE TRUCK AND WAITED A COUPLE OF MINUTES AND PROCEEDED ON MY DRIVE HOME. I DROVE ONE MORE HOUR, STOPPED IN TAMPA FOR ABOUT TWO HOURS, THEN GOT BACK ON I-75. ONE AND A HALF HOURS LATER, IT DID THE SAME THING AT 60MPH THIS TIME. THIS TRUCK IS KNOWN FOR THIS ISSUE. THE INTERCOOLER SEEMS TO BE THE PROBLEM. MY TRUCK NOW HAS 9500 MILES ON IT. WHAT'S UPSETTING IS THAT THIS IS THE 2ND TIME MY TRUCK HAS DONE THIS. THE FIRST TIME OCCURRED ON JULY 15, 2013 WITH 5,100 MILES ON THE ODOMETER. MY LOCAL FORD DEALERSHIP KEPT MY TRUCK FOR 4 DAYS AND REPLACED THE INTERCOOLER, ASSURING ME THE PROBLEM WAS RESOLVED (WHICH IT WASN'T, AS MY TRUCK REPEATED THE ISSUE YESTERDAY, EVEN WITH THE REPLACEMENT PART). THERE ARE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THIS MODEL TRUCK HAVING THIS ISSUE. THIS IS A HUGE SAFETY CONCERN, AS THE FIRST TIME THIS HAPPENED TO ME, I COULD HAVE BEEN HIT HEAD-ON BY ONCOMING TRAFFIC (BECAUSE THE VEHICLE TOTALLY LOSES ALL POWER, NO ACCELERATION). *JS

NHTSA ODI #10545262

17,000 miles · Sep 19, 2013
EngineFuel System, GasolineVehicle Speed Control

I WAS DRIVING AT 48-50- MPH WHEN I DECIDED TO PASS A CEMENT TRUCK THAT WAS GOING BELOW THE SPEED LIMIT. AS I PULLED OUT TO PASS THE TRUCK EVERYTHING SEEMED FINE. WHEN I GOT ALONGSIDE THE CEMENT TRUCK MY TRUCK STARTED TO HESITATE AND MISFIRE. THE ENGINE LIGHT STARTED FLASHING. I WAS STUCK FROM GOING BACK AS ANOTHER CAR WAS BEHIN…

Read full complaint

I WAS DRIVING AT 48-50- MPH WHEN I DECIDED TO PASS A CEMENT TRUCK THAT WAS GOING BELOW THE SPEED LIMIT. AS I PULLED OUT TO PASS THE TRUCK EVERYTHING SEEMED FINE. WHEN I GOT ALONGSIDE THE CEMENT TRUCK MY TRUCK STARTED TO HESITATE AND MISFIRE. THE ENGINE LIGHT STARTED FLASHING. I WAS STUCK FROM GOING BACK AS ANOTHER CAR WAS BEHIND ME,ALSO TRYING TO PASS THE SLOW TRUCK. I BARELY MADE IT PAST THE CEMENT TRUCK AS AN ONCOMING VEHICLE HAD TO SWERVE INTO THE SHOULDER TO MISS ME AND THE VEHICLE BEHIND ME. WHEN I RETURNED HOME I LOOKED UP ECOBOOST PROBLEMS ON THE INTERNET AND FOUND NUMEROUS OTHER PEOPLE WITH THE SAME PROBLEM. THANKFULLY NO ONE WAS INJURED OR KILLED TODAY, I BELIEVE THE IT WILL ONLY BE A MATTER OF TIME BEFORE THERE IS A FATALITY IF THERE HASN'T BEEN ONE ALREADY. *TR

NHTSA ODI #10544498

10,000 miles · Sep 17, 2013
EngineVehicle Speed Control

I WAS DRIVING FROM MILWAUKEE TO DES MOINES ON SUNDAY SEPT 15TH, 2013, AND WHEN I WENT TO PASS ANOTHER DRIVER IN DUBUQUE THAT PULLED IN FRONT OF ME THE TRUCK LOST POWER AND FAILED TO ACCELERATE AS I ANTICIPATED. IT WAS RAINING OFF AND ON THROUGHOUT THE TRIP, TEMP WAS 55DEG, AND I HAD BEEN ON CRUISE CONTROL FOR THE MAJORITY OF TH…

Read full complaint

I WAS DRIVING FROM MILWAUKEE TO DES MOINES ON SUNDAY SEPT 15TH, 2013, AND WHEN I WENT TO PASS ANOTHER DRIVER IN DUBUQUE THAT PULLED IN FRONT OF ME THE TRUCK LOST POWER AND FAILED TO ACCELERATE AS I ANTICIPATED. IT WAS RAINING OFF AND ON THROUGHOUT THE TRIP, TEMP WAS 55DEG, AND I HAD BEEN ON CRUISE CONTROL FOR THE MAJORITY OF THE TIME BEFORE THIS HAPPENED. BASICALLY, I WENT TO CHANGE LANES AND PUSHED THE ACCELERATOR PEDAL AND INSTEAD OF GAINING SPEED QUICKLY I RECEIVED NO ACCELERATION CAUSING THE CARS BEHIND ME TO HAVE TO BRAKE QUICKLY. DURING THIS TIME THE CHECK ENGINE LIGHT WAS FLASHING INDICATING A MIS-FIRE WAS OCCURRING AT WHICH POINT I KNEW WHAT WAS HAPPENING AND GOT OFF THE HIGHWAY AND THE MIS-FIRES CEASED AND AFTER A BRIEF STOP I WAS ABLE TO CONTINUE MY DRIVE. MY TRUCK WAS BUILT ON 1/15/2013 AND HAS ALL THE UPDATES TO THE INTERCOOLER FORD CLAIMS ADDRESSED THE ISSUE. THE ISSUE IS DEFINITELY NOT FIXED AND DESPITE FORDS CLAIM IN THEIR RESPONSE TO THE NHTSA INVESTIGATION THIS IS A SAFETY ISSUE. FORD ALSO CLAIMS IN THEIR RESPONSE TO THE NHTSA INVESTIGATION THAT MANY COMPLAINTS ARE JUST AGAINST THE DEALERS AND NOT FOR SAFETY CONCERNS SO LET ME BE PERFECTLY CLEAR HERE THIS IS A SAFETY COMPLAINT! *TR

NHTSA ODI #10544130

14,200 miles · Sep 11, 2013
Engine

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE BEGAN TO SHAKE, WOBBLE AND LOSE POWER. THE VEHICLE WAS TURNED OFF, SHIFTED INTO NEUTRAL, AND RESTARTED HOWEVER, THE VEHICLE CONTINUED TO RUN ERRATICALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED T…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE BEGAN TO SHAKE, WOBBLE AND LOSE POWER. THE VEHICLE WAS TURNED OFF, SHIFTED INTO NEUTRAL, AND RESTARTED HOWEVER, THE VEHICLE CONTINUED TO RUN ERRATICALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT A SHROUD WOULD NEED TO BE PLACED OVER THE INNER COOLER TO PREVENT CONDENSATION. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED THE SAME DAY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 14,200.

NHTSA ODI #10543118

2,300 miles · Sep 5, 2013
EngineFuel System, Gasoline

WHILE DRIVING FROM WILSON, N.C. TO SWAN QUARTER N.C. IN THE EARLY MORNING HOURS ON A FISHING TRIP, I STARTED TO PASS A SLOW SCHOOL BUS THEN MY TRUCK START JUMPING, LOOSING POWER AND THE CHECK ENGINE LIGHT STARTED FLASHING. IT ALMOST CAUSED ME TO HAVE TO DITCH MY TRUCK TO KEEP FROM HITTING ANOTHER VEHICLE. IT WAS A VERY FOGGY MO…

Read full complaint

WHILE DRIVING FROM WILSON, N.C. TO SWAN QUARTER N.C. IN THE EARLY MORNING HOURS ON A FISHING TRIP, I STARTED TO PASS A SLOW SCHOOL BUS THEN MY TRUCK START JUMPING, LOOSING POWER AND THE CHECK ENGINE LIGHT STARTED FLASHING. IT ALMOST CAUSED ME TO HAVE TO DITCH MY TRUCK TO KEEP FROM HITTING ANOTHER VEHICLE. IT WAS A VERY FOGGY MORNING AND I HAD BEEN DRIVING AT 50 AND 55 MPH FOR A LONG DISTANCE BEFORE THIS HAPPENED. *JB

NHTSA ODI #10542172

10,500 miles · Sep 4, 2013
Engine

I WAS DRIVING 65 MPH ON THE RIGHT HAND SIDE OF A TWO LANE HIGHWAY. IN ORDER TO PASS A CAR THAT WAS GOING AT A REDUCED SPEED I MOVED INTO THE LEFT HAND LANE AND BEGAN TO ACCELERATE. IMMEDIATELY, AS I ACCELERATED THE ENGINE MISFIRED AND THEN I LOST ENGINE POWER. I HAD TO BRAKE AND GET BACK INTO THE RIGHT HAND LANE SO I WOULD NOT C…

Read full complaint

I WAS DRIVING 65 MPH ON THE RIGHT HAND SIDE OF A TWO LANE HIGHWAY. IN ORDER TO PASS A CAR THAT WAS GOING AT A REDUCED SPEED I MOVED INTO THE LEFT HAND LANE AND BEGAN TO ACCELERATE. IMMEDIATELY, AS I ACCELERATED THE ENGINE MISFIRED AND THEN I LOST ENGINE POWER. I HAD TO BRAKE AND GET BACK INTO THE RIGHT HAND LANE SO I WOULD NOT CAUSE AN ISSUE WITH ONCOMING TRAFFIC BEHIND ME. THE CHECK ENGINE LIGHT IMMEDIATELY STARTED FLASHING AND I PULLED OVER. IT WAS A DANGEROUS SITUATION TO LOSE POWER AT HIGH SPEEDS AND THE OUTCOME COULD HAVE BEEN MUCH WORSE. I WAS GLAD I DID NOT HAVE TOO MUCH TRAFFIC BEHIND ME AND THE CARS WERE ABLE TO NAVIGATE AROUND ME AS I DECELERATED DUE TO THE ENGINE MISFIRING. SCARY SITUATION TO BE IN AND DISHEARTENING AFTER BUYING THIS TRUCK BRAND NEW AND ONLY HAVING 10,000 MILES ON IT. FORD NEEDS TO DO SOMETHING.*JB

NHTSA ODI #10541849

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of