← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
7,800 miles · Jan 26, 2014
EngineVehicle Speed Control

I HAD BEEN DRIVING ON THE HIGHWAY IN THE RAIN FOR APPROXIMATELY 2 HOURS, WHEN I NEEDED TO PASS A SEMI-TRUCK AND PUSHED THE ACCELERATOR PEDAL TO ACCELERATE THE TRUCK STARTED TO SHUDDER AND STALL, WITH AN ACCOMPANYING FLASHING MIL LIGHT. I LET OFF THE ACCELERATOR AND THE MIL LIGHT BECAME STEADY. I PULLED OFF TO THE SIDE OF THE R…

Read full complaint

I HAD BEEN DRIVING ON THE HIGHWAY IN THE RAIN FOR APPROXIMATELY 2 HOURS, WHEN I NEEDED TO PASS A SEMI-TRUCK AND PUSHED THE ACCELERATOR PEDAL TO ACCELERATE THE TRUCK STARTED TO SHUDDER AND STALL, WITH AN ACCOMPANYING FLASHING MIL LIGHT. I LET OFF THE ACCELERATOR AND THE MIL LIGHT BECAME STEADY. I PULLED OFF TO THE SIDE OF THE ROAD, SHUT-OFF THE TRUCK AND OPENED THE HOOD TO SEE IF THERE WAS ANY OBVIOUS CAUSE TO THE MISFIRE CONDITION...AND THERE WAS NOT. I RESTARTED THE TRUCK, BUT THE MIL LIGHT REMAINED ILLUMINATED STEADY. I DROVE CONSERVATIVELY HOME AND HOOKED UP MY CODE READER TO THE OBD-II PORT. IT SHOWED CODES OF P0300, P0305, AND P0306...THE FREEZE-FRAME DATA SHOWED THE CONDITION OCCURRED AT 65 MPH AND 2578 RPMS. I CALLED THE DEALER AND SETUP AN APPOINTMENT TO HAVE THE TRUCK INSPECTED. THE DEALER APPLIED FORD TSB 13-8-10 AS THE FIX (DON'T KNOW IF THIS WILL FIX THE MISFIRES OR NOT). MY TRUCK HAS THE 3.5L ECOBOOST MOTOR. *TR

NHTSA ODI #10561498

600 miles · Jan 22, 2014
EngineFuel System, Gasoline

VEHICLE WILL NOT START WHEN PARKED ON A DECLINE OF APPROXIMATELY 8% AND FUEL LEVEL BELOW 1/4 OF TANK OR LESS THAN 100 MILES ON FUEL WARNING INDICATOR. LOW FUEL WARNING LIGHT COMES ON AND VEHICLE WILL NOT START UNTIL ON LEVEL GROUND. I AM NOT COMFORTABLE TRAVELING OFF-ROAD OR IN MOUNTAINS IF FUEL LEVEL IS BELOW 1/4 TANK AS THIS…

Read full complaint

VEHICLE WILL NOT START WHEN PARKED ON A DECLINE OF APPROXIMATELY 8% AND FUEL LEVEL BELOW 1/4 OF TANK OR LESS THAN 100 MILES ON FUEL WARNING INDICATOR. LOW FUEL WARNING LIGHT COMES ON AND VEHICLE WILL NOT START UNTIL ON LEVEL GROUND. I AM NOT COMFORTABLE TRAVELING OFF-ROAD OR IN MOUNTAINS IF FUEL LEVEL IS BELOW 1/4 TANK AS THIS ISSUE MAY CAUSE VEHICLE TO STALL RESULTING IN AN ACCIDENT OR BEING STRANDED. *TR

NHTSA ODI #10560931

17,200 miles · Jan 20, 2014
Engine

FORD ECOBOOST ENGINE. TRAVELING ON STATE HIGHWAY (ONE LANE IN EACH DIRECTION) AT ABOUT 45MPG (SPEED LIMIT WAS 55). I ATTEMPTED TO PASS A SLOWER CAR. I DEPRESSED THE ACCELERATOR AND MOVE INTO THE ONCOMING TRAFFIC LANE. AS I CAME EVEN WITH THE SLOWER CAR, THE ENGINE CUT OUT AND I WAS ONLY ABLE TO MAINTAIN A SPEED OF 40 TO 45…

Read full complaint

FORD ECOBOOST ENGINE. TRAVELING ON STATE HIGHWAY (ONE LANE IN EACH DIRECTION) AT ABOUT 45MPG (SPEED LIMIT WAS 55). I ATTEMPTED TO PASS A SLOWER CAR. I DEPRESSED THE ACCELERATOR AND MOVE INTO THE ONCOMING TRAFFIC LANE. AS I CAME EVEN WITH THE SLOWER CAR, THE ENGINE CUT OUT AND I WAS ONLY ABLE TO MAINTAIN A SPEED OF 40 TO 45 MPH. ANOTHER CAR PULLED IN RIGHT BEHIND ME TO ALSO PASS THE SLOWER CAR AT THE SAME TIME. A SEMI TRAILER CRESTED THE HILL AND WAS QUICKLY APPROACHING. I WAS UNABLE TO HIT THE BREAKS AND RETURN TO MY LANE OF TRAFFIC BECAUSE THE SECOND PASSING CAR WAS ACCELERATING QUICKLY BEHIND ME AND I WAS UNABLE TO ACCELERATE AT ALL BECAUSE THE ENGINE WAS STALLING. THE SECOND PASSING CAR REALIZED SOMETHING WAS WRONG AND HIT THE BREAKS ALLOWING ME TO ALSO SLIDE BACK IN LINE AS THE SEMI SHIFTED ONTO THE SHOULDER IN HIS LANE. WE WENT THREE-WIDE ON A TWO LANE HIGHWAY AT HIGHWAY SPEEDS. AFTER ABOUT A MINUTE, THE ENGINE WARNING LIGHTS WENT OUT ON THE DASH, THE ENGINE KICKED BACK IN. I WAS ABLE TO SAFELY PASS THE SLOWER CAR AND TRAVELED HOME. I TOOK THE TRUCK TO THE LOCAL DEALER FOR EVALUATION AND THEY TOLD ME THIS IS KNOWN TO HAPPEN DURING RAINY WEATHER. WEATHER AT TIME OF INCIDENT, PARTLY CLOUDY, AROUND 4:30 IN THE AFTERNOON. THIS IS THE THIRD TIME MY ENGINE HAS CUT OUT ON ME DURING ACCELERATION. THIS IS THE ONLY TIME TO NEARLY WRAP UP FOUR VEHICLES IN A NASTY WRECK. *TR

NHTSA ODI #10560597

19,549 miles · Jan 14, 2014
EngineCrash

WHEN HARD ACCELERATION, VEHICLE LOSSES ALL POWER AND WILL NOT ACCELERATE. THIS HAS ALMOST CAUSED A ACCIDENT THREE DIFFERENT OCCASIONS. FORD DEALER TELLS ME THEY CAN'T FIND A PROBLEM BUT THERE'S OTHER ECOBOOST OWNERS WITH THE SAME PROBLEM. *TR

NHTSA ODI #10559762

8,000 miles · Jan 3, 2014
Engine

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED AS ND THE CHECK ENGINE WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 8,000 AND THE CURRENT MILEAGE WA…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED AS ND THE CHECK ENGINE WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 8,000 AND THE CURRENT MILEAGE WAS 8,100. *TR

NHTSA ODI #10558361

16,400 miles · Jan 2, 2014
Engine

WHILE DRIVING MY FORD ECOBOOST F-150 ON I-40 ON THE WAY TO WORK THIS MORNING I HAD A SEVERE LOSS OF POWER WHILE MERGING ONTO THE HIGHWAY. I HAD TO TAKE EVASIVE ACTION TO MISS OTHER TRAFFIC DUE TO THE SUDDEN LOSS OF POWER AND OTHERS HAD TO AVOID ME AS WELL. THIS WAS A VERY DANGEROUS AND SCARY SITUATION. I AM TAKING MY TRUCK TO TH…

Read full complaint

WHILE DRIVING MY FORD ECOBOOST F-150 ON I-40 ON THE WAY TO WORK THIS MORNING I HAD A SEVERE LOSS OF POWER WHILE MERGING ONTO THE HIGHWAY. I HAD TO TAKE EVASIVE ACTION TO MISS OTHER TRAFFIC DUE TO THE SUDDEN LOSS OF POWER AND OTHERS HAD TO AVOID ME AS WELL. THIS WAS A VERY DANGEROUS AND SCARY SITUATION. I AM TAKING MY TRUCK TO THE DEALERSHIP FOR THEM TO LOOK AT THE PROBLEM. CONDITIONS WERE DAMP AND COLD THIS MORNING WHILE I WAS DRIVING. I THINK THIS MAY BE RELATED TO THE WET / DAMP CONDITIONS THAT AFFECT THE ECOBOOST ENGINES LOSING POWER. *TR

NHTSA ODI #10558238

8,600 miles · Dec 30, 2013
EngineVehicle Speed Control

AFTER DRIVING IN RAIN FOR A COUPLE HOURS IN MY ECOBOOST F150, I WAS MERGING ONTO AN INTERSTATE WHERE TRAFFIC REQUIRED HEAVY ACCELERATION AND THE VEHICLE STALLED FROM 60-65 ABRUPTLY TO 45 MPH. THE VEHICLE SHUTTERED AND WOULD NOT ACCELERATE BACK TO HIGHWAY SPEEDS FOR NEARLY A MINUTE. THE ENGINE RAN EXTREMELY ROUGH AND WAS UNRESP…

Read full complaint

AFTER DRIVING IN RAIN FOR A COUPLE HOURS IN MY ECOBOOST F150, I WAS MERGING ONTO AN INTERSTATE WHERE TRAFFIC REQUIRED HEAVY ACCELERATION AND THE VEHICLE STALLED FROM 60-65 ABRUPTLY TO 45 MPH. THE VEHICLE SHUTTERED AND WOULD NOT ACCELERATE BACK TO HIGHWAY SPEEDS FOR NEARLY A MINUTE. THE ENGINE RAN EXTREMELY ROUGH AND WAS UNRESPONSIVE TO THROTTLE INPUT FROM DRIVER. I HAD MY FAMILY WITH ME AND WAS VERY UPSET THAT WE COULD HAVE BEEN IN A VERY BAD ACCIDENT. THE DEALERSHIP DID NOT INFORM ME OF PROBLEMS WITH THE ECOBOOST AT THE TIME OF SALE, EVEN THOUGH THIS PROBLEM HAS BEEN GOING ON SINCE THE ECOBOOST INTRODUCTION. THIS IS A SERIOUS SAFETY ISSUE AND I FIND THE NHTSA HAS FAILED TO RECALL THESE TRUCKS. THE DEALERSHIP WHERE PURCHASED IS MARLER FORD, NEAR ALEXANDRIA, LA. YOU ARE NOT TO USE MY PERSONAL INFORMATION IN ANYWAY EXCEPT TO HANDLE THIS COMPLAINT. WHICH INCLUDES BUT NOT LIMITED TO SELLING OR OTHERWISE PROVIDING THIS INFORMATION TO OUTSIDE AGENCIES. *TR

NHTSA ODI #10557668

15 miles · Dec 27, 2013
Electrical SystemEngineVisibility/wiper

WIPERS NOT WORKING RIGHT--BATTERY LIGHT COMES ON - ENGINE STALLS ON ROAD WHILE DRIVING--GAUGES NOT WORKING RIGHT-HAD SPEED SET AT 55 MPH AND MOTOR WENT DOWN BUT START UP ON IT'S OWN---RADIO STOPS WORKING ALONE WITH THE PHONE TOO; THEY BUT IN A NEW BATTERY ON MY REQUEST AND NOW NEW THINGS ARE HAPPENING TO GAUGES AN TACK JUMPING…

Read full complaint

WIPERS NOT WORKING RIGHT--BATTERY LIGHT COMES ON - ENGINE STALLS ON ROAD WHILE DRIVING--GAUGES NOT WORKING RIGHT-HAD SPEED SET AT 55 MPH AND MOTOR WENT DOWN BUT START UP ON IT'S OWN---RADIO STOPS WORKING ALONE WITH THE PHONE TOO; THEY BUT IN A NEW BATTERY ON MY REQUEST AND NOW NEW THINGS ARE HAPPENING TO GAUGES AN TACK JUMPING UP AND DOWN WITH THE KEY OUT??? ALARM GOES OFF SOME TIMES WHEN MY PHONE RINGS AN I AM NOT IN THE TRUCK!!! *TR

NHTSA ODI #10557406

24,000 miles · Dec 26, 2013
Engine

MY FAMILY AND I WERE DRIVING ON AN INTERSTATE IN DALLAS. THE VEHICLE WAS A 2013 FORD F150 ECOBOOST. IT WAS TOWARDS THE END OF MORNING RUSH HOUR TRAFFIC. I TRAVELING APPROXIMATELY 60 MPH AND WENT TO PASS AN 18-WHEELER. I ACCELERATED TO PASS IT, WHEN THE ENTIRE TRUCK STARTED VIOLENTLY SHAKING. THE CHECK ENGINE CAME ON AND THE…

Read full complaint

MY FAMILY AND I WERE DRIVING ON AN INTERSTATE IN DALLAS. THE VEHICLE WAS A 2013 FORD F150 ECOBOOST. IT WAS TOWARDS THE END OF MORNING RUSH HOUR TRAFFIC. I TRAVELING APPROXIMATELY 60 MPH AND WENT TO PASS AN 18-WHEELER. I ACCELERATED TO PASS IT, WHEN THE ENTIRE TRUCK STARTED VIOLENTLY SHAKING. THE CHECK ENGINE CAME ON AND THE ENGINE IMMEDIATELY LOST POWER. THE TRUCKS ENGINE WAS UNABLE MAINTAIN HIGHWAY SPEEDS AND I FEARED WE WOULD BE STRUCK BY ANOTHER VEHICLE. WE WERE ABLE TO LIMP IT OFF THE HIGHWAY WITHOUT ANY FURTHER INCIDENTS. FORTUNATELY THIS DIDN'T HAPPEN ON A TWO LANE ROAD WHILE ATTEMPTED TO PASS ANOTHER VEHICLE. *TR

NHTSA ODI #10557365

10,590 miles · Dec 21, 2013
EngineVehicle Speed Control

THIS IS THE THIRD TIME THE VEHICLE HAS DONE THIS TO ME WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE (ECOBOOST MOTOR) THE ENGINE HAS SHUDDERED AND LOST ALL POWERS WHEN ATTEMPTING TO PASS ANOTHER VEHICLE OR ACCELERATE. ON THE FIRST INSTANCE I WAS ON A TWO LANE ROAD ATTEMPTING TO ACCELERATE TO PASS A SEMI TRUCK WHEN THE TRUCK STARTE…

Read full complaint

THIS IS THE THIRD TIME THE VEHICLE HAS DONE THIS TO ME WHILE DRIVING AT HIGHWAY SPEEDS THE VEHICLE (ECOBOOST MOTOR) THE ENGINE HAS SHUDDERED AND LOST ALL POWERS WHEN ATTEMPTING TO PASS ANOTHER VEHICLE OR ACCELERATE. ON THE FIRST INSTANCE I WAS ON A TWO LANE ROAD ATTEMPTING TO ACCELERATE TO PASS A SEMI TRUCK WHEN THE TRUCK STARTED MISSING SO BAD IT CHOKED OUT AND SHUT DOWN IN THE MIDDLE OF THE ROAD WITH ONCOMING TRAFFIC I HAD TO SWERVE INTO A DITCH TO AVOID A HEAD ON COLLISION. THE SECOND TIME WAS ON A FOUR LANE DURING A 45 MINUET DRIVE WHEN I WENT TO PASS IT LOST ALL POWER CAUSING ME TO DROP TO 40 MILES AN HOUR IN THE PASSING LANE OF A HIGHWAY CAUSING MANY VEHICLES TO SWERVE TO AVOID COLLISION. THE MOST RECENT TIME WAS WHEN SAME AS THE SECOND GOING TO PASS SOMEBODY THE TRUCK LOST ALL ACCELERATION WOULD NOT GET OUT OF THE WAY OF TRAFFIC NEARLY CAUSING ANOTHER ACCIDENT. I HAVE HAD IT INTO THE DEALER SEVERAL TIMES AND I AM CONSTANTLY GETTING WE SEE THE HISTORY CODE BUT WE CAN NOT REPRODUCE THE PROBLEM. THIS PROBLEM HAS LEFT ME FEELING UNSAFE TO DRIVE MY VEHICLE AND HURTING RESALE VALUE AS WELL AS PUTTING MY SAFETY ON THE LINE. *TR

NHTSA ODI #10556924

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of