← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
87,000 miles · Jun 15, 2016
EngineFuel/propulsion System

THROTTLE BODY FAILED ON MY PICKUP WHILE DRIVING. WENT INTO LIMP MODE AND ENGINE WOULDN'T REV UP. HAD TO SHUT OFF AND RESTART MULTIPLE TIMES IN ORDER TO MAKE IT TO THE SHOP. SCANNED IT AND HAD CODE P2112 THROTTLE BODY STUCK CLOSED. REPLACED THROTTLE BODY AND SEEMS TO BE OK NOW. GLAD I WAS JUST PUTTING ALONG WHEN IT HAPPENED OR I…

Read full complaint

THROTTLE BODY FAILED ON MY PICKUP WHILE DRIVING. WENT INTO LIMP MODE AND ENGINE WOULDN'T REV UP. HAD TO SHUT OFF AND RESTART MULTIPLE TIMES IN ORDER TO MAKE IT TO THE SHOP. SCANNED IT AND HAD CODE P2112 THROTTLE BODY STUCK CLOSED. REPLACED THROTTLE BODY AND SEEMS TO BE OK NOW. GLAD I WAS JUST PUTTING ALONG WHEN IT HAPPENED OR IT COULD HAVE BEEN A DISASTER.

NHTSA ODI #10874495

78,000 miles · Jun 9, 2016
Engine

I WANTED TO MAKE YOUR OFFICE AWARE AND SEEK ANY ASSISTANCE YOU MAY BE ABLE TO OFFER REGARDING A SAFETY ISSUE WITH THE FORD ECOBOOST ENGINE FOUND IN MANY TRUCKS IN OUR STATE. RECENTLY I WAS DRIVING ON A TWO LANE ROAD AND ENDED UP BEHIND A SLOW MOVING TRACTOR TRAILER. WHEN GETTING TO A PROPER PASSING ZONE, I ACCELERATED TO PASS …

Read full complaint

I WANTED TO MAKE YOUR OFFICE AWARE AND SEEK ANY ASSISTANCE YOU MAY BE ABLE TO OFFER REGARDING A SAFETY ISSUE WITH THE FORD ECOBOOST ENGINE FOUND IN MANY TRUCKS IN OUR STATE. RECENTLY I WAS DRIVING ON A TWO LANE ROAD AND ENDED UP BEHIND A SLOW MOVING TRACTOR TRAILER. WHEN GETTING TO A PROPER PASSING ZONE, I ACCELERATED TO PASS THE VEHICLE. JUST ABOUT THE TIME I WAS ALONGSIDE IT, MY TRUCK (A 2013 F150 ECOBOOS WITH ABOUT 78K MILES) STARTED SHUDDERING, A CHECK ENGINE LIGHT CAME ON AND IT DRASTICALLY REDUCED POWER ALMOST CAUSING AN ACCIDENT WHEN ANOTHER VEHICLE WAS APPROACHING FROM THE OTHER DIRECTION (THIS TOOK SEVERAL SECONDS - THE PASSING ZONE WAS ENTIRELY CLEAR WHEN I STARTED THE MANEUVER). I TOOK MY VEHICLE TO A LOCAL DEALER FOR REPAIRS ONLY TO FIND OUT THAT IT WAS FROM A MANUFACTURER DEFECT AFFECTING CONDENSATION IN THE COOLING UNIT OF THE TURBOS. FORD HAD ISSUED A TECHNICAL SERVICE BULLETIN (TSB-14-0017) REGARDING THE ISSUE BUT NO RECALLS MADE NOR ANY CUSTOMER NOTIFICATIONS SENT OUT. I HAVE NOTIFIED FORD AND REQUESTED 1) THEY REIMBURSE THE COST OF REPAIRS; 2) ISSUE AN IMMEDIATE RECALL FOR THIS MAJOR SAFETY DEFECT; AND 3) IMMEDIATELY NOTIFY OWNERS OF THEIR PRODUCT AS TO THE POSSIBLE SAFETY HAZARD THAT COULD OCCUR WHEN PUTTING THE ENGINE UNDER A HEAVY RPM LOAD. ADDITIONALLY, I AM ASKING IF YOUR OFFICE CAN FOLLOW UP WITH THIS REQUEST TO ENSURE THAT SOMEONE DOESN'T ENCOUNTER THE SAME BAD SITUATION OR WORSE. THIS WAS A POTENTIAL FATALITY SITUATION THAT COULD HAVE BEEN AVOIDED. THANKS [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10873460

37,000 miles · Jun 7, 2016
EngineFuel/propulsion System

VEHICLE RUNS GREAT MOST OF THE TIME, BUT WHEN DRIVING AT HIGHWAY SPEEDS FOR A COUPLE OF HOURS IN THE RAIN, SNOW, HUMID OR MISTING CONDITIONS, THE TRUCK WILL SOMETIMES LOOSE POWER AND START SHAKING/STUTTERING WHEN ACCELERATING TO PASS ANOTHER VEHICLE, OR WHEN CLIMBING A HILL. MOST OF TIME, IT IS A VERY SLIGHT SHUDDER BUT WHEN UN…

Read full complaint

VEHICLE RUNS GREAT MOST OF THE TIME, BUT WHEN DRIVING AT HIGHWAY SPEEDS FOR A COUPLE OF HOURS IN THE RAIN, SNOW, HUMID OR MISTING CONDITIONS, THE TRUCK WILL SOMETIMES LOOSE POWER AND START SHAKING/STUTTERING WHEN ACCELERATING TO PASS ANOTHER VEHICLE, OR WHEN CLIMBING A HILL. MOST OF TIME, IT IS A VERY SLIGHT SHUDDER BUT WHEN UNDER HEAVY THROTTLE, THE ENGINE WILL START CUTTING OUT, LOOSE POWER AND SPEED, AND THE CHECK ENGINE LIGHT WILL START FLASHING. WHEN THIS HAPPENS, I WILL HAVE TO PULL OVER TO THE SLOWER LANE OF TRAFFIC, OR ONTO THE SHOULDER. AFTER ABOUT 30 SECONDS THE CHECK ENGINE LIGHT WILL EITHER GO OUT, OR COME ON SOLID. IT IS VERY FRIGHTENING WHEN THIS HAPPENS BUT IT HAS HAPPENED ENOUGH TIMES THAT I ALMOST EXPECT IT WHEN THE CONDITIONS ARE RIGHT FOR IT TO OCCUR. I HAVE TAKEN IT INTO VARIOUS FORD DEALERSHIPS AS I AM USUALLY OUT OF TOWN ON VACATION WHEN IT HAPPENS. THEY HAVE APPLIED ALL THE TSB'S RECOMMENDED BY FORD MOTOR, BUT OBVIOSITY THEY CAN'T RECREATE THE ISSUE ON DEMAND AND APPARENTLY CAN'T CORRECT IT. THIS IS A VERY DANGEROUS ISSUE AND I WOULD SUPPORT A TOTAL RECALL OF ALL ECOBOOST VEHICLES UNTIL CORRECTED.

NHTSA ODI #10872939

53,482 miles · May 25, 2016
Engine

CONTINUED LACK OF POWER WHEN ACCELERATING. SEVERAL TIMES WHILE IN A TURNING LANE, I CAN HIT THE ACCELERATOR AND THE ENGINE GOES TO A COMPLETE SHUT DOWN OF POWER. I HAVE READ THE RELATED ENGINE ISSUES HERE, BUT AS A MECHANICAL ENGINEER, I CAN TELL YOU THIS IS A TURBO ISSUE. THIS ISSUE HAS ALMOST CAUSED ME SEVERAL ACCIDENTS DUE…

Read full complaint

CONTINUED LACK OF POWER WHEN ACCELERATING. SEVERAL TIMES WHILE IN A TURNING LANE, I CAN HIT THE ACCELERATOR AND THE ENGINE GOES TO A COMPLETE SHUT DOWN OF POWER. I HAVE READ THE RELATED ENGINE ISSUES HERE, BUT AS A MECHANICAL ENGINEER, I CAN TELL YOU THIS IS A TURBO ISSUE. THIS ISSUE HAS ALMOST CAUSED ME SEVERAL ACCIDENTS DUE TO ONCOMING TRAFFIC AND THE LACK OF POWER FROM ENGINE THAT CAUSES LACK OF MOVEMENT FROM THE TRUCK. THE LACK OF POWER LAST FOR 1 TO 5 SECONDS AND IT IS THE SAME IN WET OR DRY WEATHER. I WANT THIS RESOLVED.

NHTSA ODI #10870822

38,491 miles · May 9, 2016
EngineFuel/propulsion System

WHILE DRIVING, INCLUDING BUT NOT ALWAYS WHILE DRIVING ON THE INTERSTATE DURING HEAVY FAST TRAFFIC, AND INCLUDING BUT NOT ALWAYS WHILE PULLING A TRAILER, THE ORANGE WRENCH LIGHT COMES ON, THE TRUCK ABRUPTLY ENTERS "LIMP" MODE REQUIRING RAPID PULLING OFF THE HIGHWAY IN ORDER TO STOP AND RESTART THE ENGINE, AND THEN A DANGEROUS PUL…

Read full complaint

WHILE DRIVING, INCLUDING BUT NOT ALWAYS WHILE DRIVING ON THE INTERSTATE DURING HEAVY FAST TRAFFIC, AND INCLUDING BUT NOT ALWAYS WHILE PULLING A TRAILER, THE ORANGE WRENCH LIGHT COMES ON, THE TRUCK ABRUPTLY ENTERS "LIMP" MODE REQUIRING RAPID PULLING OFF THE HIGHWAY IN ORDER TO STOP AND RESTART THE ENGINE, AND THEN A DANGEROUS PULLING BACK ON THE HIGHWAY FROM THE BREAKDOWN LANE IN HEAVY TRAFFIC. THIS HAS BEEN DIAGNOSED AS NEEDING A THROTTLE BODY REPLACEMENT #BL3Z-9E926-B, BUT I AM TOLD BY A FORD DEALER THAT THERE ARE ABOUT 3300 OTHERS WAITING FOR THIS PART AND THAT THEY ARE SO BACKLOGGED THAT NO DELIVERY DATE IS YET IN THEIR SYSTEM. RAPID, UNEXPECTED, AND REPEATED LOSS OF POWER WHILE DRIVING IS VERY DANGEROUS.

NHTSA ODI #10863877

115,000 miles · May 2, 2016
Engine

ON 03/17/2016 I WAS DRIVING ON ROUTE 287 IN NEW JERSEY IN THE FAST LANE AT SPEEDS AROUND 65 MPH MY TRUCK HAD A LOSS OF POWER. THE CHECK ENGINE LIGHT NEVER CAME ON AND THE TRUCK STARTED SHUTTERING REALLY BAD, WITH THE ACCELERATOR PUSHED DOWN THE TRUCK WAS SLOWING DOWN AND THE CARS BEHIND ME WERE HITTING THEIR BRAKES. AFTER ABOUT …

Read full complaint

ON 03/17/2016 I WAS DRIVING ON ROUTE 287 IN NEW JERSEY IN THE FAST LANE AT SPEEDS AROUND 65 MPH MY TRUCK HAD A LOSS OF POWER. THE CHECK ENGINE LIGHT NEVER CAME ON AND THE TRUCK STARTED SHUTTERING REALLY BAD, WITH THE ACCELERATOR PUSHED DOWN THE TRUCK WAS SLOWING DOWN AND THE CARS BEHIND ME WERE HITTING THEIR BRAKES. AFTER ABOUT 2 MINUTES THE TRUCK WENT BACK TO NORMAL. I BROUGHT THE TRUCK TO THE DEALERSHIP AND THEY WERE UNABLE TO DIAGNOSE THE PROBLEM. THEY SAID THEY KNOW ABOUT THIS ISSUE AND REMOVED THE AIR DEFLECTOR AND REPROGRAMMED THE POWERTRAIN CONTROL MODULE. 7 DAYS LATER I HAD ANOTHER CLOSE CALL ON ROUTE 287 IN NEW JERSEY WHEN MY TRUCK STARTED MISFIRING AND SHUTTERING. AGAIN NO CHECK ENGINE LIGHT EVER CAME ON. I BROUGHT THE TRUCK BACK TO THE DEALERSHIP. THERE WERE NO DIAGNOSTIC TROUBLE CODES OR ALARMS. THE MECHANIC TOOK THE TRUCK FOR A TEST DRIVE USING AN INTEGRATED DIAGNOSTIC SYSTEM AND FOUND A POWER BALANCE AND CYLINDER #4 MISFIRE. THEY REPLACED #4 COIL AND GAVE THE TRUCK BACK TO ME. 24 HOURS LATER AND ANOTHER CLOSE CALL THE TRUCK IS BACK TO THE DEALERSHIP AND I WAS TOLD IT WAS ANOTHER CYLINDER #4 MISFIRE. THE DEALERSHIP IS BEING VERY HELPFUL AND TRYING EVERYTHING THEY CAN BUT THIS IS AN ENORMOUS SAFETY PROBLEM AND IF THIS ISSUE IS NOT CORRECTED IT CAN TURN INTO A FATAL ENDING.

NHTSA ODI #10862656

63,000 miles · May 2, 2016
Engine

LOSS OF POWER AND SHUDDER AT SPEEDS OF 60+MPH WHEN TRYING TO ACCELERATE TO PASS OTHER VEHICLES OR GOING UP HILLS. IN 2014 I PURCHASED A USED 2013 FORD F-150 ECO BOOST TRUCK. ABOUT A MONTH AGO I EXPERIENCED A SHUDDER AND LOSS OF POWER WHEN TRYING TO PASS ANOTHER VEHICLE WHILE DRIVING ON THE FREEWAY. THE MPH WAS ABOUT 70+ MILES.…

Read full complaint

LOSS OF POWER AND SHUDDER AT SPEEDS OF 60+MPH WHEN TRYING TO ACCELERATE TO PASS OTHER VEHICLES OR GOING UP HILLS. IN 2014 I PURCHASED A USED 2013 FORD F-150 ECO BOOST TRUCK. ABOUT A MONTH AGO I EXPERIENCED A SHUDDER AND LOSS OF POWER WHEN TRYING TO PASS ANOTHER VEHICLE WHILE DRIVING ON THE FREEWAY. THE MPH WAS ABOUT 70+ MILES. SINCE THAT TIME IT HAPPENS ALL OF THE TIME WHEN DRIVING ABOVE 60MPH OR HIGHER WHEN I TRY TO ACCELERATE. IF I GRADUALLY ACCELERATE IT DOESN'T HAPPEN.

NHTSA ODI #10862503

34,000 miles · Apr 7, 2016
EnginePower TrainVehicle Speed Control

MY TRUCK HAS BEEN EXPERIENCING HESITATION UPON ACELLERATION AND IS MAKING NOISES AND MY CHECK ENGINE LIGHT WAS ON. I TOOK IT TO THE DEALERSHIP ON FEBRUARY 2, 2016 BE FIXED AND AT FIRST IT WAS COVERED UNDER WARRANTY. I TOOK IT BACK ON FEBRUARY 16, 2016 BC I HAD TO HAVE A FORD RENTAL PER FORD. THE TRUCK WAS REPAIRED BUT THEN IT W…

Read full complaint

MY TRUCK HAS BEEN EXPERIENCING HESITATION UPON ACELLERATION AND IS MAKING NOISES AND MY CHECK ENGINE LIGHT WAS ON. I TOOK IT TO THE DEALERSHIP ON FEBRUARY 2, 2016 BE FIXED AND AT FIRST IT WAS COVERED UNDER WARRANTY. I TOOK IT BACK ON FEBRUARY 16, 2016 BC I HAD TO HAVE A FORD RENTAL PER FORD. THE TRUCK WAS REPAIRED BUT THEN IT WASN'T COVERED PER FORD AND I HAD TO PAY OVER $400 TO GET IT FIXED. MY CHECK ENGINE LIGHT CAME ON AGAIN AND IT HAD TO GO BACK TO THE DEALERSHIP BUT THIS TIME IT WAS COVERED UNDER WARRANTY. I JUST GOT MY TRUCK BACK ON APRIL 11,2016 AND TODAY ON APRIL 14, 2016 THE LIGHT IS BACK ON. I AM WAITING ON A CALL BACK FROM THE FORD DEALERSHIP TO FIND OUT WHAT TO DO NEXT.

NHTSA ODI #10853995

18,000 miles · Mar 15, 2016
EngineService Brakes

BRAKE ROTORS WARPING PRIOR TO 18,000 MILES; ENGINE COOLER FAN RUNS IN HIGH SPEED DURING SUMMER MONTHS, ALL THE TIME.

NHTSA ODI #10849851

Mileage unknown · Mar 8, 2016
Engine

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WOULD ALSO DRIVE ABNORMALLY WHEN REACHING SPEEDS OVER 60 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR COMPRESSOR HAD FAIL…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WOULD ALSO DRIVE ABNORMALLY WHEN REACHING SPEEDS OVER 60 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR COMPRESSOR HAD FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN BACK TO THE DEALER HOWEVER, DETAILS OF THE DIAGNOSIS COULD NOT BE PROVIDED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR REPAIRS RELATED TO THE FAILURE AND IT WAS INFORMED EACH TIME THAT THE BRAKES AND ROTORS HAD PREMATURELY DETERIORATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ODI #10845517

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of