← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Engine complaints

547 reports
Clear category filter
99,000 miles · Apr 10, 2020
EnginePower TrainVehicle Speed Control

OIL AND RADIATOR FLUID LEAKS CAUSING ENGINE SMOKING AND NAUSEATING ODOR WHEN HEATER TURNED ON WHILE ENGINE COLD OR COLD EXTERIOR TEMPS. COMPLETE LOSS OF ENGINE AND DRIVE POWER RANDOMLY LASTING 15-60SECS, THEN ALL NUMBERS IE: GAS MILAGE, SPEED, MILEAGE BECOME DASHES, SPEEDOMETER QUITS WORKING, ON HIGHWAYS AND CITY STREET. PULLIN…

Read full complaint

OIL AND RADIATOR FLUID LEAKS CAUSING ENGINE SMOKING AND NAUSEATING ODOR WHEN HEATER TURNED ON WHILE ENGINE COLD OR COLD EXTERIOR TEMPS. COMPLETE LOSS OF ENGINE AND DRIVE POWER RANDOMLY LASTING 15-60SECS, THEN ALL NUMBERS IE: GAS MILAGE, SPEED, MILEAGE BECOME DASHES, SPEEDOMETER QUITS WORKING, ON HIGHWAYS AND CITY STREET. PULLING OVER SHUTTING OFF AND RESTART WILL RESET UNTIL NEXT RANDOM EPISODE. ROUGH JERKS AND OCCASIONALLY A BANG WITH JERKS (FEEL LIKE IT COMES FROM THE AXELS) USUALLY AT LOW SPEEDS. MORE OFTEN IN PARKING LOTS BUT IN TRAFFIC JAMS ON HIGHWAYS. ONCE TRANSMISSION RECALL COMPLETE IT RAN FANTASTIC FOR A WEEK AND A HALF. NOW IT'S WORSE THAN EVER AND ENGINE LIGHT COMES ON FOR A DAY AND THEN GOES OFF.

NHTSA ODI #11320748

82,000 miles · Mar 14, 2020
EngineFuel/propulsion SystemPower Train

AFTER PURCHASE, I GOT A CONTINUOUS P0308, CYLINDER 8 MISFIRE. PROBLEM IS THAT CYLINDER 4 HAS LOW/NO COMPRESSION, DRAGGING DOWN CYLINDER 8 AS WELL.

NHTSA ODI #11318028

80,000 miles · Mar 11, 2020
Electrical SystemEngine

STOPPED RUNNING, DIED COMING OFF INTERSTATE AT 75 MPH. DAY BEFORE DIED AND WOULDN'T START JUST ROLLED AND ROLLED OVER. HOUR LATER, IT STARTED. HAD IT TOWED OFF INTERSTATE WOULD NOT START. STARTED ONCE AT DEALER. DEALER STATED THE FUSE 27 IS KNOWN TO MELT AND AFTER A WEEK IN THE SHOP IT IS FUSE 27 WHICH ALSO HAD TO BE REWIRE…

Read full complaint

STOPPED RUNNING, DIED COMING OFF INTERSTATE AT 75 MPH. DAY BEFORE DIED AND WOULDN'T START JUST ROLLED AND ROLLED OVER. HOUR LATER, IT STARTED. HAD IT TOWED OFF INTERSTATE WOULD NOT START. STARTED ONCE AT DEALER. DEALER STATED THE FUSE 27 IS KNOWN TO MELT AND AFTER A WEEK IN THE SHOP IT IS FUSE 27 WHICH ALSO HAD TO BE REWIRED. IT IS ON WEBSITES THAT FUSE 27 DOES THIS ALL THE TIME.. SHUTTING OFF ON INTERSTATE IS A HORRIBLE EXPERIENCE ESPECIALLY WHEN FORD KNOWS OF THIS DEFECT.

NHTSA ODI #11317500

80,000 miles · Mar 9, 2020
Engine

AT APPROXIMATELY 80,000 MILES, I BEGAN TO HEAR A CHIRPING OR AIR WHISTLING SOUND WHEN LIGHTLY TO MODERATELY ACCELERATING. I BEGAN TO INVESTIGATE THE NOISE USING THE INTERNET WHERE I LOCATED VIDEOS FROM OTHER F-150 ECOBOOST 3.5 ENGINE OWNERS WHO WERE EXPERIENCING THE SAME EXACT SENARIO AS I WAS. THEY HAD FOUND THAT THE DRIVERS …

Read full complaint

AT APPROXIMATELY 80,000 MILES, I BEGAN TO HEAR A CHIRPING OR AIR WHISTLING SOUND WHEN LIGHTLY TO MODERATELY ACCELERATING. I BEGAN TO INVESTIGATE THE NOISE USING THE INTERNET WHERE I LOCATED VIDEOS FROM OTHER F-150 ECOBOOST 3.5 ENGINE OWNERS WHO WERE EXPERIENCING THE SAME EXACT SENARIO AS I WAS. THEY HAD FOUND THAT THE DRIVERS SIDE AND/OR PASSENGER SIDE EXHAUST MANIFOLDS WERE LEAKING EXHAUST. THE TELL TALE SIGN IS A DARKENING OF THE AREA AROUND THE REAR OF EACH MANIFOLD. THE MANIFOLDS WERE WARPING FROM EITHER A DESIGN FLAW OR MATERIAL FAILURE AT THE REAR AND ALSO BREAKING THE MOUNTING FASTENERS. I HAVE DETERMINED BOTH OF MY MANIFOLDS ARE LEAKING EXHAUST FROM THE NOISES COMING FROM THE ENGINE COMPARTMENT WHILE DRIVING. THIS MAY TRIGGER A SAFETY INSPECTION FAILURE IF FOUND DUE TO LEAKING EXHAUST AS WELL AS AN EMISSION TEST FAILURE IF REQUIRED BY THE STATE WHERE THE OWNER RESIDES. ALSO THE RELEASE OF CARBON MONOXIDE FORWARD OF THE PASSENGER COMPARTMENT IS A CONCERN ESPECIALLY IF THE LEAKS INCREASE IN SIZE.

NHTSA ODI #11317047

167,000 miles · Feb 29, 2020
EngineUnknown Or OtherVehicle Speed Control

I AM HAVING TROUBLE WITH MY ECO BOOST BECAUSE WHEN I START MY TRUCK I HAVE A LOUD RATTLING SOUND THEN MY TRUCK LOSES POWER AND SHAKES ALOT LIKE A COMPRESSION LEAK

NHTSA ODI #11312279

58,000 miles · Feb 18, 2020
EngineFuel/propulsion SystemPower Train

WE OWN A FORD F-150 3.5 L ECOBOOST V-6 KING RANCH PICKUP TRUCK. TRUCK WAS PURCHASED IN 2014 NEW. HAVE SERIOUS CONCERNS AS THE VEHICLE HAS SO MANY CURRENT ISSUES. FROM DAY ONE OF PURCHASE AND WHILE STILL IN THE DEALERSHIP PARKING LOT, UPON START UP THERE WAS A VERY LOUD CLATTERING SOUND. SALES REP SAID IT WAS BECAUSE IT WAS C…

Read full complaint

WE OWN A FORD F-150 3.5 L ECOBOOST V-6 KING RANCH PICKUP TRUCK. TRUCK WAS PURCHASED IN 2014 NEW. HAVE SERIOUS CONCERNS AS THE VEHICLE HAS SO MANY CURRENT ISSUES. FROM DAY ONE OF PURCHASE AND WHILE STILL IN THE DEALERSHIP PARKING LOT, UPON START UP THERE WAS A VERY LOUD CLATTERING SOUND. SALES REP SAID IT WAS BECAUSE IT WAS COLD AND IT HAD BEEN SITTING. PURCHASED VEHICLE, HAD PROBLEMS IMMEDIATELY WITH DANGEROUS LAG IN ACCELERATION (WHICH WE STILL DO), AN AVERAGE OF 12 MPG IF WE WERE LUCKY AND VERY SERIOUS ENGINE MISFIRES WITH MAJOR DECREASE IN POWER ACCOMPANIED BY SPUTTERING WHOLE VEHICLE SHUDDERING WHILE TRYING TO MERGE ON THE HIGHWAY OR WITH HARD ACCELERATION. VERY DANGEROUS, ESPECIALLY IF IN THE FAST LANE, WHICH WE WERE. WE STARTED TO LIMP OVER SEVERAL LANES OF TRAFFIC TO THE SHOULDER AND THE TRUCK REGAINED POWER. MANY MISFIRES LIKE THIS, ALL EXPLAINED TO THE FORD SERVICE TECH AND VERIFIED ON THE TRUCKS COMPUTER. SO MANY IN FACT IT WAS NECESSARY TO REPLACE ALL SPARK PLUGS AT LESS THAN 57K MILES. WE JUST PICKED OUR TRUCK UP TODAY, FEB 18TH, 2020, AFTER IT WAS IN THE SHOP AGAIN, THIS TIME FOR 12 DAYS, TO FIX THIS MISFIRE PROBLEM AGAIN AND NUMEROUS OTHER ISSUES WITH THE FRONT HUBS STAYING LOCKED IN 4 WD WHILE IN 2 WHEEL DRIVE AND SWITCHING IN AND OUT, TIMING CHAIN REPLACED, AND THE ECOBOOST TURBO TUBES REPLACED AS THEY WERE CRACKED, IWE REPLACED, AND LEFT FRONT ACTUATOR. ALSO ABOUT 3 WEEKS AGO IT HAD TRANSFER CASE MOTOR REPLACED AS WELL AS NUMEROUS SWITCHES, ALL WHICH DID NOT CORRECT THE PROBLEMS. MY HUSBAND AND I DECIDED TO TAKE IT ON THE HIGHWAY TO SEE IF THE LAG MISFIRE PROBLEM WAS FIXED. WHEN HE HIT THE GAS THERE WAS A SCREECHY SOUND FROM THE TOP OF THE ENGINE, POWER SERIOUSLY DECREASED ONCE AGAIN ON THE HIGHWAY AND THE CHECK ENGINE LIGHT WAS BACK ON. I SENT AN EMAIL TO FORD AND AUFFENBERG FORD IN REF TO THESE CONTINUING PROBLEMS.

NHTSA ODI #11310006

66,283 miles · Jan 22, 2020
Engine

THROTTLE BODY FAILED 12/4/17 LEADING TO ENGINE POWER LOSS AT HIGHWAY SPEED. ENGINE LIGHT AND WRENCH WARNING DISPLAY APPEARED. COULD NOT ACCELERATE. WAS ABLE TO COAST TO SHOULDER SAFELY. RESTARTING THE VEHICLE, IT IMMEDIATELY WENT TO LIMP MODE. VEHICLE WAS TOWED TO DEALERSHIP (APPLE FORD, SHAKOPEE MN). TB WAS REPLACED BY DE…

Read full complaint

THROTTLE BODY FAILED 12/4/17 LEADING TO ENGINE POWER LOSS AT HIGHWAY SPEED. ENGINE LIGHT AND WRENCH WARNING DISPLAY APPEARED. COULD NOT ACCELERATE. WAS ABLE TO COAST TO SHOULDER SAFELY. RESTARTING THE VEHICLE, IT IMMEDIATELY WENT TO LIMP MODE. VEHICLE WAS TOWED TO DEALERSHIP (APPLE FORD, SHAKOPEE MN). TB WAS REPLACED BY DEALERSHIP SERVICE CENTER. ON 1/22/2020, THE VEHICLE AGAIN LOST POWER ON HIGHWAY AND WARNING LIGHTS CAME ON. AGAIN, WAS ABLE TO COAST TO SHOULDER AND EXIT THE FREEWAY IN LIMP MODE AND GET TO NEARBY DEALERSHIP (WOLD MOTORS, JORDAN MN). DETERMINED THAT THE THROTTLE BODY AGAIN FAILED, WAS REPLACED. TWO FAILURES WITH THE SAME PART IN SUCH A SHORT PERIOD OF TIME INDICATES A CLEAR DEFECT. VEHICLE LOSING POWER DUE TO THIS EQUIPMENT FAILURE TO A VERY UNSAFE SITUATION AND COULD CAUSE AN ACCIDENT AND RISK.

NHTSA ODI #11301212

89,100 miles · Jan 16, 2020
EnginePower TrainSeats

1. ENGINE DOESN'T RUN SMOOTH AT HIGHWAY SPEED.. 2. POWERTRAIN, TRANSMISSION - RECEIVED A RECALL 19V-075 FOR SOFTWARE UPDATE NOTICE 6/25/2019. TOOK THE F150 TO GATEWAY FORD DEALERSHIP FOR THE UPDATE. THE NEXT TIME TRIED TO ACCELERATE (8/16/19) THE TRANSMISSION SHIFTER ERADICABLE THE DASH ICONS FLASHED AND THE PICKUP STALLE…

Read full complaint

1. ENGINE DOESN'T RUN SMOOTH AT HIGHWAY SPEED.. 2. POWERTRAIN, TRANSMISSION - RECEIVED A RECALL 19V-075 FOR SOFTWARE UPDATE NOTICE 6/25/2019. TOOK THE F150 TO GATEWAY FORD DEALERSHIP FOR THE UPDATE. THE NEXT TIME TRIED TO ACCELERATE (8/16/19) THE TRANSMISSION SHIFTER ERADICABLE THE DASH ICONS FLASHED AND THE PICKUP STALLED AS TO BE IN LOW GEAR, I SHUT OFF THE IGNITION AFTER PULLING TO THE SIDE OF THE ROAD, RESTARTED IT AFTER A BIT AND CONTINUED ON MY WAY. THIS HAS HAPPENED AGAIN, NOT SURE OF DATES. AS I WAS TRAVELING OUT OF SOUTH DAKOTA I CONTACTED GATEWAY, THEY SAID TO TAKE THE PICKUP TO ANOTHER FORD DEALERSHIP AND THEY WOULD FIX IT. TOOK IT TO AUTO NATION FORD IN CORPUS CHRISTI, TX. THEY WOULDN'T FIX IT . THEY SAID THE UPDATE WAD ALREADY DONE. THE PICKUP DROVE AND WORKED GOOD PRIOR TO THE RECALL UPDATE AND NOW IT WILL SHIFT RADICALLY AND DASH ICON FLASHING WHEN ACCELERATING RAPIDLY. IN ADDITION THE DRIVERS SEAT IS WEARING OUT. IT SHOULD REAR BETTER THAN THAT. THE PICKUP ONLY HAS 90,178 MILES ON IT AND SHOULD LAST ME LONGER THAN THAT. ONE MORE ISSUE. THE POSITIVE BATTERY POST CONTINUALLY CORRODES. I'VE CLEANED IT MANY TIMES AND STILL CORRODES. PLEASE HAVE SOMEONE ADDRESS THESE ISSUES ON MY F150. I THINK THERE SHOULD BE NO COST TO ME PER YOUR ADVERTISING ON TV. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #11299683

140,000 miles · Jan 10, 2020
EngineService Brakes, Air

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE FAILED TO RESPOND WITH ACCELERATOR PEDAL DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE WHEEL SPEED SENSOR NEE…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE FAILED TO RESPOND WITH ACCELERATOR PEDAL DEPRESSED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE WHEEL SPEED SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

NHTSA ODI #11298353

128,073 miles · Dec 19, 2019
EnginePower Train

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 80 MPH, THE VEHICLE DOWNSHIFTED ON ITS OWN WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO LUTHER FAMILY FORD (LOCATED AT 3302 36TH ST S, FARGO, ND 58104, (701) 282-2350) WHERE IT WAS DIAGNOSED THAT UNKNOWN ENGINE COMPONENTS NEEDED TO BE REPLACED…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING 80 MPH, THE VEHICLE DOWNSHIFTED ON ITS OWN WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TO LUTHER FAMILY FORD (LOCATED AT 3302 36TH ST S, FARGO, ND 58104, (701) 282-2350) WHERE IT WAS DIAGNOSED THAT UNKNOWN ENGINE COMPONENTS NEEDED TO BE REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V075000 (POWER TRAIN). THE CONTACT STATED THAT THE RECALL REPAIR WAS COMPLETED IN JUNE OF 2019. THE VEHICLE WAS NOT REPAIRED FOR THE RECENT FAILURE. THE CONTACT WAS UNABLE TO COMMUNICATE WITH THE MANUFACTURER ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 128,073.

NHTSA ODI #11290172

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of