← New search

2013 Ford F-150

Owner reports · Recalls · Investigations

More warning signs than most F-150 years

Owner complaints for the 2013 Ford F-150 are substantially higher than the model-year median of 676.

About this comparison →

When problems were reported

Mileage at the reported incident

2,215 reports with mileage · 765 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 1,335 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 547 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 322 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

77 crash reports35 fire reports53 injury reports

Electrical System complaints

322 reports
Clear category filter
70,000 miles · May 28, 2018
Electrical SystemFuel/propulsion System

DRIVING IN TRAFFIC FRIDAY OF THE LONG MEMORIAL DAY WEEKEND, TRAVELING AT 75MPH, NO WARNING MY F150 STALLS. FINALLY GET PULLED ALL THE WAY TO THE SHOULDER. AFTER SITTING FOR AN HOUR AND GETTING HELP, IT WAS FOUND THAT THE FUSE FOR THE FUEL RELAY HAD MELTED. 50 CENT PART COULD HAVE CAUSED A DEADLY CRASH! WHY IS THERE NOT A RECALL …

Read full complaint

DRIVING IN TRAFFIC FRIDAY OF THE LONG MEMORIAL DAY WEEKEND, TRAVELING AT 75MPH, NO WARNING MY F150 STALLS. FINALLY GET PULLED ALL THE WAY TO THE SHOULDER. AFTER SITTING FOR AN HOUR AND GETTING HELP, IT WAS FOUND THAT THE FUSE FOR THE FUEL RELAY HAD MELTED. 50 CENT PART COULD HAVE CAUSED A DEADLY CRASH! WHY IS THERE NOT A RECALL ON THIS? MECHANIC THAT WORKED ON MY F150 SAID THIS IS ABOUT THE 12TH ONE HE HAD WORKED ON. I ALSO SEE THAT FORD HAS ISSUED A TSB ON THIS EXACT SAME PROBLEM.

NHTSA ODI #11098257

150,000 miles · May 22, 2018
Electrical SystemVehicle Speed Control

MY 2013 FORD F150 WILL SHIFT INTO DIFFERENT GEARS WHILE DRIVING CAUSING THE TRUCK TO LOCK UP. I WAS DRIVING 65 MPH DOWN THE INTERSTATE THIS MORNING WHEN IT SHIFTED INTO 1ST GEAR CAUSING MY TIRES TO LOCK UP AND SKID ALL OVER THE ROAD. LUCKILY I WAS ABLE TO GET IT OFF THE ROAD BEFORE CRASHING. I HAVE HEARD THIS IS THE OUTPUT SPEED…

Read full complaint

MY 2013 FORD F150 WILL SHIFT INTO DIFFERENT GEARS WHILE DRIVING CAUSING THE TRUCK TO LOCK UP. I WAS DRIVING 65 MPH DOWN THE INTERSTATE THIS MORNING WHEN IT SHIFTED INTO 1ST GEAR CAUSING MY TIRES TO LOCK UP AND SKID ALL OVER THE ROAD. LUCKILY I WAS ABLE TO GET IT OFF THE ROAD BEFORE CRASHING. I HAVE HEARD THIS IS THE OUTPUT SPEED SENSOR WHICH HAS HAPPENED TO MILLIONS OF OTHER F150'S. WHY HAS THIS NOT BEEN RECALLED?? THIS IS A MAJOR SAFETY HAZARD! HTTPS://WWW.SLASHGEAR.COM/FORD-FACES-1M-RECALL-EXPANSION-OVER-WORRYING-TRANSMISSION-FLAW-02513360/

NHTSA ODI #11097282

70,000 miles · May 17, 2018
Electrical SystemFuel/propulsion SystemPower Train

WHILE DRIVING TO WORK TODAY, AND MAKING A RIGHT HAND TURN, MY VEHICLE COMPLETELY SHUT OFF. THAT IS, THE ENGINE DIED, THE POWER STEERING DIED, AND THE BRAKES DIED WHILE THE TRUCK CAME TO A COMPLETE STOP IN THE MIDDLE OF THE LANE. LET ME REITERATE - THE TRUCK COMPLETELY DIED IN THE MIDDLE OF THE ROAD AND THERE WAS A COMPLETE LO…

Read full complaint

WHILE DRIVING TO WORK TODAY, AND MAKING A RIGHT HAND TURN, MY VEHICLE COMPLETELY SHUT OFF. THAT IS, THE ENGINE DIED, THE POWER STEERING DIED, AND THE BRAKES DIED WHILE THE TRUCK CAME TO A COMPLETE STOP IN THE MIDDLE OF THE LANE. LET ME REITERATE - THE TRUCK COMPLETELY DIED IN THE MIDDLE OF THE ROAD AND THERE WAS A COMPLETE LOSS OF CONTROL OVER THE VEHICLE. HAD THERE BEEN ANOTHER VEHICLE, OBJECT, OR PERSON IN FRONT OF ME, I WOULD HAVE LIKELY COLLIDED WITH THEM (THANKFULLY THE ROAD WAS EMPTY) RESEARCH HAS LEAD ME TO FIND THAT THIS IS A KNOWN ISSUE WITH FORD AND THE F150 SERIES FROM YEARS 2010 TO APPROXIMATELY 2014. FUSE NUMBER 27 IN THE ENGINE FUSE BOX IS UNDERSIZED FROM THE FACTORY AND MELTS DUE TO THE INABILITY TO HANDLE THE AMPERAGE. I FOUND MINE MELTED AFTER TODAY AS WELL. FORD HAS "ADDRESSED" THIS ISSUE WITH A TSB (FORD TSB-15-0137 SEE ATTACHED) WHICH IT CHARGES CUSTOMERS FOR TO REPLACE THE FUSE AND WIRING FOR THE FUSE WITH A NEW, UP SIZED FUSE AND WIRES. THEY DO NOT COVER THIS FREE OF CHARGE UNLESS YOUR TRUCK IS UNDER WARRANTY. AS THIS IS A GLARING SAFETY ISSUE THAT NUMEROUS PEOPLE HAVE REPORTED, I ASK THAT THE NHTSA INVESTIGATE THIS AND HAVE FORD INITIATE A RECALL ON THE AFFECTED VEHICLES, AND MAKE THE REPAIR FREE OF CHARGE TO CUSTOMERS. THIS ISSUE IS A MANUFACTURING FLAW AND ONE THAT HAS THE ABILITY TO CAUSE LOSS OF LIFE AND PROPERTY DUE TO FAILURE TO CONTROL THE VEHICLE. SOME FORUMS WHERE PEOPLE HAVE REPORTED THE SAME ISSUE: HTTP://WWW.FORDRAPTORFORUM.COM/F39/ENGINE-CUT-OFF-LOW-OIL-PRESSURE-WARNING-11894/INDEX16.HTML HTTP://WWW.FORDRAPTORFORUM.COM/F39/FORD-RAPTOR-FUEL-PUMP-FUSE-ISSUE-45129/INDEX37.HTML HTTPS://WWW.F150FORUM.COM/F12/ENGINE-SHOTS-OFF-WHILE-DRIVING-402848/ HTTP://WWW.F150ECOBOOST.NET/FORUM/31-F150-ECOBOOST-PROBLEMS/26113-ENGINE-RANDOMLY-DIED-WHILE-DRIVING.HTML

NHTSA ODI #11096601

94,000 miles · May 7, 2018
Electrical SystemEngine

VEHICLE WAS IN MOTION, PULLING A TRAILER AND THE LIGHT CAME ON AND THEN SHUT DOWN COMPLETELY. TURNED IT OFF THEN BACK ON AND IT WAS FINE FOR 2 BLOCKS THEN DID IT AGAIN. IT TOOK SEVERAL ATTEMPTS TO GET IT TO THE DEALERSHIP. THEY INFORMED IT IS ELECTRONIC THROTTLE BODY FAILURE.

NHTSA ODI #11092251

125,000 miles · May 3, 2018
Electrical System

BOUGHT THE TRUCK USED ABOUT 6 MONTHS AGO AND THE LEFT REAR AND PASSENGER RIGHT FRONT DOOR LOCK ASSEMBLY WOULD NOT WORK. TOOK INTO THE SHOP AND THE DOOR LATCHES ON BOTH DOORS HAD TO BE REPLACED. NOW THE PASSENGER REAR DOOR WILL NOT UNLOCK OR OPEN.

NHTSA ODI #11091487

52,000 miles · Mar 13, 2018
Electrical SystemUnknown Or OtherVisibility/wiper

AFTER USING REAR DEFROST, LEFT SIDE OF THE REAR WINDOW SHATTERED WITH A LOUD POP, SENDING BITS OF GLASS ONTO PAX IN THE BACK SEAT. AFTER READING ONLINE THIS IS A KNOWN ISSUE WITH THIS MODEL OF TRUCK AND NEEDS TO BE A SAFETY RECALL.

NHTSA ODI #11078828

44,000 miles · Mar 12, 2018
Electrical SystemEngine

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER AND THE GAUGES DID NOT FUNCTION. THE FAILURE OCCURRED WITHOUT WARNING. THE FAILURE WAS CORRECTED AFTER A MANUAL RESTART. THE FAILURE OCCURRED ON THREE SEPARATE OCCASIONS. WOODHOUSE FORD (3633 NORTH 72ND STREET, OMAHA, N…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A LOSS OF ENGINE POWER AND THE GAUGES DID NOT FUNCTION. THE FAILURE OCCURRED WITHOUT WARNING. THE FAILURE WAS CORRECTED AFTER A MANUAL RESTART. THE FAILURE OCCURRED ON THREE SEPARATE OCCASIONS. WOODHOUSE FORD (3633 NORTH 72ND STREET, OMAHA, NE) WAS CONTACTED, BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 44,000.

NHTSA ODI #11078640

66,000 miles · Mar 7, 2018
Electrical System

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE ACCELERATED AND THEN STALLED. THE WRENCH WARNING INDICATOR ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, IT DROVE NORMALLY. THE VEHICLE WAS TAKEN TO ROG…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE ACCELERATED AND THEN STALLED. THE WRENCH WARNING INDICATOR ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, IT DROVE NORMALLY. THE VEHICLE WAS TAKEN TO ROGERS FORD (4200 W WALL ST, MIDLAND, TX 79703, (432) 694-8801), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 66,000.

NHTSA ODI #11076689

81,000 miles · Feb 28, 2018
Electrical SystemLatches/locks/linkagesUnknown Or Other

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT THE DOOR LOCKS ON THE VEHICLE FAILED AND COULD NOT BE UNLOCKED. THE DOOR WAS ABLE TO UNLOCK THE NEXT MORNING. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE DEALER (KIRK AUTO COMPANY, 235 SW FRONTAGE RD, GRENADA, MS 38901) WAS NOTIFIED OF THE …

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. THE CONTACT STATED THAT THE DOOR LOCKS ON THE VEHICLE FAILED AND COULD NOT BE UNLOCKED. THE DOOR WAS ABLE TO UNLOCK THE NEXT MORNING. THERE WERE NO WARNING INDICATORS ILLUMINATED BEFORE THE FAILURE. THE DEALER (KIRK AUTO COMPANY, 235 SW FRONTAGE RD, GRENADA, MS 38901) WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 81,000.

NHTSA ODI #11075446

67,000 miles · Feb 27, 2018
Electrical System

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE DOWNSHIFTED FROM HIGH GEAR TO FIRST GEAR, CAUSING THE REAR WHEELS TO LOCK UP. AS A RESULT, THE CONTACT'S VEHICLE SKIDDED OFF THE ROAD. IN ADDITION, THE CONTACT STATED THAT THE WRENCH WARNING ICON ILLUMINATED. THE FAILURE RECURRED THREE TIMES.…

Read full complaint

TL* THE CONTACT OWNS A 2013 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE DOWNSHIFTED FROM HIGH GEAR TO FIRST GEAR, CAUSING THE REAR WHEELS TO LOCK UP. AS A RESULT, THE CONTACT'S VEHICLE SKIDDED OFF THE ROAD. IN ADDITION, THE CONTACT STATED THAT THE WRENCH WARNING ICON ILLUMINATED. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO THOMASVILLE FORD LINCOLN (1515 E JACKSON ST, THOMASVILLE, GA 31792) WHERE IT WAS DIAGNOSED THAT AN ELECTRICAL FAILURE WITH THE LEAD FRAME CAUSED THE VEHICLE TO DOWNSHIFT AND WOULD NEED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE MANUFACTURER WAS CONTACTED AND OPENED CASE NUMBER: CAS14180308. THE APPROXIMATE FAILURE MILEAGE WAS 67,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11075211

Official recalls

3

19V433000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2013 F-150 vehicles equipped with 5.0L or 6.2L gasoline engines, that previously had the powertrain control module (PCM) software reprogrammed under recall 19V-075. The software used to reprogram the PCM did not have the necessary updates to prevent the transmission from unexpectedly downshifting into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began June 24, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S19.

19V075000 · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Feb 11, 2019

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence & remedy

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

Power Train:automatic Transmission

Ford Motor Company (Ford) is recalling certain 2011-2013 F-150 vehicles equipped with a 6-speed automatic transmission. The transmission may unexpectedly downshift into first gear, regardless of vehicle speed.

Consequence: Unexpectedly downshifting into first gear may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began March 4, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S07.

16V345000 · Service Brakes, Hydraulic:fluid

May 24, 2016

Ford Motor Company (Ford) is recalling certain model year 2013-2014 F-150 vehicles manufactured August 1, 2013, to August 31, 2014 equipped with 3.5L engines. The master cylinder rear cup seal may roll, resulting in brake fluid leakage from the primary reservoir into the brake booster.

Consequence & remedy

Consequence: Loss of brake fluid from the primary reservoir results in a complete loss of front brake function, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake master cylinder and, if necessary, the brake booster, free of charge. The recall began on October 28, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S24.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

RQ17010 · Unexpected Transmission Downshift

Opened Dec 25, 2017 · Closed Oct 22, 2019

Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Additional source detail variants (2)

Power Train:automatic Transmission:control Module (tcm/pcm/tecm)

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

Power Train:automatic Transmission

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.

PE16003 · Master Cylinder External Leak

Opened Feb 29, 2016 · Closed Jul 26, 2016

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Additional source detail variants (4)

Service Brakes

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:fluid

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

Service Brakes, Hydraulic:foundation Components:master Cylinder

On May 23, 2016, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA regarding a master cylinder defect that could result in loss of the front brake circuit in approximately 225,012 model year 2013 through 2014 Ford F-150 vehicles equipped with 3.5-liter GTDI engines and built at the Dearborn Truck Plant from August 1, 2013 through August 22, 2014; and the Kansas City Assembly Plant from August 1, 2013 through August 31, 2014 (NHTSA Recall #16V-345, Ford Recall #16S24).Ford indicated that the rearmost cup seal in the brake master cylinder may roll, resulting in leakage from the brake fluid reservoir to the brake booster.According to Ford's DIR, Depending on the amount of brake fluid loss from the brake master cylinder into the brake booster, the driver will experience an audible chime, message center alert, red brake warning light in the instrument cluster and may begin to experience a change in brake pedal travel and feel.In the event that a loss of brake fluid is substantial enough to reduce brake function to the front wheels, the driver may experience longer pedal travel, increased pedal effort, and extended stopping distance, increasing the risk of a crash.Full braking function would remain in the rear wheel brake circuit.Ford's recall will replace the master cylinder and, if the master cylinder is leaking, also replace the brake booster.Seventy-three (73) of the complaints received by ODI contained vehicle identification number (VIN) information required to determine date of build and recall applicability.ODI's analysis found that 66 complaints to ODI and 278 complaints to Ford involving vehicles built in the range covered by 16V-345, resulting in an overall complaint rate of 152.9 incidents per 100,000 vehicles.Twelve (12) crash incidents were reported, including 11 with VIN information.All 11 crash incidents with VIN information reported involve vehicles covered by Ford's recall.ODI's analysis identified 7 ODI complaints and 36 Ford complaints in the 194,139 subject vehicles built outside of the build range for 16V-345, resulting in a complaint rate of 22.1 incidents per 100,000 vehicles.Ford indicated that warranty return analyses identified issues with minor internal leakage between circuits due to internal contamination caused by supplier assembly plant cleanliness concerns in these vehicles.Ford assessed the internal leak condition as an early-life condition with minimal safety risk that does not result in loss of fluid or circuit failure.ODI will continue to monitor complaints in subject vehicles not included in 16V-345.No complaints have been identified in MY 2013 through 2014 Ford F-150 vehicles equipped with other engine options.The recall action initiated by the manufacturer appears to address the safety risks identified by this investigation.This preliminary evaluation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetylssues under the following identification numbers:10870768, 10870747, 10870511, 10870395, 10870055, 10869981, 10865843, 10865521, 10865342, 10865043, 10864862, 10864714, 10864360, 10863982, 10863527, 10862333, 10862047, 10861735, 10861190, 10860378, 10860118, 10855381, 10855356, 10854785, 10853751, 10853295, 10853012, 10852349, 10852134, 10852037, 10851317, 10851268, 10851109, 10850015, 10849862, 10846488, 10846335, 10846193, 10846006, 10840414, 10840377, 10839994, 10839985, 10839981, 10839833, 10839825, 10839816, 10838782, 10838510, 10818273, 10817706, 10809601, 10788886, 10788369, 10785526, 10779854, 10776834, 10766291, 10762034, 10761412, 10760663, 10758997, 10750065, 10749886, 107

PE13018 · Reduced Power During Hard Acceleration

Opened May 22, 2013 · Closed Apr 7, 2014

Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Additional source detail variants (2)

Engine And Engine Cooling

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of

Engine

On May 22, 2013, the Office of Defects Investigation (ODI) opened PE13-018 to investigate 95 complaints alleging incidents of reduced engine power during hard accelerations in model year (MY) 2011 through 2013 Ford F-150 trucks.ODI was aware of three technical service bulletins (TSBs) issued by Ford for a condition that was related to moisture accumulation in the Charge Air Cooler (CAC) for the turbochargers.A Preliminary Evaluation was opened to gather information to assess whether the subject vehicles contain a safety related defect.The subject vehicles are powered by Ford?s 3.5L EcoBoost engine which uses twin turbochargers to obtain a balance of fuel economy and engine power based on the driver?s demand.When the driver requests more power from the engine, as in accelerating to pass, merge, ascend hills or haul a load the two turbochargers will spin up compressing the air which is then used to increase the power created by the combustion in the engine.The compressed air, which gains heat by the compression process, is passed through a Charge Air Cooler (CAC) which is designed to lower the temperature of the air in order to make the combustion process even more efficient (Figures 1 and 2).In response to ODI?s Information Request letter, Ford indicated that a misfire condition could occur after steady-speed operation under significantly humid and rainy conditions.Ford?s analysis found that under those conditions, condensation could form and accumulate on the inside of the CAC tubes which could then be ingested into the engine during particularly hard acceleration near wide-open throttle.An engine misfire of up to three cylinders could occur if the amount of condensed water released from the CAC exceeded the engine?s operating threshold for water ingestion.Ford noted that due to regulations set by the EPA, the powertrain software would disable up to two of the misfiring cylinders for no more than 30 seconds and until the driver tips out the throttle in order to protect the catalytic converter from damage. Ford?s testing of this condition on the subject vehicles showed that a vehicle experiencing such a condition would continue to maintain its speed as well as accelerate, albeit at a lower rate than expected by the driver.Similar results were obtained in testing done by NHTSA?s Vehicle Research and Testing Center in East Liberty, Ohio (Figure 6).In an ongoing process to address the problem Ford issued a series of TSBs where a deflector shield was installed onto the CAC (Figures 3, 4 and 5).In January 2014 Ford indicated that its data shows that the TSBs have been effective in resolving the problem, that for the MY 2013 vehicles their remedy is 100% effective and the latest TSBs for MY 2011 ? 2012 are 95% effective.The 525 complaints to ODI and the total 4,120 unique VIN complaints listed in the Failure Report are incidents of alleged reduced power or driveability symptoms and not all are necessarily related to the condition created by water ingestion.Reduced power conditions can occur for a variety of reasons including faults with ignition coils, spark plugs, a catalytic converter, the throttle body, turbocharger, fuel pump/filter, powertrain control module (hardware or software) or transmission shifting problems.Ford also noted that in a large number of warranty claims on the subject vehicles, the CAC was replaced or a TSB procedure was performed when the symptoms exhibited were inconsistent with a CAC water ingestion related issue.Given these circumstances, further use of the agency resources in this matter does not appear to be warranted.Accordingly, this investigation is closed.The closing of