THE RIGHT FRONT FLEXIBLE BRAKE LINE DETERIORATED AT THE CRIMPED FITTING. THE DETERIORATION IS ON THE INSIDE OF THE LINE AT THE CRIMP. THE DETERIORATION ACTS LIKE A CHECK VALVE ALLOWING THE APPLICATION OF THE BRAKE BUT NOT RELEASE OF BRAKING PRESSURE. I HAVE VERIFIED THIS ON THREE (3) REPLACEMENTS. THE ORIGINAL LINE WAS REPLACED …
Read full complaint
THE RIGHT FRONT FLEXIBLE BRAKE LINE DETERIORATED AT THE CRIMPED FITTING. THE DETERIORATION IS ON THE INSIDE OF THE LINE AT THE CRIMP. THE DETERIORATION ACTS LIKE A CHECK VALVE ALLOWING THE APPLICATION OF THE BRAKE BUT NOT RELEASE OF BRAKING PRESSURE. I HAVE VERIFIED THIS ON THREE (3) REPLACEMENTS. THE ORIGINAL LINE WAS REPLACED AT ABOUT 120K AND NON OEM AT ABOUT 20K.
NHTSA ODI #11302221
68,000 miles · Dec 29, 2019
Service BrakesWheels
I TURNED MY TRUCK ON AFTER IT SAT OVERNIGHT AND THE ABS AND EMERGENCY BRAKE LIGHTS WERE ILLUMINATED ON THE DASH CLUSTER. TOOK THE TRUCK INTO A LOCAL PART STORE AND HAD A OBD2 READER HOOKED UP AND IT PULLED ABS CONTROL MODULE CODE. I TOOK INTO A AUTO SHOP AND THEY WERE PULL THE CODE AND DECIPHER WHAT THE ACTUAL PROBLEM WAS. THE …
Read full complaint
I TURNED MY TRUCK ON AFTER IT SAT OVERNIGHT AND THE ABS AND EMERGENCY BRAKE LIGHTS WERE ILLUMINATED ON THE DASH CLUSTER. TOOK THE TRUCK INTO A LOCAL PART STORE AND HAD A OBD2 READER HOOKED UP AND IT PULLED ABS CONTROL MODULE CODE. I TOOK INTO A AUTO SHOP AND THEY WERE PULL THE CODE AND DECIPHER WHAT THE ACTUAL PROBLEM WAS. THE ABS CONTROL MODULE COMPLETELY STOPPED WORKING.
NHTSA ODI #11291931
109,000 miles · Feb 29, 2016
Service BrakesSteeringWheels
WHILE DRIVING AT APPROXIMATELY 30 MPH A REAR WHEEL LOCKED UP CAUSING THE TRUCK TO TURN TO ONE SIDE. TRAVELLING A LITTLE FURTHER IT HAPPENED AGAIN. I TURNED THE TRUCK AROUND AND HEADED BACK TO MY HOUSE. TWO OR THREE TIMES AGAIN A REAR WHEEL LOCKED UP CAUSING A LACK OF CONTROL. IF I WAS AT HIGHWAY SPEED, THE VEHICLE WOULD HAVE CAU…
Read full complaint
WHILE DRIVING AT APPROXIMATELY 30 MPH A REAR WHEEL LOCKED UP CAUSING THE TRUCK TO TURN TO ONE SIDE. TRAVELLING A LITTLE FURTHER IT HAPPENED AGAIN. I TURNED THE TRUCK AROUND AND HEADED BACK TO MY HOUSE. TWO OR THREE TIMES AGAIN A REAR WHEEL LOCKED UP CAUSING A LACK OF CONTROL. IF I WAS AT HIGHWAY SPEED, THE VEHICLE WOULD HAVE CAUSED AN ACCIDENT AS THE CONDITION WOULD CAUSE THE TRUCK TO GO SIDEWAYS.
NHTSA ODI #10838963
80,000 miles · Jun 8, 2015
Wheels
TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT STATED THAT THE FACTORY WHEELS WERE DEFECTIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE WHEELS WERE PREMATURELY WORN AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE …
Read full complaint
TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT STATED THAT THE FACTORY WHEELS WERE DEFECTIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE WHEELS WERE PREMATURELY WORN AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #10723952
56,000 miles · Nov 26, 2013
Wheels
TL* THE CONTACT OWNS A 2009 FORD F150. THE CONTACT STATED THAT THE TIRE AIR PRESSURE FAULT SENSOR WAS ILLUMINATED HOWEVER, THE TIRE AIR PRESSURE WAS ACCURATE. THE CONTACT VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIR. THE CONTACT INFORMED THE MANUFACTURER OF THE DEFECT. THE FAILURE MILEAGE WAS 56,000.
NHTSA ODI #10553854
43,000 miles · Apr 15, 2011
Wheels
WHILE DRIVING 2009 FORD F150 AT FREEWAY SPEED THE FRONT RIGHT WHEEL SEPARATED. WHEN THE WHEEL SEPARATED IT MADE HEAVY CONTACT WITH THE BRAKE CALIPER AND SOME CONTACT WITH THE UPPER A-ARM OF THE SUSPENSION CAUSING VEHICLE TO MOMENTARILY LOOSE CONTROL, CROSSING LANES OF TRAFFIC. FORTUNATELY THE ROADS WERE RELATIVELY UNOCCUPIED A…
Read full complaint
WHILE DRIVING 2009 FORD F150 AT FREEWAY SPEED THE FRONT RIGHT WHEEL SEPARATED. WHEN THE WHEEL SEPARATED IT MADE HEAVY CONTACT WITH THE BRAKE CALIPER AND SOME CONTACT WITH THE UPPER A-ARM OF THE SUSPENSION CAUSING VEHICLE TO MOMENTARILY LOOSE CONTROL, CROSSING LANES OF TRAFFIC. FORTUNATELY THE ROADS WERE RELATIVELY UNOCCUPIED AND THERE WAS NO COLLISION. THE WHEEL HAD NO PREVIOUS DAMAGE AND HAD NOT BEEN INVOLVED IN ANY PREVIOUS ACCIDENTS. THE TIRE MOUNTED ON THE WHEEL HAD APROX 800 MILES OF USE. FORD CURRENTLY HAS THE WHEEL AND WILL BE INSPECTING THE VEHICLE IN THE NEXT FEW DAYS. I ASSUME THAT REPLACEMENT OF THE WHEEL, TIRE, BRAKE CALIPER ANT PMS SENSOR WILL BE NECESSARY. *TR
NHTSA ODI #10396019
5,965 miles · Feb 25, 2010
Wheels
ALL 5 RIMS ON 2009 FORD RANGER SHOW EVIDENCE OF FAILURE/CRACKS. FORD TECHNICIAN RECOMMENDED REPLACEMENT OF ALL RIMS. VEH CURRENTLY HAS 5965 MILES (SEE REPORT 10307412 AND 10311415)(FS ID 1235) USDA FOREST SERVICE GWJEFF COMPLETED A FLEET WIDE INSPECTION OF ALL FORD VEHICLES WITH STEEL WHEELS. THIS IS THE 5TH INCIDENT OF THIS NAT…
Read full complaint
ALL 5 RIMS ON 2009 FORD RANGER SHOW EVIDENCE OF FAILURE/CRACKS. FORD TECHNICIAN RECOMMENDED REPLACEMENT OF ALL RIMS. VEH CURRENTLY HAS 5965 MILES (SEE REPORT 10307412 AND 10311415)(FS ID 1235) USDA FOREST SERVICE GWJEFF COMPLETED A FLEET WIDE INSPECTION OF ALL FORD VEHICLES WITH STEEL WHEELS. THIS IS THE 5TH INCIDENT OF THIS NATURE. I CURRENTLY HAVE 10 RIMS FROM VARIOUS VEH AFTER BEING REPLACED BY FORD TECHNICIANS. RECOMMEND FORD INITIATE A RECALL ON STEEL WHEELS TO DETERMINE IF THIS IS A FLEET WIDE PROBLEM. *TR
FORD IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 F-150 VEHICLES MANUFACTURED FROM JANUARY 18, 2008, THROUGH NOVEMBER 30, 2009. THE INTERIOR DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE INTERIOR DOOR HANDLE SPRING MAY FRACTURE DURING NORMAL USAGE RESULTING IN INSUFFICIENT SPRING FORCE TO RETURN THE HANDLE TO THE FULLY STOWED POSITION.
Consequence & remedy
Consequence: IN THE EVENT OF A SIDE IMPACT CRASH, THE DOOR HANDLE SPRING CAN FAIL CAUSING THE DOOR LATCH TO OPEN.
Remedy: OWNERS WILL BE INITIALLY NOTIFIED AND INSTRUCTED TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER IF ANY INTERIOR DOOR HANDLE IS LOOSE OR FAILS TO RETURN TO THE STOWED POSITION AFTER ACTIVATION FOR REPLACEMENT OF THE AFFECT MODULE. ONCE PARTS BECOME AVAILABLE, OWNERS WILL BE RENOTIFIED AND INSTRUCTED TO TAKE THEIR VEHICLES TO A FORD OR LINCOLN/MERCURY DEALER FOR INSPECTION OF EACH INTERIOR DOOR HANDLE. DEPENDING ON THE RESULTS OF THE INSPECTION, THE DEALER WILL EITHER ADD A SPRING EMBOSSMENT REINFORCEMENT OR REPLACE THE INTERIOR DOOR HANDLE MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 10, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
FORD IS RECALLING 8,735 MY 2009 F-150 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE BRAKE STOP LAMP SWITCH MAY BE IMPROPERLY ADJUSTED. THIS MAY RESULT IN A DELAY IN BRAKE STOP LAMP ILLUMINATION WHEN THE BRAKE PEDAL IS DEPRESSED. IN SITUATIONS OF VERY MILD BRAKE APPLICATION, THE BRAKE STOP LAMPS MAY NOT ILLUMINATE.
Consequence & remedy
Consequence: DELAY OR LOSS OF BRAKE STOP LAMP FUNCTION MAY INCREASE THE RISK OF AN ACCIDENT.
Remedy: DEALERS WILL INSPECT AND HAVE THE BRAKE STOP LAMP SWITCH REMOVED AND REINSTALLED WHICH WILL PROVIDE PROPER ADJUSTMENT. THE REMEDY WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON MAY 13, 2009. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.OWNERCONNECTION.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2009 Ford F-150 Problems, Complaints & Recalls | Skip That Year
Illustration