At 65mph driving in sport mode which has increased regeneration during deceleration which provides substantial braking, I was approaching stopped traffic. I let off the throttle pedal anticipating the braking effect and regeneration but the truck instaneously switched driving modes to normal without my input. It took me a second…
Read full complaint
At 65mph driving in sport mode which has increased regeneration during deceleration which provides substantial braking, I was approaching stopped traffic. I let off the throttle pedal anticipating the braking effect and regeneration but the truck instaneously switched driving modes to normal without my input. It took me a second to realize I was not slowing and had to manually activate the brake pedal in order to stop in time. I tried to reselect sport mode after stopping and it was greyed out with a message saying some features are disabled while driving. Normally you can switch drove modes while driving. After restart truck returned to normal operation. The danger was the unantisipated change to braking effect during a critical time before a high speed stop.
NHTSA ODI #11595325
Mileage unknown · May 20, 2024
Service Brakes
The parking brake engages randomly when the 2023 F150 Lightning Lariat ER comes to a stop while driving, thus increasing the risk of a crash. Dealership is "unable" to replicate the issue which currently occurs several times per day. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)…
Read full complaint
The parking brake engages randomly when the 2023 F150 Lightning Lariat ER comes to a stop while driving, thus increasing the risk of a crash. Dealership is "unable" to replicate the issue which currently occurs several times per day. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11589768
Mileage unknown · Nov 26, 2023
Forward Collision AvoidanceService BrakesVehicle Speed Control
I WAS DRIVING IN TRAFFIC ON THE 405 AND THE COLLISION AVOIDANCE SYSTEM ACTIVATED AND SLAMMED ON THE BRAKES BRINGING THE VEHICLE TO A SCREECHING HALT ON FREEWAY. I WAS NEARLY REAR ENDED. THE VEHICLE DISPLAYED "FRONT CAMERA FAULT" AND :COLLISION AVOIDANCE NO AVAILABLE" ON THE DASH FOR A FEW MINUTES. NO ERROR CODES WERE FOUND IN TH…
Read full complaint
I WAS DRIVING IN TRAFFIC ON THE 405 AND THE COLLISION AVOIDANCE SYSTEM ACTIVATED AND SLAMMED ON THE BRAKES BRINGING THE VEHICLE TO A SCREECHING HALT ON FREEWAY. I WAS NEARLY REAR ENDED. THE VEHICLE DISPLAYED "FRONT CAMERA FAULT" AND :COLLISION AVOIDANCE NO AVAILABLE" ON THE DASH FOR A FEW MINUTES. NO ERROR CODES WERE FOUND IN THE COMPUTER. I ALSO HAVE "ONE PEDAL DRIVE" FAULTS THAT CAUSE THE VEHICLE TO ROLL WHEN I REMOVE MY FOOT FROM THE ACCELERATOR. IT SHOULD STOP, BUT INTERMITTENTLY KEEPS GOING. THIS IS THE SECOND FORD LIGHTNING I'VE HAD WITH THAT PROBLEM AND MANY OTHERS. FORD BOUGHT THE FIRST ONE BACK UNDER THE CA LEMIN LAW. GALPIN FORD HAS FOUND NO CAUSE FOR THE COLLISION AVOIDANCE FAILURE AND NO CAUSE FOR THE ONE PEDAL DRIVE FAULTS. ERROR CODES ARE NOT BEING STORED IN THE COMPUTER SYSTEM. FORDS ANSWER WAS TO TRY TO GIVE ME THE VEHICLE BACK WITHOUT REPAIRS BECAUSE THEY SAY THEY CAN'T REPLICATE THE PROBLEM. AFTER THE PROBLEMS WITH THE FIRST TRUCK I PHOTOGRAPH ALL ERRORS ON DASH. DESPITE MY PICTURES THEY ARE UNABLE TO MAKE REPAIRS. I HAVE APPLIED TO GET THIS SECOND LIGHTNING BOUGH BACK UNDER THE CA LEMON LAWS AS WELL. I HAVE FOUND MANY OTHER INSTANCES OF OWNERS REPORTING THESE SAME OR SIMILAR PROBLEMS IN FORUMS.
NHTSA ODI #11556869
Mileage unknown · Aug 25, 2023
Forward Collision AvoidanceService BrakesCrash
We were in a low speed situation. A car 2 cars in front of us was signaling a right hand turn. We began to slow down from approximately 25 mph to 5-7 mph. The car turning right stop short of completing their turn, the car immediately in front of us came to a complete stop. We were only traveling 5 - 7 mph behind and had plen…
Read full complaint
We were in a low speed situation. A car 2 cars in front of us was signaling a right hand turn. We began to slow down from approximately 25 mph to 5-7 mph. The car turning right stop short of completing their turn, the car immediately in front of us came to a complete stop. We were only traveling 5 - 7 mph behind and had plenty of room to stop. I depressed the brake further (we were already slowing due to turning vehicle) but the truck did not slow at which point I depressed the brake pedal as hard as I could. The truck did not slow at all in this time (no brake locking, no skid marks). We only came to a stop when we hit the stopped vehicle in front of us. Additionally, this vehicle has advanced safety features (forward collision warning and active braking assist) -- none of these features triggered. I have lost all faith in this vehicles ability given the situation. I contacted Ford customer service, they referred me to their Office of General Counsel and said to expect a response in 45 - 60 days. That is unacceptable to me -- I have a very expensive vehicle that I cannot drive as I do not trust it. I want to understand why all these systems failed, have them as well as my vehicle fixed or the vehicle bought back from me. I cannot wait 60 days for resolution.
Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: A loss of park function can allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: The park module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed February 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 26, 2026.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning BEV vehicles previously repaired under recall number 23V418. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace the rear lightbar and fasteners as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 29, 2025.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles previously repaired incorrectly under recall number 23V801. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: Dealers will update the Accessory Protocol Interface Module (APIM) software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C15.
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Consequence & remedy
Consequence: Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 21, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S11. This recall expands previous recall number 24V-144.
Ford Motor Company (Ford) is recalling certain 2022-2024 F-150 Lightning battery electric vehicles. A manufacturing defect in the high voltage battery cells may result in an internal short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will inspect and replace the high voltage battery array as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Ford Motor Company (Ford) is recalling certain 2023-2024 F-150 Lightning BEV vehicles. The front upper control arm ball joint nut may not have been tightened properly, allowing the front upper control arm to detach from the knuckle assembly.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy: Dealers will inspect the upper control arm ball joint nut, and replace the nut and/or knuckle assembly, as necessary, free of charge. Owner notification letters were mailed February 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S76.
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Consequence & remedy
Consequence: Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 31, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S11.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C38.
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning pickup trucks. The electronic cabin coolant heater module may be missing a solder joint, which can cause intermittent or no cabin heat and result in an inoperative windshield defrosting and defogging system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will replace the electronic cabin coolant heater, free of charge. Owner notification letters were mailed January 3, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C32.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 BEV vehicles. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the rear lightbar, free of charge. Owner notification letters were mailed October 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S30.
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning pickup trucks. The high-voltage battery pack may experience an electrical short-circuit when the battery is fully charged or near fully charged.
Consequence & remedy
Consequence: A battery short-circuit increases the risk of a fire.
Remedy: Dealers will replace the high-voltage battery pack, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S15.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2023 Ford F-150 Lightning Bev Problems, Complaints & Recalls | Skip That Year
Illustration