NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
60 reportsClear category filterMileage unknown · Jan 10, 2024
Electrical SystemExterior LightingVehicle Speed Control
In this vehicle the instrument panel is an electronic display. This display did not show any controls, speedometer, mileage, warning lights, etc. It was black, with only the backlight on. This morning (Jan 10) on my way to work I noticed my instrument panel was not working. The screen was completely black instead of displayi…
Read full complaint
In this vehicle the instrument panel is an electronic display. This display did not show any controls, speedometer, mileage, warning lights, etc. It was black, with only the backlight on. This morning (Jan 10) on my way to work I noticed my instrument panel was not working. The screen was completely black instead of displaying the normal information (charge level, speed, etc).
NHTSA ODI #11564591
1,170 miles · Jan 8, 2024
Electrical SystemParking Brake
The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the instrument panel and display screen went blank at every one and a half miles. The Parking Brake and Front Camera Malfunction, Clear Screen messages were displayed. The vehicle was taken to the dealer, where it was diagnosed tha…
Read full complaint
The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed, the instrument panel and display screen went blank at every one and a half miles. The Parking Brake and Front Camera Malfunction, Clear Screen messages were displayed. The vehicle was taken to the dealer, where it was diagnosed that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 1,170.
NHTSA ODI #11564264
Mileage unknown · Jan 6, 2024
Electrical SystemUnknown Or Other
instrument cluster would not function and was completely black. Had to pull the fuse to reset it
NHTSA ODI #11563897
Mileage unknown · Jan 1, 2024
Electrical SystemExterior LightingVehicle Speed Control
We were driving down the road and the cluster screen went completely black. We couldn’t tell what speed we were going or any other information that gets displayed there. This is a very hazardous problem that should be looked into further.
NHTSA ODI #11562913
Mileage unknown · Nov 15, 2023
Back Over PreventionElectrical System
The Sync 4 main display reboots very often. It has occurred over 30 times in 10k miles. I am considering this a safety issue as it often happens shortly after startup of the vehicle, and prevents the backup cameras from functioning. In fact, it has rebooted the screen while I was reversing probably five times. Ford has had n…
Read full complaint
The Sync 4 main display reboots very often. It has occurred over 30 times in 10k miles. I am considering this a safety issue as it often happens shortly after startup of the vehicle, and prevents the backup cameras from functioning. In fact, it has rebooted the screen while I was reversing probably five times. Ford has had numerous software updates and yet this problem remains endemic across multiple owners that I have spoken to.
NHTSA ODI #11555221
Mileage unknown · Nov 10, 2023
Electrical SystemVehicle Speed Control
The entire over steering wheel display/cockpit stopped functioning. No ability to view charge level, speed, and other related details normally shown in this display was available. The things I tried to repair were: parking the car, locking the door to simulate a full stop/start cycle, disconnecting everything from the vehicle po…
Read full complaint
The entire over steering wheel display/cockpit stopped functioning. No ability to view charge level, speed, and other related details normally shown in this display was available. The things I tried to repair were: parking the car, locking the door to simulate a full stop/start cycle, disconnecting everything from the vehicle ports, Etc. eventually after leaving the car for an extended period this functionality eventually returned to normal. If I had been far from home I’d have been faced with essentially driving blind. I also have video of this issue if desired.
NHTSA ODI #11554588
Mileage unknown · Nov 6, 2023
Electrical SystemUnknown Or Other
I’ve owned this Lightning for only four months. When I started it this morning, the digital instrument display would not work. Without it, I have no speedometer, odometer, battery temp, battery charge, or other displays.
NHTSA ODI #11553709
Mileage unknown · Oct 27, 2023
Back Over PreventionElectrical System
When reversing, the center screen that contains the backup camera freezes, with no indication it has stopped functioning. This leads to a situation where you are seeing a camera image that is not related to the actual view behind you. This can cause crashes and pedestrian hazards if you do not realize the screen has broken. A…
Read full complaint
When reversing, the center screen that contains the backup camera freezes, with no indication it has stopped functioning. This leads to a situation where you are seeing a camera image that is not related to the actual view behind you. This can cause crashes and pedestrian hazards if you do not realize the screen has broken. Attached photos show what the camera was showing and what the actual situation was. The only solution to getting the cameras to function again is by a full reset of the center screen.
NHTSA ODI #11552251
Mileage unknown · Jun 28, 2023
Electrical System
The 240V mobile charging cord that is sold with the vehicle repeatedly overheats and derates the charging speed once overheated. Problem has existed since the vehicle was brand new. Cord is used in a warm climate but not an abnormal temperature for a non-climate controlled garage. Overheating electrical equipment could result in…
Read full complaint
The 240V mobile charging cord that is sold with the vehicle repeatedly overheats and derates the charging speed once overheated. Problem has existed since the vehicle was brand new. Cord is used in a warm climate but not an abnormal temperature for a non-climate controlled garage. Overheating electrical equipment could result in a household electrical fire if the temperature sensors were to fail, which is a safety mechanism and shouldn’t be triggered in normal everyday operation. An alternate brand charging cord with similar capabilities works fine on the same outlet in similar environmental conditions. This is a well known problem from other owners of F-150 Lightnings and Mustang Mach-Es. Therefore a warranty replacement with an identical unit does not appear to be a prudent resolution and would be preferable to be recalled and re-engineered.
NHTSA ODI #11529480
Mileage unknown · Feb 16, 2023
Electrical System
I have a F150 Lightning being delivered ( expected 2/23 - 3/2 ). I’ve read about the fire on 2/5 almost exactly the date my truck was shipped. Ford says “should” be OK. Dealer says Ford problem. I don’t want a bomb in my garage. What should I do? Know you’re on it as I read a story today. You should know that Ford is basical…
Read full complaint
I have a F150 Lightning being delivered ( expected 2/23 - 3/2 ). I’ve read about the fire on 2/5 almost exactly the date my truck was shipped. Ford says “should” be OK. Dealer says Ford problem. I don’t want a bomb in my garage. What should I do? Know you’re on it as I read a story today. You should know that Ford is basically telling me to take delivery “as is”. This hardly seems safe to me as well as others who have builds that coincide with this very dangerous issue. Thank you for any help.
NHTSA ODI #11507655
Official recalls
11Dec 12, 2025
Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: A loss of park function can allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: The park module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed February 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 26, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning BEV vehicles previously repaired under recall number 23V418. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace the rear lightbar and fasteners as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 29, 2025.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles previously repaired incorrectly under recall number 23V801. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: Dealers will update the Accessory Protocol Interface Module (APIM) software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C15.
Apr 23, 2025
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Consequence & remedy
Consequence: Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 21, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S11. This recall expands previous recall number 24V-144.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2022-2024 F-150 Lightning battery electric vehicles. A manufacturing defect in the high voltage battery cells may result in an internal short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will inspect and replace the high voltage battery array as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Dec 19, 2024
Ford Motor Company (Ford) is recalling certain 2023-2024 F-150 Lightning BEV vehicles. The front upper control arm ball joint nut may not have been tightened properly, allowing the front upper control arm to detach from the knuckle assembly.
Consequence & remedy
Consequence: A detached control arm can cause a loss of vehicle steering and control, increasing the risk of a crash.
Remedy: Dealers will inspect the upper control arm ball joint nut, and replace the nut and/or knuckle assembly, as necessary, free of charge. Owner notification letters were mailed February 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S76.
Feb 23, 2024
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Consequence & remedy
Consequence: Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 31, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S11.
Nov 28, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C38.
Oct 13, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning pickup trucks. The electronic cabin coolant heater module may be missing a solder joint, which can cause intermittent or no cabin heat and result in an inoperative windshield defrosting and defogging system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."
Consequence & remedy
Consequence: An inoperative windshield defrosting and defogging system may decrease the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will replace the electronic cabin coolant heater, free of charge. Owner notification letters were mailed January 3, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C32.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 BEV vehicles. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the rear lightbar, free of charge. Owner notification letters were mailed October 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S30.
Mar 15, 2023
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning pickup trucks. The high-voltage battery pack may experience an electrical short-circuit when the battery is fully charged or near fully charged.
Consequence & remedy
Consequence: A battery short-circuit increases the risk of a fire.
Remedy: Dealers will replace the high-voltage battery pack, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S15.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration