Within first two months of ownership of new F-150 Lightning, we found the windshield is covered by or contains in its lamination far too many tiny bright dots, specks, or tiny pin point bubbles (say, on average, less than 1/4" apart) that appear and cause glare when the sun shines almost directly through them. This glare from t…
Read full complaint
Within first two months of ownership of new F-150 Lightning, we found the windshield is covered by or contains in its lamination far too many tiny bright dots, specks, or tiny pin point bubbles (say, on average, less than 1/4" apart) that appear and cause glare when the sun shines almost directly through them. This glare from the tiny defects makes it hard to see the full road, especially when the sun is low. I assume it is a manufacturing defect. Reported to Ford Dealer back in December, 2022, but they never responded to me. And after windshield glass was replaced due to a rock hit with OEM glass, it has the same sun glare with the tiny bubbles, so manufacturing is consistently bad? I think this could be a recall situation.
NHTSA ODI #11619490
Mileage unknown · Aug 17, 2024
Visibility/wiper
About a year ago there was a wiper motor recall, bought jt in for that. Last few months wipers get “stuck” mid wipe for a few seconds and then rectify. Today wipers got stuck mid wipe indefinitely. I hit the button a few times and they completed the wipe. Annoying for a 2 year old vehicle , perhaps a problem with the recall rep…
Read full complaint
About a year ago there was a wiper motor recall, bought jt in for that. Last few months wipers get “stuck” mid wipe for a few seconds and then rectify. Today wipers got stuck mid wipe indefinitely. I hit the button a few times and they completed the wipe. Annoying for a 2 year old vehicle , perhaps a problem with the recall replacement motors?
NHTSA ODI #11609164
Mileage unknown · Feb 12, 2023
Visibility/wiper
Windshield wiper motor has been recalled with no "quick or timely" solution I ask ford to provide a rental car until repair can be completed or buy back the truck. I tried to take to a Ford dealership but they keep saying there is no parts. Which I understand buy in the meantime I need a working car due to my work I can't have a…
Read full complaint
Windshield wiper motor has been recalled with no "quick or timely" solution I ask ford to provide a rental car until repair can be completed or buy back the truck. I tried to take to a Ford dealership but they keep saying there is no parts. Which I understand buy in the meantime I need a working car due to my work I can't have any active recalls.
NHTSA ODI #11506866
Mileage unknown · Dec 20, 2022
Visibility/wiper
Windshield Wipers do not operate consistently. Initial problem was identified while driving; pressing the wash button resulted in water on the windshield mixing with dirt to create a lack of visibility issue, the wipers moved a few inches and stopped. Repeated attempts to turn wipers on and off eventually solved the problem. …
Read full complaint
Windshield Wipers do not operate consistently. Initial problem was identified while driving; pressing the wash button resulted in water on the windshield mixing with dirt to create a lack of visibility issue, the wipers moved a few inches and stopped. Repeated attempts to turn wipers on and off eventually solved the problem. Condition is repeatable when cold, and intermittent after warm up. After a long delay and a replaced SCCM, Ford returned vehicle only to encounter safety failure again during driving. There are no warning lamps to indicate a malfunction.
Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: A loss of park function can allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: The park module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed February 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 26, 2026.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning BEV vehicles previously repaired under recall number 23V418. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace the rear lightbar and fasteners as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 29, 2025.
Ford Motor Company (Ford) is recalling certain 2022 F-150 Lightning BEV vehicles equipped with 20" or 22" all season tires that were repaired incorrectly under recall 22V-453. The tire pressure monitoring system (TPMS) light may not illuminate as intended, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Low tire pressure can lead to poor vehicle handling and a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the body control module (BCM) software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C20.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles previously repaired incorrectly under recall number 23V801. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: Dealers will update the Accessory Protocol Interface Module (APIM) software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C15.
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Consequence & remedy
Consequence: Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 21, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S11. This recall expands previous recall number 24V-144.
Ford Motor Company (Ford) is recalling certain 2022-2024 F-150 Lightning battery electric vehicles. A manufacturing defect in the high voltage battery cells may result in an internal short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will inspect and replace the high voltage battery array as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C38.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 BEV vehicles. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the rear lightbar, free of charge. Owner notification letters were mailed October 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S30.
Ford Motor Company (Ford) is recalling certain 2022 F-150 BEV vehicles equipped with 20" or 22" all season tires. The tire pressure monitoring system (TPMS) light may not illuminate as intended, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Low tire pressure can lead to poor vehicle handling and a loss of vehicle control, increasing the risk of a crash.
Remedy: The body control module (BCM) software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C15.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2022 Ford F-150 Lightning Bev Problems, Complaints & Recalls | Skip That Year
Illustration